2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints
1,340 reports, newest first.
Vehicle speed control, Oct 13, 2009, fire
ON OCTOBER 7TH MY FORD F-150 STARTED ON FIRE AND BURNED UNDER THE HOOD. I HAD TAKEN MY TRUCK FROM ONE SIDE OF TOWN TO THE OTHER ABOUT 12 MILES. I PARKED AND STARTED TO UNLOAD SOME TOOLS OUT OF IT AND WENT INSIDE. AFTER ABOUT 5 MINUTES THE MAN I WAS TALKING TO SAID WHAT IS GOING ON WITH YOUR TRUCK IT IS SMOKING. I RAN OUT TO THE TRUCK AND SMOKE WAS BILLOWING OUT OF THE HOOD UP THE WINDSHIELD AND SIDES. I POP THE HOOD AND FLAMES SHOT OUT ABOUT 4 FOOT UP FROM THE ENGINE COMPARTMENT. I WAS ABLE TO PUT THE FIRE OUT WITH A FIRE EXTINGUISHER AND A BUCKET OF WATER FROM NEARBY, JUST PLAIN LUCK. I HAD CONTACTED THE FIRE DEPARTMENT AS THE FIRE WAS BURNING AND THEY CAME OUT TO MAKE SURE EVERYTHING WAS ALRIGHT. THE TOW TRUCK DRIVER CAME THE NEXT DAY AND SAID THIS LOOKS LIKE A FORD FIRE SO THAT BRINGS ME HERE. I NEED TO START A COMPLAINT AND FIND OUT WHERE I FIND A PERSON TO INVESTIGATE THE CAUSE OF THIS FIRE. *TR
Engine and engine cooling, Oct 3, 2009
FORD 5.4 LITERS HAVE THE SPARKPLUG BLOW OUT OF THE CYLINDER HEAD VERY OFTEN 4 HAVE HAPPEN TO MY 2001 FORD F150 WITH THE 5.4 THEY WANT YOU TO USE A THREAD INSERT TO REPAIR THE DAMAGE BUT EVEN THEN IT STILL HAPPENS NOT TO MENTION PRETTY EXPENSIVE TO BOOT IT IS A WELL KNOWN PROBLEM WITH THESE MOTORS THEY ALSO BREAK THE COIL PACKS ON TOP OF THE SPARK PLUG FORD KNOWS OF THE PROBLEM BUT WILL NOT FIX. *TR
Electrical system, Oct 2, 2009, fire
TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE THE VEHICLE WAS PARKED IT CAUGHT FIRE ON THE DRIVER SIDE. THE FIRE DAMAGED THE DRIVE WAY WHERE THE VEHICLE WAS PARKED. THE FIRE DEPARTMENT STATED THAT THE FIRE WAS CAUSED BY AN ELECTRICAL SHORTAGE. THE CONTACT IS AWARE OF THE SAFETY RISK SINCE THE FIRE NEARLY BURNED HIS HOME TO THE GROUND. THE CURRENT AND FAILURE MILEAGES WERE 220,000.
Air bags, Sep 29, 2009, crash
WE WERE INVOLVED IN AN ACCIDENT ON 09/23/09 IN MY HUSBAND'S 2001 FORD F150 PICK UP TRUCK. WE HIT AN INDIVIDUAL WHO RAN A STOP SIGN. WE HIT HIM GOING APPROX 55 MPH. THE TRUCKS AIRBAGS DID NOT DEPLOY. THIS IS THE FIRST TIME WE HAVE BEEN INTO AN ACCIDENT WITH THIS TRUCK AND OUR COMPLAINT IS...WHEN YOU BUY A PRODUCT, YOU EXPECT THE SAFETY FEATURES TO WORK. WE HAVE NEVER RECEIVED ANY TYPE OF RECALL ON THE AIRBAGS OR AIRBAG SYSTEM. MY HUSBAND TRUCK IS TOTALED. THE IMPACT DESTROYED THE FRONT OF HIS TRUCK. THE EMT'S AND FIREMAN ON SCENE SAID WE WERE VERY LUCKY WITH THE IMPACT THAT WE HAD SUSTAINED AND NO AIRBAGS DEPLOYING. *TR
Engine and engine cooling, Sep 22, 2009, fire
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT WHILE EATING DINNER, THE FIRE DEPARTMENT INFORMED HER THAT HER VEHICLE CAUGHT ON FIRE. THE FLAMES WERE EXTINGUISHED, AND SHE HAS A COPY OF THE REPORT. THE INSURANCE COMPANY WAS IN THE PROCESS OF INVESTIGATING THE CAUSE OF THE FAILURE. SHE WAS IN THE PROCESS OF CONTACTING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 147,300.
Engine and engine cooling, Sep 17, 2009, fire
2001 FORD F150 CAUGHT FIRE IN THE MIDDLE OF THE NIGHT AND WAS COMPLETELY DESTROYED. VEHICLE HAD NOT CRANKED IN OVER 24 HRS., AND NO KEYS WERE IN THE IGNITION. *TR
Engine and engine cooling, Sep 14, 2009, fire
DRIVING HOME IN MY 2001 F150 SUPERCREW AND WHEN I TURNED ON THE A/C FAN, SMOKE STARTED COMING OUT FROM UNDER THE GLOVE BOX. I PULLED OVER AND LOOK UNDER THE BOX AND NOTICED THE CONNECTOR TO THE FAN SPEED PACK WAS BURNING. I BLEW IT OUT BEFORE IT DID ANY FURTHER DAMAGE, THEN UNPLUGGED IT. NO ISSUES SINCE THEN. *TR
Engine and engine cooling, Sep 3, 2009
I HAVE A 2001 FORD F-150 XLT 4.6L WITH 151,000 MILES. A FEW DAYS AGO, I WAS DRIVING ON INTERSTATE 64 AND HEARD A LOUD POP FROM THE ENGINE AREA. THE ENGINE STARTED TO MISS VIOLENTLY. I PULLED TO THE SIDE OF THE ROAD, RAISED THE HOOD AND NOTICED THE SPARK PLUG HAD BLOWN OUT. OF COURSE, I COULD NOT DRIVE THE TRUCK ANYWHERE SO MY 10 YEAR OLD SON AND I HAD TO WAIT FOR AN HOUR FOR A TOW TRUCK. AFTER SOME RESEARCH, I REALIZE THAT THIS HAS HAPPENED TO THOUSANDS OF PEOPLE. FORD SEEMS TO BLAME INCORRECT TORQUING OF THE SPARK PLUGS, BUT MOST PEOPLE BLAME A POOR DESIGN IN THE SMALL QUANTITY OF THREADS HOLDING THE SPARK PLUG. I CAN SAY THAT NO ONE HAS TOUCHED THE PLUGS IN THIS TRUCK EXCEPT FOR A FORD DEALERSHIP WHEN THE PLUGS WERE CHANGED AT 75,000 MILES. I AM NOW STUCK WITH AN ENORMOUS REPAIR BILL OF OVER $2000 FOR INSTALLATION OF A NEW HEAD AND COIL PACK (NOT TO MENTION A TOW BILL AND THE STRESS OF BEING STRANDED ON THE INTERSTATE AND NOT OWNING A FUNCTIONAL VEHICLE). IF THIS IS A DESIGN ISSUE, THEN FORD NEEDS TO AT LEAST MAKE THE REPAIRS AFFORDABLE. *TR
Engine and engine cooling, Aug 23, 2009
MY 4.6L ENGINE ON MY 2001 FORD F150 PICKUP TRUCK NEEDED NEW SPARK PLUGS. I HAVE CHANGED PLUGS ON MANY MOTORS BEFORE SO IT IS NOT NEW TO ME. I READ THE SERVICE MANUAL AND LEARNED MORE ABOUT THIS PARTICULAR MODEL BY READING INFORMATION OFF THE NET. I WAS VERY CAREFUL AND DID EVERYTHING THE SERVICE MANUAL AND NET INFO TOLD ME TO DO. EVEN SO, THE VERY FIRST PLUG I REMOVED FROM THE ENGINE BLOCK BROKE. THE PORCELAIN AND HEX NUT CAME OUT IN ONE PIECE BUT THE BOTTOM THREADS AND GROUND ELECTRODE REMAINED IN THE ENGINE BLOCK. I WENT BACK TO THE NET TO SEARCH FOR SOLUTIONS TO THE PROBLEM ONLY TO FIND THAT MORE OFTEN THAN NOT THE SPARK PLUGS ON THESE MODELS WILL BREAK APART WHEN REMOVING THEM. I BELIEVE THIS FALLS UNDER THE CATEGORY OF A RECALL. THIS WILL BE A COSTLY REPAIR THAT I CANNOT DO MYSELF AND I DON'T BELIEVE FORD CAN JUSTIFY THIS MANY PLUGS BREAKING. *TR
Structure, Aug 22, 2009
2001 FORD F-150: PAINT IS PEELING OFF THE ROOF, HOOD, AND TAILGATE AREAS. TWO BODY SHOPS ADVISE THAT THIS IS A KNOWN DEFECT WITH THE FORD PAINTING PROCESSES USED FOR THIS YEAR VEHICLE. ALSO EXPERIENCING INTERIOR RUSTING PROBLEMS. FORD ADVISES THAT THEY WILL NOT REMEDY THIS PROBLEM. I AM THE ORIGINAL PURCHASER OF THIS VEHICLE. VEHICLE HAS BEEN WELL MAINTAINED. I HAVE NEVER EXPERIENCED PAINT ISSUES LIKE THIS WITH ANY OTHER VEHICLE. *TR
Seat belts, Aug 12, 2009
TL*THE CONTACT OWNS A 2001 FORD F-150. SINCE THE DATE OF PURCHASE, THE CONTACT NOTICED THAT THE DRIVER'S SIDE SEAT BELT WOULD NOT LATCH AND CONNECT. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 155,000 AND FAILURE MILEAGE WAS 63,000.
Engine and engine cooling, Aug 7, 2009
I OWN A 2001 FORD F150 PICKUP. I'VE HAD TO CHANGE A COIL (ABOVE SPARK PLUG) ON THIS TRUCK SEVERAL TIMES (AT LEAST 5 FAILURES) SINCE I'VE OWNED THIS TRUCK. WHEN A COIL GOES OUT THE TRUCK MISSES A LOT AND AT TIMES WHEN YOU SLOW DOWN TO TURN A CORNER THE TRUCK WILL DIE, CAUSING ME TO BRAKE TO AN IMMEDIATE STOP BECAUSE THE POWER STEARING GOES OUT. VERY DANGEROUS. *TR
Engine and engine cooling, Jul 22, 2009
SPARK PLUG BLOWN OUT OF ENGINE. 2 YEARS AFTER DEALER INSTALLED. *TR
Power train, Jul 20, 2009, crash
TL*THE CONTACT OWNS A 2001 FORD F-150. WHEN THE CONTACT PLACED THE VEHICLE INTO PARK AND EXITED, THE VEHICLE ROLLED BACKWARDS AS IF THE GEAR WAS PLACED INTO REVERSE. SHORTLY AFTER, THE VEHICLE APPEARED TO GAIN SPEED AND DID NOT STOP UNTIL IT CRASHED INTO A TREE. THE VEHICLE WAS UNOCCUPIED AT THE TIME OF THE CRASH, BUT THE AIR BAGS FAILED TO DEPLOY AND THE EMERGENCY BRAKE WAS NOT ENGAGED. THERE WAS A LOT OF DAMAGE TO THE LANDSCAPING AS WELL AS A FENCE. THE VEHICLE APPEARS TO HAVE A LOT OF DAMAGE ALSO, BUT IT HAS NOT YET BEEN INSPECTED. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 110,000.
Vehicle speed control, Jul 13, 2009, fire
ON 7/10/09 (FRIDAY) MY FORD 2001 F150 SUPERCREW WAS PARKED AT MY RESIDENTS AROUND 7:30PM. ABOUT 30 MINS. AFTER THE VEHICLE WAS TURNED OFF, SMOKE BEGAN TO COME OUT OF THE HOOD, DRIVERS SIDE. IT SMOKED FOR ABOUT 5-10 MINS. I LIFT THE HOOD AND SAW THE WIRES AND CONNECTION PLUG TO THE SPEED CONTROL DEACTIVATION SWITCH WAS STILL SMOLDLERING. AFTER IT COLD DOWN I DISCONNECTED THE PLUG FROM THE SWITCH (THE TOTAL DAMAGE AT THIS TIME SEEMS TO BE THE FAULTY SPEED CONTROL DEACTIVATION SWITCH, THE SWITCH CONNECTION PLUG AND SOME WIRES LEADING UP TO THE PLUG). ON 7/13/09(MONDAY)I HAD THE VEHICLE TOWED TO MY LOCAL MECHANIC TO INSPECT AND REPAIR THE DAMAGE.I ALSO PLACED A CLAIM WITH MY INSURANCE CO..ALONG WITH CALLING THE NEARS FORD DEALER(ABOUT 50 MILES AWAY) AND GOT A "WILL CALL YOU BACK" ANSWER, ALSO THEY WERE SUPPOSE TO HAVE DISCONNECTED THE SWITCH THREE YEARS PRIOR WHEN I HAD THE VEHICLE IN TO THEM FOR ROUTINE MAINTENANCE ( I WAS SENT A NOTICE OF RECALL FROM FORD MOTOR CORP. ALONG WITH THE DEALERS COMPUTER FLAGGING IT TOO FOR THIS PROBLEM), I ALSO CALLED FORD'S 800 CUSTOMER SERVICE HOTLINE AND FILED A REPORT WITH THEM (THEY SAID I DID NOT HAVE TO TAKE THE VEHICLE TO THE DEALER SINCE I HAD ALREADY FILED A INSURANCE CLAIM AND HAD IT ALREADY TOWED TO A REPAIR SHOP. AS OF 5:00 PM PST, ON 7/13/09 I AM WAITING FOR MY INSURANCE AGENT TO LOOK AT THE VEHICLE AND AUTHORIZE REPAIR. I AM HAVING THE REPAIR SHOP SAVE THE OLD PARTS. *TR
Engine and engine cooling, Jul 6, 2009
I HAVE A FORD F-150 2001 WITH TRITON 5.4 V8 I STARTED MY TRUCK AND HEARD A LOUD POP AND THEN WHAT SOUNDED LIKE A VERY BAD EXHAUST LEAK. COME TO FIND OUT THE BACK SPARKPLUG ON PASSENGER SIDE BLEW OUT. I HAD TO HAVE A NEW COIL NEW PLUG AND HELICOIL INSTALLED. *TR
Tires, Jun 21, 2009
THE FAMILY WAS TRAVELING ON US HIGHWAY 77 ABOUT 45 MILES NORTH OF RAYMONDVILLE ON KING RANCH IN 2001 F150 SUPERCREW (LARIET). WE HEARD A LOUD EXPLOSION AND SAW SMOKE COMING FROM REAR TIRE ON PASSENGER SIDE. WE HAD COMPLETE TREAD SEPARATION BUT DID NOT LOSE AIR. WE WERE ABLE TO DRIVE TO CROSSOVER TO CHANGE TIRES. THERE WAS EXTENSIVE DAMAGE TO THE TRUCK'S WHEEL WELL, FIBERGLASS FENDER, AND REAR PANEL OF TRUCK. ACCORDING TO COLLISION CENTER, IT IS AT LEAST $1800 WORTH OF DAMAGE. *TR
Engine and engine cooling, Jun 7, 2009
2001 FORD F150 SPARK PLUG BLOWOUT HAS LEFT ME WITHOUT A VEHICLE AND OUT OF MONEY NOW. ACCORDING TO MY RESEARCH THIS IS A COMMON PROBLEM AMONG ALL FORD V8'S AND V10'S FROM 1999 TO 2002. THE PROBLEM IS DUE TO LACK OF THREADS IN THE ALUMINUM HEADS (ONLY FOUR THEADS), AND HAS RESULTED IN SEVERAL FIRES AND EXTENSIVE PROPERTY DAMAGE. APPARENTLY ALL ATTEMPTS AT A RECALL AND CLASS ACTION LAW SUIT HAVE BEEN MET WITH RELATIVE DISREGARD. DESPITE THE FACT THAT FORD REDESIGNED THEIR HEADS AFTER 2002 TO CORRECT THIS PROBLEM THEY STILL REFUSE ANY ASSISTANCE TO CUSTOMERS WHO SUFFER DUE TO THEIR DESIGN FLAW. APPARENTLY SOMEONE WILL HAVE TO DIE FROM THE ENGINE FIRE BEFORE ANYTHING WILL BE DONE. AND EVENTUALLY SOMEONE WILL DIE, IF THEY HAVEN'T ALREADY. PERHAPS A DEATH DUE TO THIS PROBLEM MIGHT FORCE LEGAL ACTION. I'M CURRENTLY LOOKING AT OVER $3000 WORTH OF REPAIR COST, THE VEHICLE CANNOT CURRENTLY BE DRIVEN DUE TO RISK OF FIRE. PLEASE REFER TO CONSUMERCOMPLAINTS.COM FOR A LIST OF THOUSANDS OF INDIVIDUALS WHO HAVE SUFFERED BECAUSE OF FORD'S DESIGN FLAW. *TR
Structure, May 29, 2009
2001 FORD F150 SUPER CREW, THE FRAME AND CAB COMPLETELY ROTTEN/RUSTED OUT 118,000 MILES SO (YOU KNOW IT STARTED ALONG TIME BEFORE)THE REST OF THE TRUCK LOOKS LIKE NEW. AS IS, THE TRUCK IS NOT SAFE TO BE ON THE ROADS AND WILL NOT PASS STATE INSPECTIONS. ANY OTHERS LIKE THIS? *TR
Engine and engine cooling, May 28, 2009, fire
TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT HIS VEHICLE HAD BEEN PARKED AT HIS RESIDENCE FOR THREE DAYS WHEN IT CAUGHT FIRE. THE FIRE ORIGINATED UNDER THE HOOD OF THE VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS ATTACHED TO A BOAT, WHICH WAS ALSO DAMAGED IN THE FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THE CONTACT WAS ADVISED TO CALL THE FORD MANUFACTURER. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 125,000.
Vehicle speed control, May 17, 2009, fire
2001 FORD F150 CAUGHT ON FIRE OUTSIDE MY HOUSE YESTERDAY. IT HAD BEEN PARKED FOR ABOUT 45 MINS. TO AN HOUR. IT LOOKS LIKE MOST OF THE HEAT DAMAGE IS ON THE DRIVERS SIDE PART OF THE VEHICLE. THE FIRE DEPARTMENT FINALLY CAME AND PUT OUT THE FIRE. DAMAGE WAS CONTAINED TO THE ENGINE AND THE OUTSIDE OF THE VEHICLE THAT WAS SUBMITTED TO THE HIGHER TEMPERATURES. THE INSIDE HAS A STRONG SMELL OF BURNT PLASTIC. *TR
Vehicle speed control, May 14, 2009, fire
JUST GOT HOME AND PARKED MY TRUCK. I LEFT 15 MINUTES LATER IN MY OTHER VEHICLE. WHILE I WAS GONE (APPROX. 20 MINUTES LATER) MY TRUCK CAUGHT ON FIRE. LOOKS LIKE THE CRUISE CONTROL SWITCH ON THE BRAKE MASTER CYLINDER, WHICH IS A FORD RECALL. MY NEIGHBORS PUT OUT THE FIRE. THIS IS THE FIRST ACTION I HAVE TAKEN. *TR
Vehicle speed control, May 6, 2009
2001 FORD F150 TRUCK HAS A RECALL FOR THE CRUISE CONTROL HARNESS. *NJ THE CONSUMER STATED THE CRUISE CONTROL HARNESS WAS REPLACED UNDER RECALL, BUT AT THE TIME OF REPLACEMENT, THE SWITCH WAS NOT LEAKING, BUT NOW IT IS LEAKING. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALER, BUT WAS TOLD THE RECALL WAS CLOSED OUT AND THERE WAS NOTHING THEY COULD DO BUT CHARGE HIM TO FIX IT. *JB
Engine and engine cooling, Apr 30, 2009
I HAVE 2001 FORD F150. TRITON V8 ENGINE. DRIVING UNDER VERY LIGHT LOAD, GOING 35 MPH THE NUMBER 1 CYLINDER SPARK PLUG SHOT OUT AND CAUSED DAMAGE TO THE THREADS. *TR
Engine and engine cooling, Apr 28, 2009
I HAVE A 2001 FORD F150 WITH THE 4.6L TRITON. DRIVING HOME FROM WORK ON THE EVENING OF APRIL 27TH, IM AT A RED LIGHT. AS SOON AS IT TURNS GREEN I PUSH THE PEDAL TO GO. OUT COMES THE SPARK PLUG FROM THE BLOCK. I HAVE READ NUMEROUS COMPLAINTS ABOUT THIS ISSUE ON THE INTERNET. I CANNOT BELIEVE FORD HAS NOT ISSUED A RECALL OVER THIS. NOT ONLY IS IT DANGEROUS, BUT ITS A SILLY PROBLEM TO HAVE. I HAVE HAD 5 ESTIMATES TO FIX THIS PROBLEM ALL OVER $2000. THERE'S NO WAY I CAN AFFORD THIS, I AM LOOKING FOR A CLASS ACTION LAWSUIT TO JOIN. VERY DISAPPOINTED IN FORD AND WHEN I GET THIS FIXED I WILL NEVER OWN ANOTHER FORD VEHICLE. *TR