2003 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 464 owner complaints filed for this model year. This is the 8th highest complaint count among 26 F-150 model years with reports.
Of the 2003 reports, 45 involved a crash and 39 involved a fire. 39 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Vehicle speed controlMar 6, 2007
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)
Campaign 07V078000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Steering, gear box, shaft pitmanSep 22, 2003
ON CERTAIN PICKUP TRUCKS, THE PITMAN ARM TO STEERING GEAR RETAINING NUT WAS NOT FULLY TIGHTENED TO THE REQUIRED SPECIFICATION.
IF THE PITMAN ARM TO GEARBOX ATTACHMENT NUT LOOSENS, A NOISE AND A LOOSE FEEL IN THE STEERING COULD OCCUR. IF THE CONDITION PROGRESSED AND SERVICE WAS NOT SOUGHT, THE NUT COULD BACK OFF COMPLETELY AND THE PITMAN ARM COULD SEPARATE FROM THE GEAR CAUSING A LOSS OF STEERING. IF THE WARNING IS NOT HEEDED AND STEERING IS LOST, A CRASH MAY RESULT.
DEALERS WILL TIGHTEN THE PITMAN ARM RETAINING NUT TO SPECIFICATIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 1, 2003. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 03V349000 on NHTSA.gov
Representative owner complaints
464 reports, newest first.
Power train, Nov 3, 2010
TL*THE CONTACT OWNS A 2003 FORD FOCUS. THE VEHICLE WOULD NOT SHIFT INTO REVERSE FROM THE PARK POSITION. IN ORDER SHIFT INTO REVERSE HE HAD TO SHIFT THE VEHICLE INTO NEUTRAL AND ALLOW IT TO SLOWLY ROLL BACKWARDS. UPON DRIVING THE VEHICLE HE ALSO NOTICED THE VEHICLE WOULD NOT SHIFT INTO 6TH GEAR. A DIAGNOSTIC TEST WAS NOT PERFORMED. THE FAILURE AND CURRENT MILEAGES WERE 50,000.
Electrical system, Sep 20, 2010, fire
2003 FORD F150 BURNS WHILE DRIVING DOWN HIGHWAY - TOTAL LOSS - STARTS IN ENGINE. *TR
Seat belts, Sep 10, 2010, crash
TL*THE CONTACT OWNS A 2003 FORD F150 PICKUP. THE CONTACT STATED THAT THE LOCATION OF THE SEAT BELT WAS POORLY DESIGNED AND WAS PLACED IN AN AWKWARD POSITION. HE WAS REAR ENDED BY ANOTHER VEHICLE AT THE TRAFFIC LIGHT CAUSING THE SEAT BELT HOLDING MECHANISM TO JAM IN HIS SIDE AND TIGHTEN AROUND HIS SHOULDERS AND LAP. THIS CAUSED INJURIES TO HIS RIGHT LEG, RIGHT HIP AND LOWER BACK. THE MANUFACTURER WAS CONTACTED AND INFORMED HIM THAT THEY WERE SORRY FOR HIS LOST AND HE SHOULD HAVE HIS LAWYER CONTACT THEM. THE FAILURE MILEAGE WAS 84,000.
Vehicle speed control, Aug 16, 2010, fire
TL* THE CONTACT OWNS A 2003 FORD F150 PICKUP. THE CONTACT STATED THE VEHICLE WAS PARKED WITH THE ENGINE OFF WHEN IT CAUGHT ON FIRE. THE CONTACT HAD PARKED THE VEHICLE FIVE MINUTES PRIOR TO THE FAILURE. THE FIRE DEPARTMENT WAS CALLED TO ASSIST AND ADVISED THAT THE FIRE ORIGINATED FROM THE CRUISE CONTROL MECHANISM. A FIRE DEPARTMENT REPORT WAS AVAILABLE. THE CONTACT STATED THAT PART OF THE UTILITY BUILDING, THE CARPORT THAT THE VEHICLE WAS PARKED IN, ALL OF ITS CONTENTS AND THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE 88,000. UPDATED 11/15/10. *LJ UPDATED 11/19/10.*LJ UPDATED 11/26/10
Fuel system, Gasoline, Electrical system, Aug 5, 2010
COMING HOME TO VA FROM OHIO WE WERE GOING THROUGH THE MOUNTAINS AND HAD TO KEEP FLOORING THE TRUCK. THE SPARK PLUGS ACTED LIKE THEY WERE FOULING AND THE TRUCK SPUTTERED HOME. WE CAME HOME AND OUR MECHANIC SAID WE BLEW OUT OR EJECTED TWO SPARK PLUGS ON OUR TRITON 4.6L 2003 PICK UP TRUCK. HE SAID IT WOULD HAVE TO BE REPAIRED BY FORD AND IT WOULD PROBABLY COST ABOUT $900. WE FOUND OUT THIS IS A RECURRING PROBLEM ON THE NEW NON-PLUG WIRES TRUCKS USING A SERIES OF COIL, OVER PLUG COIL CONNECTORS SPECIFICALLY ON THE TRITON FORD TRUCK MOTORS. WHY HASN'T NHTSA CONTACTED FORD. WE SMELLED GAS THE WHOLE WAY HOME; ABOUT 500 MILES AFTER IT HAPPENED. IF THE GAS FUMES IGNITED IT WOULD HAVE BURNED MY TRUCK UP BUT COULD HAVE HURT MY WIFE AND THREE GRANDCHILDREN RIDING WITH US. [XXX] I BOUGHT THE MECHANIC EIGHT SPARKPLUGS *$6.99 EACH, THEN EIGHT COILED/SLEEVES $52 EACH AND A NEW COIL UNIT $163, HE IS HAVING A COMPANY HELIARC-COILS TO REPAIR THE SPARKPLUG SEATS. THIS IS A VERY POOR DESIGN, AND HAD I KNOWN THIS WHEN WE BOUGHT THE TRUCK, WE WOULDN'T HAVE. I SENT FORD MOTOR A CUSTOMER SERVICE COMPLAINT AS WELL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine and engine cooling, Aug 3, 2010
THERE WERE NO EVENTS LEADING UP TO THE INCIDENT. DRIVING 10-20 MPH THE FIRST TIMES AND 25-35 THE SECOND. 2 SPARK PLUGS EJECTED OUT OF THE ENGINE TWICE IN 4 DAYS 1ST TIME WE TOOK IT TO THE MECHANIC AND IT WAS REPLACED 2ND TIME TOOK IT TO THE MECHANIC AND IT WAS REPLACED. *TR
Engine and engine cooling, Jul 11, 2010
FORD F150 2003, 5.4 ENGINE. THE SPARK PLUG ISSUE HAS JUST BITTEN ME, NOW I HAVE A 10,000 DOLLAR PEICE OF STEEL IN MY DRIVEWAY BECAUSE I AM NOT PAYING 5400 AND SOME CHANGE TO FIX A PROBLEM THAT SHOULD BE RECALLED, THE PLUG GETTTING HIT BY THE PISTON OR SHOOTING OUT OF THE HOLE CAN BE VERY DANGEROUS BY ALLOWING FUEL TO COME IN CONTACT WITH HOT ENGINE OR ELECTRICAL SPARK THEREFORE STARTING A FIRE, THIS PROBLEM HAS BEEN AN ONGOING ISSUE AND YET NOTHING IS DONE I THINK A RECALL SHOULD BE PLACED FOR THE ISSUE. BEFORE SOMEONE GETS KILLED. *TR
Engine and engine cooling, Power train, Jul 7, 2010
FORD F-150 SPARK PLUG BLOW OUT, COMMON IN F-150'S. *TR
Fuel system, Gasoline, Jul 3, 2010
FUEL TANK FELL OFF VEHICLE AS A RESULT OF RUSTED MOUNTING IS A ONE OWNER WELL MAINTAINED FORD F150 PURCHASED NEW IN 2003 AND MILEAGE IS ONLY 100,222. NEW STRAPS WERE LOCATED AND INSTALLED 6/29/2010 AND OLD STRAPS WERE LABELED AND KEPT. *TR
Visibility, Jun 27, 2010
PASSENGER WINDOW REGULATOR FAILURE ON 2003(2004 BODY STYLE) F150 LARIAT. REGULATOR FAILED ON ROAD TRIP IN 95 PLUS DEGREE WEATHER IN EASTERN NC ON JUNE 26, 2010. THIS IS THE SECOND ONE. *TR
Engine and engine cooling, Jun 5, 2010
I HAD MY 2003 FORD F-150 SHOOT SPARK PLUGS OUT OF THE HEADERS I DON"T KNOW WHY BUT THIS IDS THE 3RD TIME IT HAS HAPPENED AND IF IT WOULD BE POSSIBLE TO START A RECALL ON THE HEADERS TO CHANGE THEM TO A 8 THREAD INSTEAD OF 4. *TR
Engine and engine cooling, Power train, May 17, 2010
BLOW OUT OF SPARK PLUG ON 2003 FORD F-150 4.6L TRITON V8. *TR
Engine and engine cooling, May 15, 2010
2003 FORD F-150 CREW CAB , 4.6 TRITON ENGINE. SPARK PLUG BLEW WHILE ON HIGHWAY. NORMAL DRIVING WITH NO LOAD IN TRUCK. NO WARNING BEFORE FAILURE. THE TRUCK HAS JUST OVER 100,000 MILES. *TR
Visibility, Structure, Apr 28, 2010
I HAVE A 2003 FORD F150, WITH A 5.4L ENGINE. I FOUND OUT THAT MY WINDSHIELD IS LEAKING AND SEEPING WATER ONTO MY GEM/CJB AND MAKING IT SO IN RAIN MY WINDSHIELD WIPERS SHUT OFF, MY HEATER BLOWER TO STAY ON OR GO ON WHEN THE KEY IS NOT IN THE IGNITION, AND HAS DRAINED MY BATTERY. HERE IS A COPY OF THE NOTICE FORD SENT TO THERE DEALERSHIPS IN 2004, *FORD SPECIAL MESSAGE #15773 VARIOUS ELECTRICAL CONDITIONS RESULTING FROM WATER INTRUSION INTO THE GEM/CJB SOME 1997-2002 EXPEDITION AND 1998-2002 NAVIGATOR VEHICLES MAY EXHIBIT VARIOUS UNUSUAL ELECTRICAL CONDITIONS, INCLUDING BUT NOT LIMITED TO: FRONT OR REAR BLOWER OR EATC STAYING ON WITH KEY OUT OF THE IGNITION, RADIO STAYING ON AFTER DOORS OPENED AND KEY OUT OF IGNITION, WIPER CIRCUIT FAILURE CODES, AND MULTIPLE SYSTEM WARNING LIGHTS WITH 'SHORT TO POWER' OR 'LOW BATTERY VOLTAGE' DTCS. THESE SYMPTOMS MOST OFTEN OCCUR AFTER A RAIN OR SNOW. THIS MAY BE DUE TO GEM/CJB WATER INTRUSION RESULTING FROM A WINDSHIELD WATER LEAK. TO SERVICE, REMOVE THE GEM AND CJB FROM THE VEHICLE, SEPARATE THEM AND INSPECT FOR WATER CONTAMINATION OR CORROSION. IF FOUND IN EITHER COMPONENT, REPLACE BOTH COMPONENTS AND COMPLETELY RESEAL THE WINDSHIELD. EFFECTIVE DATE: 04/05/2002 SO THIS IS A KNOWN ISSUE AND THEY ARE CHARGING BETWEEN $900 - $1500+ FOR REPAIRS AND THEN ON TOP OF THAT CHARGING FOR THE WINDSHIELD TO BE REPLACED. THE HAZARDS OF THIS POTENTIALLY SHORTING OUT AND HAVING A FIRE IS A RISK THAT I THINK SHOULD BE ADDRESSED FOR THE SAFETY OF THE CONSUMERS. HAVING MY WINDSHIELD WIPERS STOP ON ME IN HEAVY RAIN ON THE HIGHWAY ALMOST CAUSED ME TO GET INTO A POTENTIAL ACCIDENT. *TR
Vehicle speed control, Apr 23, 2010
MY SON WAS DRIVING HOME AND THE THROTTLE STUCK, THE BRAKES DID NOTHING. HE HAD TO THROW THE VEHICLE IN PARK. *TR
Service brakes, Hydraulic, Apr 1, 2010
THE BRAKE LINE FROM CAB AREA TO REAR WHEEL ON MY 2003 FORD F150 CORRODED AND EMPTIED THE MASTER CYCLINDER OF BRAKE FLUID. IT IS SIGNIFICANT TO NOTE THAT NO OTHER BRAKELINES OR CONNECTIONS SHOWED SIMIILAR CORROSION- MORE LIKE YOU WOULD EXPECT ON A 7 YEAR OLD VEHICLE. IT IS MY OPINION THAT THE CORROSION IS A MATERIALS PROBLEM AND MAY BE A REOCCURRING PROBLEM IN OTHER VEHICLE OF THIS TYPE. I ALSO NOTED EXCESSIVE SCALING OF THE FRONT WHEEL HUBS AND STEARING ARMS OF THE SAME VEHICLE. THIS I BELIEVE IS THE RESULT OF INFERIOR PARTS- I HAVE NEVER SEEN THIS LEVEL OF DETERIOATION OF VEHICLE COMPONENTS LIKE THIS. WHETHER THIS IS A SAFETY PROBLEM OR NOT I DON'T KNOW. PLEASE ACCEPT THIS INFORMATION AS A COUPLE OF DATA POINTS ON THIS VEHICLE. I JUST FELT IT WAS NECESSARY TO ADVISE NHTSA OF THE SITUATION.
Engine and engine cooling, Mar 22, 2010
NORMAL DRIVING WHEN THE SPARK PLUG BLEW OUT OF THE MOTOR LEAVING ME AND MY KIDS STRANDED STILL TRYING TO CORRECT PROBLEM THIS IS THE SECOND TIME REPAIR BILL APPROXIMATELY $3000. *DT
Structure, Mar 2, 2010
2003 FORD F150 KING RANCH 4X4 PICKUP ALL FOUR DOORS ARE ROTTING OUT ON THE BOTTOM. *DT 2/20/10 THE CONSUMER WAS INFORMED THE DRAIN HOLES OR WEEP HOLES WERE PLUGGED PROBABLY FROM RUST AND ROAD MATERIAL THUS TRAPPING WATER INSIDE THE DOORS CAUSING THEM TO RUST OUT. WHEN THE CONSUMER LOOKED AT THE WEEP HOLES, THEY WERE NOT CLOGGED UP, BUT PLUGGED WITH FACTORY INSTALLED PLUGS THE CONSUMER STATED THE PLUGS SHOULD HAVE BEEN REMOVED BEFORE THE SALE OF THE VEHICLE. . *JB UPDATED 04/06/10.*JB
Engine and engine cooling, Feb 26, 2010
I OWN A FORD F150 WITH A TRITON V8 ENGINE. ONE OF THE SPARK PLUGS BLEW OUT OF THE ENGINE ON 2/25/10 WHILE I WAS DRIVING ON A HIGHWAY. I HAD THE TRUCK TOWED TO A LOCAL REPAIR SHOP. AFTER LOOKING AT THE PROBLEM THEY SENT ME TO A FORD DEALER. THE DEALER HAS TOLD ME IT IS A $1000 FIX AND THAT IT WAS POSSIBLY DUE TO THE PERSON WHO REPLACED THE PLUGS FOR ME. *TR
Power train, Jan 20, 2010
TL*THE CONTACT OWNS A 2003 FORD F150. WHILE DRIVING APPROXIMATELY 30 MPH WHEN THE ROAD WAS SLIPPERY AND ATTEMPTING TO SHIFT INTO FOUR WHEEL DRIVE, IT FAILED TO ENGAGE. THE DEALER LOCATED THE FAILURE AND STATED THAT THE FRONT SHIFT FORK AND THE SUB SHIFT FORK NEEDED TO BE REPLACED. THE CONTACT WAS RESPONSIBLE FOR PAYING $ 1,009 TO HAVE THE FRONT AND SUB SHIFT FORKS REPLACED. HE CONTACTED THE MANUFACTURER; HOWEVER, THE MANUFACTURER DIDN"T TAKE A REPORT OR OFFER ANY ASSISTANCE WITH THE REPAIR. THE FAILURE MILEAGE WAS 66,879 AND THE CURRENT MILEAGE WAS 66,921.
Engine and engine cooling, Jan 12, 2010
2003 FORD F150 5.4L #3 SPARK PLUG BLEW OUT OF ENGINE'S HEAD AND STRIPPED OUT ALL THREADS. INSERT WAS PUT IN TO REPLACE DAMAGED THREADS AT A COST OF $500 FROM FORD DEALERSHIP. *TR
Engine and engine cooling, Dec 15, 2009
WHILE I WAS ACCELERATING AND ENTERING ONTO INTERSTATE 80 AT A SPEED OF 50MPH I HEARD A LOUD POP AND LOST POWER. THE ENGINE CONTINUED TO RUN BUT WITH A GREAT LOSS OF POWER. I CONTINUED TO DRIVE AT A MODERATE SPEED UNTIL I COULD GET TO A MONROE SERVICE CENTER APPROX. 20 MILES. THE #7 PLUG FOR THE SECOND TIME BLEW OUT OF THE HEAD. THE REPAIR COST THIS TIME WAS $294.38 AND THE ENGINE LIGHT IS STILL ON. IT'S BEEN EIGHT MONTHS SINCE I HAD IT REPAIRED THE FIRST TIME. THE #7 CYLINDER IS NOW MISFIRING EVEN THOUGH THE PLUG HAS BEEN REPLACED. MILEAGE TO DATE IS 200,892. *TR
Engine and engine cooling, Nov 22, 2009
I HAD BEEN DRIVING MY TRUCK FOR ABOUT TEN MINUTES AND AS I WAS DRIVING ON THE FREEWAY THE ENGINE SPARK PLUG BLEW. I GOT MY TRUCK TO START UP AND DROVE A SHORT DISTANCE BEFORE THIS OCCURRED AGAIN. THIS REPEATED UNTIL I MANAGED TO GET TO MY HOME WHICH WAS ABOUT TWO MILES AWAY WHEN THE PROBLEM FIRST OCCURRED. THEN I CALLED VENUS, A TOWING AND REPAIR SHOP, TO HAVE MY TRUCK TOWED FROM MY HOUSE TO THEIR SHOP. THE TOWING SERVICE COST $80.00. WHEN THE PROBLEM WAS DIAGNOSED THEY CALLED ME AND TOLD ME WHAT HAPPENED. THEY FIXED MY TRUCK AND CHARGED $250.00. *TR
Engine and engine cooling, Nov 16, 2009
ON APRIL 20, 2009, SPARK PLUG #7 BLOWOUT WHILE ACCELERATING FROM A TRAFFIC LIGHT. APPROX. SPEED 25 TO 35 MPH. ENGINE LOST COMPRESSION, DAMAGED THE IGNITION COIL, BUT I WAS ABLE TO MAKE IT TO A FIRESTONE REPAIR GARAGE WITHIN 10 MILES. THE SPARK PLUG #7 WAS REPLACED WITH THE HELI COIL AND THE IGNITION COIL DAMAGE WAS ALSO REPLACED. TOTAL COST OF LABOR AND PARTS WAS $352.81. *TR
Electrical system, Visibility, Nov 10, 2009
WINDSHIELD LEAKS AND IS FRYING MY ELECTRICAL SYSTEM. 2003 F150. I HAVE READ NUMEROUS ARTICLES ON FORD NEEDING TO FIX THESE ISSUES. *TR