2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
263 reports, newest first. Show all
Engine and engine cooling, Feb 12, 2008
#3 SPARK PLUG DRIVERS SIDE BLOWN OUT , DAMAGED COIL AND POSSIBLY FUEL RAIL. 5.4 TRITON ENGINE IS IN A 2001 F-150 4X4 WITH 126,000 MILES, NOT VERY SAFE WITH THE POSSIBILITY OF A SPARK RIGHT NEXT TO THE FUEL RAIL. *TR
Engine and engine cooling, Feb 5, 2008
'99 - '08 FORD 5.4L V8'S ARE EQUIPPED WITH 100,000 MILE SPARK PLUGS FROM THE FACTORY. THEY ARE FAILING IN LARGE NUMBERS AT WELL UNDER 50,000 MILES. MOST TIMES PULLING THE THREADS OUT OF THE ALUMINUM HEADS OF THE MOTOR. OTHER TIMES THE SPARK PLUGS BREAK LEAVING PART OF IT IN THE BLOCK. MY PROBLEM WAS THE #7 PLUG BREAKING IN HALF WHILE THE VEHICLE WAS IN OPERATION. WHEN I TOOK MY '01 F-150 SUPER CREW TO THE DEALER I WAS TOLD THAT THEY COULDN'T REPLACE THE REST OF THE SPARK PLUGS BECAUSE THEY WOULD PROBABLY STRIP THE THREADS OUT OF THE HEADS WHEN THEY REMOVED THEM. *TR
Engine and engine cooling, Jan 28, 2008
HAD MINOR TICKING NOISE - WAS TOLD THIS IS TYPICAL IN THIS FORD ENGINE. 16 MONTHS AGO I HAD THE DEALER REPLACE THE SPARK PLUGS, TICKING WAS STILL THERE, AND JUST LAST WEEK ONE OF THE PLUGS BLEW OUT OF THE HEAD. LUCKILY NO ACCIDENT OR INJURY. THIS COULD BE QUITE DANGEROUS HAVING A PLUG SPARKING WITH FUEL VAPORS ESCAPING FROM THE HOLE WHERE THE PLUG USED TO BE. AFTER TALKING TO A NUMBER OF F150 OWNERS - FOUND THIS IS A RATHER COMMON PROBLEM. WHY NO RECALL? DEALER INSTALLED SPACER INSERT RATHER THAN HELICOIL. RATHER EXPENSIVE REPAIR, AND IF IT HAPPENS AGAIN, WILL NEED NEW HEAD. *CN
Engine and engine cooling, Jan 22, 2008
FORD 2001 F150 CREW4X4 REPLACED SPARK PLUGS AFTER #4 COIL PACK WENT BAD THEN NUMBER2 COIL PACK WENT BAD AFTER ONLY 65,000 MILES. THEN AT 142,000MILES #6COIL PACK AND SPARKPLUG BLEW OUT OF MOTOR. *TR
Engine and engine cooling, Dec 26, 2007, fire
DROVE MY FORD F150 TO WORK, PARKED IT AND 30 - 40 MINUTES LATER THE ENTIRE ENGINE COMPARTMENT WAS ON FIRE. I ENTERED THE TRUCK 30 MINUTES AFTER I PARKED TO REMOVE MY CHECK BOOK, BUT I DID NOT SEE OR SMELL ANYTHING THAT RESULTED IN THE FIRE. THE TRUCK WAS NOT INSURED, BUT APPEARS TO BE A TOTAL LOSS. *TR
Engine and engine cooling, Dec 18, 2007
SPARK PLUG BLOWN OUT OF CYLENFAR HEAD (#3) 2001 FORD F-150 5.4 TRITON. *TR
Engine and engine cooling, Dec 18, 2007
SPARK PLUG EJECTED FROM CYLINDER HEAD. *TR
Engine and engine cooling, Dec 17, 2007
WAS CRUISING IN MY FORD LIGHTNING, WHEN I HEARD A LOUD POP AND THEN SOUNDED LIKE MY ENGINE WAS RUNNING OFF THE HEADERS. PULLED OVER AND HAD TO CATCH A TOW TRUCK, TO THE SHOP. THEY TOLD ME MY SPARK PLUG HAD SHOT OUT OF THE HEAD. $1,100 BUCKS LATER IT IS BACK IN THE SHOP NOW AND HAVING THE ENTIRE MOTOR PULLED COST NOT KNOWN BUT APPROXIMATELY 5-10 GRAND... *TR
Engine and engine cooling, Dec 16, 2007
TOTAL ENGINE FAILURE. MUST BE REPLACED AFTER 137,000 MILES AND HAS NEVER BEEN RUN LOW ON OIL NOR FAILED TO CHANGE AT APPROPRIATE INTERVALS. NEVER BEEN OVERHEATED. WELL MAINTAINED AND NO GOOD REASON FOR THIS. FORD F150XLT 2001 4.2L ENGINE. SEVERAL MECHANICS HAVE NOW TOLD ME THIS IS COMMON FOR THIS ENGINE. *TR
Engine and engine cooling, Dec 10, 2007
UPPER INTAKE GASKET MANIFOLD. *TR
Engine and engine cooling, Nov 21, 2007
EMISSIONS LIGHT WENT ON AND OFF AND THE CAR SEEMED TO MISFIRE. DID NOT DRIVE SMOOTH. I WAS GLAD I WAS CLOSE TO HOME. I FELT THE CAR WOULD CONK OUT WHILE I WAS DRIVING. *TR
Engine and engine cooling, Oct 21, 2007
SPARK PLUG BLOW OUT. *TR
Engine and engine cooling, Aug 7, 2007, fire
TL*THE CONTACT OWNS A 2001 FORD F150. ON JULY 27, 2007, THE VEHICLE CAUGHT FIRE WHILE PARKED. THE VEHICLE WAS DESTROYED. A FIRE AND POLICE REPORT WERE FILED. THE FIRE MARSHALL STATED THAT THE FIRE BEGAN IN THE ENGINE COMPARTMENT. THE PASSENGER SIDE FENDER OF ANOTHER PARKED VEHICLE WAS SCORCHED DUE TO THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 80,000. UPDATED 02-01-08 *BF UPDATED 02/01/08 *TR
Engine and engine cooling, Aug 3, 2007, fire
TL*THE CONTACT OWNS A 2001 FORD F-150. SHE WAS INFORMED THAT HER VEHICLE CAUGHT FIRE. THE FIRE WAS EXTINGUISHED USING A FIRE EXTINGUISHER AND THE FIRE DEPARTMENT WAS CALLED. AS OF AUGUST 3, 2007, THE DEALER HAS NOT REPAIRED THE VEHICLE. THE MANUFACTURER STATED THAT THEY WOULD SEND A LETTER TO THE CONTACT WITHIN TWO WEEKS. THE CURRENT AND FAILURE MILEAGES WERE 119,000. UPDATED 02-01-08. *KB UPDATED 02/01/08 *TR
Engine and engine cooling, Jul 27, 2007
I WAS DRIVING MY 2001 FORD SVT LIGHTNING, WITH ONLY 30,000 MILES ON THE ODOMETER. NO SIGN OF A PROBLEM WHATSOEVER. WHILE PASSING A BIG TRUCK, POP........AND THEN I LOST POWER AND ALMOST DIDN'T COMPLETE THE PASS IN TIME. ONCE I PULLED OVER, I FOUND THAT A SPARK PLUG BLEW OUT, AND TOOK OUT A COIL ON IT'S WAY. THE FORD DEALER WANTS BIG MONEY FOR THE REPAIR (NEW HEADS), AND I CAN'T AFFORD IT RIGHT NOW. I'VE FOUND THIS TO BE A COMMON PROBLEM, AND FORD WON'T DO ANYTHING ABOUT IT. MY PLUGS ARE ORIGINAL, SO NOTHING WAS DONE BY ME TO CONTRIBUTE TO THIS FAILURE. NOW MY TRUCK IS SITTING IN THE DRIVEWAY, AND IT CAN'T BE DRIVEN. HOPE MY OTHER FORDS DON'T SPIT OUT A PLUG. *TR
Engine and engine cooling, May 31, 2007, fire
ON TUESDAY MORNING, 05/29/2007 AT 1:30AM, I WAS AWAKENED BY A LOUD BOOM AND A BRIGHT FLASH FROM OUTSIDE OF MY BEDROOM WINDOW. WHEN I JUMPED UP TO SEE WHAT WAS HAPPENING, I SAW MY TRUCK ENGULFED IN FLAMES. I GRABBED MY CELL PHONE FROM BESIDE MY BED AND DIALED 911 AS I RAN TO THE FRONT PORCH. BY THE TIME I REACHED THE FRONT PORCH THE ENTIRE FRONT OF THE VEHICLE WAS ENGULFED, THE HOOD WAS COMPLETELY GONE AND THE FRONT TIRES WERE ON FIRE. WHEN THE FIRE DEPARTMENT ARRIVED, THE TRUCK WAS ON FIRE FROM THE FRONT BUMPER TO THE REAR BUMPER. THE INSIDE OF THE TRUCK WAS COMPLETELY IN FLAMES AND ALL OF THE WINDOW GLASS HAD EITHER MELTED OR BEEN BLOWN AWAY FROM THE TRUCK BODY. IT WAS DETERMINED BY THE FIRE DEPARTMENT THAT THE FIRE BEGAN INSIDE OF THE ENGINE COMPARTMENT. *TR
Engine and engine cooling, May 14, 2007
I EXITED ON I-75 ONTO SR 200, TRAVELED 100 FEET APPROXIMATELY 20 MPH, HEARD POPPING SOUND LIKE BASEBALL CARD IN SPOKES OF A BICYCLE WHEEL. HAPPENED SATURDAY NIGHT WHILE BRINGING MY SON HOME FROM COLLEGE. COST $75 TO TOW HOME TO UNLOAD THE 2001 F150 5.4 LITER V-8. $75 TO TOW TO FORD OF OCALA, BELLEVIEW, WHO DIAGNOSED BLOWN #3 PLUG, CHARGED $98, THEN $75 TOW TO FORD OF OCALA IN OCALA TOLD $4000 TO REPLACE HEAD OR $6000 TO REPLACE ENGINE. THIS WAS A COMMON OCCURRENCE WITH THIS FAULTY HEAD AND PLUG DESIGN. FORD SHOULD BE MADE TO FIX THIS PROBLEM SINCE REPLACING EITHER THE HEAD OR ENGINE WITH THE SAME FAULTY FORD PRODUCT WAS NOT AN OPTION TO ME. ESTIMATED CHARGES WERE OUTRAGEOUS EVEN FOR A PHYSICIAN TO PAY. PLEASE SEE WWW.F150ONLINE.COM FORUM FOR ADDITIONAL DISGRUNTLED F-150 OWNERS WHOM HAVE HAD SAME PROBLEM. THIS WAS A FRAUD ALERT. *AK
Engine and engine cooling, May 13, 2007
01 F150 SUPERCREW 5.4L WITH LESS THAN 41,000 MILES. RIGHT REAR SPARK PLUG BLEW OUT OF HEAD ALSO BREAKING COIL MOUNTING BRACKET. DEALER REMOVED ENGINE TO ATTEMPT REPAIR AND FOUND SPARK PLUG HOLE WOULD NOT ACCEPT HELI-COIL. IN PROCESS AT THIS TIME TRYING TO LOCATE A NEW HEAD. THIS TRUCK HAS BEEN WELL TAKEN CARE OF AND WITH LESS THAN 41,000 MILES, HOW WAS THIS POSSIBLE! I HAVE BEEN A FORD DRIVER MOST OF MY LIFE. BUT I WILL THINK TWICE BEFORE BUYING ANOTHER FORD. THIS PROBLEM IS WELL DOCUMENTED AND SHOULD BE REPAIRED UNDER A RECALL. *AK
Engine and engine cooling, May 7, 2007
SPARK PLUG # 7 BLEW OUT OF THE FORD F-150 TRUCK WITH A V8 MOTOR. THE PLUG AND COIL STUCK THE FUEL RAIL ABOVE THIS AREA , AND TOOK A CHUNK OF THE FUEL RAIL OUT, ALMOST CRATING A LEAK , VEHICLE COULD CATCH ON FIRE. OVER 100,000 REPORTS ON THE EXACT SAME SPARK PLUG ALONG WITH # 3 PLUG DOING THE SAME THING WITH THE FUEL RAIL ALSO. USUALLY THE OTHER PLUG BLEW A FEW MONTHS AFTER THE FIRST ONE BLEW OUT OF THE ENGINE. REPAIRS WERE TO PULL THE HEADER ,AND DRILL HOLE IN HEADER TO INSTALL A COIL TO REPLACE THREADS TORN ON THE HEAD, AND INSTALL A NEW PLUG DUE TO BLOW OUT AND COIL. *AK
Engine and engine cooling, Apr 16, 2007
A SPARK PLUG BLEW OUT OF MY FORD F-150. DID NOT KNOW UNTIL RECENTLY THAT THIS PROBLEM OCCURS A LOT IN FORD TRUCK MOTORS. ENGINE DOES NOT REALLY RUN NOW BECAUSE IT WOULD PROBABLY CATCH ON FIRE FROM EXHAUST FLAMES. I DO NOT KNOW WHAT I HAVE TO DO TO GET THE PROBLEM FIXED, BUT AFTER READING MULTIPLE COMPLAINTS, I AM LED TO BELIEVE I WILL BE PAYING ROUGHLY $5,000 TO GET THE PROBLEM FIXED. *JB
Engine and engine cooling, Apr 16, 2007
TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING 70 MPH IN DRY CONDITIONS, THE CONTACT HEARD A LOUD NOISE COMING FROM THE VEHICLE. INITIALLY, THE CONTACT THOUGHT A TIRE WAS BLOWN AND PULLED THE VEHICLE OFF THE ROAD. ALL FOUR TIRES WERE IN NORMAL CONDITION, BUT THE SCENT OF GAS WAS DETECTED. THE VEHICLE WAS TOWED TO A MECHANIC, WHO DISCONNECTED THE FUEL INJECTOR TO THE NUMBER SEVEN CYLINDERS, SO THE VEHICLE COULD BE DRIVEN HOME. THE FAILURE WAS NOT REPAIRED AT THAT TIME. THE CONTACT TOOK THE VEHICLE TO A LOCAL SHOP CLOSER TO HOME, AND WAS CHARGED $1,863 FOR REMOVING BOTH HEADS, AND HAD THE MACHINE FLAT AT THE NUMBER SEVEN CYLINDER. THE FORD MANUFACTURER WAS NOTIFIED, AND STATED THAT THE CONTACT WAS RESPONSIBLE FOR THE ENGINE REPAIR. THE CURRENT MILEAGE WAS 91,750, AND FAILURE MILEAGE WAS 90,075. *AK THE CONSUMER FEELS THE PROBLEM WAS THE TRITON ENGINE AND FORD SHOULD BE HELD ACCOUNTABLE FOR THE COST OF THE REPAIRS. UPDATE 5/3/07*TR
Engine and engine cooling, Mar 21, 2007
FORD - SPARK PLUG DEFECT. WHILE DRIVING ON THE INTERST A SPARK PLUG POPPED OUT OF ITS SOCKET AND BROKE THE SPARK PLUG COIL. I WAS IN TH MIDDLE OF HEAVY TRAFFIC AN WS VERY SCARED BECAUSE I COULD NOT INITIALLY PULL OVER DUE TO THE AMOUNT OF TRUCKS ON THE HIGWAY.I WAS BOXED IN. AFTER I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD I OPENED THE HOOD AN FOUND A SPARK PLUG STUCK TO A PIECE OF PLASTIC MELTED TO IT DUE TO THE HEA). I ALSO OUNDTHE SPARK PLUG COIL, WITH THE SPRING HANGING OUT OF THE RUBBER INSULATOR, SPAKING AGAINST ANOTHER PIEC OF PLASTIC.*AK I FEEL THE IS AN EXTREME DANGER BECAUSE: 1. I COULD HAVE CAUSED A MAJOR ACCIDENT ON THE FREEWAY. 2. THE SPARK PLUG COIL COULD HAVE SHOCKED MEOR EVEN STARTED SOMETHING ON FIRE. AFTER RESEARCHINGTHE PROBLEM ON THE INTERNET, I SEE THAT MORE AND MORE INCIDENTS EXACTLY LIKE E ARE HAPPENING EVERY DAY. FORD REFUSES TO ADMIT THERE IS A PROBLEMEVEN THOUGH THEY CHANGED THE DESIGN IN 2004 AND THEPROBEM DOESN'T EXIT WITH SPARK PLUGS ANYMORE. WHAT NEEDS TO BE DONE TO GET THIS PROBLEM RESOLVED. DOES OMEONE HAVE TO DIE?
Engine and engine cooling, Electrical system, Feb 28, 2007
MY 2001 FORD F-150 TRUCK HAD A SPARK PLUG EJECT FROM THE CYLINDER AND HIT THE FUEL RAIL WHILE ON THE HIGHWAY ON 9-1-06 (70,000 MILES ON ODOMETER). I HAD THE TRUCK HAULED TO NEAREST SERVICE CENTER WHERE THEY FIXED THE CYLINDER WITH A REPAIR KIT MADE FOR THIS PROBLEM. ON 2-26-07 AT 79 THOUSAND MILES ANOTHER PLUG EJECTED WITH THE SAME CONSEQUENCE. NOW THE ENTIRE HEAD HAS TO BE REPLACED AT A COST OF $3600 TO ME. *JB
Engine and engine cooling, Electrical system, Feb 12, 2007
TL* - THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING 40 MPH THE VEHICLE MADE A LOUD POPPING SOUND SIMILAR TO A TRUCK BACK FIRING. THE MECHANIC STATED THE SPARK PLUG AND COILS WERECAUSING THE FAILURE. THIS FAILURE OCCURRED ON 2 PREVIOUS OCCASIONS. THE RECENT FAILURE THE MECHANIC WAS UNABLE TO REPAIR BY CHANGING THE SPARK PLUGS, THE DAMAGEWAS MORE ADVANCED AND COSTLY. MOST FORD TRUCKS EXPERIENCED THIS FAILURE AT 8 YEARS. THE VEHICLE WAS TOWED, AND WAS CURRENTLY AT THE DEALER FOR REPAIR. THE FAILURE AND CURRENT MILEAGE WERE 93000.*AK
Engine and engine cooling, Jan 31, 2007
WHILE TRAVELING ON A BUSY HIGHWAY NEAR MY HOME MY 2001 F150 BLEW A SPARK PLUG FROM THE MOTOR. THIS IS THE SECOND TIME THIS HAS HAPPENED TO ME. THE FIRST AT 37K MILES AND THE SECOND AT 48K. THE LOSS OF ENGINE POWER NEARLY CAUSED A COLLISION. I WAS IN HEAVY TRAFFIC AND IN THE PASSING LANE AT THE TIME. THIS IS A FREQUENT OCCURENCE WITH THIS FORD MOTOR FROM WHAT I CAN SEE ON THE INTERNET. WHY IS NOTHING BEING DONE TO PROTECT THE CONSUMER FROM THIS OBVIOUS DESIGN FLAW? DOES SOMEONE HAVE TO DIE FIRST?