2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
263 reports, newest first. Show all
Engine and engine cooling, Nov 14, 2005
DT: THE CONSUMER'S VEHICLE WAS AT A RED LIGHT AND HEARD A LOUD POPPING NOISE FROM THE UNDERNEATH THE HOOD. UPON ACCELERATION THE VEHICLE BEGAN TO SHAKE. THE CONSUMER PULLED OVER TO INSPECT THE VEHICLE AND DISCOVERED A SPARK PLUG WAS LYING ON TOP OF THE ENGINE. THE CONSUMER LATER DROVE THE VEHICLE TO A REPAIR SHOP. THE MECHANIC INSPECTED THE VEHICLE AND CONSULTED A FORD DEALER. THE MECHANIC USED A HEEL COIL TO RESOLVE THE PROBLEM AS SUGGESTED BY THE FORD DEALER. THE VEHICLE COULD NOT BE COMPLETELY REPAIRED DUE TO A LACK OF TOOLS TO SET THE TIMING CHAIN ON THE VEHICLE. FORD DID NOT HAVE THESE SPECIAL TOOLS AVAILABLE TO THE PUBLIC. NO FURTHER REPAIRS COULD BE MADE BY THE MECHANIC AT THIS TIME. *AK (12/02/05)*SC
Engine and engine cooling, Oct 24, 2005
OUR FORD F150 HAS 46,000 MILES ON IT. ON FRIDAY THE 14TH MY HUSBAND WAS DRIVING DOWN A RESIDENTIAL STREET WHEN HE HEARD A LOUD BANGING UNDER THE HOOD. HE PULLED OVER RIGHT AWAY AND THE ENGINE DIED. HE LOOKED UNDER THE HOOD AND COULD SEE THAT THE DISTRIBUTOR CAP WAS BROKEN AND FLOPPING AROUND. HE HAD A FRIEND TOW THE TRUCK TO THE FRIENDS RESIDENCE SO THAT THE TRUCK WOULDN'T BE LEFT ON THE SIDE OF THE ROAD. MY HUSBAND THEN CALLED A TOW COMPANY TO TOW THE TRUCK 18 MILES TO A NEARBY DEALERSHIP TO EXAMINE THE TRUCK. WE WERE TOLD THAT THE SPARK PLUG THREADS WERE STRIPPED AND THAT NEW HEADS WOULD BE REQUIRED TO REPAIR OUR TRUCK. WE WERE ALSO INFORMED THAT OUR EXTENDED WARRANTY DID NOT COVER THIS REPAIR AND THAT OUR BILL WOULD BE APPROX $3,200.00. AFTER THE TOW BILL, PARTS, LABOR AND RENTAL CAR WE ARE NOW UP TO $3,500.00 IN EXPENSES. *JB
Engine and engine cooling, Oct 23, 2005
2001 FORD F150 SUPERCREW 5.4 LITER TRITON V8 ENGINE. ON SEPT 16, 2005 MY TRUCK EXPERIENCED A #7 SPARK PLUG BLOWOUT. THE HEAD WAS REPLACED. ONE MONTH LATER, THE OTHER HEAD EXPERIENCED A SPARK PLUG BLOWOUT. IT SEEMS THERE ARE NOT ENOUGH THREADS TO HOLD THE SPARK PLUGS IN THE ENGINE DURING NORMAL OPERATIONS. THE ENGINE ONLY HAS 71,000 MILES ON IT. AT 60,000 MILES, THE FORD SERVICE CENTER REPLACED THE SPARK PLUGS IN ACCORDANCE WITH THE FORD MOTOR COMPANY MANUFACTURER SPECIFICATIONS AND RECOMMENDED MAINTENANCE SCHEDULE. *NM
Engine and engine cooling, Oct 19, 2005
DT: 2001 FORD F150. THE CONTACT STATED, ON OCTOBER 16, 2005 THE SPARK PLUG FLEW OUT OF HIS VEHICLE. THE VEHICLE WAS NOT ABLE TO BE DRIVEN AT THAT TIME. IT WAS PULLED OFF THE ROAD AND TOWED TO A LOCAL SHOP. THE MECHANIC DID NOT KNOW WHY THIS OCCURRED. ACCORDING TO FORD, THEY HAVE NOT HEARD OF THIS PROBLEM. THE VEHICLE HAS NOT BEEN FIXED AT THIS TIME. THE HEAD NEEDS TO BE REPLACED AS A RESULT.*AK
Engine and engine cooling, Oct 17, 2005
DT: THE CONTACT OWNS 2001 FORD F-150. THERE IS A CLATTERING SOUND COMING FROM THE ENGINE. UPON INSPECTION OF THE VEHICLE THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE REASON FOR REPLACEMENT WAS THAT THERE WAS A ROD KNOCKING IN THE ENGINE. THE MANUFACTURER HAS NOT BEEN CONTACTED. *AK UPDATED 11/16/05. *JB
Engine and engine cooling, Oct 13, 2005
DT: THE CONSUMER OWNS A 2001 FORD F150. ON 9-2-05 WHILE DRIVING ON INTERSTATE HE HEARD A LOUD POP AND LOST POWER, PULLED OVER AND FOUND THAT A SPARK PLUG BLEW OUT OF THE ENGINE. THE CONSUMER DROVE THE VEHICLE TO THE DEALERSHIP, THEY SAID THAT THE ENGINE HEAD WOULD HAVE TO BE REPLACED AND THE COST WOULD BE OVER $3000. THE CONSUMER HAD IT REPAIRED AT A COST OF $33000. THE CONSUMER TALKED TO SEVERAL DIFFERENT DEALERSHIPS AND THEY OFFERED NO ASSISTANCE. *AK (11/17/05) *SC
Steering, Engine and engine cooling, Oct 6, 2005
IN NOVEMBER 2004 I TOOK MY 2001 EXPEDITION INTO THE FORD DEALERSHIP SERVICE DEPARTMENT. THEY FOUND A HEAD GASKET DEFECTIVE AND REPLACED IT. IMMEDIATELY AFTER GETTING THE CAR BACK FROM DEALERSHIP THE STEERING WAS GIVING RESISTANCE WHILE DRIVING. WE CALLED THE DEALERSHIP AND THEY TOLD US IT WAS PROBABLY "AIR IN THE POWER STEERING LINES" AND THAT SOMETIMES HAPPENS AFTER FIXING THE PROBLEM THEY FIXED. THEY TOLD US IT WOULD "WORK ITSELF OUT". WELL, IT DIDN'T WORK ITSELF OUT, IT GOT WORSE. SO WE TOOK THE CAR BACK TO DEALERSHIP IN JUNE 2005 AND THEY COULD NOT "REPRODUCE THE PROBLEM SO AFTER SOME COMPLAINING FROM US, THEY RECHECKED THE VEHICLE AND FOUND THAT P/S PUMP EVO ACTUATOR TO BE CAUSING THE PROBLEM AND REPLACED THE POWER STEERING PUMP. THIS DID NOT FIX THE PROBLEM. THE CAR WAS STILL GIVING RESISTENCE IN THE STEERING. THE PROBLEM CONTINUED TO GET WORSE AND WORSE, SO IN OCTOBER 2005, WE TOOK THE CAR TO THE DEALERSHIP AGAIN. THEY AGAIN SAID THEY COULD NOT REPRODUCE THE HANGING UP OR NOISE. NOBODY EVER SAID ANYTHING TO THEM ABOUT POPPING NOISE. WHEN I GOT THERE TO PICK THE CAR UP I WAS NOT OUT OF THE PARKING LOT AND IT STARTING DOING IT AGAIN, SO I PULLED BACK IN AND THEY REFUSED TO LOOK AT THE CAR ANYMORE. *JB
Engine and engine cooling, Oct 4, 2005
I WAS IN THE PARKING LOT OF A STORE AND WHEN I WENT TO START THE TRUCK IT MADE A HUGE POPPING SOUND UPON INVESTIGATION I FOUND THAT THE SPARK PLUG SHOT OUT OF THE HOLE AFTER CONTACTING MY FORD DEALERSHIP THEY INFORMED ME THAT THIS HAS BEEN AN ONGOING ISSUE WITH THE 5.4 AND V-10 MOTORS THE PROBLEM WAS THE SPARK PLUG COULD ONLY BE INSTALLED USING THREE THREADS AND THAT THEY HAVE CORRECTED THAT PROBLEM AND NOW WHEN I FIX THE TRUCK THE NEW HEADS YOU WILL BE ABLE TO GO DOWN 5 THREADS AT THE PRICE OF $1300.00 PER HEAD AND THE TOTAL COST OF $3200.00 PARTS & LABOR. *NM
Engine and engine cooling, Sep 13, 2005
THE #3 SPARK PLUG BLEW OUT WHILE ACCELERATING FROM A STOP SIGN. MY SMALL TOWN MECHANIC SAID HE IS SEEING 4-5 OF THESE PER YEAR AND BLAMES A DESIGN DEFECT IN THE TRITON 5.4 HEAD. THE HEAD IS TOO THIN AND MADE FROM ALUMINUM SO THE THREADS STRIP OUT. THE TRUCK HAS 70,000 MILES AND THE PLUGS ARE ORIGINAL. FORD HAS CHANGED THE HEAD DESIGN BUT WON'T ADMIT TO THE FLAW. THIS COULD HAVE BEEN VERY DANGEROUS. *NM
Engine and engine cooling, Aug 30, 2005
DT: WHILE THE CONSUMER WAS DRIVING A SPARK PLUG BLEW OUT ON 7-30-05. WHEN THE CONSUMER TOOK VEHICLE TO THE DEALERSHIP PUT THE SPARK PLUG BACK IN ITS PLACE. THE PROBLEM HAS NOT OCCURRED AGAIN. THE SERVICE ENGINE LIGHT CAME ON AND THE ENGINE WAS RUNNING ROUGH. OTHER THAN THE ABOVE ENTIONED PROBLEMS THE CONSUMER HAD NO OTHER TROUBLE WITH THE VEHICLE. THE CONSUMER BELIEVED THE PROBLEM WAS WITH THE ENGINE. *AK
Engine and engine cooling, Aug 25, 2005
HAVE 2001 FORD F150 SUPERCREW 5.4 ENGINE WITH 51K MILES. ACCELERATED TO ENTER HIGHWAY AND HEARD LOUD "POP", THEN LOST ENGINE COMPRESSION AND HEARD LOUD UN-MUFFLED ENGINE NOISE EMINATING FROM THE ENGINE COMPARTMENT. HAVING A FAIR KNOWLEDGE OF CARS, I THOUGHT I BLEW THE HEAD GASKET, BUT UPON INSPECTION BY A LOCAL DEALER (COSWAY FORD IN STAFFORD, NJ) WAS TOLD I BLEW A SPARK PLUG AND IT IS NOT A COVERED ITEM UNDER MY EXTENDED WARRANTY. THE SERVICE TECH SEEMED TO KNOW RIGHT AWAY WHAT THE PROBLEM WAS WHEN I DESCRIBED IT, LEADING ME TO BELIEVE THIS IS A VERY COMMON PROBLEM. AS I GATHERED, UPON RESEARCHING THE INTERNET, THIS IS MORE THAN COMMON, IT IS A MANUFACTURER DEFECT IN THE ALUMINUM CYLINDER HEARD. I AM 33 YEARS OLD AND HAVE BEEN AROUND CARS FOR A LONG TIME AND HAVE NEVER HEARD OF THIS PROBLEM. I BOUGHT THE TRUCK NEW AND BABIED THE VEHICLE. IT SEEMS THIS PROBLEM IS LIMITED TO THOSE YEAR 5.4'S THAT USE THE FLAWED 4-THREAD CYLINDER HEAD, AS TO WHY IN 2003 FORD CHANGED THE DESIGN TO 8-THREADS. PLEASE HELP FORCE FORD MOTOR COMPANY TO FESS UP AND RECALL THESE VEHICLES. I UNDERSTAND IT CAN HAPPEN AGAIN. THIS REPAI WILL BE COSTING ME $501.80, PLUS THE RENTAL OF A CAR (WAS FAR FROM HOME ON VACATION).
Engine and engine cooling, Aug 23, 2005
I OWN A 2001 FORD F150 4.6 LTER AND AT APPROXIMATELY 105,000 MILES #3 SPARK PLUG BLEW OUT OF THE HEAD. FORD ATTEMPTED TO REPLACE THE PLUG AND AGAIN IT BLEW OUT. I FIXED IT WITH A HELICOIL MYSELF AS THE EXPENSE WAS $3000 FOR THE DEALERSHIP TO FIX. RECENTLY WITH 121,000 MILES IT WAS RUNNING ROUGH AND WHEN THE DEALERSHIP WENT TO REPLACE THE SPARK PLUGS THEY DROPPED SOMETHING INTO CYLINDER #7. THE MECHANIC STARTED THE ENGINE AND NOW HAVE AN INOPERABLE VEHICLE THAT THEY ARE REFUSING TO FIX.
Engine and engine cooling, Aug 18, 2005
SPARK PLUG GETTING BLOWN FROM THE HEAD, DAMAGING THE HEAD IN A 5.4L FORD F-150. REPAIR WAS DONE BY MYSELF, USING A BIG-SERT REPAIR KIT FROM TIME-SERT. THIS WAS THE SECOND TIME IT HAS HAPPENED. *JB
Engine and engine cooling, Aug 13, 2005
WELL AT FIRST MY 2001 F-150 SUPERSCRIPT AT 55000 MILES STARTED TO LAG, WHEN I WOULD PRESS THE GAS IT WOULD TAKE A LONG TIME TO PICK UP SPEED OR CHANGE GEARS. THEN ONE DAY I WAS DRIVING HOME FROM WORK GOING ABOUT 55 MPH WHEN I HEAR A LOUD POP, I LET GO OF THE GAS PEDAL BECAUSE IT REALLY SCARED ME I HAD TO REGAIN CONTROL OF MY VEHICLE ONCE I DID I TRIED PRESSING ON THE GAS AND IT WOULDN'T GO ANYWHERE SO I DECIDED TO PULL OVER AND HAVE TO TOWED TO A FORD DEALERSHIP, IT WAS THERE THAT THEY TOLD ME IT WAS GOING TO COST ME 2500 HUNDRED DOLLARS TO FIX. NOW I HAVE TO WAIT TWO WEEKS UNTIL IT GETS REPAIRED. *JB
Engine and engine cooling, May 26, 2005
BOUGHT A 2001 FORD EXPLORER 6 WEEKS AGO FROM A FORD DEALER. NOW I AM HAVING A NOISE UNDER THE HOOD OF THE CAR. I AM TOLD IT NEEDS TIMING CHAIN WORK DONE. THERE IS A TSB 02-8-1 OUT ON THIS PROBLEM. THIS IS AN EXPENSIVE PROBLEM. APPROX. $800. I DON'T FEEL CUSTOMERS WHO SPEND SO MUCH MONEY ON CARS SHOULD HAVE TO PAY FOR PROBLEMS THAT ARE EVIDENTLY OCCURING TO A LOT OF THEIR CARS.
Engine and engine cooling, May 14, 2005
ON OR ABOUT 4/21/05 I WAS DRIVING MY 2001 FORD F-150 TAKING MY SON AND NEPHEW TO SCHOOL. AS I MADE A RIGHT TURN AT THE SCHOOL MY ENGINE STALLED. I LOST ALL STERING CONTROL AND HAD JUST ENOUGH BRAKE POWER TO SLOW THE VEHICLE. I PUT THE TRUCK IN NEUTRAL AND STARTED THE TRUCK. I TOOK IT TO MY LOCAL FORD DEALER AND THEY REPLACED THE AIR INTAKE CONTROL VALVE. ABOUT 2 WEEKS LATER AT THE EXACT SAME SPOT AND TIME THE ENGINE AGAIN STALLED ON ME. AGAIN, I LOST ALL STERING AND HAD JUST ENOUGH BRAKES TO SLOW SO I COULD PUT THE TRUCK IN NEUTRAL AND START THE ENGINE. MY FORD DEALER IS TELLING ME THEY CAN NOT FIND THE PROBLEM WITH IT AND STATED I COULD PICK THE TRUCK UP AND DRIVE IT IF I WANTED TO. NOT WANTING TO HAVE MYSELF OR MY FAMILY KILLED IN A CAR CRASH I TOLD THEM NO AND THAT THEY NEEDED TO FIX THE TRUCK. THEY AGREED TO TRY AND FIX THE TRUCK. I UNDERSTAND THAT YOU MAY NOT BE ABLE TO HELP ME WITH THIS NEXT ISSUE BUT IF YOU CAN I WOULD APPRECIATE IT. WHILE THEY TRY TO FIND THE PROBLEM WITH MY TRUCK THEY HAVE THE RIGHT TO KEEP MY TRUCK FOR 30 DAYS AND I WOULD HAVE TO RENT A CAR. AT $20 PER DAY FOR 30 DAYS THAT WOULD COST ME $600. I CAN NOT AFFORD THIS AS FORD REFUSES TO LEND ME A CAR. THANK YOU. ROBERT R. HERNANDEZ
Engine and engine cooling, Electrical system, Apr 25, 2005
WHILE DRIVING AT APPROXIMATELY 30 MPH ENGINE MADE A PING NOISE. IT SOUNDED AS IF SOMETHING BROKE. OWNER CALLED FOR A TOW TRUCK AND HAD THE VEHICLE TOWED TO THE DEALER. THE VEHICLE WAS PUT ON THE DIAGNOSTIC MACHINE, AND OWNER WAS INFORMED THAT THE SPARK PLUG EJECTED FROM THE CYLINDER HEAD THAT BECAUSE IT WAS MADE OF ALUMINUM, AND IF THE SPARK PLUGS WERE TIGHTENED TOO MUCH, OR THE SPARK PLUGS WERE CROSS THREADED WHEN INSTALLED THEY WOULD BE EJECTED. *AK
Engine and engine cooling, Apr 8, 2005, fire
2001 FORD F150 CAUGHT ON FIRE WHILE PARKED.*MR *NM
Engine and engine cooling, Apr 5, 2005, fire
WHILE PARKED FOR 24 HOURS VEHICLE CAUGHT ON FIRE IN THE ENGINE COMPARTMENT WHERE THE CRUISE CONTROL CABLE WAS LOCATED. OWNER WAS ABLE TO PUT THE FIRE OUT. *AK
Engine and engine cooling, Mar 2, 2005
(1) THERE WERE NO EVENTS TO LEAD TO FAILURE; (2) THE ENGINE CAM SHAFT SENSOR CONTINUES TO FAIL. THIS WILL BE OUR 5TH TRIP TO THE DEALERSHIP FOR THE SAME SENSOR. EACH TIME, WITHIN 24 HOURS OF IT BEING FIXED THE ENGINE LIGHT IS BACK ON AGAIN. WE HAVE SPENT OVER $350 ON THE SAME SENSOR. WE HAVE RECEIVED NO EXPLANATION AS TO WHY THE SENSOR CONTINUES TO FAIL. *AK
Engine and engine cooling, Feb 21, 2005
MY 2001 FORD SVT F-150 LIGHTNING BLEW A SPARK PLUG OUT OF THE CYLINDER HEAD OF THE ENGINE. THERE WAS NO PRIOR WARNING TO THIS HAPPENING. WHEN THIS HAPPENED THE VEHICLE WAS UNDRIVABLE AND I WAS FORCED TO HAVE IT TOWED. FORD TOWING WAS UNABLE TO GET THE VEHICLE UNTIL THE FOLLOWING DAY SO I WAS FORCED TO PAY FOR THE TOW OUT OF MY POCKET. THE FIRST DEALERSHIP I WENT TO SAID THEY WOULDN'T FIX THE TRUCK UNDER WARRANTY. THE SECOND DEALERSHIP THAT IT WENT TO WAS ABLE TO COVER THE REPAIR UNDER WARRANTY. THIS ENTIRE INCIDENT HAPPENED WHY I WAS ON VACATION. I AM A SOLDIER RETURNING FROM IRAQ AND I WAS FORCED TO SPEND A WEEK IN A HOTEL ROOM WHY THEY WAITED ON PARTS TO FIX MY VEHICLE. AFTER THE VEHICLE WAS FIXED I WAS SENT ON MY WAY AND TWO HOURS LATER THE VEHICLE HAD MORE PROBLEMS. SEVERAL OTHER SMALL COMPONENTS WERE ALSO DAMAGED AND I WAS FORCED TO STOP AGAIN. THIS WAS ALSO COVERED UNDER WARRANTY. I THOUGHT THAT THIS WAS UNHEARD OF, BUT AS IT TURNS OUT IS VERY COMMON TO THE FORD TRITON V-8 ENGINES. I AM ONE OF THOUSANDS THAT THIS HAS HAPPENED TO AND I FEEL FORTUNATE THAT I WASN'T LEFT STRANDED IN AN UNSAFE AREA.
Engine and engine cooling, Jan 26, 2005, fire
VEHICLE WAS PARKED INSIDE OF THE GARAGE AND IT CAUGHT ON FIRE. THE DRIVER CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. NO INJURIES REPORTED. VEHICLE WAS TOWED, AND TOTALED BY THE INSURANCE COMPANY. *AK
Engine and engine cooling, Dec 29, 2004
THIS IS A 2001 FORD SVT LIGHTNING THAT HAS BEEN A VICTIM OF A BLOWN SPARK PLUG. THIS IS A COMMON FAILURE IN THESE TRITON MOTORS. IN THE NEW GROUPS, IT IS SPECULATED THAT THIS OCCURS FOR TWO REASONS. 1) A DESIGN ERROR IN THE CYLINDER HEAD. IN THE PRE-2003 5.4 MOD MOTOR HEADS, THERE ARE A TOTAL OF 4 THREADS. FORD HAS REALIZED THIS PROBLEM AND CORRECTED THE 2003-LATER HEADS WITH 8 THREADS TO HOLD THE SPARK PLUG IN. THIS PROBLEM EFFECTED ALL TRITON 5.4 MOTORS AND THE PROBLEM HAS SHOWN UP IN 5.4 LITER MOTORS IN OTHER NON-LIGHTNING TRUCKS AND EXPEDITIONS. 2) THERE HAVE BEEN MANY INSTANCES WHERE FORD CUSTOMERS HAVE FOUND THAT THE SPARK PLUGS HAVE BEEN VERY LOOSE IN THESE TRITON HEADS. THIS IS NOT KNOWN WHETHER THIS IS FROM A LACK OF THREADS OR BEING LOOSE FROM THE FACTORY. EITHER WAY, IN THIS DAY AND AGE IN AUTOMOTIVE TECHNOLOGY, THE REQUIREMENT THAT A CUSTOMER HAS TO CHECK THE TORQUE ON SPARK PLUGS IS UNREALISTIC. OTHER FACTORS TO CONSIDER: MY LIGHTNING IS A 2001 MODEL WITH 15,000 MILES ON IT. OBVIOUSLY IT IS INFREQUENTLY USED. THERE IS A PERFORMANCE CHIP THAT DOES NOT ADD BOOST. IN ESSENCE, THIS TRUCK IS PAMPERED. THE HEAD FAILURE OCCURRED DURING NORMAL DRIVING ON A SLIGHT INCLINE GO THE SPEED OF TRAFFIC. APPROXIMATELY 35 MPH. THERE IS NO DETONATION ISSUES WITH THIS VEHICLE. PRIOR TO THIS FAILURE THE POWER TRAIN HAD NO CHRONIC ISSUES SUCH HAS UNKNOWN SUPERCHARGER NOISES, ENGINE TICKS/KNOCKS, IGNITION, FUEL ISSUES OR SMOKY EXHAUST. FORD WILL NOT COVER THIS DAMAGE AND FAILURE EVEN THOUGHT THIS HAPPENS FREQUENTLY IN F-150 FORD TRUCKS RUNNING THIS ENGINE. *NM
Engine and engine cooling, Dec 21, 2004
2001 FORD F150 CREW CAB. 4.6 V8 HAS A LEAKY HEAD GASKET. FORD IS AWARE OF THE PROBLEM BECAUSE THERE IS A SERVICE BULLITEN. ARTICAL NO.03-6-2 DATED 03/31/03. I FEEL IF THERE ARE MANY LIKE THIS WHY IS THERE NOT A RECALL. *AK
Engine and engine cooling, Equipment, Dec 17, 2004, fire
THE CONSUMER PARKED THE VEHICLE IN THE DRIVEWAY AND HEARD THE HORN HONKING, WHEN THE OWNER WENT TO SEE WHAT WAS HAPPENING, THE ENTIRE VEHICLE HAD GONE UP IN FLAMES. THE FIRE DEPARTMENT WAS NOTIFIED AND THE FIRE CHIEF SAID THE FIRE STARTED UNDER THE HOOD AND THAT IT WAS A MECHANICAL DEFECT WHICH IGNITED THE FLAMES. PROVIDE FURTHER DETAILS. *JB