2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
263 reports, newest first. Show all
Engine and engine cooling, Fuel system, Gasoline, Jul 26, 2010, fire
WHILE DRIVING ON THE FREEWAY, I HEARD A LOUD POP FROM THE ENGINE COMPARTMENT FOLLOWED BY THE ENGINE RUNNING ROUGHLY AND ACCOMPANIED BY POPPING SOUNDS. WITHIN 10 SECONDS, THE SMELL OF GASOLINE WAS NOTICED. I PULLED OFF AT THE NEXT EXIT, APPROXIMATELY 30 SECONDS LATER, AND CAME TO A STOP. AS I CAME TO A STOP, FLAMES ERUPTED FROM THE HOOD AND THE ENTIRE ENGINE COMPARTMENT WAS ENGULFED IN FLAMES. A FIRE TRUCK ARRIVED WITHIN A FEW MINUTES AND EXTINGUISHED THE FIRE, BUT NOT BEFORE THE FIRE HAD BURNED THROUGH THE FIREWALL INTO THE PASSENGER COMPARTMENT. THE VEHICLE WAS A TOTAL LOSS. UPON FURTHER INSPECTION, IT WAS DISCOVERED THAT THE #8 CYLINDER SPARK PLUG HAD EJECTED FROM THE CYLINDER (THE INITIAL POP SOUND) WITH SUCH FORCE THAT IT RUPTURED THE RUBBER FUEL LINE IMMEDIATELY ABOVE IT AND AFT OF THE STAINLESS FUEL INJECTOR BAR. WITH FUEL SPRAYING FROM THE HOSE, IT WAS THEN IGNITED BY THE COIL WHICH WAS STILL ATTACHED TO THE ENGINE AND EMITTING SPARKS. IT HAS BEEN DOCUMENTED THAT THE CYLINDER HEAD DESIGN IN THIS VEHICLE HAS HAD A HISTORY OF PROBLEMS WITH EJECTING SPARK PLUGS DUE TO A LACK OF ADEQUATE THREADS IN THE SPARK PLUG HOLES. I BELIEVE THIS DEFECT CONTRIBUTED DIRECTLY TO THIS FIRE AND IS A SAFETY HAZARD. *TR
Engine and engine cooling, Jul 16, 2010, fire
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THE VEHICLE WAS PARKED IN FRONT OF HIS RESIDENCE AND CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS AVAILABLE. THE VEHICLE WAS DESTROYED. THE DEALER ADVISED THAT THE VEHICLE WAS NOT UNDER RECALL AND DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 158,000.
Engine and engine cooling, Jul 10, 2010
SPARK PLUG BLOW OUT ON MY 2001 FORD F-150 EXPENSIVE REPAIR TO REPLACE SPARK PLUGS. DEALER WANTS ME TO PURCHASE A NEW CYLINDER HEAD. *TR
Engine and engine cooling, Jun 15, 2010
I HAVE A 2001 FOCUS ZX3 - 5SP THAT TENDS TO STALL WHEN THE AC IS ON. BUT IT MAY NOT STALL DURING THE "INITIAL" USE PERIOD. WITHOUT WARNING, IT WILL STALL AFTER THE VEHICLE IS TURNED OFF AND THEN RESTARTED. MY SERVICE SHOP CHECKED THE COMPUTER CODES FOR A PROBLEM AND NOTHING CAME UP. YESTERDAY, IT WAS DRIVEN FOR ABOUT 30MINS WITH THE AC ON (OUTSIDE TEMPERATURE AROUND 80+ DEGREES). THE VEHICLE RAN FINE WITH THE RPMS NORMAL WHEN STOPPED. THE VEHICLE WAS TURNED OFF FOR ABOUT 90 MINS. WHEN ATTEMPTING TO RESTART IT WOULD STALL. TO GET STARTED I NEEDED TO KEEP FOOT ON GAS PEDAL (TO MAINTAIN A HIGH ENOUGH RPM TO PREVENT THE STALL). IF I DID NOT KEEP THE RPMS UP, VEHICLE WOULD STALL. WHILE DRIVING AND STOPPING, I NEEDED TO KEEP MY FOOT ON THE GAS PEDAL TO MAINTAIN THE RPMS. (THIS CAN BE CHALLENGING WITH A 5-SPD.) THE VEHICLE WAS THEN PARKED FOR OVER FOUR HOURS. IT THEN STARTED WITHOUT PROBLEM AND RAN NORMALLY. DURING THIS PERIOD I DID NOT HAVE THE AC ON. I SEE THAT THIS MAY BE A COMMON PROBLEM WITH THE FOCUS. HOWEVER, NEITHER FORD MOTOR'S CUSTOMER SERVICE LINE NOR THE LOCAL FORD DEALER ARE AWARE OF THE PROBLEM. THE VEHICLE WAS TAKEN TO A FORD DEALERSHIP (ECHELON FORD) ON 6/8/10 FOR A DIAGNOSTIC OF THE PROBLEM AND THEY COULD NOT RECREATE IT. I WAS CHARGED $108 FOR THE SHOP TIME AND STILL HAVE NO TECHNICAL ANSWER TO THIS CRITICAL AND POTENTIALLY FATAL PROBLEM... *TR
Engine and engine cooling, Jun 11, 2010
SPARK PLUG #3 HAS BLOWN OUT OF CYLINDER HEAD ON TWO OCCASIONS. THIS SECOND OCCURRENCE DAMAGED THE THREADS REQUIRING REPAIR WITH A HELICOIL KIT. THIS DEFECTIVE HEAD CAN CAUSE FIRE HAZARD. *TR
Engine and engine cooling, Jun 8, 2010, fire
2001 FORD F150 WAS PARKED FOR 4-5 DAYS IN DRIVEWAY. WOKE UP EARLY A.M. TO LOUD THUMB NOISE. LOOKED OUT, TRUCK WAS ENGULFED IN FLAMES. FIRE DEPTS SAYS IT LOOKS LIKE IT WAS ELECTRICAL AND FROM UNDER HOOD. TRUCK IS A TOTAL LOSS. INSURANCE CO. HAS YET TO LOOK AT TRUCK. *TR
Engine and engine cooling, Jun 7, 2010
2001 FORD F-150 WITH A 4.6 TRITON-2 SPARK PLUGS BLEW OUT OF THE HEAD ON THE DRIVER'S SIDE. HAD THEM REPAIRED AND THEY BLEW OUT AGAIN A MONTH LATER. *TR
Engine and engine cooling, May 18, 2010
2001 FORD F150 5.4L CRACKED INTAKE MANIFOLD. CRANKED TRUCK AND SAW ANTIFREEZE LEAKING FROM PASSENGER SIDE OF INTAKE. GETTING MOTOR FIXED AND HAVE VERIFIED IT TO BE CRACKED MANIFOLD. *TR
Engine and engine cooling, Apr 20, 2010
TL*THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED WHEN STARTING THE VEHICLE THE ENGINE WOULD EXHIBIT A CONTINUOUS INCREASE AND DECREASE IN ENGINE RPMS. WHILE DRIVING AT SPEEDS OF AT LEAST 20 MPH, THE ENGINE WOULD IDLE TREMENDOUSLY LOUD AND THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC HE PERFORMED AN OIL CHANGE. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO A SECOND MECHANIC. THE MECHANIC REPLACED THE MASS SENSOR HOWEVER; THE REPAIR DID NOT CORRECT THE FAILURE. THE MECHANIC THEN ADVISED CYLINDER THREE HAD MISFIRED. THE FAILURE HAD NOT YET BEEN CORRECTED TO DATE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 62,052.
Engine and engine cooling, Apr 5, 2010
TWICE, THREE WEEK APART I HAVE HAD ORIGINALL FACTORY INSTALLED SPARK PLUGS EJECTED FROM THE HEAD ON MY 2001 FORD F150 TRITON 5.7 LITER ENGINE. NUMBER 2 PLUG WAS FIRST AND NUMBER 3 PLUG WAS NEXT ALONG WITH THE CD COIL PACKS. *TR
Engine and engine cooling, Mar 27, 2010
I OWN A 2001 FORD F150 WITH A 5-4 TRITON MOTOR.HAD A SPARK PLUG BLOWOUT WHILE ON THE FREEWAY,IT OCCURED ON NUMBER 3 CYLINDER AND 2 MORE THAT WERE LOOSE ON THE ENGINE.MECHANIC REPAIRED BY INSTALLING AN INSERT DO TO STRIPPED OUT THREADS.ALSO WHEN THE PLUG BLEW OUT IT DAMAGED THE COIL PACK.I SAVED THE PARTS THAT WERE REPLACED.
Engine and engine cooling, Mar 22, 2010
TL*THE CONTACT OWNS A 2001 FORD F150 LIGHTNING SBT. THE CONTACT STATED THAT THE SPARK PLUGS ARE BLOWN FROM THE ENGINE. WHILE DRIVING 45 MPH THE SPARKS PLUG BLEW OUT WHILE THE ENGINE WAS RUNNING. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THEY REPLACED THE SPARK PLUGS. THE MANUFACTURER WAS CALLED AND INFORMED HIM TO CALL NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS 56,000.
Engine and engine cooling, Mar 9, 2010
FORD F150 SPARK PLUG # 8 BLOW OUT WHILE DRIVING TO WORK. THERE WERE NOXIOUS FUMES THAT EVENTUALLY BECOME VERY STRONG. I HAVE READ NUMEROUS COMPLAINTS ABOUT THIS AND FEEL THAT THIS MUST BE A SAFETY HAZARD DUE TO OBVIOUS RAW FUEL, HEAT AND POTENTIAL SPARKS. *TR
Engine and engine cooling, Mar 2, 2010, fire
2001 FORD F-150 LARIAT..5.4 CU .IM ENGINE. MULTIPLE SPARK PLUGS SELF EXTRACT ..AFTER 50,000 MILES, CREATING POSSIBLE FIRE HAZARD. NO WARNING WHEN IT WILL OCCUR. THIS HAPPENS IN SPITE OF ROUTINE NORMAL MAINTENANCE BEING PERFORMED. WHEN THE PLUG POPS OUT IT ALSO BREAKS THE IGNITION COIL TAB FOR THIS CYLINDER THUS MAKING THE CYLINDER INOPERATIVE WITH THE POSSIBILITY OF RAW GASOLINE/ETHANOL BEING EJECTED NEXT TO A UNCONTROLLED SPARK FROM THE LOOSE COIL. VERY DANGEROUS,ESPECIALLY WITH MY WIFE AND KIDS IN THE VEHICLE. THERE HAS BEEN NO NOTIFICATION FROM FORD OF THIS POSSIBILITY. THIS HAS HAPPENED TO AT LEAST A FEW DOZEN TIMES TO VEHICLES IN MY LOCAL AREA. IN FACT, IT MUST BE A FREQUENT SITUATION BECAUSE THERE ARE AFTER MARKET REPAIR KITS.. HELI-COIL INSTALLATION (NOT A PERMANENT REPAIR). THE REPAIR FROM FORD IS TO REPLACE THE ENGINE HEADS...A $5,000.00 PLUS REPAIR COST IF PAST THE WARRANTY PERIOD. FORD WILL NOT PROVIDE ANY SATISFACTION. *TR
Engine and engine cooling, Feb 5, 2010
I HAVE A 2001 FORD F-150 WITH 195,000 MILES ON IT ,.. I AM THE THIRD OWNER AND HAVE NOT HAD ANY PROBLEMS WITH IT UNTIL NOW.. I WAS DRIVING DOWN THE ROAD AND SUDDENLY HEARD A LOUD DISTURBING SOUND COMING FROM THE ENGINE COMPARTMENT,.. I PULLED OVER AND SHUT THE TRUCK OFF IMMEDIATELY,.. I OPENED THE HOOD AND DID NOT SEE ANYTHING WRONG, SO I STARTED IT BACK UP AND THE SAME NOISE COULD BE HEARD,.. I LOOKED UNDER THE HOOD AND COULD SEE A SPARK BY WHERE A SPARK PLUG WOULD BE,.. I SHUT THE TRUCK OFF AND INVESTIGATED A LITTLE BIT,.. I NOTICED THAT THE COIL WAS OFF AND THE SPARK PLUG WAS LAYING BY THE VALVE COVER,... I HAD TO CALL MY BROTHER TO HAUL THE TRUCK HOME SINCE I KNEW THAT DRIVING IT LIKE THAT COULD CAUSE ENGINE PROBLEMS,.. AFTER DOING A LITTLE RESEARCH ABOUT THIS PROBLEM, I FOUND THAT SPARK PLUGS POPPING OUT OF THEIR HOLES IS KIND OF A COMMON THING FOR FORD TRITON ENGINES. WHY HAS THIS ISSUE NOT BEEN ADDRESSED BY FORD MOTOR COMPANY YET,... I HAVE BEEN TOLD THAT THEY HAVE KNOWN ABOUT TIT FOR QUIT SOME TIME AND HAVEN'T BEEN FORCED TO FIX THE PROBLEM SO THEY PROBABLY WONT SEND OUT A RECALL FOR THIS... WHAT CAN B E DONE TO FIX THIS PROBLEM !!! *TR
Engine and engine cooling, Feb 3, 2010
MY 2001 FORD F-150 TRUCK HAD ONE OF THE SPARKPLUGS EJECT FROM THE CYLINDER HEAD. THE VEHICLE HAS APPROXIMATELY 118,000 MILES. MY CONCERN IS THAT THIS COULD HAVE IGNITED INTO A FIRE SINCE GAS FUMES ARE COMING OUT OF THE SPARKPLUG OPENING. *TR
Engine and engine cooling, Jan 21, 2010
TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING 40 MPH THE CONTACT HEARD A BANGING NOISE IN THE ENGINE AND THE VEHICLE STARTED TO LOSE POWER. THE CONTACT WAS ABLE TO SAFELY DRIVE ONTO THE EMERGENCY LANE AND AFTER LOOKING UNDER THE HOOD, HE OBSERVED THAT A SPARK PLUG WAS MISSING. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC TO HAVE THE VEHICLE REPAIRED. THE CONTACT IS CONCERNED THAT A CRASH COULD HAVE OCCURRED WHEN THE SPARK PLUGGED POPPED OUT OF THE ENGINE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 98,000.
Engine and engine cooling, Jan 3, 2010
SPARK PLUG BLOWN OUT OF ENGINE AND STRIPPED THREADS IN ENGINE HEAD. DUE TO POOR ENGINEERING OF ORIGINAL THREAD LENGTH. SHORT THREAD LENGTH IN ALUMINUM BLOCK WILL NOT HOLD COMPRESSION PRESSURES OVER TIME. I MUST EITHER REPAIR THE HEAD OR REPLACE THE HEAD WITH NEWER DESIGN WITH THREADS OF PROPER LENGTH. HAS NOT BEEN FIXED YET. *TR
Engine and engine cooling, Jan 2, 2010, fire
I HAD AN ORIGINAL SPARK PLUG BLOW OUT OF MY FORD F-150 V-8 TRITON MOTOR WHILE I WAS DRIVING ON THE FREEWAY. IT MADE A LOUD POP NOISE AND THEN I SEEN A FLAME I PULLED OVER RIGHT AWAY AND SHUT OFF THE TRUCK AND CALLED FOR HELP. THANKFULLY I WAS NOT HURT AND THE FIRE WENT OUT AND DID NOT BURN THE TRUCK TO THE GROUND. FORD REFUSED TO FIX IT THEY SAID IT WAS NOT A LUBRICATED PART AND MY WARRANTY DIDN'T COVER THE $2000-3000.00 REPAIR. IT IS A DEFECTIVE DESIGN AND THEY KNOW IT BUT ARE NOT ALLOWED TO FIX IT UNDER THE WARRANTY'S. *TR
Engine and engine cooling, Dec 28, 2009
I OWN A FORD F150 TRITION TRUCK IN MAY OF 2008 I BLEW MY FIRST SPARK PLUG WHILE DRIVING HOME. I TOOK IT TO A LOCAL DEALER, AND THE SERVICE DEPARTMENT INFORMED ME THAT IT WAS A DEFAULT IN THE DESIGN OF THE ENGINE AND THAT FORD WOULD NOT COVER THE APPROXIMATE COST OF $700. FOUR MONTHS LATER, I THREW ANOTHER ONE WHILE SIMPLY STARTING MY TRUCK IN A PARKING LOT. I PAID ANOTHER $700. IT HAS BEEN THREE MONTHS. ON CHRISTMAS EVE, WHILE PULLING OUT INTO TRAFFIC FROM A COMPLETE STOP, I THREW MY 3RD. SPARK PLUG. THIS IS A DEFECT! *TR
Engine and engine cooling, Dec 8, 2009
SPARK PLUG BLEW OUT OF 2001 FORD F150. *TR
Engine and engine cooling, Dec 4, 2009
THE #3 CYLINDER SPARK PLUG BLEW OUT ON MY 2001 FORD F-150 LARIAT. MY TRUCK HAS THE 5.4 LITER ENGINE AND IT HAS 139,000 MILES. I WAS DRIVING APPROXIMATELY 15 MPH AND THE SPARK PLUG BLEW OUT. THERE WAS A LOUD "POPPING" NOISE FROM THE ENGINE COMPARTMENT. UPON INVESTIGATION I FOUND THE #3 CYLINDER SPARK PLUG HAD BLOWN OUT AND ALSO DESTROYED THE COIL ON TOP OF THE SPARK PLUG. *TR
Engine and engine cooling, Nov 19, 2009
BLOWN SPARK PLUG FROM 2001 F-150 (LIGHTNING) NOTE: THIS IS THE THIRD BLOWN SPARK PLUG. THE FIRST TIME FORD REPLACED THE ENTIRE HEAD (UNDER WARRANTY). THE NEXT TWO WERE OUT OF MY POCKET (AT $1K EACH). *TR
Engine and engine cooling, Nov 6, 2009, fire
2001 FORD F-150 THE ENGINE ON THE TRUCK CAUGHT ON FIRE CAME TO WORK AT 6AM AROUND 10:15AM FIRE DEPARTMENT WAS CALL TRUCK WAS ON FIRE, THE RADIATOR AND FRONT END WAS ALL MELTED ENGINE COMPLETELY BURN THERE WAS A HOLE IN THE MIDDLE OF THE DASH BOARD AND ALL THE WIRES LOOK BURN. *TR
Engine and engine cooling, Oct 30, 2009
MY FORD F-150 JUST BLEW OUT THE 2ND SPARK PLUG IN A MONTH. TRUCK HAS 74,000 MILES AND THE REPAIR ISN'T COVERED BY FORD. ORIGINAL PLUGS, SO CAN'T BE DUE TO WRONG TORQUE SPECS. LUCKILY IT HAPPENED AS I PULLED INTO MY DRIVEWAY, AND I WAS ABLE TO SHUT IT DOWN BEFORE IT CAUGHT FIRE. *TR