2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: fuel system
122 reports, newest first. Show all
Fuel system, Gasoline, Aug 3, 2011
I WANT TO KNOW WHY THE RECALL FOR THE GAS TANK STRAPS ON FORD F-150 PICKUPS 1997-2004 IS NOT IN NEBRASKA? BECAUSE NEBRASKA IS A COLD WEATHER STATE AND THEY USE CHEMICALS TO DE-ICE THE ROADS?
Fuel system, Gasoline, Aug 2, 2011
GAS TANK FELL OUT OF MY 2001 F-150 RUPTURING GAS IN THE STREET. COST ME $1500 TO FIX AND CLEAN UP. WHO IS GOING TO PAY FOR THIS? *KB
Fuel system, Gasoline, Aug 2, 2011
2001 F-150 2 DOOR 6 CYLINDER; FUEL TANK DROPPED ONTO ROADWAY DUE TO RUSTED THROUGH TANK STRAP. HAD AUTO REPAIR SHOP FIX: REPLACED FUEL TANK, FUEL TANK STRAPS, FUEL PUMP, FUEL TANK PRESSURE SENSOR, TOWING CHARGE TOTAL BILL $2,600. *KB
Fuel system, Gasoline, Aug 2, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS HAD BEGUN TO RUST. THE CONTACT NOTIFIED THE DEALER AND THE MANUFACTURER OF THE FAILURE, WHO ADVISED THE CONTACT OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE WAS 115,000.
Fuel system, Gasoline, Aug 1, 2011
JUST FILLED THE GASOLINE TANK TO FULL ON SATURDAY EVENING, JULY 30, 2011. LEFT THE STATION AND DROVE ABOUT A 1/4 BLOCK AND THE FRONT PART OF THE GASOLINE TANK FELL OFF. HEARD THE DRAGGING NOISE AND STOPPED. REPAIR GARAGE STATED THEY HAVE REPAIRED MANY WITH THIS SAME PROBLEM. KNEW HOW TO HANDLE IT. CALLED BOB ALLEN FORD IN OVERLAND PARK, KS. ON MONDAY MORNING, AUGUST 1, 2011, AND THEY STATED THEY HAD NO KNOWLEDGE OF ANY TSB ON THE PROBLEM. NEVER MENTIONED THERE MAY BE A RECALL ON IT.
Fuel system, Gasoline, Aug 1, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING 45 MPH, THE CONTACT STATED THAT THE FUEL TANK SUDDENLY DETACHED FROM THE VEHICLE WITH A HALF TANK OF GAS. THE DEALER DID NOT OFFER ANY ASSISTANCE WHEN CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED. A PRIVATE MECHANIC REPLACED THE FUEL FILTER, STRAPS, AND THE FUEL TANK. THE CURRENT MILEAGE WAS 105,861. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Fuel system, Gasoline, Aug 1, 2011
HIT A BUMP AND FRONT GAS TANK STRAP BROKE AND DRAGGED FOR 2 MILES LEAKING GAS,$40, WORTH. STOPPED IN PARKING LOT WITH GAS RUNNING,FIRE DEPARTMENT AND COPS ARRIVED. TRUCK TOWED TO LOT. STILL NOT ATTEMPTED REPAIRS. *KB
Fuel system, Gasoline, Jul 31, 2011
MY 2001 FORD F150 GAS TANK FELL OF MY TRUCK , NOSE FORWARD WHILE DRIVING. RESTRAINTS SEPARATED AND FUEL TANK CAME DOWN ON THE HIGHWAY. I AM VERY LUCKY, NO EXPLOSION OR FIRE ENSUED. HAD TO BE TOWED. CLEARLY THE RESTRAINTS HAD CORRODED. WHOLE SYSTEM NEEDS REPLACEMENT. *TR
Fuel system, Gasoline, Structure, Jul 29, 2011
MY WIFE WAS DRIVING HOME FROM WORK LAST EVENING AROUND 9:00 PM IN OUR 2001 FORD F-150 PICKUP TRUCK WHEN SHE HEARD A NOISE COMING FROM UNDER THE TRUCK. SHE STOPPED TO INVESTIGATE THE SOURCE OF THE NOISE TO FIND THAT THE GAS TANK HAD FALLEN ONTO THE ROAD WHICH PUT A HOLE IN THE TANK WHICH LEAKED OUT ALL THE GASOLINE. THE STRAPS WHICH SUPPORT THE TANK HAD RUSTED OUT CAUSING THE TANK TO FALL OUT. THANKFULLY SHE WAS NOT INJURED. FORD NEEDS TO ADDRESS THIS ISSUE BEFORE SOMEONE IS KILLED. *TR
Fuel system, Gasoline, Jul 28, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT ONE OF THE STRAPS WHICH HELD THE FUEL TANK IN PLACE BROKE OFF FROM THE FUEL TANK AND THE OTHER STRAP WAS RUSTED. NEITHER THE DEALER, NOR MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 170,000.
Fuel system, Gasoline, Jul 21, 2011
DRIVING MY 2001 FORD F-150 DOWN THE HIGHWAY AND THE GAS TANK FELL OFF AND WAS DRAGGING BENEATH THE TRUCK. IT WAS A FULL TANK OF GAS THAT WE WERE LUCKY DID NOT IGNITE. *KB
Fuel system, Gasoline, Jul 19, 2011
2001 FORD F-150. CONSUMER STATES PROBLEM WITH VEHICLE GAS TANK *TGW THE CONSUMER STATED WHILE DRIVING, HE HEARD A LOUD METAL NOISE. HE PULLED TO THE SIDE OF THE ROAD, EXITED THE VEHICLE AND LOOKED UNDERNEATH, ONLY TO DISCOVER THE ENTIRE GAS TANK WAS ON THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE GAS TANK WAS RE-INSTALLED AND THE FUEL TANK STRAPS, PRESSURE SENSOR AND FUEL FILLER NECK WERE REPLACED. *JB UPDATED 07/20/11
Fuel system, Gasoline, Jul 18, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, THE FUEL TANK DETACHED FROM THE VEHICLE AND BEGAN TO LEAK FUEL. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE, BUT WERE UNABLE TO ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 166,000.
Fuel system, Gasoline, Jul 15, 2011
UPON LOOKING UNDER MY TRUCK I NOTICED THE FUEL TANK WAS HANGING DOWN. UPON FURTHER INSPECTION I NOTICED THE REAR STRAP HAD RUSTED AND BROKE APART. THIS LED TO THE REAR OF THE TANK DROPPING DOWN 3-4 INCHES. I REPLACED BOTH STRAPS WITH OEM STRAPS AND AM BACK ON THE ROAD. *TT
Fuel system, Gasoline, Jul 15, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS FRACTURED. THE FAILURE CAUSED THE FUEL LINES TO ALSO FRACTURE AS GASOLINE SPILLED ONTO THE ROADWAY. THE VEHICLE WAS TOWED TO THE DEALER AND REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 82,513.
Fuel system, Other, Jul 12, 2011
APPARENTLY THE STRAPS HOLDING THE GAS TANK ON TO MY 2001 FORD F-150 PICK UP RUSTED. TODAY THE TANK FELL OFF WHILE I WAS DRIVING WHEN ONE OF THE STRAPS LET GO. FORTUNATELY THERE WAS NO FIRE, HOWEVER I SPILLED A FULL TANK OF GAS WHEN THE TANK SPLIT. THE MILEAGE IS 101,000. FORD SAYS IT'S NO LONGER IN WARRANTY EVEN THOUGH THIS SEEMS TO BE A GROWING PROBLEM. *TT
Fuel system, Other, Structure, Jul 12, 2011
2001 F-150 SUPERCREW 4X4 LARIAT 5.4 TRITON 136000 MILES. GREAT TRUCK HOWEVER THE UNDER SIDE OF THIS TRUCK IS LITERALLY RUSTING OUT FROM UNDERNEATH. ROCKER PANELS ARE GONE, BUT A LARGER ISSUE AT THIS TIME IS THE FUEL TANK STRAP HAS RUSTED AND BROKE. PATHETIC RUSTING ON THIS BEAUTIFUL TRUCK. *TT
Fuel system, Gasoline, Jul 11, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK DETACHED FROM THE VEHICLE AS A RESULT OF THE FUEL TANK STRAPS FRACTURING. THE CONTACT STATED THAT THE TANK DID NOT HAVE TO BE REPLACED BUT THE DEALER REPLACED THE STRAPS. THE FAILURE AND CURRENT MILEAGE WAS 137,126.
Steering, Suspension, Fuel system, Gasoline, Structure, Jul 8, 2011
THE FUEL TANK STRAPS ON MY 2001 FORD F150 ARE COMPLETELY RUSTED. OTHER AREAS HAVE ALSO RUSTED OUT SUCH AS THE RADIATOR SUPPORTS - RADIATOR AND SHROUD DROPPED OUT AND ARE HITTING AGAINST THE ENGINE FAN. THE PICK-UP BED OF THE TRUCK IS ALSO RUSTING OUT. UPDATED 08/11/11 *BF THE CONSUMER STATED WHEN HE INSPECTED THE STRAPS, HE FOUND ONE OF THEM COMPLETELY COVERED IN RUST, BUT STILL IN TACT. ALSO, THERE WAS UNUSUAL RUSTING ALL OVER THE UNDERSIDE OF THE VEHICLE. THE ENTIRE LOWER RADIATOR SUPPORT WAS ROTTED OUT AND THE UNDERSIDE OF THE PICK-UP BED AND OTHER SUPPORTS HAVE MAJOR RUST. UPDATED 08/12/11 THE CONSUMER STATED WHEN THE SUPPORT GAVE OUT THE RADIATOR AND RADIATOR SHROUD FELL ONTO THE FAN THAT IS MOUNTED TO THE ENGINE. ALSO, THE BALL JOINTS AND STEERING WERE WEARING PREMATURELY DUE TO LACK OF GREASE FITTINGS. UPDATED 08/30/11 *TR
Fuel system, Gasoline, Jul 7, 2011
CHECKED FUEL TANK STRAPS AFTER SEEING NEWS REPORTS. 1 STRAP BROKEN 2ND STRAP ABOUT TO BREAK. AT DEALER FOR REPLACEMENT AT MY EXPENSE. UPDATED 08/11/11 *BF THE CONSUMER STATED ONE OF THE STRAPS WAS RUSTED THROUGH AND THE OTHER STRAP WAS RUSTED CLOSE TO A COMPLETE BREAK. UPDATED 08/12/11 *TR
Fuel system, Gasoline, Jul 6, 2011
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT WHILE APPROACHING A TRAFFIC LIGHT, THE FUEL TANK SEPARATED FROM THE VEHICLE CAUSING GASOLINE FUEL TO SPILL OVER THE ROADWAY. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO DISCOVERED THAT THE FUEL TANK STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE FAILURE WAS UNDER INVESTIGATION. THE FAILURE AND CURRENT MILEAGE WAS 115,000. UPDATED 08/15/11 *BF THE CONSUMER STATED BOTH STRAPS FAILED, BREAKING IN THE MIDDLE OF THE STRAP. THE TANK DID DROP TO THE GROUND AND WAS DRAGGED A SHORT DISTANCE. THERE WAS DAMAGE TO THE FUEL TANK AND IT HAD TO BE REPLACED. UPDATED 08/24/11 UPDATED 08/31/11 *BF THE VEHICLE HAS SINCE BEEM REPAIRED. UPDATED 09/01/11
Fuel system, Gasoline, Fuel system, Other, Jul 5, 2011
I WAS DRIVING SOUTH ON HWY 41 IN MILWAUKEE, WI. WHEN I HEARD A DRAGGING SOUND UNDER TRUCK. I PULLED OFF HWY AND DISCOVERED MY GAS TANK WAS DRAGGING FOR APPROX. 2 MILES. WHY IT DIDN'T BLOW UP I AM NOT SURE. TWO STRAPS SNAPPED. I HAD JUST FILLED THE TANK W/ $75.00 IN GAS AND HAD TRUCK TOWED AND APPROX. COST OF GETTING TRUCK FIXED IS $700.00 PLUS THE TOW. *KB
Steering, Fuel system, Gasoline, Jul 4, 2011
I HAVE A 2001 FORD F150 REGULAR CAB LONG BED WITH 75,000 MILES. WHILE DRIVING AT APPROXIMATELY 40 MPH THE RIGHT INNER TIE ROD BROKE CAUSING THE VEHICLE TO SHUDDER SIGNIFICANTLY UNTIL I WAS ABLE TO STOP THE VEHICLE. THIS BRIEF SHUDDERING CAUSED THE REAR FUEL TANK STRAP TO SNAP IN HALF PRIMARILY DUE TO EXCESSIVE CORROSION OF THE STRAP. LOSS OF THE SUPPORTING STRAP CAUSED THE REAR OF THE TANK TO DROP ALMOST TO GROUND LEVEL WHICH ALSO BROKE THE FILLER INLET OFF OF THE TOP OF THE TANK, COMPLETELY DISCONNECTING THE FILLER TUBE AND PRESENTING A LARGE HOLE FOR FUEL TO ESCAPE. BOTH OF THESE FAILURES ARE NOT WHAT I WOULD EXPECT FROM A VEHICLE WITH ONLY 75,000 MILES ON THE ODOMETER. EITHER COULD HAVE RESULTED IN SERIOUS INJURY OR PROPERTY DAMAGE. *TR
Fuel system, Gasoline, Jun 30, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 TO 40 MPH HE NOTICED THE TANK HAD DETACHED FROM THE VEHICLE. WHEN HE INSPECTED THE VEHICLE HE NOTICED THAT TWO STRAPS WERE FRACTURED AND WERE SEVERELY RUSTED, BUT NO FUEL HAD SPILLED OUT OF THE FUEL TANK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 126,000.
Fuel system, Gasoline, Jun 29, 2011
BOTH FRONT AND REAR FUEL TANK STRAPS ARE BROKE. TANK IS BEING HELD UP BY FUEL LINE IN REAR. FRONT STRAP BEING HELD ON BY PLASTIC COVER ONLY. IN THE PROCESS OF REPAIRING NOW AT A FORD DEALERSHIP. PARTS COST IS APPROX. $80, LABOR IS STILL NOT CALCULATED. THE CONSUMER STATED BOTH STRAP BROKE IN THE MIDDLE DUE TO SEVERE RUST; THE REAR MORE THAN THE FRONT. THE FUEL LINE WAS STILL IN GOOD SHAPE. IT WAS SUPPORTING THE REAR TANK AFTER THE STRAP BROKE. THE TANK NEVER HIT THE GROUND. WHILE BOTH STRAPS WERE RUSTED OUT COMPLETELY IN THE MIDDLE, THERE WAS A PIECE OF PLASTIC BETWEEN THE STRAP AND THE TANK. THE PLASTIC WAS MOLDED AROUND THE STRAPS WELL ENOUGH THAT THE FRONT OF THE TANK WAS SUPPORTED BY THE PLASTIC PIECE EVEN THOUGH THE METAL STRAP HAD RUSTED AWAY. HOWEVER, THE BACK STRAP HAD RUSTED AWAY TO A POINT THAT THE STRAP FELL AND THE TANK WAS ONLY BEING SUPPORTED BY THE FUEL LINE. UPDATED 09/21/11 *TR