2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: electrical system
153 reports, newest first. Show all
Electrical system, Apr 19, 2023, fire
The contact owns a 2001 Ford F-150. The contact stated that while the vehicle was parked and turned off the vehicle suddenly caught on fire and was destroyed. The fire department was called to the impoundment lot and extinguished the flames which came from the engine compartment. A fire report was taken at the scene. The cause of the fire was not determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 190,000.
Electrical system, Engine, Aug 19, 2021, fire
The contact owns a 2001 Ford F-150. The contact stated that while the vehicle was parked in the driveway flames were suddenly present coming from the engine compartment. The fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed. The cause of the failure was not determined. The local dealer and manufacturer were not notified. The contact indicated that prior to the fire the vehicle had not been driven or turned on for two days. The failure mileage was 89,000.
Electrical system, Exterior lighting, Service brakes, Apr 6, 2021
WE PURCHASED OUR 2001 F150 SUPERCREW USED. I AM A MECHANIC, SO THE FIRST THING I DO WHEN BUYING A USED VEHICLE IS INSPECT IT THOROUGHLY. THERE WERE A FEW MINOR ISSUES, BUT ONE STOOD OUT AS A MAJOR SAFETY HAZARD. UPON FURTHER RESEARCH, IT SEEMS TO BE EXTREMELY COMMON TO ALL 1997-2003 F-150S. SYMPTOMS - THIS ISSUE MAINLY AFFECTS THE REAR LEFT AND RIGHT BRAKE LIGHTS, TURN SIGNALS, AND HAZARD LIGHTS. THESE LIGHTS, PARTICULARLY BRAKE LIGHTS, CAN CEASE TO FUNCTION ENTIRELY, INTERMITTENTLY AND UNKNOWN TO THE DRIVER. CAUSE - THERE IS A WIRE HARNESS WHICH CONNECTS TO THE "MULTI - FUNCTION SWITCH". THIS WIRE HARNESS IS PULLED WHEN THE STEERING WHEEL IS TILTED DOWN. AS A RESULT, THE CONNECTOR OR INDIVIDUAL TERMINALS CAN BECOME LOOSE OR DISCONNECTED. THIS PROBLEM IS MOST PREVALENT WITH THE STEERING WHEEL IN THE DOWN POSITION, BUT ONCE LOOSE CAN HAPPEN AT ANY POSITION AND ANY DRIVING SITUATION. SOLUTION - REPAIR OR REPLACE WITH MOTORCRAFT PART# WPT607, AND ENSURE THE HARNESS HAS ENOUGH SLACK TO ALLOW STEERING WHEEL TILT WITHOUT TENSION ON THE HARNESS. IN OUR CASE, I REPLACED THE CONNECTOR AND PULLED THE WIRES ENOUGH TO ALLOW SLACK FOR STEERING WHEEL TILT. THERE ARE NUMEROUS REPORTS OF THIS ISSUE ONLINE, AND IT IS WELL DOCUMENTED BY F150 OWNERS. I HAVE PICTURES BUT THE FILE SIZES ARE OVER 5MB.
Electrical system, Engine, May 26, 2020, fire
CAUGHT ON FIRE UNDER THE HOOD DRIVER SIDE WIRE WALL AREA.*DT CONSUMER STATED ORIGINAL COMPONENTS AND PARTS WERE MELTED AND DAMAGED.*JB
Electrical system, Fuel/propulsion system, May 15, 2019, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE OPERATING THE VEHICLE, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED EXTENSIVE RED SMOKE AND FIRE UNDER THE FRONT END OF THE VEHICLE. THE FIRE SPREAD TO ANOTHER VEHICLE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A FIRE INSPECTION REPORT WAS PROVIDED. TWO VEHICLES HAD BEEN IMPACTED DUE TO THE FIRE. THE INSURANCE COMPANY HAD NOT YET INSPECTED THE VEHICLE. THE CONTACT WAS NOT AWARE OR NOTIFIED OF A SPEED CONTROL SYSTEM MODIFICATION FROM JANUARY 27, 2005 AND NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) AS OF JULY 29, 2011. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 275,000.
Electrical system, Apr 8, 2017, fire
THE TRUCK WAS PARKED OUT FRONT OF MY HOUSE ON THE STREET AND IT CAUGHT FIRE.
Electrical system, Vehicle speed control, Service brakes, Sep 28, 2015, crash
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE REVERSING, THE VEHICLE CRASHED INTO A TELEPHONE POLE WHEN SHIFTING THE GEAR INTO DRIVE. THE VEHICLE ACCELERATED TO APPROXIMATELY 70-80 MPH. THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO STOP THE VEHICLE. THE VEHICLE CRASHED INTO A GARAGE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Electrical system, Other or unspecified, Engine, Sep 20, 2015, fire
ALL I KNOW IS I WAS AT A NEIGHBORS FOR AROUND 1 1/2 HOURS AND WE HEAR A LOUD BOOM. WE RAN OUT SIDE AND MY TRUCK HOOD WAS ON FIRE, IT BURNED EVERYTHING VISIBLE ON TOP OF THE MOTOR AND TOWARD THE DRIVER FIREWALL . IT BUSTED THE DRIVER SIDE TIRE AND COMPLETELY BURNED EVERYTHING VISIBLE UNDER THE HOOD. THE DASH COMPONENTS AS FAR AS THE EYE CAN SEE ARE NOT BAD, UNKNOWN OF INTERNAL DAMAGE.I'M NOT SURE WHAT CAUSED THE PROBLEM. I DID GO TO THE RECALL SITE TO SEE IF THERE MAY HAVE BEEN SOMETHING I DID FIND THIS CONTROL SWITCH FOR SPEED RECALL AND NOT SURE IF IT APPLIES TO MINE.EVEN THOUGH IT BROUGHT IT UP WHEN I ENTERED MY VIN #. I DID RECEIVE A RECALL ON THE GAS TANK STRAPS BUT DID NOT REPLACE THEM THEY WERE IN GREAT SHAPE. BUT I DID NOT RECEIVE ON ON THIS. I DO HAVE PICTURES IF YOU NEED THEM. THANKS
Electrical system, Exterior lighting, Jun 16, 2015
TURN SIGNAL ARE NOW SPORADIC. UPON INVESTIGATING I FOUND THAT WHEN THE TILT IS ENGAGED AND LOWERED THE TURN SIGNALS WOULD NOT WORK. RAISE STEERING WHEEL BACK UP IT WOULD WORK. START TO DRIVE DOWN THE ROAD THEY WOULD TURN OFF OR NOT WORK AT ALL OR WOK SOMETIMES. RAISE THE STEERING WHEEL THEY WORK. LOWER IT THEY DON'T. THIS INDICATES FROM FURTHER RESEARCH ON LINE IN FORD F150 FORUMS THIS IS A PROBLEM WITH THE WIRING BEING TO SHORT AND THE WIRES GET PULLED OUT OF THE SWITCH. IT IS A VERY COMMON OCCURRENCE IN F!%) FROM 98 UP TO 2004 AND ARE NOW BEING REPORTED IN NEWER MODELS AS WELL. THIS IS A SEVERE SAFETY HAZARD FOR DRIVERS AND PASSENGERS AND DRIVERS BEHIND THE VEHICLES.AND SHOULD BE REMEDIED BY FORD AT NO EXPENSE TO THE OWNERS.
Electrical system, Jun 11, 2015
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE AUTO THEFT SENSOR ILLUMINATED SEVERAL TIMES AND CONTINUED TO ILLUMINATE RANDOMLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO REPLACED THE KEY, BUT THE FAILURE RECURRED. THE CONTACT CONTINUED TO HAVE EXTREME DIFFICULTY WITH TURNING THE KEY TO START THE IGNITION AND THE AUTO THEFT WARNING LAMP CONTINUED TO ILLUMINATE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Electrical system, Structure, Engine, Apr 26, 2015, fire
I PARKED, WALKED INSIDE...MOMENTS LATER THE TRUCK WAS ON FIRE.. *TR
Electrical system, Nov 4, 2014, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT SHE NEVER RECEIVED A RECALL NOTICE FOR THE VEHICLE NOR WERE ANY WARNING LIGHTS ILLUMINATED. THE VIN ASSOCIATED WITH THE VEHICLE IS LISTED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE CONTACT DROVE THE VEHICLE ON SATURDAY. ON WEDNESDAY, THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS NOT TOWED TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.
Steering, Electrical system, Engine, Aug 22, 2014, fire
THE TRUCK WAS PARKED IN MY DRIVEWAY FOR AT LEAST 24 HOURS WITHOUT BEING USED OR TURNED ON. THE FRONT OF THE TRUCK SUDDENLY WENT ON FIRE. THE FIRE DEPARTMENT CAME AND PUT IT OUT. THE FIRE BURNED ONLY THE FRONT UP TO THE WINDSHIELD LEAVING THE CAB PARTIALLY MELTED AND MY DAUGHTERS CAR SEAT UNSAFE. NOW THIS MESS SITS IN MY DRIVEWAY AS I WAIT FOR INSPECTOR. AS IT FALLS APART MORE AND MORE EACH DAY AS MY FAMILY AND NEIGHBORS SMELL THE BURNT RUBBLE AND ARE REMINDED OF THAT FRIGHTENING AFTERNOON. *TR
Electrical system, Oct 7, 2013, fire
VEHICLE WAS NOT IN USE- PARKED AND NOT ON SMOKE AND FIRE CAME FROM UNDER HOOD THE WIRING MELTED CAUSING THE HOOD TO MELT UNDERNEATH WHERE IT CAN NOT BE OPENED. *TR CONTACTED FORD ON MONDAY JUNE 24 WAITED FEW WEEKS FOR PAPER WORK- PROMPTLY FILLED IT OUT AND NEVER HEARD BACK FROME THEM- MADE SEVERAL CALLS RECEIVED A LETTER FROM LEGAL DEPARTMENT INDICATING THEY NEED THE PART TO REVIEW WE WANTED FORD TO COME TO LOOK AT TRUCK AND RETIREVE THE PART THEY ARE NOT WILLING AND ARE CLOSING THE CASE THERE IS A RECALL ON THIS AND MY FAMILY WAS IN THE TRUCK THAT MORNING- WE RE LUCKY NO ONE WAS KILLED
Electrical system, Jun 23, 2013
2001 F150 XLT 4.2 V6 ELECTRONICAL CONTROL MODULE (ECM) SHORTED OUT CAUSING MALFUNCTION TO MY LIGHTS WINDOWS AND ALARM AND MY LOCKS AS WELL WHICH IS A THEFT CONCERN AND FIRE HAZARD AS WELL. I FEEL IN MY OPINION THAT THIS ISSUE SHOULD BE ADDRESSED AND SHOULD BE UNDER RECALL AND FIXED UNDER FORD I SPOKE WITH A TECH AT A FORD DEALERSHIP NEAREST ME AND HE TOLD ME THAT FORD HAS NOT STEPPED UP AND SAID ANYTHING. I FEEL THIS NEEDS TO BE ADDRESSED AND IS A BIG CONCERN FOR ME AND IM SURE ITS A CONCERN FOR OTHERS AS WELL. SO FORD IF YOU WANT BUSINESS AND YOU LOVE YOUR CUSTOMERS THIS WILL BE FIXED. *TR
Electrical system, Apr 15, 2013, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED AND OCCUPIED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE AND POLICE DEPARTMENT REPORTED TO THE SCENE AND FILED A REPORT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000. *TR
Electrical system, Engine, Mar 20, 2013
I KEEP HAVING MAJOR ISSUES WITH MY TRUCK EJECTING SPARK PLUGS FROM THE ENGINE WHICH IS BREAKING NOT ONLY MY SPARK PLUGS BUT MY COIL PACK AS WELL. THIS IS REDICULIOUS. THE FIRST TIME I WAS AT A LIGHT AT A DEAD STOP WHEN I HEAR A LOUD BANGING NOISE LIKE SOMETHING EXPLODED THEN MY TRUCK STARTED RUNNING ROUGH AND HAD TO GET IT TOWED. IT STRANDED US 45 MINUTES FROM HOME. THE SECOND TIME WAS TWO DAYS AGO ON MARCH 18 I WAS DRIVING THROUGH A DRIVE THRU AGAIN AT A DEAD STOP AND HEARD A LOUD NOISE AND HAD THE SAME ISSUE. AGAIN MY SPARK PLUG WAS EJECTED AND COIL PACK BROKEN. THE FIRST TIME WAS IN CYLINDER 1 AND WAS REPAIRED THEN ONE MONTH LATER THE NEXT TIME CYLINDER 2 EJECTED. 5 MINUTES AFTER IT WAS REPAIRED AND HAD NEW PLUG AND COIL PACK IT AGAIN EJECTED. IM UPSET BECAUSE I CAN NO LONGER DRIVE MY TRUCK. IF FORD DOESNT FIX THIS I WILLNEVER PURCHASE ANOTHER FORD. NOW IT IS USELESS SITTING IN MY GARAGE TAKIN UP SPACE. *TR
Electrical system, Feb 6, 2013, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
Electrical system, Engine, Dec 5, 2012, fire
2001 FORD F150 WAS SITTING OUT IN DRIVEWAY OF OWNER'S HOME. HE HAD BEEN HOME APPROX 1/2 HOURS WHEN OWNERS VEHICLE WAS ON FIRE COMING FROM THE ENGINE COMPARTMENT. NO FIRE DAMAGE TO THE INSIDE CAB OF OWNERS VEHICLE. *TR
Electrical system, Structure, Sep 22, 2012, fire
CAR WAS SITTING IN DRIVEWAY FOR AROUND 30 -45 MINUTES THEN JUST SET FIRE. *TR
Electrical system, Exterior lighting, Sep 4, 2012
REAR LIGHTS, INCLUDING BRAKE, TURN SIGNALS, AND HAZARD LIGHTS QUIT WORKING. THIS ISSUE CAN BE FOUND ON MANY ONLINE FORD F-150 FORUMS. THE STEERING COLUMN WIRING IS TOO SHORT, AND BREAKAGE IN THE WIRE, OR CONNECTORS CAN OCCUR WITH THE TILT STEERING MECHANISM. THE TILT STEERING MECHANISM AND SHORT WIRING HAS CAUSED THE CONNECTION TO BREAK INSIDE THE STEERING COLUMN TRIM ON OUR VEHICLE, WHICH CAUSED THE LIGHTS TO STOP FUNCTIONING PROPERLY. I INSPECTED THE PROBLEM, AND FOUND THE CONNECTOR CAN MOVE FREELY. I FEEL THIS IS AN ISSUE SINCE I AM ABLE TO LOCATE MANY OTHERS THAT HAVE HAD THE SAME ISSUE FROM 1997 UP TO 2001 FORD F-150S. *TR
Electrical system, Engine, Jun 26, 2012
AS I WAS LEAVING A STOP SIGN, I ACCELERATED AND A SPARK PLUG BLEW OUT OF IT'S HOLE AND WILL NOT GO BACK IN. THIS IS A PRODUCT DEFECT THAT CAN CAUSE SERIOUS INJURY OR DEATHS TO UNKNOWING FORD OWNERS. FORD SHOULD RECALL ASAP. *JB
Electrical system, Vehicle speed control, Mar 2, 2012, fire
ON OR ABOUT 2004, COMPLAINANT PURCHASED A FORD TRUCK, F-150, SUPERCREW, 4X2, MODEL 2001. COMPLAINANT OWNS AND LIVES IN A HOUSE. SAID HOUSE HAS A GATE CARPORT. BY SEPTEMBER 20, 2011, THE ABOVE REFERENCED VEHICLE HAD BEEN PARKED AND TURNED OFF FOR ABOUT ONE (1) WEEK IN THE GATED CARPORT OF COMPLAINANTS HOUSE. ON SEPTEMBER 20, 2011, SOMETIME BETWEEN 12:00PM AND 1:00PM THE ABOVE REFERENCE VEHICLE BEGAN TO BURN INSIDE THE CARPORT. THE FLAMES AND THE SMOKE FLOWING FROM THE VEHICLE EXPANDED INTO COMPLAINANTS HOUSE CAUSING DAMAGES TO THE STRUCTURE AND A MYRIAD OF MOVABLE OBJECTS LOCATED THEREIN. ACCORDING TO COMPLAINANTS FORENSIC EXPERT, THE VEHICLE BEGAN TO BURN AS A RESULT OF A FAILURE IN THE VEHICLE'S CRUISE CONTROL SWITCH DEACTIVATOR. *TR
Engine and engine cooling, Electrical system, Feb 6, 2012
SPARK PLUG BLEW OUT OF ENGINE CAUSING FAILURE. ENGINE. *TR FIRE
Electrical system, Jan 5, 2012, fire
MY F150 BLOWER MOTOR UNIT JUST SHORTED OUT AND CAUGHT FIRE WHILE I WAS ON THE FREEWAY. I AM JUST SO DISGUSTED AS I ALREADY GOT PAST BLOWING OUT SPARKPLUGS ON THIS TRUCK AS I HAD TO REMOVE THE HEAD AND RE THREAD IT SO THEY WOULD BE SAFE AND NOW THIS. HOW DOES FORD CONTINUE TO GET A AWAY WITH PRODUCING VEHICLES THAT ARE DANGEROUS TO THE PUBLIC? I LOVED MY TRUCK BUT WILL PROBABLY HAVE TO MOVE TO A SAFER VEHICLE NOW. *TR