2003 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 464 owner complaints filed for this model year. This is the 8th highest complaint count among 26 F-150 model years with reports.
Of the 2003 reports, 45 involved a crash and 39 involved a fire. 39 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Vehicle speed controlMar 6, 2007
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)
Campaign 07V078000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Steering, gear box, shaft pitmanSep 22, 2003
ON CERTAIN PICKUP TRUCKS, THE PITMAN ARM TO STEERING GEAR RETAINING NUT WAS NOT FULLY TIGHTENED TO THE REQUIRED SPECIFICATION.
IF THE PITMAN ARM TO GEARBOX ATTACHMENT NUT LOOSENS, A NOISE AND A LOOSE FEEL IN THE STEERING COULD OCCUR. IF THE CONDITION PROGRESSED AND SERVICE WAS NOT SOUGHT, THE NUT COULD BACK OFF COMPLETELY AND THE PITMAN ARM COULD SEPARATE FROM THE GEAR CAUSING A LOSS OF STEERING. IF THE WARNING IS NOT HEEDED AND STEERING IS LOST, A CRASH MAY RESULT.
DEALERS WILL TIGHTEN THE PITMAN ARM RETAINING NUT TO SPECIFICATIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 1, 2003. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 03V349000 on NHTSA.gov
Representative owner complaints
464 reports, newest first.
Tires, Jul 20, 2004
TIRES WERE SHOWING WEAR ON OUTER EDGES AT 4,000 MILES. I ROTATED AT THAT TIME. THEY CONTINUED TO SHOW WEAR. HAD TRUCK ALIGNED AT 12,000 BUT IT REALLY WASN'T OUT OF ALIGNMENT. FORD SAYS THAT IS NORMAL AND WE ARE TURNING TOO MUCH AND THAT IS WHAT IS CAUSING THE WEAR. *JB
Power train, Jul 14, 2004
2003 FORD F-150 SUPER CREW, HOWLING/WHINING NOISE FROM REAR DIFFERENTIAL DURING ACCELLERATION. NOISE ONLY OCCURRES BETWEEN THE SPEED OF 40MPH AND 60MPH, MOST NOTICABLE AT 50 MPH.*AK SO FAR DEFECT HAS NOT CAUSED OPERATIONAL FAILURE. PROBLEM HAS BEEN BROUGHT TO ATTENTION OF THE FORD DEALERSHIP WHO SOLD ME THE TRUCK. FIRST ATTEMPT TO REPAIR RESULTED IN NO WORK PERFORMED, NOISE CONSIDERED ACCEPTABLE BY FORD SPECS. SECOND REPAIR ATTEMPT (AFTER WRITING TO DEALERSHIP) RESLULTED IN SERVICE MANAGER DIAGNOSING A RING AND PINION GEAR PROBLEM. THEY REPLACED THE RING AND PINION GEAR 3/30/2004. PROBLEM REOCCURED AFTER 4 WEEKS, ADDITIONAL ATTEMPT TO REPAIR RESULTED IN ORIGINIAL CONCLUSION THAT NOISE WAS ACCEPTABLE PER FORD SPECS. INCONSISTENT PATTERN OF REPAIR WITH PROBLEM STILL EXISTING.
Power train, Jul 7, 2004
HOWLING NOISE IN REAR DIFFERENTIAL. REAR DIFFERENTIAL REPLACED TWICE. NOISE CONTINUES. FORD NOW REFUSES TO REPAIR REAR DIFFERENTIAL BECAUSE OF COMPLETE OVERHAUL TWICE. FORD NOW SAYS NOISE IS "CHARACTERISTIC" OF THIS VEHICLE. THIS IS NOT TRUE AS I HAVE DRIVEN OTHER IDENTICAL VEHICLES WITHOUT THE NOISE. NOISE GOES AWAY AFTER REPAIRS ARE MADE FOR ABOUT 6000 MILES. *AK
Service brakes, Hydraulic, Jul 6, 2004
WHILE DRIVING AT 70 MPH AND TRYING TO AVOID A MERGING VEHICLE CONSUMER ATTEMPTED TO SLOW DOWN THE VEHICLE BUT BRAKES WERE NOT RESPONDING PROPERLY. THE BRAKE PEDAL WENT TO THE FLOOR, AND THE EMERGENCY BRAKES WERE EMPLOYED TO STOP THE VEHICLE. THE DEALER HAS POSSESSION OF THE VEHICLE AWAITING AN EXAMINATION. *AK THE SERVICE DEALER DETERMINED THAT THE MASTER CYLINDER FAILED AND CAUSED THE COMPLETE BRAKE FAILURE. *SC
Engine and engine cooling, Jul 2, 2004
PINGING NOISE COMING FROM ENGINE, HAVE TAKEN VEHICLE IN TWICE WITH NO RESOLVE. BOUGHT TRUCK NEW IN JAN 03, HAVE 29,000MI ON IT. FIRST THEY REPLACED THE MAF STILL HEARD NOISE, THEN SECOND TRY THEY REPROGRAMED THE COMPUTER. SERVICE MANAGER STATED IT MIGHT BE COMING FROM FUEL INJECTORS. SOUND HEARD ON ACCELERATION AT ALL SPEEDS GREATER UNDER LOAD.*AK
Wheels, Jul 1, 2004
WHILE DRIVING AT 10 MPH THE CONSUMER FELT A VIBRATION IN THE FRONT END ON THE VEHICLE. THE CONSUMER EXAMINED THE VEHICLE AND FOUND THAT THE LUG NUTS HAD BACKED OFF OF THE SCREWS. THE DEALER CLAIMS NO RESPONSIBILITY FOR THE MALFUNCTION. *NM
Suspension, Jun 28, 2004
THE REAR END SUSPENSION IS GOING OUT PER THE DEALERSHIP. VEHICLE MAKES A LOUD HUMMING NOISE AT 50 MPH. ON 2 SEPARATE OCCASIONS, WHILE DRIVING ON THE INTERSTATE ON A SMOOTH SURFACE ROAD, VEHICLE MADE A LOUD CLUNG NOISE THAT FELT LIKE THE SUSPENSION DROPPED. DEALERSHIP HAS SERVICED THE VEHICLE 3 TIMES FOR THIS ISSUE, AND REPLACED THE BEARINGS AND OTHER SUSPENSION COMPONENTS. A FACTORY ENGINEER ALSO INSPECTED VEHICLE FOR THIS PROBLEM AND INDICATED THAT THERE' WAS NO SOLUTION THIS ISSUE, AND TO EXTEND THE WARRANTY. *AK
Power train, Jun 10, 2004
2003 FORD 150 EXT CAB 4X4 TRUCK WAS BEING DRIVEN AT APPROXIMATELY 40 MPH WITH A LIGHT LOAD. AS THE TRUCK WAS SHIFTED FROM 3RD TO 4TH THE DRIVE LINE BROKEN IN HALF AND BEGAN POUNDING THE UNDERCARRIAGE OF THE VEHICLE DAMAGING THE FUEL TANK AND EXHAUST SYTEM. THE DRIVER CLAIMS THE CLUTCH WAS NON RESPONSIVE AND THERE WAS A STRONG SMELL OF BURNED CLUTCH HAS THE VEHICLE WAS STOPPED. FORD REP IS CLAIMING DAMAGE IS THE RESULT OF ABUSE AND/OR PRIOR DAMAGE TO THE DRIVELINE BASED ON PHOTOGRAPHS SUPPLIED BY DEALERSHIP (THE FORD REP DID NOT PHYSICALLY INSPECT). THE DEALERSHIP HAS NO OPINION OF WHY THE FAILURE OCCURRED AND HAS CLAIMED TO HAVE NEVER SEEN SUCH A FAILURE. I DO NOT FEEL THAT THERE IS DOCUMENTATION TO SUPPORT FORD'S POSITION AND THEY ARE SIMPLY ATTEMPTING TO AVOID A WARRANTY CLAIM. OF EVEN DEEPER CONCERN IS THE POSSIBILITY THAT OTHER F150'S COULD EXPERIANCE THE SAME FAILURE WHICH COULD RESULT IN INJURIES AND/OR LOSS OF LIFE. *AK
Power train, Jun 5, 2004
PURCHASED THE 2003 F-150USED FROM HERTZ RENTAL AT 22,00O MILES. WITHIN 2000 MILES, A GRATING SOUND BEGAN TO OCCUR PERIODICALLY. BASICALLY, AFTER YOU ARE AT A STOP OR COMPLETE A TURN, THE TRUCK WILL MAKE THIS GRINDING SOUND AS YOU ACCELERATE. IT LASTS FOR A SECOND OR SO AND SOUNDS AND FEELS LIKE YOU RAN OVER A CATTLE GUARD. IT DOES IT SOMETIMES AND NOT OTHERS. ALSO, THE TRUCK WILL SOMETIMES DROP ITS IDLE TO 100 WHILE STOPPED AND ALMOST DIE. ALSO THE AIR CONDITIONING MAKES A LOUD GROANING TYPE WHILE WHEN YOU FIRST TURN IT ON. YOU HAVE TO TURN THE TRUCK OFF AND BACK ON TO MAKE IT STOP. IVE HAD THE VEHICLE 3 MONTHS AND ITS BEEN IN THE SHOP 8 TIMES. EACH TIME THEY TELL ME THEY CANT FIND A PROBLEM. I DONT BELEIVE THIS CONSIDERING THERES MANY OTHERS ON HERE WITH THE SAME PROBLEMS. IVE CALLED CUSTOMER ASSITANCE AND THEY JUST SAY GO TO THE DEALER. ITS GOT 30,000 MILES ON IT. MY WARRANTY TIME IS RUNNING OUT. I CANT SELL IT BECAUSE ID HAVE TO TAKE A LOSS ON IT. FORD HAS HUNG ME OUT TO DRY. PLEASE PLEASE HELP. MY WIFE AND I CANNOT AFFORD THIS KIND OF FINANCIAL HIT. I DONT EXPECT A NEW TRUCK, I JUST WANT MY TRUCK FIXED SO I CAN TRUST IT.*AK
Service brakes, Hydraulic, Jun 4, 2004
ON 2 SEPARATE OCCASIONS WHEN THE CONSUMER PRESSED THE BRAKE PEDAL IT FAILED TO STOP THE VEHICLE IMMEDIATELY. THE CONSUMER HAD TO PRESS THE BRAKE PEDAL 3 MORE TIMES TO STOP VEHICLE. THE DEALERSHIP INDICATED THAT THIS ALWAYS HAPPENED WHEN THE BRAKE PARTS GET WET. *AK *SC *JB
Engine and engine cooling, Jun 2, 2004
I PURCHASED MY FORD F150 ON DECEMBER 29, 2002 FROM SUNRISE FORD IN NORTH HOLLYWOOD, CALIFORNIA. I RETURNED IT IN MARCH 2003 BECAUSE THERE WAS AN ODD CLUNKING, GRINDING AND WHINING SOUND WHEN IT WAS DRIVEN. I WAS TOLD THAT THEY COULD NOT FIND ANYTHING WRONG WITH IT. THEN I TOOK IT BACK ONE MORE TIME IN APRIL OF 2003 AND THEY STILL COULD NOT FIND ANYTHING WRONG. IN MAY 2003, I MOVED TO ARIZONA AND ON MAY 9, 2003 I TOOK IT TO BERGE FORD LOCATED MESA, ARIZONA. THEY TESTED THE VEHICLE AND COULD NOT FIND ANYTHING WRONG. EVEN THOUGH THEY PREVIOUSLY MENTIONED THAT IT COULD BE THE REAR END THAT HAS THE PROBLEM. I TOOK IT IN AGAIN ON SEPTEMBER 17, 2003 TO BERGE FORD AND THEY FOUND SEVERAL ITEMS WRONG WITH THE TRUCK. ALTHOUGH THEY FIXED THE ITEMS LISTED ON THE SERVICE TICKET, THE TRUCK IS NOT FIXED. THIS VEHICLE OBVIOUSLY HAS A PROBLEM. I WOULD NOT WASTE MY TIME LEAVING WORK TO DEAL WITH SUCH ISSUES IF THE ISSUES DID NOT EXIST. IT TOOK FOUR TIMES TO LOCATE A PROBLEM AND IT IS STILL NOT FIXED. I TOOK THE CAR TO BERGE FORD ON MAY 26, 2004 AGAIN. THIS TIME THEY REPLACED THE AIR FLOW VALVE. I AGAIN TOOK THE VEHICLE IN ON JUNE 1, 2004 AND THEY COULDN'T FIND ANYTHING WRONG AGAIN. I BELIEVE THAT THIS VEHICLE IS TRULY A LEMON AND I AM HOPING THAT FORD CAN WORK WITH ME ON THESE ISSUES. I WAS TOLD I DO NOT QUALIFY FOR THE LEMON LAW BECAUSE OF MY MILEAGE, BUT THE PROBLEMS STARTED BEFORE I WAS OVER THE MILEAGE LIMIT. IT IS FRUSTRATING TO DEAL WITH THESE ISSUES FOR OVER A YEAR. IF THERE WERE NOT ANY PROBLEMS THEN WHY WOULD I HAVE RETURNED THE TRUCK 3 MONTHS AFTER I BOUGHT IT? I WOULD LOVE TO TRADE IT IN, BUT I DO NOT WANT TO LOSE AGAIN BY BEING UPSIDE DOWN. I SPOKE WITH A GENTLEMAN AT BERGE FORD AND HE SAID THAT THERE IS A POSSIBILITY THAT FORD MIGHT BE ABLE TO BUY THE TRUCK BACK AND THAT IS EXACTLY WHAT I NEED THEM TO DO AT THIS POINT. THANK YOU FOR YOUR IMMEDIATE ATTENTION TO THIS MATTER. *AK
Structure, May 31, 2004
I PURCHASED A LEFT OVER 2003 FORD F-150 PICKUP TRUCK AT CONDIT FORD IN NEWTON, NEW JERSEY. I PICKED UP THE VEHICLE ON FRIDAY EVENING MAY 28, 2004 ON SUNDAY MORNING AT 8:00 WHEN I BENT DOWN TO PICK UP A PIECE OF PAPER IN MY DRIVEWAY I NOTICED THAT THE UNDER SIDE OF THE REAR BUMPER IS RUSTED FROM SEVERAL SCRATCHES, I WALKED AROUND THE TRUCK AND NOTICED SEVERAL PAINT AND BODY DEFECTS AS FOLLOWS: REAR BUMPER HAS SEVERAL SCRATCHES AND RUST, TOW HOOK IS RUSTED, THE LEFT REAR FENDER HAS CRACKED/RIPPLED FIBERGLASS IN THE SECTION THAT IS NEAR THE BUMPER, THE LEFT DOOR HAS RAISED PAINT BLEMISH AND DENT, THE RIGHT DOOR ON THE INSIDE BY THE DOOR LATCH IS MISSING PAINT, THE RIGHT REAR CAB DOOR IS DEFECTIVE - IT BOWS OUT ON THE BOTTOM OF THE DOOR. WHEN I CALLED THE DEALERSHIP THE SALES MANAGER STATED THAT I MUST HAVE CAUSED THE DAMAGE. I MENTIONED THAT WHO CRAWLS UNDER A NEW TRUCK TO SEE IF THE BUMPER IS DAMAGED AND RUSTED AND THAT WITH AN ALL WHITE TRUCK IT IS MORE DIFFICULT TO IMMEDIATELY DETECT DAMAGES. AND THAT WHEN A CONSUMER BUYS A NEW VEHICLE IT IS EXPECTED THAT THE NEW VEHICLE IS NEW AND NOT DAMAGED. *AK
Seat belts, Equipment, May 29, 2004
I HAVE BEEN HAVING A PROBLEM WITH REAR-SEAT SEATBELT EXTENDERS. THE EXTENDER PROVIDED BY OUR DEALER IS NUMBER F58Z-16611C22-A. THE PROBLEM IS THAT THE RECEPTACLE ON THE EXTENDER WILL NOT LATCH ONTO THE SEAT BELT UNLESS THE EXTENDER RECEPTACLE IS AT ROOM TEMPERATURE OR ABOVE. WE HAVE BEEN TRYING TO GET THIS PROBLEM RESOLVED FOR SEVERAL MONTHS. THE PARTS AND SERVICE FOLKS AT FRIENDLY FORD OF MONROE, MICHIGAN CLAIM THAT NOTHING CAN BE DONE ABOUT IT BECAUSE, ACCORDING TO FORD MOTOR COMPANY, THERE IS NO OTHER EXTENDER AVAILABLE. THEY HAVE REORDERED THE EXTENDERS SEVERAL TIMES, THINKING THAT MAYBE THEY WERE DEFECTIVE, BUT WE STILL HAVE THE PROBLEM. WE HAVE TO WARM UP THE EXTENDERS IN ORDER TO GET THEM TO WORK, AND EVEN THEN THEY WILL NOT LATCH 100 PERCENT OF THE TIME. I HAVE ALSO CONTACTED THE FORD MOTOR COMPANY AND THEY HAVE ALSO TOLD ME THAT NOTHING CAN BE DONE. *LA
Service brakes, Hydraulic, Power train, May 27, 2004
WHILE THE VEHICLE WAS PARKED WITH THE BRAKE DEPRESSED, THE FRONT WHEELS BEGAN TO TURNED WHICH CAUSED THE VEHICLE TO ROLL DOWN A DRIVEWAY. DURING THIS INCIDENT A BABY WAS INJURED. THE CAUSE OF THE PROBLEM HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Power train, May 7, 2004
DRIVE TRAIN WINE BETWEEN 47 MPH AND 55 MPH IN MY 2003 F-150 SUPPER CREW. THE FORD DEALER REPLACED THE REAR DRIVE SHAFT BUT THE PROBLEM STILL EXISTED. DEALER CALLED FORD AND FORD SAID BECAUSE I HAVE A SLIDING REAR WINDOW, TONNEAU COVER AND 3.73 REAR END GEARING THESE ITEMS ARE CAUSING THE WINE. THE FORD DEALER SAID THAT IF TRIED TO RUN THIS PROBLEM THROUGH WARRANTY AGAIN FORD WOULD DENY IT. THE DEALER ALSO SAID I SHOULD TAKE THIS PROBLEM TO ANOTHER DEALER.*AK
Fuel system, Gasoline, May 4, 2004, crash, fire
ODOR OF GASOLINE, CAUGHT ON FIRE. AN INVESTIGATOR DETERMINED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT AND HAD IGNITED FROM GASOLINE VAPORS. IT WAS DETERMINED THAT THE FUEL RAIL HAD CRACKED, CAUSING THE FUEL LEAK.*AK
Power train, Apr 29, 2004, crash
WHILE PARKED VEHICLE CAME OUT OF GEAR AND ROLLED DOWN THE HILL INTO A DITCH. *AK
Service brakes, Hydraulic, Apr 29, 2004
WHILE DRIVING AT ANY SPEED THE BRAKES SYSTEM WARNING LIGHT CAME ON AND OFF ON IT'S OWN.. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. *NM THE DEALER REPLACED THE VSS AND FOUND OPEN CIRCUIT IN WIRING CONNECTOR. THE DEALER ALSO ADDED BRAKE FLUID BECAUSE IT WAS LOW. *NM
Power train, Apr 13, 2004
REAR AXLE WHINE NOISE AT 45 TO 50MPH & 67 TO 72 MPH. LOUD & GETTING LOUDER. FORD DEALERS ALL OVER THE AREA SAID FORD KNOWS OF NOISE BUT HAS NO FIX. SAID THEY WERE TOLD FORD WOULD NOT SPEND MONEY TO FIX BECAUSE THEY WERE NOT MAKING MUCH AS A COMPANY NOW. TWO REPARS ON REAR END & STILL NOISY, ENGINEER HAD DEALER PUT 125 WT GREASE IN REAR AXLE TO TRY & QUIET NOISE DOWN. NO GOOD> LOST FUEL ECONOMY ALSO. I NEED HELP GETTING REPAIRED OR GETTING A BUY BACK FROM FORD.
Other or unspecified, Apr 1, 2004, crash, fire
WHILE DRIVING AT 30 MPH, VEHICLE WAS INVOLVED IN A REAR END COLLISION . THEN, IT COLLIDED WITH A UTILITY POLE AND ERUPTED INTO FLAMES. CONSUMER SUSTAINED CRACKED RIBS AND WAS HOSPITALIZED. POLICE ARRIVED ON THE SCENE. *AK *LA
Seat belts, Seats, Mar 26, 2004, crash
VEHICLE WAS INVOLVED IN REAR END COLLISION. DRIVER'S SIDE SEAT BELT UNFASTENED, AND THE SEAT BACK COLLAPSED. THE DEALER HAD BEEN CONTACTED. *AK
Suspension, Mar 23, 2004
WHILE DRIVING 25-40 MPH FRONT OF THE VEHICLE SHOOK. VEHICLE HAD BEEN TO THE DEALER TWENTY TIMES, AND MECHANIC COULD NOT DETERMINE THE CAUSE OF THE PROBLEM. *AK
Power train, Mar 18, 2004
WHEN MAKING SLOW TURNS IN MY 2003 FORD F-150 SUPERCREW (ONLY 42,000 MILES ON THE TRUCK), THE TRUCK HAS A VIBRATION. WENT TO A FORD SERVICE TECHNICIAN, AND THEY COULD NOT DIAGNOSE THE PROBLEM, THEY SUGGESTED TO RE-PACK THE CLUTCH PACKS, WHICH WAS DONE. VIBRATION STILL OCCURING 1 WEEK LATER. ACCORDING TO OTHER'S WHO ALSO OWN FORD VEHICLES, THIS SEEMS TO BE A HUGE PROBLEM THAT FORD STATES IS NORMAL WEAR AND STATING ITS A PROBLEM WE HAVE TO LIVE WITH. *AK
Electrical system, Mar 15, 2004, fire
WHILE THE VEHICLE WAS PARKED ON THE DRIVEWAY IT CAUGHT ON FIRE. FLAMES AND SMOKE CAME UNDER THE DASHBOARD. *AK
Electrical system, Interior lighting, Equipment, Mar 11, 2004
CONSUMER COMPLAINED ABOUT AN ELECTRICAL SYSTEM PROBLEM. INSIDE LIGHTS WOULD NOT GO OUT ONCE THE DOOR WAS CLOSED. ALARM SYSTEM DID NOT WORK, AND SIDE REFLECTOR LIGHTS DID NOT COME ON. THE DOOR AJAR LIGHT STAYED ON. *AK DOOR AJAR LIGHT STAYED ON FOR ABOUT 20 TO 25 MINUTES BEFORE THEY GO OFF. DOORS WON'T LOCK WHEN THEY'RE SUPPOSED TO. DEALER SAID THAT THEY CAN'T LOCATE THE PROBLEM WITH INSIDE LIGHTS. HOWEVER, DEALER MADE REPAIR ON HORN AND REPLACED FUSE FOR ALARM HORN. *LA