2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints
1,340 reports, newest first.
Fuel system, Gasoline, May 28, 2014
I FILLED THE FUEL TANK WITH GAS AND DROVE ABOUT 20 MILES. WHILE PULLING INTO A RESTAURANT AT ABOUT 5 TO 10 MPH I WENT THROUGH A VERY SLIGHT DIP. I HEARD A SOFT THUNK AND HEARD SOMETHING DRAGGING ON THE GROUND. IT WAS NOT REAL LOUD SO I SLOWLY PULLED INTO THE PARKING LOT. WHEN I LOOKED UNDER MY VFORD F-150 I NOTICED THAT THE GAS TANK HAD DROPPED DUE TO BOTH STRAPS BREAKING. THE REAR OF THE TANK WAS HELD UP BY THE HOSE GOING TO THE GAS CAP AREA. FORTUNATELY, THIS DID NOT HAPPEN AT HIGH SPEED OR I MAY NOT BE AROUND TO REPORT THE INCIDENT. I CALLED FORD AND THEY STATE THAT THIS VIN NUMBER DID NOT HAVE NAY RECALLS. THE CUSTOMER RESOURCE PERSON (800.392.3673 OPTION 1, 5, 4) STATED THEY WERE NOT AWARE OF ANY GOVERNMENT NUMBER WHERE I COULD CALL IN THIS COMPLAINT. I QUICKLY DID A WEB SEARCH AND FOUND THIS NUMBER SO I FIND IT HARD TO BELIEVE THEY DID NOT KNOW ABOUT IT. THIS IS A VERY SERIOUS SAFETY ISSUE THAT COULD VERY EASILY LEAD TO SERIOUS INJURIES/DEATH TO OCCUPANTS OF THE 2001 F-150. *TR
Engine and engine cooling, May 20, 2014, fire
VEHICLE WAS PARKED AND MOTOR WAS OFF. VEHICLE CATCH ON FIRE AND FIRE DEPARTMENTS HAD TO GO TURN IT OFF BUT WE COULD NOT SAVE ANYTHING FROM THIS TRUCK IT GOT VERY DAMAGED. *TR
Suspension, Structure, Service brakes, Apr 10, 2014
SEVERE CORROSION ISSUES. *TR
Vehicle speed control, Apr 2, 2014, fire
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT THE VEHICLE IGNITED IN FLAMES WHILE PARKED AND UNOCCUPIED. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT INSPECTED THE VEHICLE AND FILED AN INCIDENT REPORT STATING THAT THE FIRE ORIGINATED FROM THE SPEED CONTROL DEACTIVATION SWITCH. THE VEHICLE WAS DESTROYED AND REMAINED AT THE CONTACT'S RESIDENCE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL) AND STATED THAT HE HAD EXPERIENCED THE CONSEQUENCE LISTED IN THE RECALL HOWEVER, THE CONTAC'S VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.
Vehicle speed control, Mar 19, 2014
TL* THE CONTACT OWNS 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL) BUT THE CRUISE CONTROL DID NOT ENGAGE WHEN ACTIVATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 210,000.
Steering, Mar 13, 2014
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE STEERING WHEEL ABRUPTLY SEPARATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE STEERING WHEEL WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 180,000.
Seat belts, Feb 25, 2014
WHILE DRIVING, THE SEATBELT CLIP WILL RELEASE FROM THE CATCH, CAUSING THE BELT TO RETRACT AND BECOME INEFFECTIVE WHILE IN MOTION. THIS HAS HAPPENED SEVERAL TIMES, AND UNDER VARIOUS DRIVING CONDITIONS. I CAN FIND NO REASON FOR THIS TO HAPPEN EXTERIOR OF THE INSTALLED EQUIPMENT. MY VEHICLE HAD THE SEATBELT RETRACTOR REPLACED AFTER RECEIVING A RECALL NOTICE SEVERAL YEARS AGO. THIS APPEARS TO NOT HAVE ANYTHING TO DO WITH THAT RECALL. *TR
Fuel system, Gasoline, Power train, Feb 4, 2014
2001 FORD F-150. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEMS. *SMD THE CONSUMER STATED DURING ROUTINE USE OF THE TRUCK, THE TRANSMISSION STOPPED FUNCTIONING. THE TRANSMISSION REPAIR SHOP, INFORMED THE CONSUMER THE CAST STEEL GEAR WITHIN THE TRANSMISSION HAD SHATTERED INTO TWO PIECES. IN OCTOBER 2009, DURING AN ANNUAL SAFETY INSPECTION, THE STRAPS HOLDING THE FUEL TANK IN PLACE WERE CORRODED AND ALMOST COMPLETELY RUSTED THROUGH. IN THE SUMMER OF 2013, FORD MOTOR COMPANY, SENT THE CONSUMER A NOTICE, INFORMING HIM THE FUEL TANK STRAP WERE BEING RECALLED. THE CONSUMER WAS NOT OVERLY CONCERNED, SINCE THEY HAD ALREADY BEEN REPLACED, FORD SENT ANOTHER RECALL. THE CONSUMER INFORMED FORD, HE HAD THE STRAPS REPLACED. FORD THEN ADVISED THE CONSUMER TO VISIT THE DEALER ABOUT REIMBURSEMENT. THE DEALER WANTED TO SEE WHAT REPAIRS HAD BEEN MADE. ONCE THE TRUCK WAS ON THE LIFT, IT WAS DISCOVERED THE ORIGINAL FAULTY TANK STRAPS HAD CAUSED A WEAKENING IN THE SKIN OF THE FUEL TAN ITSELF AND THAT IT WAS LEAKING GASOLINE THROUGH THE SKIN OF THE TANK. THE TANK WAS LEAKING FUEL AROUND THE AREA WHERE THE STRAPS RUBBED ON THE TANK. FORD WOULD ONLY HONOR THE RECALL, IF THEY REPLACED THE STRAPS. HOWEVER, THEY REFUSED TO REPLACE LEAKING FUEL TANK. *JB
Fuel system, Gasoline, Structure, Engine, Dec 30, 2013, fire
I WAS DRIVING NORTHBOUND ON I-95 WHEN THE DRIVER OF AN ADJACENT VEHICLE ALERTED ME THAT THERE WAS FIRE SHOOTING OUT FROM THE AREA OF THE FUEL FILLER DOOR. I IMMEDIATELY PULLED OVER ONTO THE HIGHWAY MEDIAN AND JUMPED OUT. THE TRUCK WAS ENGULFED IN FLAMES, AND THE CAB WAS ON FIRE. I BURNED MYSELF ON THE MELTING STEERING WHEEL AND WAS SINGED BY MELTING PLASTIC. *TR
Steering, Dec 17, 2013
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE STEERING WHEEL BECAME LOOSE AS THE STEERING COLUMN BECAME SEPARATED FROM THE UNIVERSAL JOINT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE UNIVERSAL JOINT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Engine and engine cooling, Structure, Dec 11, 2013, fire
WHILE DRIVING DOWN THE INTERSTATE, THE VEHICLE CAUGHT ON FIRE. EVERYTHING UNDER THE HOOD WAS DESTROYED. *TR
Electrical system, Oct 7, 2013, fire
VEHICLE WAS NOT IN USE- PARKED AND NOT ON SMOKE AND FIRE CAME FROM UNDER HOOD THE WIRING MELTED CAUSING THE HOOD TO MELT UNDERNEATH WHERE IT CAN NOT BE OPENED. *TR CONTACTED FORD ON MONDAY JUNE 24 WAITED FEW WEEKS FOR PAPER WORK- PROMPTLY FILLED IT OUT AND NEVER HEARD BACK FROME THEM- MADE SEVERAL CALLS RECEIVED A LETTER FROM LEGAL DEPARTMENT INDICATING THEY NEED THE PART TO REVIEW WE WANTED FORD TO COME TO LOOK AT TRUCK AND RETIREVE THE PART THEY ARE NOT WILLING AND ARE CLOSING THE CASE THERE IS A RECALL ON THIS AND MY FAMILY WAS IN THE TRUCK THAT MORNING- WE RE LUCKY NO ONE WAS KILLED
Seat belts, Aug 13, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE PASSENGER'S SIDE SEAT BELT BECAME UNBUCKLED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER A MANUFACTURER'S RECALL BUT NO FAILURE WAS DETERMINED. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 68,000.
Tires, Wheels, Jul 30, 2013
TWO BLOCKS FROM MY RESIDENCE, I EXPERIENCED A LOUD 'BOOM', TREAD SEPARATION AND DAMAGE TO MY RIGHT REAR QUARTER PANEL, FENDER BRACES AND MY EXHAUST PIPE. THE TIRE IN QUESTION IS A GOODRICH T/A KM LT 285/75R/16/122/119/D M + S MUD TIRE. THIS IS A LOAD RANGE D TIRE WITH A MAX OF 65 PSI. I USE 50 PSI. THE TIRES WERE PURCHASED IN 2007/2008, AND MOUNTED ON SEPARATE RIMS. THE ORIGINAL EQUIPMENT AND THE MUD TERRAIN TIRES WERE EXCHANGED OFTEN.MY TRUCK HAS APPROXIMATELY 40K TOTAL MILES. IF THE DRIVING ON EACH TIRE WERE DIVIDED EVENLY, EACH TIRE WOULD ONLY HAVE 18K MILES, AT THE TIME OF THE TIRE FAILURE. THE TIRES WERE ROTATED OFTEN. INFLATION WAS CHECKED EVERY WEEK. I CHOSE NOT TO USE THE ROAD HAZARD WARRANTY TO REPLACE THE TIRE. AS IT HAPPENED ON A NEWLY REBUILT STREET.THIS TIRE HAS A 3 PLY SIDE WALL AND A 5 PLY TREAD. THIS TYPE OF TREAD SEPARATION SHOULD NOT HAPPEN. I WANT GOODRICH TO REPLACE ALL TIRES, BECAUSE I'M AFRAID TO USE THEM. HAD THIS FAILURE HAPPENED AT HIGHWAY SPEED, RESULTS COULD BE WORSE. I HAVE TRIED TO REASON WITH GOODRICH CONSUMER REPRESENTATIVES, TO NO AVAIL. THE TIRES 'WERE TOO OLD', BASED ON THE DOT NUMBER. SEARS WANTS TO ONLY REPLACE 1 TIRE. I BELIEVE THE SET TO BE DANGEROUS. THE ORIGINAL 2001 TIRES ARE VERY SERVICEABLE. I NOTICED SOME 59 COMPLAINTS ON 'CONSUMER AFFAIRS' FOR B. F. GOODRICH OFF-ROAD TIRES. MY COMPLAINT WILL MAKE 60. THE ONES REPORTED TO YOUR AGENCY NUMBERED IN THE 70'S SOME THE COMPLAINTS REPORTED SERIOUS INJURY WITH THIS TYPE OF TIRE. THEIR LINK IS: HTTPS://WWW.CONSUMERAFFAIRS.COM/BRANDS/SUPPORT/ . I WOULD HOPE THAT YOU REVIEW THE COMPLAINTS, AND ASK B. F. GOODRICH TO BE A RESPONSIBLE CORPORATION, FILE A VOLUNTARY RECALL AND REPLACE SUSPECT TIRES; AT NO COST TO THE CONSUMER. PLEASE INFORM ME OF THE RESULTS OF YOUR INVESTIGATIONS, ALONG WITH ANY RECOMMENDATIONS MADE TO GOODRICH. THANK YOU. *TR
Fuel/propulsion system, Jul 25, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT BOTH FUEL TANK STRAPS WERE REPLACED UNDER NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE). THE FUEL TANK WAS ALSO SEVERELY RUSTED WHERE THE STRAPS WERE ATTACHED. THE MANUFACTURER WAS NOTIFIED AND THEY REFUSED TO INCLUDE THE REPLACEMENT OF THE DAMAGED FUEL TANK UNDER THE RECALL SERVICE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
Engine, Jul 24, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, HE HEARD A LOUD NOISE AS THE VEHICLE ACCELERATED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE BOLT ON THE ENGINE HEAD WAS RUSTED AND BECAME CORRODED. IN ADDITION, THE MANIFOLD WAS CRACKED AND LEAKING CARBON DIOXIDE DUE TO THE CORROSION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 120,000.
Structure, Jun 26, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING AND HEADLIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THAT WATER WAS ENTERING THE VEHICLE THROUGH THE A-PILLER AND WAS LEAKING ONTO THE ECM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 59,900. *TR
Electrical system, Jun 23, 2013
2001 F150 XLT 4.2 V6 ELECTRONICAL CONTROL MODULE (ECM) SHORTED OUT CAUSING MALFUNCTION TO MY LIGHTS WINDOWS AND ALARM AND MY LOCKS AS WELL WHICH IS A THEFT CONCERN AND FIRE HAZARD AS WELL. I FEEL IN MY OPINION THAT THIS ISSUE SHOULD BE ADDRESSED AND SHOULD BE UNDER RECALL AND FIXED UNDER FORD I SPOKE WITH A TECH AT A FORD DEALERSHIP NEAREST ME AND HE TOLD ME THAT FORD HAS NOT STEPPED UP AND SAID ANYTHING. I FEEL THIS NEEDS TO BE ADDRESSED AND IS A BIG CONCERN FOR ME AND IM SURE ITS A CONCERN FOR OTHERS AS WELL. SO FORD IF YOU WANT BUSINESS AND YOU LOVE YOUR CUSTOMERS THIS WILL BE FIXED. *TR
Structure, Jun 18, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE ROCKER PANEL WAS SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
Vehicle speed control, Jun 17, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE DRIVING 60 MPH THE VEHICLE SUDDENLY ACCELERATED UP TO 80 MPH; HOWEVER, WHEN THE BRAKES WERE APPLIED THAT DID NOT SLOW THE VEHICLE DOWN. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL GEAR AND WHEN THE BRAKES WERE APPLIED THE SPEED DECREASED TO 50 MPH AND THE CONTACT SHIFT THE VEHICLE BACK INTO DRIVE GEAR. THE VEHICLE CONTINUED TO ACCELERATE AND THE CONTACT WAS FORCED TO KICK THE ACCELERATOR PEDAL IN ORDER TO DECREASE THE SPEED. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR LOCAL MECHANIC. THE CONTACT DID NOT CALL THE MANUFACTURER REGARDING THE FAILURE. THE FAILURE MILEAGE WAS 124,000.
Structure, Jun 10, 2013
THE CONTACT OWNS 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXHIBITED A THUMPING NOISE WHEN DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO A MECHANIC TO BE INSPECTED WHERE THE FAILURE WAS LOCATED AT THE METAL FRAME LOWER CORE SUPPORT FOR THE RADIATOR, WHICH WAS SEVERELY CORRODED. THE FRAME WAS ALSO CORRODED AND WOULD REQUIRE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE STEEL TUBES FOR THE BRAKE LINES WERE RECENTLY REPLACED DUE TO CORROSION. THE RADIATOR METAL FRAME LOWER CORE SUPPORT WAS NOT REPLACED. THE FAILURE AND CURRENT MILEAGE WAS 82,000. KMJ UPDATED 07/16/13*LJ
Vehicle speed control, May 29, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE BECAME HESITANT TO ACCELERATION ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. *TR
Structure, Engine, May 16, 2013
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, ATTEMPTING A TURN OR TRAVELING OVER A ROAD BUMP, THE VEHICLE WOULD SPORADICALLY EMIT A METAL-TO-METAL DRAGGING NOISE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE SUPPORT FOR THE RADIATOR WAS FRACTURED, CAUSING THE RADIATOR TO SWAY WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE DIAGNOSIS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 201,000. UPDATED 07/23/13*LJ
Electrical system, Apr 15, 2013, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED AND OCCUPIED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE AND POLICE DEPARTMENT REPORTED TO THE SCENE AND FILED A REPORT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000. *TR
Vehicle speed control, Apr 2, 2013, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE IGNITED IN FLAMES AND WAS COMPLETELY DESTROYED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND INFORMED THE CONTACT THAT THE FIRE ORIGINATED FROM THE SPEED CONTROL DEACTIVATION SENSOR. THE VEHICLE REMAINED AT THE CONTACT'S RESIDENCE FOR FURTHER INVESTIGATION. THE CONTACT STATED THAT THE FAILURE COINCIDED WITH THE CONSEQUENCE MENTIONED IN NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL), IN WHICH THE CONTACT'S VEHICLE WAS INCLUDED. THE CONTACT HAD NOT RECEIVED THE RECALL REPAIRS AT THE TIME OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.