2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints: power train
85 reports, newest first. Show all
Power train, Sep 6, 2005
MY 2002 FORD F-150'S TRANNY COMPLETELY BROKE AT 35,000 MILES 27 DAYS AFTER THE 3 YEAR WARRANTY WAS UP. I DON'T HAUL OR PULL ANYTHING WITH THIS TRUCK. WE ARE HAVING TO PUT A FACTORY REBUILT TRANNY IN IT AS WE SPEAK. *NM
Power train, Aug 24, 2005
DT: THE CONTACT OWNS A 2002 FORD F150. THE REAR END DIFFERENTIAL MADE A WHINING NOISE. THEY TOLD HIM THAT IT WILL NOT HURT THE VEHICLE BUT IT WAS NOT NORMAL SINCE THE JUNE 16,2005 CONTACT WAS TRYING TO GET VEHICLE FIXED. THEY REPLACED THE RACK AND PINION TWICE, BUT PROBLEM RECURRED. THE MANUFACTURER TOLD CONTACT THAT THEY COULD NOT FIX THE VEHICLE. TECHNICIAN AT DEALERSHIP SAID HE OWNED THE SAME VEHICLE AND IT WAS DOING THE SAME THING. THE DEALERSHIPS LAUGHED WHEN CONTACT BROUGHT THE VEHICLE TO BE FIXED. AT 40-45 MPH CONTACT COULD HEAR THE NOISE ,AND IF WHEN PULLING TA LOAD THE NOISE GOT WORSE. THE DEALERSHIP TRIED TO FIX THIS PROBLEM, BUT FORD KEPT SENDING WRONG PARTS THAT WERE NOT CORRECTING THE PROBLEM. CONTACT HAS HAVE AN EXTENDED WARRANTY ON VEHICLE. *AK *NM
Power train, Aug 21, 2005
I HAVE A 2002 FORD EXPLORER. I HAVE APPROXIMATELY 85,000 MILES ON THIS CAR AND HAVE A PROBLEM WITH THE TRANSMISSION. THE O/D LIGHT CAME ON FLASHING. THEN IT REFUSED TO SHIFT INTO SECOND GEAR. IT HAS SHIFTED HARD SINCE WE PURCHASED IT USED WITH APPROXIMATELY 25,000 MILES ON IT. WHAT A PAIN. I HAVE BEEN TO MANY FORD FORUMS AND I SEE NOTHING BUT TROUBLE WITH THIS MAKE AND MODEL YEAR. FORD NEEDS TO RECALL THIS CAR PRONTO. EVERY ONE I KNOW WHO HAS THIS MAKE AND MODEL ARE HAVING SIMILAR PROBLEMS. THEY NEED TO CORRECT THIS ITEM NOW. OR WE WILL JUST HAVE TO BUY JAPANESE NEXT TIME. THEY BELIEVE IN CUSTOMER SERVICE.
Power train, Vehicle speed control, Aug 5, 2005
REF 2002 FORD EXPLORER, TRANSMISSION PROBLEMS. THIRD GEAR WENT OUT AT 57,000 MILES. BEACH FORD REPLACED. HAVE NEVER GOTTEN THE GEARS SYNCRONIZED. HAVE TO TOUCH GEAR SHIFT SOMETIMES TO PUT IN GEAR. TONIGHT CAR IS BACK AT BEACH FORD WITH A TRANSMISSION PUMP LEAK. REPORTED THIS CAR LAST WEEK FOR ACCELERATION PROBLEMS. *NM
Power train, Aug 1, 2005
THE EVENTS LEADING UP TO THE FAILURE OF MY VEHICLE IN THE MIDDLE OF A BUSY INTERSTATE WAS THAT THE OVERDRIVE LIGHT STARTED TO FLASH WHICH IN TURN WOULD TRIGGER THE CHECK ENGINE LIGHT. THE FAILURE WAS A SHOT TRANSMISSION AT ONLY 60,000 MILES. A PROBLEM THAT FORD MOTOR COMPANY KNOWS ABOUT FROM THE HUNDREDS OF TECH BULLETIN'S I'VE READ. THE VEHICLE WAS TAKEN INTO ADAMSON FORD IN BIRMINGHAM,ALA. AND WAS DIAGNOSED AS HAVING TROUBLE CODES,P0733,P0735,P0775 AND A FAULTY POWERTRAIN CONTROL MODULE. AFTER RECEIVING MY CAR AND ALMOST $800.00 LATER,THE SAME THING HAPPENED AGAIN. THE OVERDRIVE LIGHT STARTED BLINKING TRIGGERING THE CHECK ENGINE LIGHT. AFTER RETURNING TO THE DEALER WHOM THEN INFORMS ME THAT I WOULD HAVE TO BUY A REMANUFACTURER TRANSMISSION AT OVER $2200,00 PLUS LABOR. I CAN'T AFFORD THIS AND NOW I'M STUCK WITH A LATER MODEL CAR THAT I CAN'T USE, AND A HIGH CAR NOTE. I WILL NEVER BUY ANOTHER FORD AGAIN PERIOD. *JB
Power train, Jul 20, 2005
RIGHT AFTER 2002 EXPLORER SPORT 4X4 WAS OUT OF WARRANTY A WHINE FROM THE DIFFERENTIAL IN THE RANGE OF 40 - 80 MILE PER HOUR HAPPENS. FORD STATES TO LIVE WITH IT AND DOES NOT ACCEPT RESPONSIBILTY FOR DEFECTIVE PARTS AND MANUFACTURING OF DIFFERENTIAL.
Engine and engine cooling, Power train, Jun 21, 2005
PURCHASED A 2002 FORD EXPLORER NEW. WITH LESS THAN 45,000 MILES THE TRANSMISSION HAD TO BE REBUILT. CAR NOW HAS LESS THAN 65000 MILES AND THE ENGINE HAS TO BE REPLACE. FORD WILL NOT OFFER ANY FINANCIAL ASSISTANCE. RAPHAEL
Power train, Apr 25, 2005
WE HAVE OWNED OUR 2002 F150 4 DOOR TRUCK FOR 5 MONTHS NOW PURCHASED IN DEC 04', WE HAVE 34,000 MILES ON THIS TRUCK WHICH WAS PURCHASED USED. ON SATURDAY 4/23/05 OUR TRANSMISSION COMPLETELY SLIPPED OUT LEAVING US NO POWER ON A BUSY, HILLY, COUNTRY ROAD. THE TRUCK'S RMP'S WOULD GO UP HOWEVER, THE TRUCK WAS NOT GAINING SPEED ONLY LOSING SPEED, WE ARE VERY LUCKY THAT NO ONE CAME OVER THE HILL, OR THIS WOULD HAVE CAUSED A MAJOR WRECK. ONCE WE GOT US AND VEHICLE TO SAFETY WE CALLED OUR FORD DEALERSHIP CHUCK ANDERSON FORD, WHO TOLD US TO HAVE IT TOWED IN. HOWEVER, THEY WOULD NOT COVER THE TOW SINCE IT WAS OUT OF WARRANTY. THE VEHICLE EVIDENTLY WENT OUT OF WARRANTY ON FEB. 14TH OF THIS YEAR 2005. I DON'T BELIEVE A TRUCK WITH ONLY 34,000 MILES ON IT SHOULD HAVE A TRANSMISSION BLOWN IN IT. WE THEN HAD THE TRUCK TAKEN TO THE DEALERSHIP. I HAVE SPOKEN WITH THE DEALERSHIP TODAY, WHICH WE WE'RE TOLD WE WOULD HAVE TO COVER THE DEDUCTIBLE OF $400/500.00 FOR THIS REPAIR. THEY ARE NOW TEARING THE TRANSMISSION APART. *AK
Power train, Mar 1, 2005
THE TRANSMISSION ON MY 2002 EXPLORER STARTED SHUDDERING WHEN GOING UP HILLS, WHEN PASSING CARS, AND THERE IS A DELAY WHEN SHIFTING TO REVERSE. WHEN TRYING TO GET INTO REVERSE THERE IS ALSO VERY ROUGH SHIFTING WITH THE DELAY. THESE PROBLEMS STARTED AT ABOUT 45,000 MILES. *JB
Power train, Feb 19, 2005
HEARD BANGING IN REAR OF TRUCK,MOSTLY WHILE BACKING UP AND TURNING TO LEFT AT FIRST. HEARD LOUD BANG WHILE PULLING INTO GAS STATION,THEN WHEN I DROVE AWAY,FELT DRAGGING,STILL NOT SURE WHAT THE PROBLEM WAS,TILL I GOT HOME WHILE BACKING INTO A PARKING SPOT,HEARD THE LOUD BANG AGAIN. AFTER SOME IVESTIGATION,DETERMINED THE PROBLEM WAS IN THE DIFFERENTIAL. HAD TO HAVE TRUCK TOWED TO DEALER,AND THEY FOUND BROKEN SPIDER GEARS IN THE DIFFERENTIAL. DEALER REPLACED PARTS. SATTISFIED WITH REPAIR.*AK
Power train, Feb 7, 2005
WHILE DRIVING YOU EXPERIENCE A HESITATION FORD DEALERSHIP ORIGINALLY SAID IT WAS A SPARK PLUG-AND REPLACED IT-PROBLEM STILL EXISTS- CURRENTLY IT IS BACK AT THE DEALERSHIP-AND AT THIS POINT THEY SAID THERE IS A PROBLEM WITHIN THE TRANSMISSION BUT THEY DO NOT KNOW SPECIFICALLY WHAT PROBLEM IS-OR WHAT IF ANYTHING THEY WILL PAY FOR PROBLEM- IN THE MEANTIME I HAVE TO PAY FOR A RENTAL- THE SUV HAS 48,000 MILES- I HAVE KEPT UP WITH ALL SERVICES. *JB
Engine and engine cooling, Power train, Electrical system, Structure, Jan 25, 2005
ELECTRICAL: AT 306 MILES THE SOLENOIDS HAD TO BE REPLACED. UPON SHUTTING THE VEHICLE OFF; THE DASH BOARD WOULD STILL ILLUMINATE. ALSO, UPON SHUTTING THE VEHICLE OFF IT WOULD CONTINUE TO RUN. THIS HAS HAPPENED A TOTAL OF FOUR TIMES. THE TRANSMISSION COMPLETELY FAILED WITH NO WARNING. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THE WINDSHIELD HAD A LEAK WHICH CORRODED THE ELECTRICAL SYSTEM. THE ELECTRICAL PROBLEMS STARTED AT 44000 MILES. THE GASKET HAD TO BE REPLACED, AND THE HARNESS WIRING HAD TO BE REPLACED ALSO. UPON TRYING TO START THE VEHICLE AGAIN THE BATTERY WOULD BE COMPLETELY DEAD. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB
Power train, Jan 4, 2005
DRIVING AT SLOW SPEED ON GRAVEL ROAD, LOST CONTROL OF VEHICLE, SWERVED TO THE RIGHT, WAS ABLE TO STOP VEHICLE, FOUND LEFT REAR WHEEL HAD COME OFF, LEFT REAR AXLE SHAFT BROKEN AT WHEEL. NO VEHICLE DAMAGE, DID NOT CONTACT ANYTHING. AXLE JUST BROKE. *AK
Power train, Nov 3, 2004
VEHICLE LOST MOTION INTERMITTENTLY WHILE DRIVING 0-40 MPH AND WHEN THE CLUTCH WAS BEING ENGAGED. VEHICLE WAS TAKEN TO THE DEALER, WHO FOUND THE CLUTCH SLAVE CYLINDER WAS LEAKING FLUID. *AK
Power train, Nov 1, 2004
THE VEHICLE FAILED TO ACCELERATE WHEN THE CLUTCH WAS APPLIED DURING VARIOUS SPEEDS OF 0-45 MPH. THE VEHICLE WAS TAKEN TO A DEALER WHO INFORMED THE CONSUMER THAT THE CLUTCH SLAVE CYLINDER WAS LEAKING FLUID. *JB
Power train, Oct 4, 2004
ROUGH IDLE.*AK
Power train, May 10, 2004
I WAS DRIVING DOWN SR 33 IN POLK CITY WHEN IT SEEMED AS IF MY CAR WAS SLOWING DOWN. I HAD THE PEDAL DEPRESSED BUT THE TRUCK CONTINUED TO SLOW DOWN. I HAD TO PULL OFF TO THE SIDE OF THE ROAD. WHEN THE SPEEDOMETER FELL BACK DOWN TO ZERO I ATTEMPTED TO TAKE OFF AGAIN. ONCE AGAIN, THE TRUCK WOULD GET TO 50 AND THEN NOT SHIFT TO THE NEXT GEAR. THIS WAS THE FIRST AND ONLY SIGNS SOMETHING WAS WRONG. I ASSUMED IT WAS A PROBLEM WITH THE TRANSMISSION. I DROVE TO WORK (15 MILES) IN SECOND GEAR, CALLED A TOW TRUCK AND HAD IT TOWED TO LAKELAND FORD. I WAS TOLD THE OVERDRIVE CLUTCH BURNED UP AND THE DIRECT DRIVE PAK BURNED UP. THE FORD DEALERSHIP WANTED $2,326.09 TO FIX A 2002 VEHICLE THAT IS NOT EVEN TWO YEARS OLD AND HAS 44,176 MILES ON IT. MOST OF THE MILES ON THIS VEHICLE WERE HIGHWAY MILES ALWAYS DRIVEN WITH OVERDRIVE ON AND ONLY WAS SOMETHING TOWED. THIS VEHICLE HAS THE TOWING PACKAGE IN IT SO THIS PROBLEM SHOULD NOT HAVE HAPPENED. MY WARRANTY WAS 3 YEARS/36,000 MILES. TRUCK IS NOW AT AAMCO WITH TRANSMISSION BEING REBUILT. *LA
Power train, May 7, 2004
TRUCK IS A F-150 WITH A 3.55 LIMITED SLIP AXLE. THERE IS A VERY NOTICEABLE WHINE COMING FROM THE REAR DIFFERENTAIL. NOISE STARTS AT 40 MPH BUT IS MOST NOTICEABLE AT 60 MPH. NOISE IS WITH SLIGHT ACCELERATION, IF I TAKE MY FOOT OFF THE GAS IT STOPS. I HAVE HAD THE TRUCK TO THE DEALER THREE DIFFERENT TIMES. THEY HAVE REPLACED THE BEARINGS, DRIVE SHAFT AND GEARS BUT IT HASN'T HELPED. THIS IS A WIDESPREAD KNOWN PROBLEM BUT THEY DON'T SEEM TO HAVE A FIX FOR THE PROBLEM. I WOULD NEVER BE ABLE TO SELL THIS TRUCK WITH THIS PROBLEM.*AK
Power train, Mar 9, 2004
TRANSMISSION PROBLEMS: CLUTCH DOES NOT DISENGAGE PROPERLY. DEALER REPLACED CLUTCH ASSEMBLY AT CONSUMER'S EXPENSE. *AK
Power train, Mar 9, 2004
TRANSMISSION PROBLEMS: CLUTCH DID NOT DISENGAGE PROPERLY. DRIVER HAD TO CHANGE GEARS REPEATEDLY IN ORDER TO SHIFT. THIS PRODUCED DANGEROUS DRIVING PROBLEMS. DEALER REPLACED THE MASTER CYLINDER RELAY AT CONSUMER'S EXPENSE. *AK
Power train, Feb 26, 2004
VIBRATION IN DRIVETRAIN AT HIGHWAY SPEED (BETWEEN 65 -75 MPH). ONLY HAPPENS WHEN TRUCK IS UNDER POWER. AS SOON AS YOU REMOVE YOUR FOOT FROM THE PEDAL, THE VIBRATION GOES AWAY. DRIVE SHAFT WAS REPLACED OVER 6 MONTHS AGO, BUT THAT DID NOT FIX THE ISSUE.*AK
Power train, Feb 19, 2004
DUE TO A DESIGN FLAW IN THE FORD 5.4 ENGINE MY 2002 HARLEY F-150 BLEW A SPARK PLUG LAST WEEKEND (2/15/04). FORD IS ONLY WILLING TO REPLACE THE ONE HEAD WITH THE NEWLY DESIGNED HEAD (AND THAT IS COSTING ME $500 BECAUSE MY TRUCK HAS 40,000 MILES). IT'S A KNOWN DESIGN FLAW AND HAS HAPPENED TO MANY OWERS WITH LESS THAN 10,000 MILES. FORD NEEDS TO STAND BEHIND THEIR PRODUCT.
Power train, Nov 19, 2003
WHILE DRIVING CONSUMER HEARD NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN ACCELERATING. *AK
Power train, Electrical system, Structure, Aug 7, 2003
PROBLEMS WITH VEHICLE PASSENGER DOOR, AND PAINT DEFECT ON DRIVER SIDE OF VEHICLE. *MR THE CONSUMER WAS TOLD THAT THE ONLY PROBLEMS WERE WITH THE TORQUE CONVERTER WHICH WAS REPLACED AND THE ALTERNATOR. THE CONSUMER WAS CONCERNED THAT THE VEHICLE WAS PREVIOUSLY INVOLVED IN AN ACCIDENT, AS THERE WAS A PAINT DEFECT ON THE DOOR HANDLE WHICH DIDN'T FULLY SHUT AT TIMES. THE CONSUMER WAS WILLING TO GIVE BACK THE VEHICLE IN RETURN OF ALL THE MONIES (PAYMENT(S)/DOWN PAYMENT). *SCC *JB
Suspension, Power train, Structure, Equipment, Apr 4, 2003
THE TRANSMISSION SLIPPED, THE PAINT WAS DEFECTIVE, AND THE RUNNING BOARD ON THE PASSENGER SIDE WAS DAMAGED. THE BACK BED ON TRUNK NEEDED TO BE REALIGNED AND THE VEHICLE PULLED TO THE RIGHT WHILE DRIVING. IN ADDITION, THE FRONT PASSENGER DOOR DID NOT CLOSE PROPERLY EVEN AFTER REPAIR.*PH *JB