2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints: vehicle speed control
193 reports, newest first. Show all
Vehicle speed control, Jun 30, 2025, fire
The contact owned a 2001 Ford F-150. The contact stated that he parked the vehicle on the street in front of the residence, and ten minutes later, the contact heard the horn abruptly sounding. His son looked out the window and discovered the vehicle in flames. No warning light was illuminated. The contact called 911 about the failure. There were no injuries sustained. The police and fire departments arrived on the scene, and the firefighters extinguished the fire. The fire consumed and destroyed the entire vehicle. The origin of the fire was in the engine compartment of the driver's side. Police and fire department reports were filed. The vehicle was not towed and remained at the residence. The insurance company was notified of the failure; however, pending an inspection. The contact related the failure to NHTSA Campaign Number: 05V017000 (VEHICLE SPEED CONTROL), which was associated with the VIN, and upon research, believed that the recall consequence was related to the fire. The manufacturer was not made aware of the failure and opened a case. The failure mileage was unknown.
Vehicle speed control, Jun 25, 2025, fire
The contact owned a 2001 Ford F-150. The contact stated that while the vehicle was parked and unoccupied, the vehicle caught on fire. The contact stated that a bystander driving by became aware of the fire underneath the hood of the vehicle and used a fire extinguisher to extinguish the fire. The contact stated that failure was caused by brake fluid leaking onto a faulty brake pressor sensor switch, also called a speed control deactivation switch under the hood, and caused the switch to corrode, causing the fire. No injuries were sustained. The contact stated that the Fire Department was not notified of the fire. The vehicle remand at the residence. The vehicle was destroyed. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 05V388000 (VEHICLE SPEED CONTROL); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 283,000.
Vehicle speed control, Feb 27, 2025, fire
The contact owned a 2001 Ford F-150. The contact received notification of NHTSA Campaign Number: 05V017000 (VEHICLE SPEED CONTROL); The contact's husband had left the vehicle unoccupied and parked outside his workplace. The contact's husband was then contacted by his co-workers via walkie-talkie to inform him the vehicle was on fire. When the contact arrived at the scene of the fire, nine other co-workers and himself attempted to extinguish the fire with water and extinguishers however wires were burnt on the front part of the vehicle and they were unsuccessful. The Fire Department was on scene and extinguished the fire. The origin of the fire was unknown, but the fire department did state it had to do with something electric. The fire took place at [XXX] . The vehicle was consumed by the fire. The manufacturer was made aware of the failure. The contact believes the vehicle is a total loss. The vehicle was consumed by the fire. There were no injuries or property damage. A dealer was called and confirmed that there were 2 open recalls associated with the VIN. The failure mileage was unknown. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle speed control, Aug 19, 2024, fire
The contact owns a 2001 Ford F-150. The contact stated while the vehicle was parked and turned off, there was smoke coming from the vehicle. The contact stated the engine compartment had caught on fire. The fire was extinguished by the Fire Department. A fire report was filed, and a fire report number was provided; however, the cause for the failure was not yet determined. A police report was not filed. There were no injuries sustained. The contact had received notification of NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 154,000. Parts distribution disconnect.
Vehicle speed control, Jun 13, 2022, fire
The contact owned a 2001 Ford F-150. The contact stated that he had noticed that the cruise control had stopped functioning. The contact stated that the vehicle had been parked for three hours at his residence driveway with no keys in the ignition and had caught on fire. The contact stated that he had no warning. The vehicle had been engulfed in flames and the fire department had been called and extinguished the fire using water. The contact stated that a fire report was issued. The contact's insurance company declared the vehicle a complete loss. The contact related the failure to an open recall on his vehicle NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The manufacturer had not been informed of the failure. The failure mileage was approximately 230,000.
Vehicle speed control, Service brakes, Apr 14, 2022
The contact's associate owns a 2001 Ford F-150. The contact stated while his associate was driving approximately 35 MPH, the vehicle experienced a braking failure. The ABS warning light was illuminated on the instrument panel. The vehicle was taken to the local dealer where it was diagnosed that the braking system had failed and the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 190,000.
Vehicle speed control, Mar 3, 2020, fire
WHILE GIVING A CUSTOMER A QUOTE (WORK) MY TRUCK STARTED SMOKING. I OPENED THE DRIVER SIDE DOOR FLAMES HAD ALREADY TAKEN OVER, THERE WAS NO SAVING ANYTHING. SO I THEN CALLED 911 & TRIED PUTTING IT OUT WITH WHAT RESOURCES WE DID HAVE. WE HAD TO MANUALLY UNHOOK MY LAWN TRAILER FROM TRUCK TO PREVENT FROM LOOSING MY ENTIRE LIVELIHOOD.
Vehicle speed control, Jan 29, 2019, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE THE CONTACT WAS INSIDE HIS HOUSE, HE NOTICED SMOKE COMING FROM THE HOOD OF THE VEHICLE. THE CONTACT EXTINGUISHED THE FIRE UNDER THE HOOD WITH A FIRE EXTINGUISHER. THE FIRE DEPARTMENT WAS NOT CALLED. THE VEHICLE WAS TOWED BY AAA TO PASO ROBLES FORD (2401 OAKWOOD ST, PASO ROBLES, CA 93446, (805)-239-3673) WHERE IT WAS DIAGNOSED THAT THE CLASSIC CRUISE CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE DEALER MENTIONED AN UNKNOWN RECALL RELATED TO THE FAILURE THAT WAS CLOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DECLINED TO ASSIST SINCE THE CONTACT RECEIVED SEVERAL RECALL NOTICES. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V388000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 160,000.
Vehicle speed control, May 16, 2017, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED AND OFF, SMOKE WAS SEEN COMING FROM UNDER THE HOOD. THE CONTACT STATED THE HOOD WAS OPENED AND FLAMES WERE SEEN IN THE ENGINE. THE CONTACT EXTINGUISHED THE FIRE WITH A WATER HOSE. THE FIRE DEPARTMENT OR POLICE WERE NOT NOTIFIED. THE CONTACT MENTIONED THAT NO DAMAGE WAS SEEN IN THE INTERIOR OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). A CASE WAS ALSO OPENED WITH THE MANUFACTURER WHOM INSTRUCTED THE CONTACT TO HAVE THE VEHICLE TOWED TO A DEALER. THE DEALER DIAGNOSED THE FAILURE AND INFORMED THAT IT WAS RELATED TO THE RECALL AND THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT CAUSING A FIRE. THE FAILURE MILEAGE WAS UNKNOWN.
Vehicle speed control, Engine, Mar 6, 2017, fire
TL* THE CONTACT OWNED A 2001 FORD F-150. WHILE THE VEHICLE WAS PARKED ON THE STREET, AWAY FROM THE CONTACT'S HOME, IT CAUGHT FIRE. THE CONTACT WAS NOTIFIED BY THE NEIGHBOR FOLLOWED BY THE FIRE DEPARTMENT. THE ORIGIN OF THE FIRE WAS FROM THE SPEED CONTROL DEACTIVATION SWITCH/ENGINE AS DESCRIBED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). A POLICE AND FIRE REPORT WERE FILED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS 137,000. THE VEHICLE WAS DESTROYED. ...UPDATED 05/17/17 *BF
Vehicle speed control, Feb 9, 2017, fire
TL* THE CONTACT OWNED A 2001 FORD F-150. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL) AND HAD BEEN UNABLE TO RECEIVE THE PART FROM THE DEALER WITHIN A REASONABLE TIME FRAME TO REPAIR THE VEHICLE. THE DEALER WAS CONTACTED FOR SEVERAL MONTHS. THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND AFTER EXITING THE VEHICLE, A FIRE ERUPTED UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES. THE VEHICLE WAS DESTROYED. THE INSURANCE COMPANY WAS NOTIFIED AND THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER TO INVESTIGATE THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
Vehicle speed control, Jan 23, 2017, fire
MY TRUCK CAUGHT ON FIRE WHILE PARKED WITH THE KEY NOT IN THE IGNITION. THE FIRE BURNED THE TRUCK AND EVERYTHING IN IT COMPLETELY. CRIUISE CONTROL DEACTIVATION SWITCCH RECALL.
Vehicle speed control, Dec 30, 2016
WHILE DRIVING @ 50 MPH OR MORE, IF I LET OFF THE ACCELERATOR PEDAL, IT REMAINS ENGAGED AND THE VEHICLE DOES NOT SLOW DOWN. SOMETIMES IT NEEDS TO BE STEPPED ON 2 - 3 TIMES BEFORE IT WILL DE-ACCELERATE. THIS CAN BE QUITE UNNERVING AND DANGEROUS. WHY HAS FORD NOT ADDRESSED THIS? *TR
Vehicle speed control, Other or unspecified, Dec 8, 2016, fire
THE TRUCK WAS PARKED AFTER BEING DRIVEN 2 MILES. IT HAD STARTED TO SMOKE AND NEXT THING I KNOW IT WAS ON FIRE. I CALLED THE FIRE DEPARTMENT, WHILE MY 15 Y/O SON PUT OUT FIRE WITH A FIRE EXTINGUISHER. IT WAS SAID TO BE A ELECTRICAL FIRE. A FRIEND THAT DRIVES TOW TRUCKS CAME BY TO LOOK AT IT AND SAID IT HAD A RECALL ON IT WHERE IT BURNED. IT BURNED THE MASTER CYLINDER AND FIRE DEPARTMENT SAID IT WAS THE WIRING UNDER THAT, THAT CAUSED THE FIRE. I DID SOME RESEARCH AND FOUND OUT THAT THERE WAS A RECALL. SO I CONTACTED THE FORD COMPANY AND MADE A CLAIM WITH THEM ON THE FOLLOWING THURSDAY AFTER FIRE.I WAS TOLD I SHOULD HAVE A RESPONSE FROM THEM IN 15 BUSINESS DAYS, HERE IT IS 6 1/2 WEEKS LATER AND NOTHING. NOT A LETTER, NOT A PHONE CALL, NOTHING. I CALL AND GET TLD THERE HAS NOT BEEN ANYTHING DONE. I JUST WANT MY TRUCK FIXED. I WANT TO KNOW IF THE FORD COMPANY WILL REPAIR IT OR IF I NEED TO FIX IT MYSELF. MY HUSBAND IS ON DIALYSIS AND HAS MULTIPLE HEALTH ISSUES AND THIS WAS OUR ONLY RUNNING VEHICLE UNTIL THIS HAPPENED. PLEASE HELP.
Vehicle speed control, Nov 28, 2016, fire
AT ABOUT 2:00 A.M. THE VEHICLE WAS PARKED OUTSIDE IN THE DRIVEWAY AND LAST TIME IT HAD BEEN DRIVEN WAS ABOUT 18HRS PRIOR. THE FIRE INITIALLY STARTED UNDER THE HOOD MELTING IT DOWN TO THE ENGINE COMPARTMENT EVENTUALLY THE WHOLE VEHICLE CAUGHT FIRE AND IS NOW TOTAL LOSS.
Vehicle speed control, Apr 20, 2016, crash
WHILE DRIVING AT LESS THAN 25 MPH AND BRAKING THE TRUCK ACCELERATED UNCONTROLLABLY. ENGINE RPM ACCELERATED TO MAX AND TRUCK STRUCK A PARKED VEHICLE AT APPROXIMATELY 5-10 MPH. FULL BRAKE APPLICATION WAS UNABLE TO STOP THE VEHICLE. ENGINE CONTINUED TO REV AT MAX RPM AND WAS TURNED OFF WITH THE IGNITION SWITCH. THIS PREVIOUSLY HAD HAPPENED WHEN MERGING INTO HIGH SPEED TRAFFIC OR PASSING WITH ACCELERATOR PUSHED TO NEAR FULL DOWN POSITION. THIS TIME THE DRIVER HAD HIS FOOT ON THE BRAKE.
Vehicle speed control, Feb 22, 2016, fire
FORD F150 2001 TRUCK CAUGHT FIRE AND WAS TOTALED. TRUCK WAS PARKED OUTSIDE OF HOUSE.
Vehicle speed control, Wheels, Engine, Sep 28, 2015, fire
I HAD BEEN AT MY NEIGHBORS HOUSE FOR OVER 1 1/2 HOURS. WE HEARD A LOUD BOOM THAT SHOOK THE TRAILER WE RAN OUTSIDE AND DISCOVERED THE DRIVERS SIDE TIRE BLEW OUT DUE TO THE FIRE. THE ENTIRE HOOD WAS MELTING DOWN ONTO THE MOTOR . THERE WAS NO ELECTRICAL COMPONENTS LEFT UNDER THE HOOD BY THIS TIME AND THE FIRE WAS SPREADING TO THE CAB , BUT WE FINALLY PUT IT OUT THEN THE FIRE DEPARTMENT CAME . I CALLED MY INSURANCE CO , THEY ARE INVESTIGATING THE CAUSE OF THE FIRE . PLEASE LET ME KNOW IF ANY OF THIS PERTAINS TO MY CASE . THANK YOU *TR
Electrical system, Vehicle speed control, Service brakes, Sep 28, 2015, crash
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE REVERSING, THE VEHICLE CRASHED INTO A TELEPHONE POLE WHEN SHIFTING THE GEAR INTO DRIVE. THE VEHICLE ACCELERATED TO APPROXIMATELY 70-80 MPH. THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO STOP THE VEHICLE. THE VEHICLE CRASHED INTO A GARAGE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Vehicle speed control, Jul 14, 2015
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 05V388000 (VEHICLE SPEED CONTROL); HOWEVER, THE CRUISE CONTROL EXPERIENCED A FAILURE. THE CONTACT STATED THAT THE BRAKE MASTER CYLINDER WHERE THE SPEED CONTROL SENSOR WAS LOCATED WAS FRACTURED, CAUSING THE BRAKE FLUID TO LEAK OUT OF THE CYLINDER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED, BUT THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 246,000.
Vehicle speed control, Engine, Jul 7, 2015, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE THE VEHICLE WAS PARKED APPROXIMATELY 12 FEET FROM THE CONTACT'S RESIDENCE, THE SECURITY ALARM SOUNDED. THE CONTACT OBSERVED FLAMES COMING FROM THE FRONT OF THE VEHICLE THAT SPREAD TO THE DRIVER'S SIDE OF THE VEHICLE WITHOUT WARNING. THE FIRE WAS EXTINGUISHED BY THE CONTACT AND OTHER INDIVIDUALS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
Vehicle speed control, Engine, Sep 22, 2014, crash
THE GAS PEDDLE STUCK ON THE FOR F150, I SEE COMPLAINT AND A RECALL ABOUT THE ESCAPE, BUT WHAT ABOUT THE FORDS? ON THE INTRANET ARE SEVERAL COMPLAINTS ABOUT THE SAME ISSUE WITH THE FORD TRUCKS. WE HAD A MAJOR ACCIDENT AND OUT TRUCK WAS DESTROYED DUE TO THIS. *TR
Vehicle speed control, Jul 30, 2014
2001 FORD F-150. CONSUMER WRITES IN REGARDS TO THE SPEED CONTROL DEACTIVATION SWITCH FIRE RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE WAS REPAIRED, PRIOR TO RECEIVING THE RECALL NOTICE, AS IT WAS A SERIOUS FIRE HAZARD, BECAUSE THE VEHICLE STARTED SMOKING. THE CONSUMER IS SEEKING REIMBURSEMENT, BUT HAS BEEN MET WITH GREAT DIFFICULTY FROM FORD. *JB
Vehicle speed control, Jun 17, 2014, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT FOURTEEN HOURS AFTER PARKING THE VEHICLE, IT BURST INTO FLAMES WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE HAD BEEN REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 05V388000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS CONTACTED AND THERE WERE NO INJURIES REPORTED. IN ADDITION, THE CONTACT STATED THAT PART OF HIS GARAGE WAS DAMAGED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 130,000.
Vehicle speed control, Engine, Jun 4, 2014, fire
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE CAUGHT FIRE WHILE IT WAS PARKED. THE FIRE DEPARTMENT STATED THAT THE FIRE INITIATED IN THE ENGINE NEAR THE MASTER CYLINDER AREA. THE CONTACT ALSO STATED THAT NHTSA CAMPAIGN NUMBER: 06V286000 (VEHICLE SPEED CONTROL) WAS RECEIVED AFTER THE FAILURE OCCURRED. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.