2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Fuel system, Gasoline, Jan 13, 2012
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE CONTACT STATED THAT THE FUEL TANK STRAPS WERE TO BE REPLACED UNDER THE RECALL BUT THE FUEL TANK STRAPS WERE ALSO RUSTED. AS A RESULT, THE FUEL TANK EXHIBITED A HOLE, WHICH CAUSED A FUEL LEAK. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT ONLY THE FUEL TANK STRAPS COULD BE REPAIRED UNDER THE RECALL, NOT THE ACTUAL FUEL TANK. THE MANUFACTURER PROVIDED NO ASSISTANCE. THE FUEL TANK WAS REPLACED. THE FAILURE MILEAGE WAS 107,150 AND THE CURRENT MILEAGE IS 110,000. UPDATED 02/14/12*LJ UPDATED 02/29/12
Engine and engine cooling, Jan 3, 2012
WHILE AT A STOP LIGHT WAITING TO PROCEED ON THE ARROW, I ACCELERATED AND HEARD VERY LOUD POP AND A VIOLENT SHAKE. PULLED OVER OUT OF TRAFFIC AND CHECK UNDER THE HOOD AND FOUND THAT THE RIGHT REAR SPARK PLUG EJECTED OUT OF HEAD. IT SHOULD BE NOTED THAT THIS THE SECOND TIME FOR THIS TO HAPPEN MY VEHICLE THE FIRST TIME THE HAD 71000 MILES AND NOW. FORD WILL NOT DO ANY THING ABOUT THIS REQUIRING PROBLEM WITH IT'S FORD F-150 5.4 TRITON ENGINE 2002. *TR
Engine and engine cooling, Dec 28, 2011
BLEW SPARK PLUG OUT OF HEAD WHILE ACCELERATING TO GET ON HIGHWAY. HAD GAS SPILL ON MOTOR. IT HAS THE 5.4 TRITON MOTOR. *TR
Engine and engine cooling, Dec 22, 2011
I WAS TRAVELING 60 MPH ON THE FREEWAY WHEN A SPARKPLUG WAS EJECTED FROM THE ENGINE, BREAKING THE COIL ATTACHMENT FROM THE ENGINE. I FOUND BOTH THE SPARK PLUG AND THE COIL LYING ON TOP OF THE ENGINE. *TR
Electrical system, Vehicle speed control, Dec 21, 2011
TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WITH THE CRUISE CONTROL ACTIVATED AND SUDDENLY WITHOUT INTENT THE CRUISE CONTROL FAILED TO OPERATE. IN ADDITION, THE HORN WOULD NOT SOUND UPON ENGAGING. THE AUTHORIZED DEALER WAS NOTIFIED AND THEY INFORMED THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). A FEW YEARS LATER, THE IDENTICAL FAILURE RECURRED. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. ...UPDATE 01/20/12 *BF UPDATED 01/25/12
Engine and engine cooling, Dec 20, 2011
MY TRUCK THREW A SPARK PLUG WHILE DRIVING DOWN THE ROAD. THIS IS THE SECOND TIME IT HAS DONE THIS AND THE SAME EXACT ONE AS BEFORE. *TR
Engine and engine cooling, Dec 19, 2011, fire
TL* THE CONTACT OWNED A 2002 FORD F-150. WHILE DRIVING IN REVERSE AT APPROXIMATELY 2 MPH, THE CONTACT NOTICED SMOKE EMITTING FROM UNDERNEATH THE HOOD. THE CONTACT IMMEDIATELY EXITED THE VEHICLE. A POLICE REPORT OF THE INCIDENT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE MASSIVE FLAMES, WHICH EXTENDED 50 FEET INTO THE AIR. THE VEHICLE WAS TOWED TO A SALVAGE FACILITY FOR FURTHER INVESTIGATION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
Electrical system, Dec 8, 2011
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT VARIOUS WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE GEM MODULE FAILED DUE TO A WATER LEAK. THE CONTACT WAS ALSO INFORMED THAT THE MODULE NEEDED TO BE REPLACED AND THE WINDSHIELD NEEDED TO BE RESEALED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED BECAUSE THE NECESSARY PARTS WERE ON BACK ORDER. THE FAILURE MILEAGE WAS 103,000. THE VIN WAS NOT AVAILABLE.
Fuel system, Gasoline, Nov 25, 2011
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING) ON NOVEMBER 23, 2011. THE FUEL TANK HAD BEEN LEAKING FUEL EVER SINCE THE REPAIR. THE CONTACT STATED THAT THE LEAK WAS CAUSED BY THE STRAPS BEING TAKEN OFF AND REPLACED. THE CONTACT FELT THAT THE MANUFACTURER SHOULD BE OBLIGATED TO REPAIR THE FUEL TAKE IN ADDITION TO REPAIRING THE FUEL TANK STRAPS. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 130,556.
Engine and engine cooling, Electrical system, Nov 17, 2011
SPARK PLUG BLEW OUT OF PLUG HOLE, STRIPPING THREADS OF INTAKE CYLINDER HEAD. PLUG WAS FOUND LAYING BETWEEN VALVE COVER AND INTAKE MANIFOLD. *TR
Fuel system, Gasoline, Nov 16, 2011
DRIVING WITH TWO KIDS IN TRUCK HEAR BUMPING SOUND PULL OVER STRAP BROKEN AND GAS COMING OUT OF TANK GET HOME CALL SEABREEZE FORD HES AWARE OF PROBLEM GET IT THEIR SAID GAS TANK STRAP RUSTED TO THE FUEL TANK SO WHEN STRAP BROKE IT RIPPED A HOLE IN FUEL TANK HE ALSO SAID COULD NOT HAVE DONE A REPLACEMENT ON STRAP BECAUSE IT ALREADY BONDED TO TANK RUSTED TOGETHER FORD WILL ONLY PAY FOR STRAPS AT THIS TIME SERVICE MAN EVEN THE SAID FAULTY STRAPS BREAKING RIPPED THE HOLE IN THE TANK LUCKY NO FIRE HOW CAN THEY NOT ACCEPT A CAUSED B BAD STRAPS CAUSED RIPPED HOLE IN GAS TANK. *TR
Fuel system, Gasoline, Nov 15, 2011
AGAIN HERE IS VIN # AS APPEAR ON TITLE WILL NOT LET ME ENTER IN BOX AT TOP OF FORM WHY WHY WHY VIN 1 [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Electrical system, Nov 3, 2011
2002 FORD F-150. CONSUMER WRITES IN REGARDS TO RECALL AND REPAIRS *TGW THE CONSUMER STATED HE MADE AN APPOINTMENT AS SUGGESTED BY THE RECALL LETTER TWO WEEKS AGO AND AS OF OCTOBER 7, 2011 THE DEALER INFORMED HIM THE PARTS WERE STILL NOT AVAILABLE. THE CONSUMER ALSO STATED THE INSTRUMENT CLUSTER DID NOT WORK, WHICH MADE IT DIFFICULT TO SEE THE MILEAGE ON THE VEHICLE. THE CONSUMER WAS INFORMED THE ONLY WAY TO FIX THE PROBLEM WAS TO REPLACE THE ENTIRE MODULE AS THE DASH MUST BE TAKEN APART. *JB THE CONSUMER STATED HE TOOK THE VEHICLE TO THE DEALER AFTER WAITING SEVERAL MONTHS FOR THE PARTS AND WAS INFORMED THEY COULD NOT REPLACE THE GAS TANK, BECAUSE IT WAS LEAKING AND IT WAS NOT COVERED UNDER THE RECALL. THE LEAK WAS DUE TO THE FAULTY STRAPS WHERE THE METAL WAS RUBBING ON METAL. UPDATED 12/20/11
Fuel system, Gasoline, Oct 28, 2011
I RECEIVED A RECALL ON MY FORD F-150 PICKUP, REPLACE FUEL TANK STRAPS. I CALLED AND MADE A APPOINTMENT. WHEN I GOT TO THE DEALERSHIP, THEY TOOK MY TRUCK TO THE SERVICE DEPARTMENT. THEY INFORMED ME , THEY DIDN'T HAVE THE PARTS TO REPAIR IT. IT WAS UNSAFE TO DRIVE, BUT WANTED ME TO SIGN A WAVER, WHICH WOULD HOLD ME ACCOUNTABLE, IF THE STRAPS BROKE , AND CAUSED AN ACCIDENT.THEY WANTED ME TO DRIVE THE TRUCK HOME!! I HAD TO LEAVE THE TRUCK AT THE DEALERSHIP. I WASN'T GOING TO DRIVE A DANGEROUS TRUCK HOME? THIS IS FRIDAY, THEY WON'T HAVE THE PARTS UNTIL TUESDAY TO FIX IT. WHAT A PAIN!!! THEY WOULDN'T EVEN GIVE ME A RENTAL TO DRIVE, THEY HAD TO DRIVE ME HOME!! *TR
Fuel system, Gasoline, Oct 27, 2011
TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACT STATED THE FUEL STRAPS BORE A HOLE IN THE FUEL TANK AND CAUSED THE FUEL TO LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THEY WOULD REPAIR THE STRAPS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING) BUT THEY WOULD NOT REPAIR THE HOLE THAT THE STRAP CAUSED IN THE FUEL TANK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT ADVISED THAT THEY WOULD ONLY REPAIR THE STRAPS UNDER THE RECALL. THEY OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 33,278.
Electrical system, Vehicle speed control, Oct 21, 2011, fire
I AM REPORTING THIS INCIDENT AS THE PERSON WHO'S CAR WAS AFFECTED BY THE FIRE. I PARKED MY CAR NEXT TO A 2002 FORD F150, AND AFTER BEING HOME FOR ABOUT AN HOUR AND A HALF, A POLICE OFFICER CAME TO MY DOOR AND TOLD ME THAT MY CAR (VW JETTA) WAS INVOLVED IN A CAR FIRE. APPARENTLY THE F150 CAUGHT FIRE AND BURNED MY CAR, A BUSH, AND ANOTHER CAR. THE FIRE MARSHAL ON SCENE EXPLAINED TO ME THAT FORD HAD A RECALL ON MULTIPLE VEHICLES THAT HAD THIS PROBLEM. THE F150 IN QUESTION IS TOTALED AND HAS TO BE TOWED OFF THE PROPERTY. I HAVE SINCE COME INSIDE AND FOUND THE SWITCHFIRES.COM WEBSITE, AND CLICKED ON THE LINK PROVIDED BELOW, WHICH IN TURN HAS LED TO GIVING IN MY INFO, AND DISCUSSING MY DILEMMA. *TR
Suspension, Oct 16, 2011
LEAF SPRING BRACKETS ATTACHED TO THE FRAME HAVE RUSTED OUT AND HAVE SEPARATED THE LEAF SPRINGS FROM THE FRAME. *TR
Engine and engine cooling, Oct 16, 2011
UPON STARTING THE VEHICLE A SPARK PLUG BLEW OUT OF THE HEAD. 5.4 L TRIRON ENGINE. THREADS IN HEAD DAMAGED BEYOND REPAIR. FUEL VAPORS ESCAPING CYLINDER. SPARK PLUG HAS NEVER BEEN REMOVED/REPLACED TO MY KNOWLEDGE. *TR
Vehicle speed control, Oct 12, 2011, fire
FAULTY CRUISE CONTROL SHORTED OUT CAUSING FIRE IN THE ENGINE COMPARTMENT AND DAMAGING SOME WIRES, AIR FILTER HOUSING, FUSE BOX, BRAKE MASTER CYLINDER, HOOD STRUT AND HOOD. *KB
Fuel system, Gasoline, Oct 5, 2011
TL* THE CONTACT OWNS A 2002 FORD F-150 XLT. THE CONTACT STATED THAT THE NATURAL FUEL TANK WAS LEAKING. THE VEHICLE WAS INSPECTED BY THE DEALER WHO ADVISED THE CONTACT THAT THE NATURAL COMPRESSED TANK O-RING WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.
Electrical system, Oct 3, 2011, fire
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE PARKED AND UNOCCUPIED, THE VEHICLE IGNITED IN FLAMES. THE FIRE STARTED UNDER THE HOOD FROM THE DRIVER SIDE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WAS AN UNKNOWN RECALL THAT COULD HAVE BEEN ASSOCIATED WITH THE FAILURE. THE CONTACT STATED THAT THE CAUSE OF THE FIRE WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
Electrical system, Electronic stability control (ESC), Oct 3, 2011, fire
MY TRUCK WAS PARKED OUTSIDE MY HOUSE AND ALL OF A SUDDEN GOT ON FIRE UNDER THE HOOD FOR NO REASON. *TR
Structure, Sep 30, 2011
ON AUGUST 20, 2011 ON MY WAY HOME, MY SPARE TIRE THAT WAS MOUNTED UNDER TRUCK FELL ONTO ROADWAY. I RECOVERED THE TIRE AND PARTS FROM ROAD AND LOOKED UNDER TRUCK FOR CAUSE. THE CABLE AND CLAMP THAT HOLDS THE SPARE TIRE HAD CORRODED AND BROKEN CAUSING THE TIRE TO FALL TO ROADWAY. *TR
Structure, Sep 30, 2011
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED WHILE DRIVING THERE WAS A LOUD NOISE IN THE REAR OF THE VEHICLE AND FOUND THAT THE SPARE TIRE SEPARATED FROM THE VEHICLE DUE TO CORRODED CABLE AND CLIP HOLDER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILES WAS 140,000.
Fuel system, Gasoline, Sep 28, 2011
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT SHE NOTICED THAT FUEL WAS LEAKING FROM THE FUEL TANK AFTER RECEIVING THE RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (COMPONENT: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE, BUT REFUSED TO REPAIR THE FUEL TANK BECAUSE THE RECALL WAS ONLY ADDRESSING FAILURES ASSOCIATED WITH THE FUEL TANK STRAPS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 90,000. THE VIN WAS UNAVAILABLE. UPDATED 10/27/11*BF UPDATED 3/30/12 *CN