2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints
1,340 reports, newest first.
Air bags, Apr 20, 2006, fire
DT*: THE CONTACT STATED BOTH FRONTAL AIRBAGS DEPLOYED, WITHOUT AN ACCIDENT, WHILE PULLING SLOWLY OUT OF THE DRIVEWAY AT 25MPH. SHORTLY AFTER THE DEPLOYMENT THE DRIVER SIDE AIRBAG ERUPTED IN FLAMES. THE FIRE WAS EXTINGUISHED BY THE DRIVER WITH SNOW FROM OUTSIDE THE VEHICLE. NEITHER THE POLICE NOR FIRE DEPARTMENTS WERE CONTACTED. NO INJURIES WERE SUSTAINED. THE INSURANCE AGENCY DETERMINED THE DEPLOYMENT WAS CAUSED BY A MANUFACTURING DEFECT. THE MANUFACTURER ONLY REFERRED THE CONTACT TO THE INSURANCE COMPANY. THE AIRBAGS WERE REMOVED BY THE CONTACT AND VEHICLE IS CURRENTLY BEING USED "AS IS."
Engine and engine cooling, Apr 17, 2006
WHILE DRIVING, THE "SERVICE ENGINE SOON" LIGHT CAME ON. I DROVE TO THE AUTO REPAIR SHOP AND IT WAS DETERMINED IT WAS THE EGR PRESSURE SENSOR DEFECT. I WAS TOLD BY THE REPAIR SHOP THAT HE THOUGHT THIS MIGHT BE A RECALL ITEM ON THE FORD F150. I SEARCHED FOR RECALL NOTICES ON MY TRUCK AND CONTACTED THE LOCAL FORD DEALERSHIP. I WAS TOLD THAT THERE WAS NOT A RECALL FOR THE EGR, BUT A TECHNICAL SERVICE BULLETIN WAS ISSUED AND FORD SENT OUT LETTERS TO HAVE CUSTOMERS COME IN A HAVE ITEM REPLACED BECAUSE OF NUMEROUS COMPLAINTS. MY TRUCK WAS INELIGIBLE BECAUSE I NOW HAVE OVER 72, 000 MILES. FORD WILL NOT HONOR THE TSB AT NO COST AND THE REPAIRS WILL COST OVER $250. WHY IS THEIR A MILEAGE REQUIREMENT FOR A MECHANICAL DEFECT THAT FORD HAS ACKNOWLEDGED? *JB
Suspension, Apr 12, 2006
DT*: THE CONTACT STATED THE FRONT TIRES HAVE EXCESSIVE WEAR. THE CONTACT HAS REPLACED THE UPPER AND LOWER BALL JOINTS, SHOCKS, SPRINGS, CALIPERS, ROTORS, PADS, AND TIRES HOWEVER; THIS DID NOT REMEDY THE PROBLEM. THE DEALER IS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. UPDATED 05/10/06
Seat belts, Apr 9, 2006
I BELIEVE THE 2001 FORD SEAT-BELT RECALL WAS INADEQUATE AND THE LATCHES ARE CONTINUING TO BREAK INTERNALLY. I AM RESPECTFULLY REQUESTING THAT ALL THE LATCHES BE REPLACED. MY REASONING IS AS FOLLOWS: I OWN A 2001 FORD F150. IN 2001 I TOOK IT IN FOR THE SEAT-BELT RECALL. FORD REPLACED ONE LATCH (THE DRIVERS BELT LATCH). LAST WEEK THE LATCH ON MY SON'S SEAT BELT FAILED. THE LATCH BROKE INTERNALLY. I WENT TO THE DEALERSHIP TO HAVE THE LATCH REPLACED UNDER THE RECALL. I TOLD THEM THEIR SEAT BELT LATCHES WERE FAILING. THEY TOLD ME THERE WAS NO OPEN RECALL ON THE VEHICLE. I WAS TOLD BY THE FORD MOTOR COMPANIES CUSTOMER SERVICE PERSON THAT THE SEAT-BELTS ARE ONLY WARRANTED FOR 5 YEARS/50,000 MILES. MY TRUCK HAS 55,000 MILES ON IT. I TOLD THEM SEAT-BELTS SHOULD NEVER FAIL. HE TOLD ME SEAT-BELTS DO FAIL AND HE HAS SEEN THEM FALL APART BEFORE (THE CONVERSATION MAY HAVE BEEN RECORDED FOR QUALITY PURPOSES). FORD IS TAKING THE POSITION THAT IF ONE OF MY FAMILY MEMBERS DIES DUE TO A SEAT BELT FAILURE THAT IT IS NOT THEIR PROBLEM SINCE THEIR SEAT BELTS ARE ONLY WARRANTED FOR 5 YEARS/50,0000 MILES. THAT IS NOT ACCEPTABLE. TO DATE 40% OF THE SEAT BELT LATCHES IN MY VEHICLE HAVE FAILED (I HAVE 5 LATCHES IN MY VEHICLE 2 HAVE FAILED). FORD IS FAILING TO TAKE RESPONSIBILITY FOR THE DEFECTIVE SEAT-BELTS AND JEOPARDIZING THE LIVES OF MILLIONS OF PEOPLE. FURTHERMORE THEY ARE NOT TELLING NEW CAR BUYERS THAT THEIR SEAT-BELTS ARE ONLY WARRANTED FOR 5 YEARS/50,000 MILES. NOR ARE THEY PROVIDING ANY KIND OF CONSUMER INFORMATION CONCERNING RECOMMENDED REPLACEMENT/MAINTENANCE FOR THE SEAT-BELTS. IF YOU REQUIRE ANY TESTIMONY OR ASSISTANCE FROM ME CONCERNING ANY DEATHS, INJURIES OR OTHER MATTERS INVOLVING THESE DEFECTIVE SEAT BELTS I WILL BE GLAD TO ASSIST. SINCERELY ROBERT RASSI OCCUPATION: QUALITY ASSURANCE MANAGER BSIE INDUSTRIAL ENGINEER STATISTICAL SIX SIGMA BLACK-BELT 623-670-3122. *NM
Power train, Mar 28, 2006
DT*: THE CONTACT STATED WHILE ATTEMPTING TO PUT THE VEHICLE IN REVERSE IT WOULD NOT MOVE BACKWARD. ADDITIONALLY, WHEN PUT IN PARK THE VEHICLE WOULD ROLL. THE DEALER INSPECTED THE VEHICLE AND NOTED THE PLANETARY GEAR IN THE TRANSMISSION NEEDED TO BE REPLACED. THE DEALER REBUILT THE TRANSMISSION AND CORRECTED THE PROBLEM. UPDATED 05/03/06. *JB
Tires, Mar 15, 2006
DT*: THE CONTACT STATED WHILE DRIVING 25 MPH THE CABLE THAT SECURES THE SPARE TIRE IN PLACE FRACTURED WITHOUT WARNING. THE INCIDENT OCCURRED ON MARCH 13, 2006. *AK UPDATED 4/6/2006 - *NM
Vehicle speed control, Mar 15, 2006, fire
WOKE UP IN THE MORNING TO TRUCK ON FIRE..CALLED THE FIRE DEPARTMENT RIGHT AWAY AS VEHICLE WAS PARKED CLOSE TO HOME THEY WERE ABLE TO PUT IT OUT...THANKFULLY ONLY DAMAGE OUTSIDE OF VEHICLE WAS TO THE PAVERS ON DRIVEWAY..DID CALL FORD COMPANY AND MY NAME WAS NOT EVEN LISTED AS OWNER OF VEHICLE...OLD OWNER WAS...PROBABLY WHY I NEVER RECEIVED THE RECALL NOTICE. *NM
Seats, Mar 13, 2006
I OWN A 2001 FORD F150 LARIET OFF ROAD PICK UP TRUCK WITH A SUPERCAB. THE REAR SEATS IN THE TRUCK DO NOT HAVE ANY HEADRESTS. MY SEVEN YEAR OLD DAUGHTER CONSTANTLY HITS HER HEAD ON THE REAR WINDOW BECAUSE THERE IS NO HEADREST. I AM VERY CONCERNED ABOUT WHAT COULD HAPPEN TO HER IF MY VEHICLE WAS STRUCK FROM THE REAR WITH HER IN THAT SEAT. I CAN'T ALLOW HER TO SIT IN THE FRONT SEAT AS OF YET AND CAN'T FIND ANY HEADREST ALTERNATIVES TO CORRECT THE PROBLEM. I BELIEVE THAT THIS WAS A POOR DESIGN BY FORD AND I THINK THEY KNOW IT TOO SINCE ALL OF THE NEWER MODELS HAVE REAR HEADRESTS. I NEVER EVEN THOUGHT ABOUT IT UNTIL AFTER I PURCHASED THE TRUCK. I JUST THOUGHT YOU SHOULD BE AWARE OF THE PROBLEM AND WONDERED IF YOU HAD ANY SIMILAR COMPLAINTS. THANKS! *NM
Vehicle speed control, Mar 10, 2006, fire
OUR FORD F-150 TRUCK, [XXX], CAUGHT FIRE AT 2:30 AM ON FEB 10, 2006. IT WAS PARKED BESIDE OUR HOME AND MELTED THE VINYL SIDING ON THE SIDE OF THE HOME WHERE THE FIRE STARTED. THE TRUCK WAS PARKED AND THE LAST TIME IT WAS DRIVEN WAS 8:30 PM , FEB 9, 2006. WE RECEIVED A RECALL FOR THE CRUISE CONTROL IN SEPT, 2005. THE TRUCK WAS TAKEN TO BURNS FORD IN LANCASTER, SC AND WAS DISCONNECTED IN OCT, 2005. THE DEALERSHIP DID NOT HAVE THE REPLACEMENT PART TO INSTALL, THE PART WAS TO COME IN FEB, 2006. THE TRUCK BURNED BEFORE THE REPLACEMENT WAS INSTALLED. WE HAVE TRIED TO FIND OUT THE CAUSE OF THIS FIRE BY CONTACTING FORD MOTOR COMPANY'S CONSUMER AFFAIRS DEPARTMENT. WE ARE NOT GETTING ANY RESPONSE. PICTURES WERE SENT TO FORD VIA CERTIFIED MAIL, AND A CONFIRMATION THAT THE CD WITH THE PICTURES WERE RECEIVED BY FORD ON 2-28-06. WE HAVE EMAILED FORD, LEFT VOICE MAILS TO FIND OUT THE STATUS OF THEIR INVESTIGATION AS TO THE CAUSE AND HAVE NOT BEEN CONTACTED. WE ARE EXTREMELY DISAPPOINTED IN THE WAY FORD IS HANDLING THIS. THE VEHICLE WAS TAKEN TO CEDESCO ROZZELLES FERRY RD IN CHARLOTTE, NC. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Mar 8, 2006
MY 2001 FORD F150 XLT CREW CAB EJECTED A SPARK PLUG ON 03-03-06. THE EJECTED SPARK PLUG CAME FROM THE SECOND CYLINDER FROM THE FIREWALL, ON THE PASSENGERS SIDE. THE ENGINE IN THIS TRUCK IS A 5.4 TRITON. THE FUEL RAIL IS IN THE FLIGHT PATH OF THE SPARK PLUG WHEN IT BECOMES A PROJECTILE. THIS HAS THE POTENTIAL TO BECOME A MAJOR DISASTER, IF THE FUEL RAIL RUPTURES. BECAUSE WITH THE ENGINE RUNNING THE COIL ON THE SPARK PLUG CAN AND WILL IGNITE THE SPRAYING FUEL. THE CYLINDER HEADS ON THESE 5.4 TRITONS ENGINE MUST HAVE A MAJOR DEFECT AND NEEDS TO BE RECALLED BY FORD MOTOR COMPANY, AS SOON AS POSSIBLE. *JB
Seat belts, Mar 7, 2006
THE DRIVER'S SEAT BELT IN MY CAR UNLATCHES BY ITSELF. I CONTACTED THE MANUFACTURER OF THE TRUCK, AND THEY SAY MY TRUCK MODEL IS NOT INCLUDED ON THE RECALL. THIS HAVE BEEN GOING ON FOR ABOUT A YEAR, SINCE I FIRST GOT THE TRUCK IN MARCH 2005. IT HAPPENS ALMOST EVERYDAY, WHEN I LEAST EXPECT IT. *JB
Vehicle speed control, Mar 2, 2006
RECALL OF FORD F150 PICKUP FOR UNDERHOOD CRUISE CONTROL DEFECT. THE LAST COMMUNICATION SAID THE REPAIR WOULD BE MADE BY FEB 15, 2006. THIS WAS THE THIRD DATE SET. THE DEALER DISCONNECTED MY CRUISE CONTROL AT THE MANUFACTURERS REQUEST LAST FALL. I HAVE HAD NO COMMUNICATION FROM THEM SINCE. *JB
Suspension, Feb 27, 2006
DT*: THE CONTACT STATED WHILE PULLING OUT OF A PARKING LOT GOING 5 MPH A LOUD NOISE WAS HEARD COMING FROM THE VEHICLE. AT THIS TIME THE FRONT SUSPENSION DROPPED DOWN CAUSING AN ABRUPT STOP. THE VEHICLE WAS TOWED TO THE DEALERSHIP, UPON INSPECTION THE PROBLEM WAS THE PASSENGER'S FRONT LOWER BALL JOINT HAD SNAPPED OFF. REPAIRS HAVE BEEN MADE, THE MANUFACTURER HAS BEEN ALERTED. UPDATED 3/22/2006 - *NM
Engine and engine cooling, Feb 24, 2006
I NOTICED A TICKING SOUND COMING FROM MY ENGINE, SHORTLY AFTERWARDS IT BEGAN TO POP LOUDLY AFTER LEAVING AN INTERSECTION AND TRAVELING ABOUT 10-15 MPH. I HAD THE TRUCK TOWED TO A FORD DEALER AND WAS LATER INFORMED THAT A SPARK PLUG HAD BLOWN OUT AND CAUSED CONSIDERABLE DAMAGE ($4200-$5400!). *NM
Vehicle speed control, Feb 21, 2006
DT*: THE CONTACT STATED PRIOR TO HAVING THE RECALL WORK PERFORMED, THE ACCELERATOR PEDAL STUCK. THE RECALL FOR THE CRUISE CONTROL WAS PERFORMED, BUT THE PROBLEM WITH THE ACCELERATOR PEDAL REMAINED. THIS HAPPENED AT ANY SPEED, WITHOUT THE CRUISE CONTROL ACTIVATED. THE VEHICLE HAS NOT BEEN TO A MECHANIC, BUT THE CONTACT DETERMINED THE THROTTLE CABLE IS STICKING.
Vehicle speed control, Feb 15, 2006
2001 FORD F150 SUPER CREW CRUISE CONTROL ISSUES WHEN USING THE CRUISE CONTROL AT HIGHWAY SPEEDS (50-65 MPH), IF YOU ENCOUNTER AN INCLINE SUFFICIENT FOR THE TRANSMISSION TO DOWNSHIFT THE CRUISE CONTROL BEGINS TO ACCELERATE IN A RUNAWAY MODE. IT WILL NOT SHUTOFF. DURING ONE OF THESE EVENTS I ALLOWED THE VEHICLE TO CONTINUE ACCELERATING TO DETERMINE IF THE CRUISE WOULD EVENTUALLY SHUT DOWN. IT DID NOT AND I REACHED A SPEED OF OVER 90 MPH. WHEREAS THERE WAS A RECALL ON THIS VEHICLE FOR FIRES RELATED TO THE CRUISE CONTROL I WAITED UNTIL THOSE PARTS WERE AVAILABLE BEFORE MENTIONING THIS TO MY FORD DEALER. THE DEALER INSISTED THAT THE RECALL WOULD NOT FIX THIS PROBLEM. THAT IS, THE SUDDEN ACCELERATION WAS UNRELATED TO THE RECALL. ON 2/16/06 I TOOK MY VEHICLE TO THE DEALER FOR THE SUDDEN ACCELERATION COMPLAINT. HE TEST DROVE THE VEHICLE AND WAS NOT ABLE TO DUPLICATE THE PROBLEM SO HIS CONTENTION WAS THAT IF HE CANNOT DUPLICATE IT, IT DOES NOT EXIST. NOTHING COULD BE FURTHER FROM THE TRUTH. THIS IS A DANGEROUS SITUATION!*JB
Tires, Feb 14, 2006
I BOUGHT A SET OF YOUR WILDERNESS AT P255/70R16/1095 M+S TIRES , THEY SEEMED FINE. ONE DAY AFTER WORK I WENT TO GET IN MY TRUCK AND THE FRONT RIGHT TIRE HAD SIMPLY COME APART, NOT WHILE I WAS DRIVING, BUT SOMETIME DURING THE DAY. I AM ASKING FOR INFORMATION ON HOW I AM TO GET THEM REPLACED. *JB
Structure, Feb 9, 2006
DT*: THE CONTACT STATED HE IS CONCERNED ABOUT THE DESIGN OF THE VEHICLE. THE VEHICLE HAS FOUR DOORS BUT ONLY TWO DOOR HANDLES. THE BACK DOORS CANNOT BE OPENED WITHOUT OPENING THE FRONT DOORS. IF THE VEHICLE WAS INVOLVED IN A CRASH AND THE DRIVER AND/OR FRONT PASSENGER WERE IMMOBILIZED, THE OCCUPANTS IN THE BACK SEAT WOULD NOT BE ABLE TO EXIT THE VEHICLE. UPDATED 3/9/2006 - *NM
Engine and engine cooling, Feb 3, 2006
MY 2001 FORD F150 RECENTLY EJECTED A SPARK PLUG. I HAVE HAD AN ONGOING PROBLEM WITH THIS TRUCK, HAVING IT IN THE REPAIR SHOP NUMEROUS TIMES. APPROX. 2 WEEKS AGO DURING NORMAL DRIVING, THE ENGINE BLEW A SPARK PLUG COMPLETELY OUT. I RECEIVED AN ESTIMATE FROM A FORD TECH. OF APPROX. $2000. I HAVE PURCHASED A KIT TO REPAIR THIS MYSELF. THE COMPANY MADE THE KIT SPECIFICALLY FOR FORD TRITON ENGINE REPAIRS, WHICH SHOWS THIS IS A MAJOR PROBLEM. I ESTIMATE THE TOTAL COST OF MY REPAIR WILL BE OVER $1000. *NM
Power train, Jan 26, 2006
DT*: THE CONTACT STATED WHILE ATTEMPTING TO SHIFT FROM DRIVE TO REVERSE, THE VEHICLE MADE A CLICKING SOUND AND WOULD NOT MOVE FORWARD. THE CONTACT PHYSICALLY PUSHED THE VEHICLE INTO THE DRIVEWAY. AFTER FURTHER INSPECTION, THE CONTACT DETERMINED THE DRIVE SHAFT WAS BROKEN. THE DRIVE SHAFT BROKE IN TWO ALONG THE WELDS. THE DRIVE SHAFT WAS REMOVED AND TAKEN TO THE DEALER. THE DEALER SUGGESTED SENDING THE PART TO THE MANUFACTURER FOR INSPECTION. UPDATED 2/28/2006 - *NM
Power train, Jan 22, 2006
DIFFICULTY IN SHIFTING, CLUTCH TO THE FLOOR/NON-RESPONSIVE. UPON TAKING IN TO DEALER PROBLEM WAS DUE TO CLUTCH SLAVE CYLINDER FAILURE. THIS RENDERED THE VEHICLE NON-OPERABLE. DEALER REPLACED CLUTCH SLAVE CYLINDER AND WAS AUTHORIZED TO REPLACE CLUTCH DUE TO WEAR AND LABOR INVOLVED SHOULD IT FAIL IN THE NEAR FUTURE. *JB
Vehicle speed control, Jan 6, 2006
DT*: THE CONTACT STATED THERE IS A RECALL, NHTSA CAMPAIGN # 05V388000, ON THE VEHICLE REGARDING THE VEHICLE SPEED CONTROL. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE CONTACT SPOKE TO THE MANUFACTURER WHO HAS CONFIRMED THE PARTS ARE NOT AVAILABLE. ALTHOUGH A INTERIM REPAIR HAS BEEN PERFORMED BY THE DEALER, THE PART HAVE NOT BEEN REPLACED DUE TO THE UNAVAILIBILITY OF PARTS.
Seat belts, Dec 28, 2005
DT: THE CONTACT STATED THE SEAT BELT O FRONT PASSENGER'S SEAT WILL NOT BUCKLE; IT WAS REPLACED 4 YEARS AGO. THE DEALER AND MANUFACTURER WERE CONTACTED, AND THEY STATED THERE WERE NO RECALLS THE SEAT BEAT BUCKLE HAS NOT BEEN REPAIRED.*AK
Steering, Dec 25, 2005
THE UPPER A ARMS AND TIRE RODS ARE WORN OUT ON MY VEHICLE WHICH HAS LESS THAN 65K MILES ON THE VEHICLE. THIS MAKE NO SENSE FOR A VEHICLE WITH ONLY HIGHWAY MILES AND NO ABUSE. *NM
Engine and engine cooling, Dec 17, 2005
I HAVE A 2001 FORD F150 WITH A 4.2L V6 ENGINE AND AT 97,500 MILES IT STARTED TO LEAK ANTIFREEZE. A MECHANIC TOLD ME THAT IT IS A PROBLEM THAT HE HAS SEEN IN MANY F150 TRUCKS WITH THE 4.2L V6. HE SAID THAT THE LOWER INTAKE GASKET AS WELL AS THE TIMING COVER GASKET HAVE TO BE REPLACED TO FIX THIS PROBLEM. *JB