2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: electrical system
153 reports, newest first. Show all
Electrical system, Jul 7, 2004, fire
CAME HOME FROM WORK. LEFT IN ANOTHER VEHICLE. RECEIVED PHONE CALL FROM LANDLORD THAT TRUCK WAS ON FIRE AND HAD CAUGHT HOUSE ON FIRE. FAMILY FORCED TO MOVE AFTER HAVING ONLY MOVED TO THIS HOME 2 WEEKS PRIOR. TRUCK DESTOYED AS WELL AS HOME AND FURNISHINGS AND PERSONAL BELONGINGS. EXTENSIVE EXPENSE AND EMOTIONAL TRAUMA. *AK VEHICLE PARKED
Electrical system, Jul 6, 2004, fire
VEHICLE HAD APPROX. 60K MILES. WAS PARKED IN DRIVEWAY FOR ABOUT ONE HALF HOUR. NEIGHBOR SAW FIRE ON THE GROUND UNDER THE DRIVERS SIDE OF THE ENGINE COMPARTMENT TOWARD THE REAR(FIREWALL). CRUISE CONTROL QUIT WORKING ABOUT 2 WEEKS PRIOR TO THE FIRE. FIRE ORIGIN IS IN VICINITY OF BRAKE MASTER CYLINDER. TYPICAL OF CRUISE CONTROL DEACTIVATION SWITCH FAILURE. PARTS WERE RECOVERED BUT ALUMINUM BAND ON HEXPORT BODY WAS MELTED AWAY THEREFORE DO NOT HAVE DATE CODE. *JB
Electrical system, Jul 6, 2004
WHILE DRIVING 20 MPH CONSUMER HEARD A LOUD NOISE COMING FROM THE FRONT. CONSUMER PULLED OVER, AND HAD THE VEHICLE TOWED TO A DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE CYLINDER HEAD NEEDED TO BE REPLACED DUE TO A SPARK PLUG BLOWOUT. *AK *NM
Electrical system, Jul 3, 2004
2001 FORD F150 32,000 MILES. BLEW #3 SPARK PLUG ON THE DRIVERS SIDE. FORD MOTOR CORP HAD TO REPLACE THE CYLINDER HEAD.*AK
Electrical system, Structure, Equipment, May 25, 2004
I HAD SOME WARRANT ISSUES WITH FORD MOTOR CORPORATION. TRIM AROUND WINDSHIELD,FADED GRILL AND BASE NOT WORKING ON RADIO. THE BIGGEST PROBLEM HAS SOMETHING TO DO WITH THE AC AND EMISSIONS. I TURNED ON THE AC AND THE TRUCK STARTED TO RUN BAD JERKING AND SPUTTERING. TOOK IT TOO FORD AND THEY REPLACED A SENSOR. THIS SUMMER THE FIRST TIME I TURN ON MY AC AND THE SAME PROBLEM THIS TIME ITS NOT COVERED BY WARRANTY. I HAVEN'T PUT 14K MILES ON THE TRUCK. DOES EMISSIONS HAVE SOME TYPE OF EXPECTATIONS SET BY THE EPA OR DOT. IT COST $400. TO GET SENSOR REPLACED. I CANT AFFORD TO REPLACE A SENSOR EVER SUMMER I TURN ON MY AC. *NM
Electrical system, May 12, 2004, fire
NOTICED CRUISE CONTROL WENT OUT DID NOT THINK MUCH ABOUT IT. SMELLED BURNING DROVE INTO MY DRIVE WAY WENT IN HOUSE STARTED DINNER MY HUSBAND WENT OUT TO RUN TO THE CORNER STORE AND MY TRUCK WAS ON FIRE. BURNT INSIDE OF ENGINE YES OLD PARTS ARE THERE NOTHING HAS BEEN REPAIRED AS OF YET. VERY DANGEROUS SITUATION COULD OF BEEN HURT OR MY CHILD COULD OF BEEN HURT. COULD OF BEEN PROPERTY DAMAGE IF I HAD NOT CAUGHT THE FIRE WHEN I DID COULD OF BURNED MY HOUSE DOWN AND OTHERS AROUND ME.
Electrical system, May 4, 2004
1. DRIVING ALONG NORMALLY WHEN A SPARK PLUG BLEW OUT OF PASSENGER SIDE HEAD ON MY 2001 FORD LIGHTNING. 2. HAD TO PULL TO THE SIDE OF THE ROAD IN HEAVY TRAFFIC & WAIT ~2 HOURS FOR A TOW TRUCK & ANOTHER DAY TO HEAR ANYTHING FROM THE DEALERSHIP.*AK 3. VEHICLE WAS STILL UNDER WARRANTY, DEALER REPLACED PASSENGER SIDE CYLINDER HEAD.
Electrical system, Apr 1, 2004
SPARK PLUGS BLEW OUT WHILE DRIVING BECAUSE ONLY 4 TREAD WAS SCREWED IN. MANUFACTURER WAS AWARE OF THIS ISSUE, AND CHANGED THE NEWER MODEL SPARK PLUG. NEWER MODEL SPARK PLUGS HAVE 10 TREAD SCREWED IN. *AK
Electrical system, Apr 1, 2004
WHILE THE VEHICLE WAS UNDER WARRANTY IT EXPERIENCED PROBLEMS WITH THE TURN SIGNAL. THE TECHNICIAN STATED THAT THEY REPLACED THE WIRING HARNESS BUT IT WAS TOO SHORT. CURRENTLY WITHOUT WARRANTY THE VEHICLE EXPERIENCED THE SAME PROBLEM. THE VEHICLE HAD BEEN TAKEN TO THE SAME DEALER WHO STATED THAT THE WIRING HARNESS WAS TOO SHORT. *AK THE WIRING HARNESS WAS TOO SHORT WHEN THE TILT WHEEL WAS DOWN AND THE TURN SIGNALS DID NOT WORK. *SC *JB
Electrical system, Feb 5, 2004, fire
A FIRE STARTED AT WINDSHIELD WIPER CIRCUIT BOARD WHILE THE VEHICLE WAS BEING STARTED. THE MANUFACTURER AND DEALER WERE NOTIFIED. *NM
Electrical system, Equipment, Jan 7, 2004
SPARK PLUGS WORKING LOOSE AND EJECTING FROM CYLINDAR HEADS DUE TO INSUFFICIANT THREADS IN POOR HEAD DESIGN. *AK
Electrical system, Oct 27, 2003
WHILE DRIVING 50 MPH CONSUMER HEARD A POPPING SOUND AND STARTED SMELLING FUEL ODOR. CONSUMER PULLED OVER TO THE SHOULDER, FOUND OUT THAT A SPARK PLUG EJECTED OUTWARDS AND CRACKED ONE OF THE ENGINE HEADS.*AK
Electrical system, Sep 30, 2003
WATER GATTING TO THE SPARK PLUG CAVITY FROM SMALL PUDDLE CAUSING FOULING
Electrical system, Sep 15, 2003
STARTER ON F-150 SOMETIMES "GRINDS" AS IF ENGINE IS RUNNING WHEN FIRST STARTING ENGINE. HAPPENS SPERATICALLY. ONCE EVERY TWO TO THREE MONTHS. MORE OFTEN DURING COLDER WEATHER.
Electrical system, Aug 27, 2003, fire
BATTERY MELTDOWN AND BATTERY CABLE BURNOUT. *AK
Electrical system, Aug 19, 2003
I CAN'T START MY CAR. THE KEY WILL NOT START THE IGNITION, IT IS STUCK ! THIS HAS HAPPENED OVER THE LAST 2 MONTHS. GETTING WORSE!*AK
Fuel system, Gasoline, Electrical system, Aug 5, 2003
2001 FORD F-150 CRANK NO START CONDITION.BETWEEN JUNE AND AUGUST OF 2003 MY FORD F-150 HAS BEEN TOWED IN THREE TIMES AND NOT STARTED AT LEAST TWO DOZEN TIMES. THE FIRST DEALER REPLACED THE MAIN FUEL RELAY. THE SECOND TIME IT WAS TOWED TO ANOTHER DEALER AND AFTER FIVE DAYS COULD NOT REPRODUCE THE PROBLEM, AND I PICKED THE TRUCK UP. TWO DAYS LATER THE SAME THING, THIS TIME I HAD THE TRUCK TOWED TO MY HOUSE. A FEW HOURS LATER IT STARTED. AT THIS POINT I'M GETTING VERY IRRITATED. AFTER GOING BACK THRU THIS WHOLE THING I STARTED THINKING IT HAD TO BE THIS MAIN FUEL RELAY AND DECIDED TO DO SOME TESTING ON MY OWN. I WORK IN ELECTRONICS AND SO I GOT A COUPLE TYCO RELAYS AND A CAN OF FREEZE SPRAY. THE NEXT TIME THIS HAPPENED I PULLED THE FORD RELAY AND REPLACED IT WITH A NEW ONE - THE TRUCK STARTED RIGHT UP. THE NEXT TIME I GET THE CAN OF FREEZE SPRAY OUT AND COOL THE RELAY AND THE TRUCK STARTS UP. IM FINDING THIS TO BE WARM WEATHER RELATED AND EVERY TIME IT GET HOT OUTSIDE I CAN PLAN ON THE TRUCK NOT STARTING AFTER DRIVING A SHORT TIME AND THEN SHUTTING OFF. IF THE TRUCK SITS BY ITSELF LONG ENOUGH FOR THE RELAY TO COOL DOWN IT WILL START I THINK FORD SHOULD COME UP WILL A LONG TERM FIX FOR THIS PROBLEM INSTEAD OF REPLACING RELAYS.*AK
Service brakes, Hydraulic, Electrical system, May 19, 2003
FRONT AND REAR BRAKES WERE OUT OF ROUND. FRONT WERE 1.022 AFTER CUT .994 USING A LATHE. REAR WERE .471 BEFORE CUT. 452 AFTER CUT. SALES REP TOLD ME IT WAS DUE TO CORROSION. REPLACED IGNITION SWITCH ON SEPT.12 2002 I LOST POWER ON MY POWER DOOR LOCKS WINDSHIELD WIPERS . *JB
Electrical system, Apr 21, 2003
THE VEHICLES WIRING HARNESS RUBBED AGAINST THE AIR CONDITIONING UNDER THE HOOD WHICH CAUSED NUMEROUS SHORTS IN THE FUEL INJECTION SYSTEM. THE VEHICLE IS A 2001 FORD TRITAN V80 TRUCK. *NLM *SCC
Electrical system, Apr 3, 2003, fire
THERE WAS A FIRE IN THE DASH. MR SCC *JB
Electrical system, Feb 18, 2003
SPARKPLUG BLOWN OUT OF ENGINE HEAD
Electrical system, Nov 4, 2002
CONSUMER STATES THAT IT WILL BE HARD TO START THE VEHICLE AND THEY WILL HAVE TO TRY NUMEROUS OF TIME BEFORE THE VEHICLE WILL START. DEALER NOTIFIED. MR
Suspension, Engine and engine cooling, Electrical system, Exterior lighting, Aug 7, 2002
HAVE HAD PROBLEMS WITH THIS VEHICLE AT 1900 MILES. SUSPENSION, FUMES, BRAKES, SIGNAL SWITCH, ELECTRICAL SHORTAGES.
Electrical system, Jul 26, 2002
A SHORT IN WIRING CAUSING HORN TO GO OUT WHILE DRIVING. DEALER NOTIFIED.*AK
Electrical system, Jun 5, 2002
AFTER INSPECTION OF VEHICLE, MECHANIC NOTICED THAT MAIN GROUND WIRING WAS HANGING WHICH COULD RESULT IN A SHORT CIRCUIT OR POSSIBLE FIRE. *AK DEALER FOUND MAIN GROUND CABLE DISCONNECTED. *TT