2016 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 2,452 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Explorer model years with reports.
Of the 2016 reports, 39 involved a crash and 14 involved a fire. 59 people were injured.
What owners report most often
Recalls and investigations
Structure, bodyJul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Campaign 26V448000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Structure, bodyMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Campaign 25V347000 on NHTSA.gov
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearJul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Campaign 21V537000 on NHTSA.gov
Structure, bodyMay 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Campaign 21V316000 on NHTSA.gov
Suspension, rearMar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Campaign 20V675000 on NHTSA.gov
Power train, axle assembly, axle shaftNov 10, 2020
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.
Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.
Campaign 20V692000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
SeatsNov 29, 2017
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.
Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.
Campaign 17V767000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Seats, front assembly, reclinerJun 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.
Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.
Campaign 16V475000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Overheating of the engine block increase the risk of a fire.
Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.
Campaign 16V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.
Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.
Campaign 15V605000 on NHTSA.gov
Parking brakeJul 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.
Campaign 15V464000 on NHTSA.gov
Representative owner complaints
2,452 reports, newest first.
Structure, Jul 25, 2023
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 70 MPH, the driver’s and passenger’s side windshield trim panel detached. Additionally, while driving, the roof rail detached. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to NHTSA Hotline. The contact stated that the failure was related to NHTSA Action Number: PE23001 (Structure). The failure mileage was 98,000.
Structure, Jul 24, 2023
The drivers side windshield trim panel came off of the car while driving down a highway at 55mph. Luckily, there were no other cars on the highway and no further damage or injury occurred.
Visibility/wiper, Jul 24, 2023
The windshield trim blew off while driving on the Highway. Happened so fast I couldn’t tell if it blew into the ditch or what happened to it. Could have easily hit a vehicle behind me and cause an accident. Very distracting for the driver as well. I almost veered into other lane with oncoming traffic with how loud and surprising it was.
Engine and engine cooling, Engine, Jul 21, 2023
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Steering, Jul 21, 2023
The contact owns a 2016 Ford Explorer. The contact stated while making a right turn, there was a grinding sound coming from the steering wheel. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 96,500.
Steering, Service brakes, Jul 19, 2023
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Other or unspecified, Jul 19, 2023
While driving on the highway, the passenger side windshield trim flew off hitting my windshield. I've been told by the police that it happens frequently on their vehicles, but never thought it would happen to me. It did. Now. I have to pay for the repair and it could have easily caused an accident, because it scared me so much that I swerved thinking something hit me. Which it did. My own car!
Electrical system, Jul 13, 2023
The contact owns a 2016 Ford Explorer. The contact stated upon conducting a routine inspection on the vehicle, he became aware that the battery was leaking acid onto the terminal connectors, and the terminal connectors were severely corroded. The vehicle was taken to the dealer, where the battery and the terminal connectors were replaced; however, the failure reoccurred. The vehicle was taken back to the dealer, where it was diagnosed that the battery and the terminal connectors needed to be replaced again. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 36,421.
Steering, Jul 12, 2023
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Numbers: 21V316000 (Structure), 21V537000 (Suspension), and 19V435000 (Suspension). The contact stated while driving 35 MPH, the steering wheel became stiff. The power steering warning light was illuminated. The vehicle was steered to the side of the roadway. The vehicle was restarted and returned to normal operation. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
Structure, Jul 12, 2023
Windshield trim piece came loose and broke off while driving on the highway. I had to tape down the part that was still on there two times before I could have it repaired so that I did not lose the rest of it on the highway and cause an accident. The driver's side failed first and now my passenger side has split apart and is rattling while on the highway, so I have to have both sides repaired out of safety concerns!
Structure, Jul 11, 2023
Windshield trim blew off going down the interstate. I replaced it and it blew off again! Now I have extra wind noise and I’m scared it’s going to leak. I would try to glue another one down but do not want to affect my windshield integrity.
Seat belts, Jul 11, 2023
The seat belt buckle for the second row passenger-side broke, making it impossible for the seat belt buckle to lock. Ford said the part was back ordered. When the part arrived and the car was being fixed, we received a call from the service manager advising the second row driver-side buckle broke as well. This seems to be a recurring issue.
Engine, Jul 8, 2023
Coolant, water pump, and timing chamber. Last year I had it replaced for $1,800 not knowing this is a common issue for the make and model. Never received any info concerning a recall about this issue or other recalled issues. In 1yr the water pump has malfunctioned again causing the engine to overheat and oil leakage.
Steering, Electrical system, Jul 7, 2023
Vehicle is experiencing a loss of power steering at all speeds. Steering stiffens and loosens erratically. Repair shop reports failure to electronic steering system and state that a replacement of the electronic steering gear assembly is required.
Structure, Jul 5, 2023
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, he heard an abnormal sound coming from the roof of the vehicle. After a visual inspection, the contact became aware that the passenger’s side roof rack rail had detached from the roof. The vehicle was taken to the dealer and the contact was informed that parts for the repair were not available. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V316000 (Structure) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 99,000.
Steering, Jul 4, 2023
The steering felt stiff as I was pulling out this morning. It was fine yesterday, and today it felt as if the lane assist was trying to be active when it didn't need to be; I can street the car, but it feels like it's constantly trying to correct the course and keep the car going straight forward. I tried turning off the land assist to see if it changed, but didn't really see a difference. Speed did not matter; it was noticeable at all speeds. The car was recently repaired due to a turbocharger failure, and at that time they discovered and also repaired the front drive shaft; it has operated perfectly until today.
Steering, Power train, Jul 2, 2023
While driving on the interstate and set MPH were 55, a series of notifications popped up on my dashboard. One stated “Steering assist fault repair required.” After I hit Ok to clear the screen my steering wheel tightened up and locked and caused me to almost crash into another family. We were able to move it to a safe location.
Steering, Jul 1, 2023
While driving/turning vehicle becomes hard to steer as if power steering is failing. It will tighten up and loosen consistently. Most noticeable when turning or shifting lanes. Started out being occasional then increased within a couple weeks. On occasion, there is a faint winding noise coming from the steering column. No noises noticeable from the outside as of yet. Mechanics can not figure out the issue. No codes or visible failures.
Steering, Jun 30, 2023
Power steering gear rack assembly failed. Lost power steering assist when turning at intersection and almost lost control of vehicle to collision and pedestrian injury. Power steering assist recovered after engine shut down and restart and again lost power steering when driving around curve and almost collided with on coming traffic head on. Afterwards the power steering did not recover and it was confirmed defective and replaced by Midas repair shop. There were no warning lamps, messages or symptoms prior to failure. The messages that appeared on the dash display after failure are: 1. STEERING ASSIST FAULT - SERVICE REQUIRED. 2. HILLS START ASSIST NOT AVAILABLE. 3. SERVICE ADVANCE TRAC.
Other or unspecified, Jun 30, 2023
I was driving down Highway 90 in Houston Tx, doing roughly 60 mph when all of a sudden the drivers side window trim, I believe it's called a pillar, just detached and flew behind the car causing the cars behind me to swerve almost crashing into each other. When it detached, the car besides me abruptly swerved to the right almost hitting a car which caused them to swerve back towards me, almost hitting me which caused me to swerve towards the right almost hitting a concrete barrier. I drove maybe a block up, pulled over and had a panic attack. This could have been a horrific outcome and would have had to carry the responsibility, that's if I didn't get injured by the wall, things could have been very bad maybe deadly if EVERYONE wasn't paying attention. I'm actually mentally disturbed by this. There was no reason for the part to fly off, it just popped off on its own. This needs to be fixed immediately before someone dies.
Steering, Other or unspecified, Jun 28, 2023
In the past week or two I have noticed the steering in my 2016 Ford Explorer starting to feel "heavy" and that progressed to being really stiff and kind of hard to turn. Called Ford and they advised to have the vehicle examined. Took the car to my preferred repair facility and there were no codes for an issue; they found my battery was bad and suggested changing it to see if that would help the steering. Battery was replaced and still issues with the steering, the mechanic at my facility said "the rack is still bad". I will make contact with Ford again however based on the number of complaints I see from others I am sure that will get me no where. It appears there are hundreds of complaints about this issue I see for the 2016 Explorers, and many others from prior years too. And these are just the people who have taken the time to complain. This clearly can turn into a large safety issue if people aren't able to control their vehicles while operating. I have no issue with making repairs to my cars, things break. I do have an issue with having to go into my own pocket to fix issues that are a known problem. While not safety issues I also have two other seemingly "known" issues with my car. The rear air conditioning line is leaking so my air is out; and the paint on my hood is bubbling and chipping away, apparently an issue with manufacture of the hood.
Steering, Jun 27, 2023
The power steering assist failed and malfunctioned. Power steering assist does not work either standing still or driving. Turning engine off and back on corrects the problem but problem comes back without warning when driving. This conditions creates dangerous situation of crash or injury. No inspection has been done yet but will have it repaired tomorrow. Warning message on dash says, "Loss of Steering Power Assist". Also, messages light up, "Service Advance Trac" and "Hills Start Assist Not Available" There were no prior warning lamps or messages of symptoms of problem prior to failure.
Visibility/wiper, Jun 27, 2023
The windshield trim on right side of the car is coming ungluded. Now weather strip is flapping all over the place damaging my passenger window and mirror. I am now noticing trim is coming unglued on drivers side door. I already replaced the passenger door trim a few years back. Please help us consumers by demanding that Ford issue this recall. It is clear this is a defect in their vehicles.
Steering, Jun 26, 2023
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, there was a grinding and squeaking sound coming from the steering column. The vehicle was taken to the local dealer who diagnosed that the noise was due to a faulty steering rack and pinion. The contact was informed that the rack and pinion needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 40,000.
Steering, Jun 23, 2023
We are hearing a loud noise on our '16 Ford Explorer Platinum when turning the steering wheel. It only has about 62,000 miles. The Service department at our local Ford Dealership stated that the noise likely means the Steering Rack could lock up at any time while driving. It could happen soon or never. The cost to repair is about $3000. It is a common & known issue on this Ford model. How can this not be on a safety recall? If the vehicle is in the middle of traffic when the steering locks up, it could be tragic, possibly causing an accident that could take lives. There are no warning lamps or messages warning of any issues. Are we to pay $3000 for the replacement part & labor with just a possible guess of what defect the noise may cause? How is Ford not responsible to repair this known defect?