2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Other or unspecified, Jul 17, 2026
I had the recall number 05s28 repaired at high desert ford on July sixth as a part of a California safety inspection to register my vehicle. Per ford they are done however they refuse to update the system which holds my vehicle unable to be registered even after the services were rendered and complete. Multiple attempts to trendy have failed any results thus ford is holding my vehicle hostage from legal use in the state
Fuel/propulsion system, Apr 8, 2026
Cruise control kicked on and won't go off. Gas fumes come from the AC unit. When driving the truck started speeding up. Now the truck is parked.
Seat belts, May 15, 2025
Front seatbelts on 2002 Ford F-150 become unlatched unexpectedly while driving. This has been noticed over the last two or three years occasionally, but has been getting worse. Seat belt has become unlatched about 5-6 times during a 600 mile road trip. Seat belt was confirmed by two passengers that it was indeed latched correctly and nothing pushing the release button. Seatbelt was confirmed to be latched by firmly tugging on seat belt to witness that it was latched. Both passengers confirmed that the seatbelt become unlatched randomly while driving. Passenger and driver safety is at risk. If driver seatbelt comes unlatched while driving or during accident, the driver could loose control of truck and put other drivers at risk. The unlatching does not show any warning signs as to when it will become unlatched. Seatbelt just becomes unlatched and starts to recoil without warning. Ford service just says that the truck is out of warranty and that they dont cover seat belt replacements as there is no open recalls for such. Seatbelt is still currently installed on vehicle but can be available for inspection on vehicle or removed for inspection.
Fuel/propulsion system, Mar 9, 2025
Just learned of recall.
Other or unspecified, Fuel/propulsion system, Jul 26, 2024
DRIVING DOWN [XXX] THE STRAPS ON MY GAS TANK BROKE BECAUSE THEY RUSTED THRU CAUSING GAS TANK TO DROP AND SPILL FUEL ALL OVER [XXX] IN IOWA CAUSING SO MUCH FUEL SPILLED OUT THEY HAD TO CLOSE ONE LANE OF TRAFFIC....THE FIRE DEPT CHIEF OF WHITING, IOWA, STEVEN SNYDER, Can verify what happened....THERE IS A POLICE REPORT BUT I DIDN'T HAVE IT FILING OUT THIS REPORT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, May 29, 2024
The contact owns a 2002 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle made a loud sound. No warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed and determined that cylinder #3 spark plug had blown out, but no repair was recommended at the time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 108,000.
Wheels, Feb 2, 2024
The contact owns a 2002 Ford F-150. The contact stated while at a tire shop to have the tires rotated, the mechanic was unable to remove the tires due to the lug nuts being swollen. The manufacturer was made aware of the failure and suggested to the contact to call the NHTSA Hotline to report the failure. The approximate failure mileage was 100,000.
Latches/locks/linkages, Nov 27, 2023
The contact owns a 2002 Ford F-150. The contact stated that the rear driver's side and rear passenger's side doors failed to open from inside or outside the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact stated that the vehicle was previously serviced due to the failure. The failure mileage was 70,000.
Seat belts, Vehicle speed control, Service brakes, Nov 22, 2023
Systems failed. Recalls incomplete
Engine, Aug 21, 2023, fire
The contact owns a 2002 Ford F-150. The contact stated that she observed smoke emanating from under the vehicle near the engine compartment. The contact stated that she opened the hood and flames erupted from the engine compartment near the battery. The contact threw dirt on the engine to extinguish the fire. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 200,000.
Vehicle speed control, Aug 21, 2023
The contact owns a 2002 Ford F-150. The contact stated that while driving approximately 45 MPH and attempting to pass a slower vehicle, the vehicle experienced unintended acceleration. The contact stated that while depressing the accelerator pedal, the pedal suddenly extended to the floorboard causing the vehicle to immediately accelerate faster than intended. During the failure the speed increased to over 75 MPH before the contact shifted the transmission into neutral and the vehicle decelerated. The contact stated that the vehicle had experienced the failure on two other occasions and the cruise control feature was never activated during the failure. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 94,000.
Air bags, May 2, 2023, crash
The contact owned a 2002 Ford F-150. The contact stated that while his wife was driving at 50 MPH, she crashed into a tree. The air bags failed to deploy upon impact. The contact's wife was taken to the hospital where she was treated for a concussion, multiple hematomas to her right thigh, right abdomen, and head; as well as three fractures on her vertebrae. A police report was filed. The vehicle was towed from the scene to an independent tow yard where it remained in their possession. The dealer nor the manufacturer had been notified of the failure. The contact was informed by his insurance that the vehicle was a total loss. The failure mileage was approximately 280,000.
Electrical system, Mar 14, 2023
Speed control deactivation switch
Latches/locks/linkages, Feb 9, 2023
The contact owns a 2002 Ford F-150. The contact stated while opening the driver’s side rear door, the door failed to unlatch. The contact also attempted to open the passenger’s side rear door; however, the door would not unlatch. The vehicle was taken to an independent mechanic and the contact was informed that the wiring harness in the doors needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 80,000.
Electrical system, Other or unspecified, Fuel/propulsion system, Sep 4, 2022, fire
Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.
Power train, Aug 21, 2022
I have a 2002 Ford F-150 and The problem is with the transmission my vechile acts like it's going in reverse and when it goes to backup it seems as something is locked I been over the brakes and rear end and yet nothing has came up I even replaced the transmission filter to see if that would help but nothing so I been having to drive my truck with no reverse and today the overdrive light on the shifter started blinking what is the problem with these transmission please Ford do a recall to fix the transmission
Engine, Jun 17, 2022
1. Coils on top of spark plug get moisture in them when there is just the right kind of rain storm. This makes the coil or coils fail until the dry out. This seems to make the coil eventually go bad. Yes, it is available for inspection. 2. Not sure if its a combination of heat and moisture but sometime right away and sometimes a few minutes into driving the coil or coils fail and the engine loses power. Then if seems to be a random, unpredictable occurrence until it dries out, Very Unsafe. If one coil fails it loses just a little power, but if more than one fails it loses a lot of power and stalls at times. This is why I am writing it up. A few time now, I have gone to pull into traffic and then I lose power and either have to run off the road or just upset the car behind me if they are not too close. 3 & 4. I have advise all the Ford dealerships in my area trying to find one that has a fix yet. The only fix Ford has, is a new designed coil, which does not appear to be any better. The dealership just replaces the coil. I have had all my coils replaced, some 2 or 3 times. 5. It depends, sometime the engine light will come on and advise which coil is misfiring and sometimes if does not. Right now my engine light is on and it displays the #6 coil misfire. Then the engine light will go out after it dries out and stops failing or it will stay off if the coil had gone bad again. I am sure its not just the F 150, but the 4.6 liter engine that is in other vehicles. I started keeping track in 2012. I wrote a letter to Ford in 2015 and they replied, there was no recall. I have several repair receipts and the letter from Ford if you need that. Just search on your site and you will see many complaints. One example Manufacturer Communication number: 041601. If you google "ford fix for moisture in coils" you will see many forums trying to figure out a fix and just complaining.
Structure, Jun 7, 2022
Left rear passenger door will not open. Door is jammed. This will not allow rear passengers to quickly exit vehicle if pinned in due to crash or fire.
Fuel/propulsion system, Apr 26, 2022
I was driving my truck and it began vibrating; shortly thereafter it was running as if half the engine was working , with a loss of power. I pulled the fuel filter and there was trash all in the filter. I bought another filter and replaced it and ran the truck again and it was working fine. Shortly thereafter the same thing happened again, loss of power, running like half the engine was working and then stalled. After a few minutes it started up but ran terrible. I got it home. I pulled the fuel filter and it was loaded with trash again. I called the Ford dealer and spoke to a mechanic and he advised he has fixed numerous trucks like mine and the gas tank was deteriorating from the inside and clogging my fuel filter. He said there is a recall for the truck and that the fuel tank needs to be replaced. Please help me as this truck only has 75,000 miles and is like brand new, garage kept and well taken care of. Thank you for your time in this matter and I look forward to hearing from you soon.
Seat belts, Feb 1, 2022
The contact owns a 2002 Ford Think Neighbor. The contact stated that after entering the vehicle and attempting to secure the front driver’s seat belt latch into the buckle, the seat belt latch failed to lock into place. The seat belt loosened and unlatched from the buckle while the contact was driving. The contact stated that the failure was intermittent. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.
Electrical system, Forward collision avoidance, Jul 21, 2021
I went to get a state inspection and a code came up Po174
Other or unspecified, Jul 16, 2021
This F 150 has experienced SUA. I have reported it back in June. I have tried to fix the problem but I cannot. I don't know what causes my truck to accelerate full throttle. So, I've come to the conclusion I must move on. Then I realized I really cannot sell the vehicle? Somebody would be killed no doubt. I've been lucky and savvy enough to slide the shifter into neutral. If I sell the truck and do not mention the problem? The thing is I could sell this truck in 5 minutes. It runs like a top spins. I have always taken care of any maintenance issues since purchasing new. I've educated myself on SUA. It's extremely interesting but if you've experienced it, it is awful. I read one story about a guy who wanted a Toyota dealership to take his Camry back. It was practically new. They would not. So he went to another dealership and traded it in. I can't blame the guy but I can not sell my truck and sleep at night. So what do I do with a truck that roars off like a rocket ship? How many people have had this problem? And what do they do with the car/truck once they realize it really cannot be driven anymore?
Other or unspecified, Jun 17, 2021
SUA sudden unwanted acceleration, at least 4 times. No floor mats. 1st time truck surged back and forth a little then accelerated full throttle. I went to neutral. I kicked gas pedal although gas peddle was not depressed. It stopped. I was shook up but in control. I decided to remove throttle body and clean extensively. Replaced TB Sensor w/ genuine Ford part and replaced throttle valve on top. Hoped for the best. Still have the problem. 2002 F 150 XL 4.2 purchased new. I still have truck because its been such a great truck, I never felt like it was time to move on. It runs like new and I've taken care of it. I am writing this info for safety and only safety. I've been researching this issue. trying to solve problem. I took truck to qualified shop where mechanic is known to me and he was a little stumped. No codes, no check engine light. Can't solve the puzzle? So, I'm on top of the possibility of it happening. I really don't go anywhere w/ truck, to the store and back pretty much. So when its happens, I'm fast to go to neutral. I also feel like if I wanted to show somebody what I'm talking about, all they have to do is get in. I'm almost positive if I punch the gas peddle just a little, say to pass a slow driver, it'll go like hell. I have started thinking about my next truck. But no way I'm trading or selling this truck and passing the problem to someone else. So, I'm dealing with it and really hope my experience helps. I've read the story's on line. Because I've lived it, I can tell you its a bit terrifying. That's my story Thank You Jim Winn
Electrical system, Jun 4, 2021
When it rains the rain is somehow getting into the fuse box under the steering column and causing it to drain the battery, short out some of the instrument cluster, make noise, blow fuses, and rust up. It is a fire hazard and it puts all inside the truck in danger. I have not yet had a fire but if I keep the truck as is it will eventually.
Air bags, Structure, Seats, Sep 26, 2020, crash
I WAS DRIVING ON FREEWAY WHEN A CAR THAT WAS TRAVELING IN AN EXCESS OF 80+ MILES AND REAR-ENDED MY 2002 FORD F 150. MY TRUCK WAS TOTALED AND MY DRIVERS SEAT BACK FRAME BROKE FROM RIGHT SIDE AND NONE OF MY AIRBAGS DEPLOYED. I ENDED UP IN THE HOSPITAL FOR 3 DAYS. I HAD A CONCUSSION, NECK INJURY, KNEES AND RE-INJURED MY BACK. I WAS LUCKY TO BE ALIVE.