2003 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 464 owner complaints filed for this model year. This is the 8th highest complaint count among 26 F-150 model years with reports.
Of the 2003 reports, 45 involved a crash and 39 involved a fire. 39 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Vehicle speed controlMar 6, 2007
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)
Campaign 07V078000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Steering, gear box, shaft pitmanSep 22, 2003
ON CERTAIN PICKUP TRUCKS, THE PITMAN ARM TO STEERING GEAR RETAINING NUT WAS NOT FULLY TIGHTENED TO THE REQUIRED SPECIFICATION.
IF THE PITMAN ARM TO GEARBOX ATTACHMENT NUT LOOSENS, A NOISE AND A LOOSE FEEL IN THE STEERING COULD OCCUR. IF THE CONDITION PROGRESSED AND SERVICE WAS NOT SOUGHT, THE NUT COULD BACK OFF COMPLETELY AND THE PITMAN ARM COULD SEPARATE FROM THE GEAR CAUSING A LOSS OF STEERING. IF THE WARNING IS NOT HEEDED AND STEERING IS LOST, A CRASH MAY RESULT.
DEALERS WILL TIGHTEN THE PITMAN ARM RETAINING NUT TO SPECIFICATIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 1, 2003. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 03V349000 on NHTSA.gov
Representative owner complaints: power train
71 reports, newest first. Show all
Power train, Jun 10, 2004
2003 FORD 150 EXT CAB 4X4 TRUCK WAS BEING DRIVEN AT APPROXIMATELY 40 MPH WITH A LIGHT LOAD. AS THE TRUCK WAS SHIFTED FROM 3RD TO 4TH THE DRIVE LINE BROKEN IN HALF AND BEGAN POUNDING THE UNDERCARRIAGE OF THE VEHICLE DAMAGING THE FUEL TANK AND EXHAUST SYTEM. THE DRIVER CLAIMS THE CLUTCH WAS NON RESPONSIVE AND THERE WAS A STRONG SMELL OF BURNED CLUTCH HAS THE VEHICLE WAS STOPPED. FORD REP IS CLAIMING DAMAGE IS THE RESULT OF ABUSE AND/OR PRIOR DAMAGE TO THE DRIVELINE BASED ON PHOTOGRAPHS SUPPLIED BY DEALERSHIP (THE FORD REP DID NOT PHYSICALLY INSPECT). THE DEALERSHIP HAS NO OPINION OF WHY THE FAILURE OCCURRED AND HAS CLAIMED TO HAVE NEVER SEEN SUCH A FAILURE. I DO NOT FEEL THAT THERE IS DOCUMENTATION TO SUPPORT FORD'S POSITION AND THEY ARE SIMPLY ATTEMPTING TO AVOID A WARRANTY CLAIM. OF EVEN DEEPER CONCERN IS THE POSSIBILITY THAT OTHER F150'S COULD EXPERIANCE THE SAME FAILURE WHICH COULD RESULT IN INJURIES AND/OR LOSS OF LIFE. *AK
Power train, Jun 5, 2004
PURCHASED THE 2003 F-150USED FROM HERTZ RENTAL AT 22,00O MILES. WITHIN 2000 MILES, A GRATING SOUND BEGAN TO OCCUR PERIODICALLY. BASICALLY, AFTER YOU ARE AT A STOP OR COMPLETE A TURN, THE TRUCK WILL MAKE THIS GRINDING SOUND AS YOU ACCELERATE. IT LASTS FOR A SECOND OR SO AND SOUNDS AND FEELS LIKE YOU RAN OVER A CATTLE GUARD. IT DOES IT SOMETIMES AND NOT OTHERS. ALSO, THE TRUCK WILL SOMETIMES DROP ITS IDLE TO 100 WHILE STOPPED AND ALMOST DIE. ALSO THE AIR CONDITIONING MAKES A LOUD GROANING TYPE WHILE WHEN YOU FIRST TURN IT ON. YOU HAVE TO TURN THE TRUCK OFF AND BACK ON TO MAKE IT STOP. IVE HAD THE VEHICLE 3 MONTHS AND ITS BEEN IN THE SHOP 8 TIMES. EACH TIME THEY TELL ME THEY CANT FIND A PROBLEM. I DONT BELEIVE THIS CONSIDERING THERES MANY OTHERS ON HERE WITH THE SAME PROBLEMS. IVE CALLED CUSTOMER ASSITANCE AND THEY JUST SAY GO TO THE DEALER. ITS GOT 30,000 MILES ON IT. MY WARRANTY TIME IS RUNNING OUT. I CANT SELL IT BECAUSE ID HAVE TO TAKE A LOSS ON IT. FORD HAS HUNG ME OUT TO DRY. PLEASE PLEASE HELP. MY WIFE AND I CANNOT AFFORD THIS KIND OF FINANCIAL HIT. I DONT EXPECT A NEW TRUCK, I JUST WANT MY TRUCK FIXED SO I CAN TRUST IT.*AK
Service brakes, Hydraulic, Power train, May 27, 2004
WHILE THE VEHICLE WAS PARKED WITH THE BRAKE DEPRESSED, THE FRONT WHEELS BEGAN TO TURNED WHICH CAUSED THE VEHICLE TO ROLL DOWN A DRIVEWAY. DURING THIS INCIDENT A BABY WAS INJURED. THE CAUSE OF THE PROBLEM HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Power train, May 7, 2004
DRIVE TRAIN WINE BETWEEN 47 MPH AND 55 MPH IN MY 2003 F-150 SUPPER CREW. THE FORD DEALER REPLACED THE REAR DRIVE SHAFT BUT THE PROBLEM STILL EXISTED. DEALER CALLED FORD AND FORD SAID BECAUSE I HAVE A SLIDING REAR WINDOW, TONNEAU COVER AND 3.73 REAR END GEARING THESE ITEMS ARE CAUSING THE WINE. THE FORD DEALER SAID THAT IF TRIED TO RUN THIS PROBLEM THROUGH WARRANTY AGAIN FORD WOULD DENY IT. THE DEALER ALSO SAID I SHOULD TAKE THIS PROBLEM TO ANOTHER DEALER.*AK
Power train, Apr 29, 2004, crash
WHILE PARKED VEHICLE CAME OUT OF GEAR AND ROLLED DOWN THE HILL INTO A DITCH. *AK
Power train, Apr 13, 2004
REAR AXLE WHINE NOISE AT 45 TO 50MPH & 67 TO 72 MPH. LOUD & GETTING LOUDER. FORD DEALERS ALL OVER THE AREA SAID FORD KNOWS OF NOISE BUT HAS NO FIX. SAID THEY WERE TOLD FORD WOULD NOT SPEND MONEY TO FIX BECAUSE THEY WERE NOT MAKING MUCH AS A COMPANY NOW. TWO REPARS ON REAR END & STILL NOISY, ENGINEER HAD DEALER PUT 125 WT GREASE IN REAR AXLE TO TRY & QUIET NOISE DOWN. NO GOOD> LOST FUEL ECONOMY ALSO. I NEED HELP GETTING REPAIRED OR GETTING A BUY BACK FROM FORD.
Power train, Mar 18, 2004
WHEN MAKING SLOW TURNS IN MY 2003 FORD F-150 SUPERCREW (ONLY 42,000 MILES ON THE TRUCK), THE TRUCK HAS A VIBRATION. WENT TO A FORD SERVICE TECHNICIAN, AND THEY COULD NOT DIAGNOSE THE PROBLEM, THEY SUGGESTED TO RE-PACK THE CLUTCH PACKS, WHICH WAS DONE. VIBRATION STILL OCCURING 1 WEEK LATER. ACCORDING TO OTHER'S WHO ALSO OWN FORD VEHICLES, THIS SEEMS TO BE A HUGE PROBLEM THAT FORD STATES IS NORMAL WEAR AND STATING ITS A PROBLEM WE HAVE TO LIVE WITH. *AK
Power train, Jan 26, 2004
THE FOUR-WHEEL DRIVE WOULD NOT OPERATE PROPERLY. THE VEHICLE WAS TAKEN TO A DEALER THAT REPLACED THE PARTS WITH PARTS FROM ANOTHER VEHICLE OF THE SAME MAKE, MODEL, AND MODEL YEAR. THOSE PARTS FAILED THE SAME DAY OF REPAIR. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Service brakes, Hydraulic, Power train, Equipment, Jan 12, 2004
THE 4 WHEEL DRIVE FAILED TO DISENGAGE. THE TRUCK HAS BEEN SERVICED BY SEVERAL DEALERSHIPS FOR THIS ISSUE. THEY ALL GAVE DIFFERENT SOLUTIONS TO SOLVE THE PROBLEM, BUT NONE OF THE SOLUTIONS RELATED TO WHAT WAS IN THE OWNER'S MANUAL. *PH THE VEHICLE DID NOT DISENGAGE OR SHIFT OUT OF 4X4 INTO 4X2 UNDER A LOAD OR IN A BIND. THE BRAKES PUSHED TO THE DRIVERS SIDE AND A MADE NOISE, AND THE A/C DIDN'T SWITCH FROM DEFROST TO VENT DUE TO THE RADIO AND BEZEL VACUUM TO THE A/C SYSTEM. THE A/C SELECTOR SWITCH WAS REPLACED. *SC *JB
Power train, Dec 25, 2003
1 BOUGHT A 2003 F150 EXTENDED CAB. THE TRANSMISSION IS ALWAYS LOUD, SLUGGISH WHEN IT DOES SHIFT AND SLIPS ALL TOGETHER. *LA
Power train, Dec 20, 2003
WITHIN A FEW THOUSAND MILES OF PURCHASE, WE BEGAN NOTICING A SPORADIC GRATING NOISE FROM THE REAR END. MORE DISTUBING IS THE HARD SHIFTING BETWEEN 1ST AND 2ND GEARS THAT IS ALSO SPORADIC. THE SHIFTING PROBLEM HAPPENS ON LONG TRIPS OF 150 MILES OR MORE. IT WILL USUALLY HAPPEN ABOUT ONCE A DAY BUT OF COURSE WE NEVER KNOW WHEN. THE GRATING NOISE IS LESS FREQUENT AND CAN HAPPEN ANYTIME. OUR VEHICLE IS CURRENTLY AT THE DEALERSHIP FOR A FOURTH VISIT FOR THESE PROBLEMS. FORD HAS NOT BEEN ABLE TO REPLICATE THE GRATING AND HARD SHIFTING WHICH MAKES SENSE BUT AT THE SAME TIME WE ARE STUCK WITH A VEHICLE THAT HAS NOT PROVIDED NEW TRUCK PERFORMANCE. SINCE THE PROBLEM HAS BECOME MORE FREQUENT, IT WILL PROBABLY LEAD TO TRANSMISSION FAILURE ONCE IT IS OUT OF WARRANTY. I HAVE CONSIDERED SELLING IT BUT THAT WOULD BE UNETHICAL SINCE THE NEXT PERSON WOULD EVENTUALLY EXPERIENCE THE SAME PROBLEMS. FORD NEEDS TO STEP UP AND REPLACE THE TRANSMISSION. THERE IS ONE OTHER SIMILAR COMPLAINT IN THE DATA BASE. *LA
Power train, Dec 15, 2003
AT HIGHWAY SPEED VEHICLE GOES INTO LOW 4-WHEEL DRIVE. *AK
Power train, Dec 3, 2003
HAVING A PROBLEM WITH TRANSMISSION SLIPPING OR NOT CHANGING GEAR CORRECTLY. PLUS A NOISE OR VIBRATION GRINDING. DURING THIS TIME AS WELL. VERY UPSET. I HAVE TAKEN THE VEHICLE TO THE FORD DEALERSHIP BUT THEY CANNOT DUPLICATE THE PROBLEM WHILE THERE. FORD SAID THEY WILL NOT FIX UNTIL DUPLICATED. I AM VERY UPSET HAVE TAKEN TO DEALER FOUR TIMES. *NLM
Power train, Nov 30, 2003
HEARD UNUSUAL NOISE COMING FROM THE REAR-END OF MY 2003 FORD F-150 SUPERCREW THE NOISE STARTS AT 90 MPH. IS THIS AN ON GOING PROBLEM? PLEASE LOOK INTO IT. *AK
Power train, Oct 8, 2003
HEARD UNUSUAL NOISE COMING FROM THE REAR-END OF MY 2003 FORD F-150 SUPERCREW 4X2. THE DEALER NOTIFIED ME THAT DRIVESHAFT WAS BEING REPLACED. IS THIS AN ON GOING PROBLEM? PLEASE LOOK INTO IT. *LA
Power train, Sep 29, 2003
INTERMITTENTLY THE SHIFT INDICATOR WON'T ENGAGE FROM PARK TO DRIVE. DEALER INSPECTED SEVERAL TIMES AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK
Engine and engine cooling, Power train, Sep 3, 2003
I HAVE MANY PROBLEMS WITH MY 2003 FORD F150 FROM ENGINE NOISES TO TRANSMISSION LEAKING AND SLIPPING. MY VEHICLE HAS BEEN IN TWICE NOW AND NOBODY AT FORDS OR THEIR ENGINEERS SEEM TO KNOW WHAT IS WRONG. FORDS DOES NOT KNOW WHAT TO DO. I WOULD GREATLY APPRECIATE IF SOMEONE COULD LOOK INTO THIS MATTER BECAUSE NO ONE SHOULD HAVE THIS MANY PROBLEMS WITH A BRAND NEW $30,000 VEHICLE.*AK
Power train, Jul 28, 2003
2003 FORD F-150 KING RANCH "HOWL". NAR 07/28/2003.*MR DRIVELINE VIBRATION. DEALER NOTIFIED. *CB
Power train, May 22, 2003, crash
PURCHASED NEW FORD HARLEY PICKUP. LOUD NOISE IN REAR, SHOP COULD NOT IDENTIFY. REAR AXLE BROKE IN CURVE AND REAR WHEEL ON DRIVER SIDE WAS SEVERAL YARDS FROM WHERE TRUCK FINALLY RAN OFF ROAD AND OVERTURNED. TOTAL LOSS. *NLM
Service brakes, Hydraulic, Power train, Apr 28, 2003
WHEN THE CAR IS PUT INTO REVERSE IT DOES NOT WANT TO MOVE. IF YOU INCREASE THE RPM'S, IT STILL JUST SETS THERE. THE PROBLEM HAS BEEN VERY INCONSISTENT. REVERSE SEEMS TO BE AT THIS POINT, THE ONLY PLACE IT OCCURS. IN ONE OF THE ATTEMPTS TO FIX THE PROBLEM, THE TECHNICIAN FOUND THAT 3 OF THE 4 CALIPERS WERE FROZE/DRIED UP. THIS DOES NOT SET WELL WITH ME AND I SEE IT AS A POSSIBLY DANGEROUS SITUATION. *NLM
Power train, Mar 26, 2003
WE OWN SEVERAL FORD F-150 TRUCKS. IN THE LAST 3 MONTHS WE HAD FOUR SEPARATE PROBLEMS WITH THE REAR AXLES. ONE TRUCK THE AXLE BROKE AND THE WHEEL CAME COMPLETELY OFF. ANOTHER TRUCK THE AXLE WAS DESTROYED AND HAD TO BE REPLACED. THE LAST TRUCK IS BRAND NEW WITH LESS THAN 2000 MILES AND EXPERIENCED THE SAME PROBLEM YESTERDAY. *JB