2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints: steering
77 reports, newest first. Show all
Steering, May 22, 2025
The contact owns a 1997 Ford F-150. The contact stated that while driving at various speeds, the steering wheel started to wobble. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 192,699.
Steering, Dec 11, 2014
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE TIE ROD BECAME DETACHED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. THE VIN WAS NOT AVAILABLE.
Steering, Dec 31, 2013, crash
I HAVE A COMPLAINT AS FORD WITH THERE SHIFTERS I HAVE ALSO SEEN IT ON SOME OLDER AND NEWER MODELS IS THE TWO BOLTS ON THE BRACKET ON THE END OF THE SHIFTER ROD ON THE STEERING COLUMN COME LOOSE AND OR MISSING BOLT AND THERE FOR HAVE SHIFTING PROBLEMS AS I DID ONE MORNING WITH MY 2000 F 150 WENT TO START THE TRUCK EARLY IN THE MORNING TRUCK WAS I THOUGHT WAS IN PARK ALL THE WAY AS I LEFT IT WENT INSIDE TO GET SOMETHING COME BACK OUT TRUCK WAS AC-CROSS THE STREET ESTIMATED 3100 DOLLARS IN DAMAGE TO MY TRUCK WITH A SIMPLE MISSING BOLT ON THE SHIFTER CAUSED THIS ISSUE AND I FEEL THIS IS A SAFETY CONCERN I FIXED THE PROBLEM MY SELF BUT I SURE THINK IT SHOULD BE RECALLED SO NO ONE ELSE GETS HURT OR KILLED I HAVE PICS TO PROVE THE DAMAGE I CAN EMAIL THEM IF NEEDED. *TR
Steering, Service brakes, Hydraulic, Fuel system, Gasoline, Power train, Exterior lighting, Visibility, Structure, Wheels, Interior lighting, Nov 10, 2011
2000 FORD F-150. CONSUMER STATES WHEEL RIMS STARTED TO RUST OUT IN ONE YEAR *TGW THE CONSUMER ALSO STATED THE BUMPER RUSTED OUT IN ONE YEAR, AND THE ABS LIGHT ILLUMINATED. THE BRAKES WERE INSPECTED SEVERAL TIMES, BUT NO PROBLEM WAS FOUND. THE HIGH BEAMS WOULD NOT COME ON, THE PLASTIC ON THE OUTSIDE REARVIEW MIRROR FELL OFF, THE DOME LIGHT IN THE CAB WOULDN'T COME ON, AND THE TAILGATE WOULDN'T CLOSE, THE WINDSHIELD WIPER WASHER, WIPERS AND HEATING SYSTEM DID NOT WORK. THE POWER STEERING PUMP LEAKED ALL THE TIME, THE GEAR SHIFTER WOULDN'T GO INTO PARK. THE FUEL STRAP FAILED THREE YEARS AGO AND CAUSED THE FUEL TANK TO FALL TO THE GROUND. *JB
Steering, Oct 20, 2011
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT WAS DRIVING 60 MPH WHEN THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED, BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 395,000 AND THE CURRENT MILEAGE WAS 395,004.
Steering, Power train, Equipment, Oct 29, 2010
2000 FORD WINDSTAR SEL -THE ACTIVE CONTROL LIGHT GOES ON SLIGHT BUMPS OR ROUGH ON HIGHWAYS-GOES OFF, BUT RECENTLY AFTER THE REAR AXLE RECALL AND CHECK OF BY DEALERSHIP ON OCT 4, 2010, OUR CAR HAS ON MORE THAN THREE OR FOUR TIMES WENT INTO THE ACTION CONTROL MODE WHEN THE LIGHT ON DASH WENT ON --AND THIS AT HIGH INTERSTATE OR PARKWAY SPEEDS OF 65 MPH, AND ON DRY SURFACES---IT HAS , I GUESS, BECAUSE OF DRY-NON SLIP CONDITIONS CAUSED DIFFICULTY IN MAINTAINING CONTROL OF VEHICLE. ON SECONDARY SLOWER SPEED HIGHWAYS ONLY THE LIGHT HAS GONE ON --NO REAL NOTICE OF ENGAGING OF ACTIVE CONTROL ACTION, SO TO SPEAK. WE HAVE REPORTED ALL THIS TO OUR DEALERSHIP AND FORD CUSTOMER RELATIONS. ALSO TAKE NOTE THAT AT AROUND 10-19-09 WHEN CAR AT 112,468 MILES OUR DEALERSHIP REPLACED A REAR RIGHT SPEED SENSOR AT PRICE OF $149.19 --ON THAT OCCASION FOR THE REPORT BY US OF ACTIVE CONTROL LIGHT GOING ON AND STAYING ON. THAT WAS NOT AS NOW -AS THE VEHICLE NEVER WENT INTO THE ACTIVE CONTROL ACTION THAT DOING NOW AT AROUND THE MILES OF 114,980. THIS VEHICLE HAS BEEN GARAGE KEPT AND ALL SERVICE RECORDS KEPT-FIRST BY THE OWNER I PURCHASED FROM AND NOW BY US ON OUR HOME PAGE FORD SERVICE RECORDS ACCOUNT. *TR
Steering, Service brakes, Hydraulic, Electrical system, Exterior lighting, Jun 9, 2010
I WAS TRAVELING IN NEUTRAL, DOWNHILL, AT ABOUT 40MPH THROUGH A SHALLOW TURN AS I WAS EXITING A HIGHWAY. WHEN I PUT THE TRUCK IN 4TH GEAR TO ACCELERATE, I HAD NO POWER. THE TACHOMETER WAS AT ZERO AND I TRIED TO TURN ON THE HAZARD LIGHTS AND BEGIN BRAKING, BOTH FAILED TO WORK. I HAD NO LIGHTS OR ANY OTHER ELECTRICAL POWER (IT WAS DAYLIGHT) I DOWNSHIFTED AND TURNED TO EASE OFF THE ROAD, I HAD NO POWER STEERING, THEN THE STEERING WHEEL LOCKED. I HALTED THE TRUCK WITH THE E BRAKE ONCE I WAS SLOW ENOUGH AND ON THE EDGE OF THE ROAD. I TRIED TO RESTART IT SEVERAL TIMES BUT NOTHING WOULD HAPPEN. THE TRUCK HAD ZERO ELECTRICAL POWER. AFTER ABOUT 15 MINUTES IT STARTED BACK UP AS IF NOTHING WAS WRONG. WHEN I GOT IT TO JOHN ELWAY FORD IN DENVER CO, THE MECHANICS SAID THE COMPUTER DIDN'T LOG ANY ERRORS AND THERE WAS NOTHING THEY COULD DO. I CONTACTED FORD AND THEY REFUSED TO DO ANYTHING. I CONTACTED THE BBB AND THEY JUST REITERATED FORDS POLICY. THE PROBLEM HAS NEVER BEEN FIXED SINCE NO ONE CAN FIND THE REASON FOR IT. IT HAS HAPPENED ONE OTHER TIME TO ME IN 2007 (I THINK). *TR
Steering, Engine and engine cooling, Vehicle speed control, Feb 16, 2010
2000 F250 SD 7.3 DIESEL INCIDENT DATE 2/15/2010 2/12/2010 I TOOK MY TRUCK INTO THE DEALER TO GET A OIL CHANGE AND A RECALL FIXED ON THE CRUISE CONTROL. THAT MORNING WHEN I STARTED IT UP, IT HAD A NOISE WHEN I TURNED THE WHEEL, WHEN I BROUGHT IT IN, THEY SAID THE GASKET ON MY POWER STEERING HAD GONE BAD, AND I NEEDED A COMPLETE REPLACEMENT OF MY POWER STEERING PUMP. NOW IS WHEN THE REAL PROBLEM STARTS... I HAD NOT EXPERIENCED THIS PROBLEM PRIOR TO THE DEALER VISIT. ALL OF THE SUDDEN WHEN I DRIVE ON THE HIGHWAY, ANY ROUGH ROAD SENDS IT INTO UNCONTROLLABLE SHAKING, I THOUGHT I WAS GOING TO LOSE COMPLETE CONTROL OF THE TRUCK, IT COULD EASILY CAUSE AN ACCIDENT. I LOOKED FOR THIS PROBLEM ON THE INTERNET, AND FOUND THIS IS A PROBLEM FOR MANY FORD SD DRIVERS, AND AS OTHERS HAVE PUT IT, FORD WON'T DO ANYTHING UNTIL THE DEATHS OUT WAY THE RECALL COST. IT IS UP TO PEOPLE LIKE YOU, TO KEEP US SAFE, AND MAKE THESE CAR COMPANIES FIX THEIR PROBLEM VEHICLES BEFORE THERE ARE TOO MANY DEATHS. I AM SURE THERE HAS TO OF BEEN AN ACCIDENT CAUSED BY THIS PROBLEM, VERY POSSIBLY 1 OR MORE DEATHS, I KNOW OF ONE PERSON WITH THIS PROBLEM ON THE WEBSITE CAUSED A 3 CAR ACCIDENT. I CALLED THE DEALER, THEY WANT TO COME TO MY HOME AND DRIVE IT TO THE DEALERSHIP, I SAID I WOULD HAVE IT TOWED IN, BUT THEY WANT TO DRIVE IT, WHICH MAKES ME UNCOMFORTABLE, SINCE I AM LIABLE FOR WHAT HAPPENS WITH MY TRUCK. THERE HAS BEEN NO MODIFICATIONS DONE TO THIS VEHICLE, AND THE TIRES ARE THE APPROPRIATE TIRES AND THEY ARE FILLED WITH THE PROPER AIR PRESSURE. *TR
Steering, Seat belts, Oct 29, 2008
TL*THE CONTACT OWNS A 2000 FORD F SERIES. THE CONTACT STATED THAT THE STEERING WHEEL BEGAN MELTING DUE TO SUN EXPOSURE. HE ALSO STATED THAT THE SEAT BELT WAS INOPERABLE. THE DEALER STATED THAT NOTHING COULD BE DONE BECAUSE THE WARRANTY EXPIRED. IN ADDITION, THERE WERE NO OPEN RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 165,000. UPDATED 11/24/08 *CN UPDATED 11/26/08. *JB
Steering, May 13, 2008
WHILE TURNING OFF MAJOR THOROUGH-FARE, TIE-ROD SEPARATED FROM THE WHEEL CAUSING LOSS OF CONTROL. TRUCK SKIDDED TO A STOP. I WAS FORTUNATE IT OCCURRED IN A PARKING LOT AND NOT INTO ON-COMING TRAFFIC. THIS IS THE 2ND ROD TO BREAK ON THE F-150 IN THE PAST 18 MONTHS. *TR
Steering, Apr 9, 2008
WHILE DRIVING HOME FROM WORK ON A TWO LANE HIGHWAY, I STARTED TO BRAKE AT AROUND 45 MPH FOR A SLOWING VEHICLE IN FRONT OF ME. THE TRUCK STARTED BUCKING AND SHAKING VIOLENTLY. LUCKILY, I MANAGED TO TURN INTO A GAS STATION THAT WAS RIGHT THERE AND STOP. I GOT OUT AND LOOKED TO SEE THAT THE PASSENGER SIDE TIE ROD WAS BROKEN. *TR
Steering, Apr 5, 2007
TIE ROD FAILURE, BALL SEPERATED FROM SOCKET. *AK
Steering, Air bags, Jan 25, 2007, crash
TL* - THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT A COLLISION OCCURRED ON A BACK ROAD COVERED WITH SNOW. THE CONTACT STATED THAT THE SHAFT IN THE STEERING GEAR BOX TO THE PITMAN ARM SNAPPED. THE CONTACT WAS DRIVING 30 MPH WHEN THE FAILURE OCCURRED AND CAUSED THE CRASH. THE AIR BAGS DID NOT DEPLOY. THE CONTAC DID NOT KNOW THE EXTENT OF THE DAMAGE. NO POLICE REPORT WAS TAKEN. *AK
Steering, Jun 20, 2006
WHILE PULLING ONTO THE FREEWAY THIS MORNING IN RUSH HOUR TRAFFIC, THE LEFT TIE ROD ON MY 2000 F150 CAME APART, MAKING IT IMPOSSIBLE TO STEER THE VEHICLE. I WAS AFRAID FOR MY LIFE. THE VEHICLE HAD JUST 78,670 MILES ON IT AND IS USED MAINLY BY ME TO DRIVE TO WORK. ON AUG. 16, 2004, WITH JUST 55,849 MILES, I HAD TO HAVE THE RIGHT AND LEFT LOWER BALL JOINTS REPLACED, WHICH THE MECHANIC WARNED ME WERE ON THE VERGE OF TOTAL FAILURE. *NM
Steering, May 23, 2006
(1) DUE TO THE PARTICULAR DESIGN FLAW OF THE " TIE END RODS" (THE TIE ENDS DO NOT HAVE A GREASE NIPPLE TO ALLOW CRITICAL LUBRICATION OF THESE PARTS!), THE PASSENGER SIDE "UPPER TIE END ROD" COMPLETELY SEPARATED FROM ITS NORMAL POSITION WHILE THE VEHICLE WAS IN MOTION. (2) THE VEHICLE OPERATOR WAS UNABLE TO STEER THE VEHICLE TO A SAFE CLEARANCE AND WAS FORCED TO IMMEDIATELY STOP ON A TWO LANE BRIDGE AND BLOCK ONE OF THE LANES. (3) ALL OF THE "TIE ENDS RODS" WERE REPLACED WITH NEW PARTS THAT HAVE A NIPPLE FOR LUBRICATION SO THAT THE "WEAR" ITEM CAN BE MAINTAINED BY APPLYING GREASE. THE OLD PART IS AVAILABLE. *NM
Steering, Feb 16, 2006
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH, THE DRIVER SIDE TIRE STARTED BOUNCING. THE VEHICLE WAS PULLED OVER AND TOWED TO THE CONTACT'S RESIDENCE WERE IT WAS REPAIRED BY A FAMILY MEMBER. THE INNER TIE ROD WAS REPLACED ON THE DRIVER SIDE. ALSO, WHILE PULLING INTO A PARKING SPACE AT LESS THAN 5 MPH, THE PASSENGER SIDE TIRE DID NOT RESPOND TO THE STEERING WHEEL. THE VEHICLE WAS AGAIN TOWED TO THE RESIDENCE AND THE PASSENGER SIDE INNER TIE ROD WAS REPLACED. THE MANUFACTURER HAS BEEN ALERTED.
Steering, Exterior lighting, Latches/locks/linkages, Oct 27, 2005
WHEN STEERING WHEEL IS NOT ALL THE WAY UP THE TURN SIGNALS, HAZARD LIGHTS, AND THE BRAKE LIGHTS DO NOT WORK. I HAVE TAKEN IT TO THE DEALERSHIP AND THEY STATE THAT THERE IS A CLIP IN THE STEERING COLUMN THAT IS BROKE. THIS ALL HAPPENED 2 MONTHS AFTER I BOUGHT THE TRUCK AND THEY WILL NOT FIX IT DUE TO THERE BEING NO WARRANTY. AT THE SAME TIME THE KEYLESS ENTRY STOPPED WORKING AS WELL AS THE AUTOMATIC DOOR LOCKS. THEY STATED THAT THIS WAS BECAUSE THE MOTOR IN BOTH DOORS HAD WENT OUT. SEEMS ODD TO ME THAT THEY WOULD BOTH GO AT THE SAME TIME. *JB
Steering, Oct 3, 2005
DT: 2000 FORD F150. THE CONSUMER STATED THAT THE TIE ROD END LET GO WHILE IN MOTION. THIS OCCURRED ON OCTOBER 3, 2005. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALERSHIP. THE VEHICLE WAS TOWED TO CONSUMER'S RESIDENCE. THE CONSUMER HAD NOT CALLED FORD. THERE WAS NO WARNING BUT THERE WAS A SMALL VIBRATION IN THE STEERING WHEEL THEN THE TIE ROD COMPLETELY LET GO. THERE WAS NO ACCIDENT AND NO ONE WAS INJURED. *SC . *AK
Steering, Aug 31, 2005
DT: THE CONTACT STATES LEFT FRONT TIE RODS SEPARATED. HE WAS GOING APPROXIMATELY 40 MPH. THEY BOTH HAD TO BE CHANGED. THIS HAPPENED ON MAY 9-05. HE LOST CONTROL OF THE STEERING ON 5-9-05. HE HAD NOTICED THAT THE STEERING WAS WANDERING PRIOR TO THIS INCIDENT. THE DEALER TOLD HIM THE ALIGNMENT WAS PERFECT; THEY HAD USED A NEW MACHINE TO DETERMINE IF THE ALIGNMENT WAS CORRECT. *AK
Steering, Jul 26, 2005
AS I WAS DRIVING DOWN THE ROAD I LOST CONTROL OF MY VEHICLE. I WAS TRAVELING APROXIMATLY 30MPH WHEN MY TRUCK STARTED SHAKING AND VEERED OFF THE ROAD. I WAS ABLE TO STOP BEFORE ANY DAMAGE OCCURED. BEING MECHANICALY INCLINED I INSPECTED THE VEHICLE AND NOTICED THE DRIVERS SIDE TIE ROD END HAD SEPERATED. THIS SURPRISED ME IN THAT THE TRUCK ONLY HAD 60K MILES. I BELIEVE THIS IS A MAJOR SAFETY ISSUE SINCE THERE WAS NO OBVIOUS INDICATION THAT THE TIE ROD END WAS EVEN BAD.
Steering, Jul 7, 2005
DT: HAD PROBLEMS IN PAST WITH TIE ROD ENDS AND WAS UNABLE TO KEEP GREASE ON THEM. CONSUMER WAS AT CHURCH AND BEGAN TO LEAVE, AND THERE WAS A POPPING NOISE. AFTER TURNING THE WHEEL FOLLOWED BY A DRAGGING-THIS WAS LATER A PIECE OF TIE ROD END. THIS OCCURRED ON THE RIGHT SIDE, AND BEFORE THE MILEAGE HAD ACCUMULATED TO 20,000 .THIS OCCURRED ABOUT A YEAR AND A HALF AGO. THIS WAS REPAIRED BY CONSUMER'S HUSBAND. THIS 4TH OF JULY WEEKEND, WAS EXITING PARKING LOT ONTO STREET AND HEARD ANOTHER POPPING NOISE. ALMOST LOST CONTROL OF TRUCK BUT WAS ABLE TO MAKE IT OFF THE ROAD. CALLED HUSBAND WHO WAS A MECHANIC, HE CAME AND REPAIRED VEHICLE. THIS OCCURRED ON THE LEFT SIDE. THE PARTS FOR THE F150 TIE ROD ENDS WERE UNABLE TO PACK GREASE WHICH CAUSES THIS FAILURE. HAS CONTACTED FORD FOR THE FIRST INCIDENT. THE SECOND FAILURE MILEAGE WAS JUST OVER 50,000 MILES. *AK
Steering, Jun 24, 2005
LAST NIGHT, I WAS MAKING A LEFT HAND TURN INTO A PARKING LOT WHEN I LOST CONTROL OF THE STEERING IN MY VEHICLE. LUCKILY, THE ONCOMING TRAFFIC WAS ABLE TO MANUVER AROUND ME, AND I JUST MISSED A UTILITY POLE. I FOUND THE INNER LEFT TIE ROD HAD COMPLETELY SEPARATED. I HAVE SERARCHED THE INTERNET AND FOUND NUMEROUS REPORTS AND COMPLAINTS OF THE SAME ISSUE, AND EVEN A PENDING CLASS-ACTION SUIT. I WILL BE REPLAING NOT ONLY THE BROKEN TIE ROD, BUT THE OTHERS AS WELL.
Steering, Suspension, Jun 16, 2005
DT: CONSUMER TOOK THE VEHICLE TO DEALER TO BE ALIGNED, AND WAS TOLD THE FRONT BALL JOINTS WERE OUT AND WERE REPLACED. TOOK VEHICLE O ANOTHER SERVICE DEPARTMENT AND WAS TOLD THAT RACK AND PINION WORE OUT IN THE STEERING BOX. CONSUMER HAD PROBLEMS WITH THE STEERING AND HEARD A POPPING AND CRACKING.*AK
Steering, May 17, 2005
LEFT & RIGHT OUTER TIE ROD END FAILURE 2000 FORD F150 SC 2 WD
Steering, Apr 30, 2005
FORD F150 TIE ROD FAILURE--IN AUGUST OF 2004 RECEIVED A NOTICE FROM FORD TO CHECK TIE RODS DUE TO CHANGE OF INSPECTION PROCEDURES INSPECTED TIE RODS IN SEPTEMBER 2004, CHECKED OK. IN APRIL OF 2005 DRIVER'S SIDE OUTER TIE ROD FAILED AT APPROXIMATELY. 60,000 MILES DAMAGES TO VEHICLE INCLUDED DRIVER'S SIDE TIRE& RIMS. *AK