2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints: gasoline
70 reports, newest first. Show all
Fuel system, Gasoline, Jun 30, 2011
THE STRAPS HOLDING THE GAS IN PLACE ON MY 2002 F150 FAILED ON THE EXPRESSWAY CAUSING THE TANK TO DROP TO THE GROUND AT 65MPH. BY THE TIME I WAS ABLE TO STOP, A RIP IN THE TANK CAUSED ALL OF THE FUEL TO LEAK OUT. LUCKILY NO SPARKS OF FIRE. I WAS NEVER INFORMED OF A POTENTIAL PROBLEM FROM THE DEALERSHIP I REGULARLY GET SERVICED AT. I RESEARCHED THIS ISSUE ONLINE, AND FOUND MANY SIMILAR COMPLAINTS. THIS COULD HAVE BEEN TRAGIC/FATAL, FOR ME AND ALL THE OTHER PEOPLE DRIVING AROUND ME. I AM NOT ONE TO WRITE COMPLAINTS, BUT I AM UPSET AT THE DANGER THIS PUT ME IN AND THE TIME AND COST OF THIS FAILURE. *TR
Fuel system, Gasoline, Jun 27, 2011
MY 2002 FORD F-150 HAS VERY BADLY RUSTED FUEL TANK STRAPS, WHY IS THE RECALL ONLY UP TO 2001 F-150'S. FORD DEFINITELY USED SOME CHEAP METALS WHILE MAKING THESE F-150'S IS IT POSSIBLE TO INCLUDE 2002 AS WELL? *TR
Fuel system, Gasoline, Jun 21, 2011
GAS TANK STRAPS BROKE, GAS TANK FELL ONTO PAVEMENT. HAD MY TRUCK TOWED TO MY FORD DEALER WHERE THEY REPLACED THE STRAPS FOR ABOUT $200. IF THIS HAD HAPPENED 5 MINUTES LATER, I WOULD HAVE BEEN GOING 60 MPH! UPDATED 09/14/11 *BF *TR THE TANK FELL TO THE GROUND, WHILE THE VEHICLE WAS SITTING. THERE WAS NO FUEL SPILL. THE DEALER REPLACED THE STRAPS. UPDATED 09/21/11
Fuel system, Gasoline, Jun 16, 2011
I HEARD ON THE RADIO ABOUT A POSSIBLE UPCOMING RECALL ON FORD F150 PICKUP TRUCKS (1997-2001). THIS IS IN RELATION TO GAS TANK STRAPS GETTING RUSTY AND BREAKING. I THEN DECIDED TO LOOK UNDER MY TRUCK WHICH IS A 2002 FORD F150 AND DISCOVERED TWO GAS TANK STRAPS COMPLETELY RUSTED THROUGH/OFF WITH THE TANK NO LONGER BEING SUPPORTED BY STRAPS. THE TRUCK IS ONLY A 2002, BUT I THINK THE PROBLEM GOES BEYOND THE 2001 TRUCKS PER THE POTENTIAL RECALL. *TR
Fuel system, Gasoline, Jun 14, 2011
THE FRONT GAS TANK SUPPORT HANGER BROKE DUE TO CORROSION. THE REAR HANGER HELD THE TANK IN PLACE UNTIL I WAS ABLE REPLACE BOTH UNITS. THE REAR HANGER DID NOT BREAK BUT WAS SEVERELY CORRODED ALSO. I DON'T KNOW WHAT WOULD HAVE HAPPEN IF I WOULD HAVE LOST BOTH UNITS TOGETHER WHILE DRIVING DOWN THE ROAD.
Fuel system, Gasoline, Jun 13, 2011
I SMELLED GAS FUMES NEAR MY 2002 F150 TRUCK. LOOKED UNDERNEATH TO INSPECT WHERE SMELL WAS COMING FROM AND FOUND THE BACK BRACE ON THE GAS TANK BROKEN OFF AND RUSTED OUT HOLE IN THE TANK WHERE THE BRACE WAS SUPPOSED TO BE. *TR
Fuel system, Gasoline, Jun 12, 2011
I HAD DRIVEN 4 TO 5 MILES AT 40 TO 45 MPH AND WAS A 1 BLOCK FROM MY DESTINATION. I HAD TO STOP FOR A STOP SIGN AND MAKE A RIGHT TURN. WHILE MAKING THE TURN I THOUGHT I HIT SOMETHING, BUT THE STREET WAS CLEAR? I TURNED THE RADIO OFF AND OPENED THE WINDOW TO HERE SOMETHING DRAGGING. I STOPPED AT THAT TIME MAYBE 100 YARDS FROM WHERE I LAST STOPPED. MY SPEED WAS 20 TO 25 MPH. I GOT OUT AND LOOKED UNDER THE TRUCK AND THE GAS TANK WAS SITTING ON THE GROUND.THE FRONT OF THE TANK WAS ON THE GROUND THE BACK WAS STILL ELEVATED. THE FILLER HOSE AND FUEL LINES WERE THE ONLY THING HOLDING THE TANK. BOTH HANGERS WERE BROKEN, RUSTED THRU. IF I WAS DRIVING AT HIGHWAY SPEED, I DO NOT BELIEVE I WOULD HAVE A TRUCK LEFT. I ALSO UNDERSTAND THAT 2001 AND EARLIER F150'S WERE RECALLED FOR THE TANK HANGERS AND I WOULD SUGGEST IT BE EXPANDED. ASAP! MY FORD DEALER 4 WEEKS EARLIER HAD INSPECTED MY VEHICLE AT MY REQUEST FOR REGULAR MAINTENANCE AND REPAIRS BEFORE MY VACATION TRIPS. THE SERVICE TECH NEVER LOOKED AT MY TANK STRAPS EVEN KNOWING PREVIOUS YEARS HAD A PROBLEM? FORD SHOULD HAVE CAUGHT THIS BEFORE IT HAPPENED AGAIN. THE BIGGEST COMPLAINT AFTER IS THE FORD DEALERSHIP TOLD ME IT WAS NOT A PART OF ANY RECALL AND THEY KNEW NOTHING ABOUT IT. WHICH I DO NOT BELIEVE! I HAVE THE STRAPS IF ANYONE CARES TO EXAMINE THEM FROM YOUR OFFICE. *TR
Fuel system, Gasoline, Jun 2, 2011, fire
FUEL TANK DROPPED TO THE ROAD WHILE DRIVING CAUSING THE TRUCK TO BE ENGULFED IN FLAMES. DRIVER MADE IT OUT WITH FIRST AND SECOND DEGREE BURNS. TWO DOGS IN THE BACK SEAT DIED IN THE FIRE. INITIAL INVESTIGATION BY THE INSURANCE INVESTIGATOR DETERMINED THAT IT WAS THE FUEL TANK STRAPS THAT FAILED. THERE IS AN INVESTIGATION (PE10036) BY THE NHTSA FOR FUEL TANK STRAPS ON FORD F-150S 1999-2001. THE 2002 AND 2003 F-150 USE THE SAME STRAPS. LARRY HERSHMAN OF NHTSA HAS CONTACTED ME ABOUT THIS INCIDENT. UPDATED 06/13/11*BF & 06/14/11*BF UPDATED 08/11/11 *BF UPDATED 3/01/2012 *LN *TR
Fuel system, Gasoline, Jun 1, 2011
FUEL TANK STRAPS RUSTED OUT RESULTING IN GAS TANK DROPPING. UPDATED 09/14/11 *BF THE CONSUMER STATED THE FUEL TANK WAS DAMAGED AND HAD TO BE REPLACED. UPDATED 09/16/11
Fuel system, Gasoline, Jun 1, 2011
TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 TO 30 MPH HE HEARD A LOUD DRAGGING NOISE UNDERNEATH THE VEHICLE. HE THEN PULLED TO THE SIDE OF THE ROAD AND NOTICED THAT BOTH STRAPS HAD FRACTURED AND WERE COVERED WITH RUST. THE TANK FELL OFF OF THE VEHICLE, BUT NONE OF THE FUEL SPILLED. THE CONTACT WAS ABLE TO CONTINUE DRIVING THE VEHICLE AND IT WAS REPAIRED BY THE OWNER. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THERE WERE NO RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 98,500. UPDATED 07/08/11*LJ UPADTED 11/04/11
Fuel system, Gasoline, May 20, 2011
WHILE DRIVING AT HIGHWAY SPEED MY 2002 FORD F-150 DROPPED THE FUEL TANK AND THE TANK WAS DRAGGED FOR APPROXIMATELY 1/4 MILE WILE I ATTEMPTED TO MANEUVER ACROSS THREE LANES OF TRAFFIC TO THE BREAKDOWN LANE. THIS CREATED A HOLE IN THE TANK AS IT WAS DRAGGED AGAINST THE PAVEMENT. I HAD JUST FILLED THE TANK AND ALL 25 GALLONS WAS LOST ON THE SIDE OF THE HIGHWAY. THE VEHICLE WAS TOWED TO THE DEALERSHIP AND I AM WAITING FOR THE ESTIMATE FOR REPAIR. *TR
Fuel system, Gasoline, May 18, 2011
2002 FORD F150 5.4L V-8 2-WHEEL DRIVE, REGULAR CAB, 8FT BED... BROKEN GAS TANK STRAP...WALKED OUT AND NOTICED MY GAS TANK WAS HANGING DOWN...INVESTIGATION REVEALED A BROKEN GAS TANK STRAP...BOUND IT BACK UP WITH A RATCHET-STRAP, AND DROVE TO THE FORD DEALER...PURCHASED A NEW STRAP AND PLACED IT ON THE VEHICLE IN THE PARKING LOT... *TR
Steering, Fuel system, Gasoline, May 16, 2011
ONE GAS TANK STRAP WAS FOUND TO BE RUSTED AND THE TANK AT AN ANGLE. IT WAS INSPECTED BY A LOCAL FORD DEALER, WHO FOUND THAT THE GAS TANK WAS ALSO RUSTED AND LEAKING. THE GAS TANK AND STRAPS WERE REPLACED. BECAUSE THE MODEL YEAR WAS NOT IN THE DATE RANGE OF THE RECENT RECALL, WE HAD TO PAY $793. A POWER STEERING PUMP WAS ALSO LEAKING AND REPLACED. THE GAS TANK WAS THE MAJOR ITEM OF CONCERN.
Fuel system, Gasoline, May 15, 2011
2002 FORD F150 FUEL TANK MOUNTING STRAPS FAILED DUE TO CORROSION AND PERMITTED FUEL TANK TO DROP TO PAVEMENT WHILE DRIVING. *TR
Fuel system, Gasoline, May 13, 2011
TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACTED WAS DRIVING 65 MPH WHEN BOTH FUEL TANK STRAPS FRACTURED. THE STRAPS WERE RUSTED AND CORRODED AND ALSO CAUSING THE FUEL TANK TO DETACH FROM THE VEHICLE. THE FUEL TANK ALSO CAUSED THE DRIVE SHAFT TO FAIL WHILE THE VEHICLE WAS IN MOTION AND THE CONTACT COULD NOT CONTROL THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC SHOP AND WAS REPAIRED. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,442 AND THE CURRENT MILEAGE IS 92,000. UPDATED 6/8/11 *CN UPDATED 06/16/11
Fuel system, Gasoline, May 12, 2011
1. THERE WAS NOT AN EVENT LEADING UP TO THE FAILURE. 2. GAS TANK STRAPS BROKE 3. I HAVE NOT FIXED YET, WILL MOST LIKELY FIX ON MY OWN. *TR
Fuel system, Gasoline, May 12, 2011
TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACT NOTICED THAT THE METAL STRAP FOR THE REAR FUEL TANK WAS FRACTURED AS A RESULT OF RUST. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. THE VIN WAS UNAVAILABLE.
Fuel system, Gasoline, May 11, 2011
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHEN THE FUEL TANK DETACHED AND FELL FROM UNDER THE VEHICLE. THE VEHICLE WAS PULLED OVER AND TOWED TO THE CONTACTS HOME. THE CONTACT ALSO STATED THAT THE BRAKE LINES WERE ALSO DAMAGED WHEN THE FUEL TANK DETACHED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 155,000.
Fuel system, Gasoline, May 10, 2011
2002 F150 I HAD TO HAVE THE GAS TANK STRAPS REPLACED ONE FAILED, HOW COME THE INVESTIGATION IS ONLY GOING TO 2001. *TR
Fuel system, Gasoline, May 10, 2011
FUEL TANK STRAP BROKE ALLOWING FUEL TANK TO DROP AND NEARLY BREAK FREE FROM THE VEHICLE. *TR
Steering, Fuel system, Gasoline, May 10, 2011
TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT NOTICED THAT THE GASOLINE TANK STRAP WAS COVERED WITH RUST. THE CONTACT DID NOT INFORM THE DEALER OR MANUFACTURER OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THEY REPLACED THE FUEL TANK STRAPS. THE CURRENT MILEAGE WAS 97,000. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. UPDATED 07/08/11 *BF THE DRIVER SIDE TIE ROD WAS ALSO REPLACED. UPDATED 12/28/11
Fuel system, Gasoline, May 10, 2011
AFTER HEARING ABOUT THE F150 FUEL STRAP PROBLEM I DECIDED TO REPORT A RUSTED AND BUSTED STRAP ON MY 2002 F150. A FRIEND NOTICED THE STRAP HANGING DOWN SO I WAS ABLE TO FIX IT BEFORE IT FELL. MI. *TR
Fuel system, Gasoline, May 10, 2011
WE FILLED THE GAS TANK OF OUR 2002 FORD F-150 AND DROVE ABOUT THREE BLOCKS AWAY FROM THE GAS STATION. THE FUEL TANK DROPPED OFF THE BOTTOM OF THE TRUCK AND DRAGGED ON THE GROUND LEAKING FUEL EVERYWHERE. WE WERE LUCKY IT WAS RAINING AT THE TIME AS I BELIEVE OTHERWISE THE TANK WOULD HAVE CAUSED A SPARK ON THE ROAD AND WE'D HAVE HAD A LARGE FIRE WITH MY CHILDREN IN THE TRUCK. IT COST QUITE A BIT OF MONEY TO REPAIR THE TRUCK, PAY THE FIRE DEPARTMENT FOR CLEAN UP AND TOW THE VEHICLE. WE CALLED OUR LOCAL FORD DEALER AFTER OUR MECHANIC TOLD US HE SEES F-150'S WITH THE FUEL TANK STRAPS RUSTED AND BROKEN PRETTY REGULARLY. WE WERE TOLD THERE WAS NO RECALL SO WE WOULD NOT BE REIMBURSED. NOW (2 MONTHS LATER) I HEAR THERE WILL BE A RECALL BUT IT WILL INCLUDE 1997-2001 TRUCKS ONLY. OURS IS A 2002 WITH THE EXACT SAME PROBLEM AND I'VE READ FORD USED THE SAME FUEL TANK STRAPS ON 1997-2003 F-150'S. UPDATED 08/05/11 *BF THE CONSUMER STATED THE REAR STRAP BROKE AND THE FRONT STRAP BROKE FROM THE WEIGHT OF THE TANK AND THEY BROKE IN THE MIDDLE DUE TO RUST. UPDATED 08/15/11 *TR
Fuel system, Gasoline, May 9, 2011
STRAPS THAT SECURE THE FUEL TANK RUSTED. ONE STRAP RUSTED COMPLETELY THROUGH AND WAS HANGING LOOSE-- THE OTHER WAS VERY CLOSE TO FAILURE. I WAS ABLE FORTUNATELY TO GET TO A GARAGE --AND I HAD THE STRAPS REPLACED. I JUST RECENTLY SAW THE NOTICE ABOUT OTHER INSTANCES OF THIS HAPPENING AND I DECIDED TO FILE A COMPLAINT. MY TRUCK IS ONE YEAR NEWER THAN WHAT IS BEING LOOKED AT. *TR
Fuel system, Gasoline, Mar 12, 2011
SPARK PLUG BLOW OUT. # 2 PLUG PASSENGER SIDE.THIS HAPPENED YESTERDAY MARCH 11,2011. MY TRUCK HAS 37,000 MILES ON IT. THIS IS A FORD F-150, 7700 SERIES WITH A 5.4 ENGINE.WHERE IS THE RECALL ON THIS TRUCK.AFTER READING ALL THE PROBLEMS,WITH THE SAME THING. WHAT A SLAP IN THE FACE BY FORD. AND YET NO RECALL MANDATED BY THE FEDS. WHAT A COUNTRY WE LIVE IN? *TR