2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: electrical system
100 reports, newest first. Show all
Electrical system, Air bags, Other or unspecified, Dec 21, 2025
There is a recall on this vehicle
Electrical system, Service brakes, Visibility/wiper, Jun 24, 2025
Electrical malfunction with fuses , problems with brake light, engine light and air bag light . Some fuses blown out after brake light fuse popped wipers don't work at all air bog turns on and off every day not sure why
Electrical system, May 9, 2024
The contact owns a 2004 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal popping sound and then lost motive power. The contact was able to drive to the residence. The vehicle was taken to an independent mechanic, who determined that the spark plug had blown out of the cylinder and determined that the spark plug needed to be replaced. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 364,000. The VIN was unavailable.
Electrical system, Forward collision avoidance, Apr 18, 2024
I get a warning message which indicates the the Crash Sensor is not working on my Ford truck - this component inflates the Air Bag in the event of a crash. The part number for the Crash Sensor is Motorcraft 6L3Z-14B004-AA. I attempted to purchase a replacement Crash Sensor from a local Ford dealer. I was told that Ford no longer makes this part. The parts manager suggested that I check with local aftermarket parts stores; Advance Auto Parts, AutoZone, Fisher and NAPA. Nobody makes an aftermarket Crash Sensor for my vehicle. I also searched Amazon without success. I am therefore driving a vehicle with Air Bags which will not deploy - possibly causing a fatality. It seems like the manufacturer, Ford, should be required to sell replacement Crash Sensors until they become available as an Aftermarket Product.
Electrical system, Structure, Engine, Feb 24, 2020
PAINT CRACKED ,COILS MALFUNCTION,SPRINGS FRONT
Electrical system, Nov 8, 2019
BOUGHT VEHICLE FROM INDIVIDUAL HE STATED MILEAGE ON ODOMETER 125K AND 2008 WENT TO GET INSURANCE AND IT'S A 2004 AND MILEAGE WAS 240K PLUS
Electrical system, Vehicle speed control, Engine, May 21, 2019
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE STALLED AND THE ACCELERATOR PEDAL HESITATED WHEN DEPRESSED. AS A RESULT, THE VEHICLE MADE AN ABNORMAL PUTTERING SOUND WHILE IN DRIVE. IN ADDITION, THE ELECTRICAL SYSTEM FAILED. THE SPARK PLUGS WERE CHANGED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SPARK PLUGS SHOULD NOT BE TOUCHED BECAUSE THEY WERE FORD CERTIFIED SPARK PLUGS AND TEAR EASILY. A SPECIAL ONSITE FORD MECHANIC REPAIRED THE SPARK PLUGS. THE ACCELERATOR PEDAL AND STALLING FAILURES WERE NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 233,000.
Electrical system, Mar 5, 2019, fire
ELECTRICAL FIRE FRONT PASSENGER SIDE AFTER VEHICLE WAS TURNED OFF WHILE PUMPING GAS.
Electrical system, Apr 2, 2018
REFER TO NHTSA CAMPAIGN 11V107000. FORD RECALL NUMBER 11S18. VEHICLE WAS MANUFACTURED AT NORFOLK, VA PLANT. MY VIN WAS NOT INCLUDED IN THE ORIGINAL OR EXPANDED RECALL; HOWEVER, IT IS NOW EXHIBITING THE SAME PROBLEM; AIRBAG WARNING LIGHT FLASHES TWICE X FIVE TIMES, THEN REMAINS ON. POSSIBLE CLOCKSPRING JUMPER WIRE CHAFING. WEAR COULD CAUSE ELECTRICAL SHORT AND UNEXPECTED AIRBAG INFLATION WHILE DRIVING. THIS FIRST OCCURRED ABOUT TEN DAYS AGO, BUT THEN THE VEHICLE SAT IN THE DRIVEWAY FOR EIGHT DAYS. CURRENT MILEAGE IS 115544. TODAY I CALLED FORD CUSTOMER SERVICE AND WAS INFORMED THERE WAS NO WARRANTY ACTION OR ACTIVE RECALL THAT WOULD COVER THIS INVESTIGATION AND REPAIR. I BELIEVE THE RECALL SHOULD BE FURTHER EXPANDED TO COVER THIS INCIDENT. IT BEGAN WITH VEHICLES MADE AT THE NORFOLK VA PLANT.
Electrical system, Nov 6, 2017
2004 FORD F150. VEHICLE SHUT OFF WHILE DRIVING WITH A BOAT IN TOW AND WOULD NOT RE START. HAD TO HAVE VEHICLE TOWED. DEALER DIAGNOSED AS FAILED FUEL PUMP DRIVER MODULE. I WAS STRANDED IN TRAFFIC, VERY DANGEROUS. THIS IS A KNOWN PROBLEM WITH FORD F150 2004-2008. THE MODULE CORRODES AND CAUSES A SHORT CIRCUIT THAT BLOWS THE FUSE TO THE PCM AND RESULTS IN TOTAL FAILURE OF THE PCM, THUS RENDERING THE VEHICLE INOPERABLE. THIS SHOULD BE A RECALL ITEM!!!
Electrical system, Aug 14, 2017, fire
TL* THE CONTACT OWNED A 2004 FORD F-150. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, A NEIGHBOR ALERTED THE CONTACT THAT THE VEHICLE WAS ON FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FIRE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Seat belts, Electrical system, Engine, Fuel/propulsion system, May 15, 2017
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING WITHOUT WARNING. IN ADDITION, THE SEAT BELT WOULD NOT LATCH. THE DEALER DIAGNOSED THAT THE VEHICLE'S SOFTWARE NEEDED TO REFLASHED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT HAD THE ENGINE REPLACED AFTER IT WAS DIAGNOSED THAT THERE WAS WATER IN THE OIL PAN AND A FUEL ROD FAILURE. THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
Electrical system, Apr 26, 2016
I WAS DRIVING DOWN THE HIGHWAY ABOUT 40 MPH AND THE DRIVER SIDE WINDOW JUST FELL TO THE BOTTOM INSIDE THE DOOR.I HADN'T TOUCHED A THING. THE 2004 FORD F150 HAS ONLY 23,000 MILES ON IT.I BOUGHT IT NEW. I HAVE READ THERE HAS BEEN ALOT OF PROBLEMS WITH THIS. IS THERE A RECALL OR REPLACEMENT?
Electrical system, Other or unspecified, Fuel/propulsion system, Dec 4, 2015
WE'VE HAD A LOT OF ISSUES WITH THIS TRUCK BUT THE MAIN ISSUE IS WHEN WE DRIVE DOWN THE ROAD IT MISSES A LOT AND THE SMELL OF FUEL IN THE TRUCK. WE'VE TAKEN IT IN AND THEY SAID A LOT OF OTHER PEOPLE HAVE HAD THE SAME ISSUES WITH THERE TRUCK LIKE OURS. PLEASE CONTACT US ASAP.
Electrical system, Aug 11, 2015
MY HUSBAND WAS DRIVING HOME THIS PAST SUNDAY AND WAS STARTING TO TURN INTO THE DRIVE WHEN THE LEFT PASSENGER WINDOW FELL DOWN INTO THE DOOR. HE HAD NOT PUT IT DOWN OR UP - IT JUST FELL DOWN. THIS IS NOW THE 4TH WINDOW WE HAVE REPLACED IN THIS TRUCK. THE OTHER THREE HAVE BEEN REPLACED, TO THE TUNE OF $350.00 EACH. WHEN I BROUGHT THIS TO THE ATTENTION OF THE SERVICE MANAGER AT THE LOCAL FORD DEALERSHIP, HE SAID THERE WAS NOTHING THAT HE COULD DO - THE WINDOW REGULATORS JUST BREAK. I CONTACTED THE FORD 800 NUMBER AND WAS TOLD THE SAME THING - NOTHING TO BE DONE - JUST A BROKEN PART - EVEN THOUGH IT HAPPENS A LOT. HE SAID THERE WAS NO RECALL ON IT SO THERE WAS NO HELP THEY COULD GIVE. SO, I GUESS I'LL BE PAYING ANOTHER $350.00 AND PRAY THEY DON'T START DROPPING AGAIN SINCE FORD WON'T ADMIT THEY HAVE A PROBLEM.
Electrical system, Equipment adaptive/mobility, Engine, Jun 4, 2015
ON MY WAY HOME FROM THE LAKE, MY VEHICLE STARTING IDLING ROUGH. PULLED OVER TO CHECK THINGS OUT, COULDN'T FIND ANY NOTICABLE ISSUES. RETARTED VEHICLE AND ENGINE STARTED SMOKING. I RAISED THE HOOD AND SMOKE WAS BILLOWING OUT FROM THE COIL ATOP THE NUMBER 2 SPARK PLUG, DRIVERS SIDE, LOOKING FROM FRONT TO REAR OF ENGINE. HAD THEVEHICLE TOWED TO BILL COLLINS FORD OF LOUISVILLE,KY.THEY INFORMED ME THAT THE SPARK PLUGS NEEDED CHANGING. UPON REMOVAL, 4 OF THE EIGHT SPARK PLUGS BROKE OFF IN THE ENGINE HEAD. THIS COST ME $857.00 TO CHANGE 8 SPARK PLUGS THAT NORMALLY I COULD DO MYSELF. THE BREAKING OF SPARK PLUGS IN THIS TYPE ENGINE, 5.4L TRITON, IS A WELL KNOWN ISSUE, THAT FORD MOTOR COMPANY KNEW ABOUT. YET THEY HAVE YET TO DO A RECALL. INSTEAD, THEY DEVELOPED A TOOL TO TAKE THESE BROKEN SPRK PLUGS OUT, YET THE CONSUMER STILL HAS TO PAY SOMETIMES UPWARDS OF $2,000.00 FOR THE REPAIR. FORD USED A SUBSTANDARD PART IN THEIR VEHICLES AND REFUSE TO HONOR THE CUSTOMER. THEY NO LONEGR USE THAT TYPE ENGINE, BUT ANYONE WITH A 5.4L TRITON ENGINE FROM FORD WILL HAVE TO PAY A LOT OF MONEY TO CHANGE EIGHT SPARK PLUGS WHEN THE TIME COMES. I COULD NOT PUT MY VEHCILE INTO GEAR WHEN THIS HAPPENED, THAT SEEMS LIKE A SAFETY CONCERN TO ME!
Electrical system, Other or unspecified, Apr 24, 2015
I LEAVE MY WINDOWS UP ON THE TRUCK. IT IS COLD (WINTER TIME) TRUCK WAS IN THE GARAGE. I WENT TO THE GARAGE AND THE WINDOW ON THE PASSENGER SIDE WAS DOWN. I CRANKED THE TRUCK, PUSHED THE BUTTON AND THE WINDOW WOULD NOT COME UP. I TOOK THE TRUCK TO THE DEALER THEY SAID THE FRONT DOOR WINDOW REGULATOR HAD TO BE REPLACED. THIS COST $344.66 TO REPLACE THE REGULATOR. SINCE THE FIRST REPLACEMENT, THE TWO BACK WINDOWS HAVE DONE THE SAME THING. I ASSUME IF MY TRUCK IS HAVING THIS PROBLEM OTHERS ARE ALSO. THIS APPEARS TO BE A DEFECT AND THE COMPANY SHOULD PAY FOR THE REPAIRS. *TR
Fuel system, Gasoline, Electrical system, Jan 12, 2014
FUEL PUMP DRIVER MODULE, BACK SIDE OF MODULE CORRODED AWAY EXPOSING CIRCUIT BOARD CAUSING THE FUEL PUMP TO STOP RUNNING AND LEAVING ME STRANDED DURING A SNOW STORM,SEEMS TO BE A COMMON PROBLEM ON 2004-2008 FORD PICKUPS. I CONSIDER THIS A POOR DESIGN AND SHOULD BE A RECALL, LOT OF GARAGES INSTALLING NEW FUEL PUMPS AT 300.00 A CRACK WHEN ITS A EASY TO REPLACE 80.00 DOLLAR PART. *TR
Power train, Electrical system, Engine, Fuel/propulsion system, Oct 30, 2013
BOUGHT 2004 F150 BRAND NEW, NEVER OFF ROAD, ALL SCHEDULED MAINTENANCE COMPLETED: SON DRIVING ON INTERSTATE AT 65MPH, HEARD LOUD BREAKING NOISE, SEVERE RATTLING, SHAKING, NO POWER, COASTED DOWN RAMP AND TO SIDE ROAD. TOWED TO MECHANIC--ROD THROUGH THE OIL PAN. MECHANIC VERIFIED THAT OIL WAS PUMPED PROPERLY THROUGH MOTOR.. SAME MECHANIC HAS WORKED ON THIS CAR SINCE WE HAVE HAD IT. WE HAVE HAD TO HAVE ALL 4 DOOR WINDOW MOTORS REPLACED (TWICE-SECOND TIME, WE FIXED FRONT DOOR WINDOWS AND HAD BACK DOOR WINDOWS WIRED UP) , THE BACK GLASS REPLACED FOR LEAKING, THE 4 WHEEL DRIVE SENSORS REPLACED, THE TRANSMISSION REBUILT, THE OVERHEAD CAM SYSTEM REPLACED AND NOW THIS. *TR
Electrical system, Visibility, Aug 14, 2013
ON MY 2004 FORD F150 XLT LARIAT SUPERCAB, THE PASSENGER REAR WINDOW REGULATOR HAS NOW FAILED. THE DRIVER'S ONE WENT FIRST (WITHIN THREE YEARS OF OWNERSHIP), THEN THE FRONT PASSENGER ONE (A FEW MONTHS LATER) THEN THE REAR PASSENGER ONE ( ABOUT A YEAR AFTER THE FIRST) AND NOW THIS. ALL FOUR REGULATORS HAVE HAD TO BE REPLACED FROM THE ORIGINAL FACTORY INSTALLED ONES. THIS LATEST ONE OCCURRED WHILE THE TRUCK SAT PARKED IN THE DRIVEWAY UNOCCUPIED; ALL THE OTHERS HAPPENED ON THE ROADWAY WHILE THE VEHICLE WAS IN MOTION. *TR
Electrical system, Exterior lighting, Service brakes, Aug 4, 2013
I OWN A 2004 FORD F-150. IN 2012 I HAD MY E-BRAKE LIGHT START FLASHING AT ME. I BROUGHT IT INTO THE MECHANIC AND HAD THEM LOOK IT OVER, THEY SAID THEY COULDN'T FIND ANYTHING WRONG OTHER THEN THE WIRING UNDER THE DASH WAS PROBABLY BAD, SO I BROUGHT IT TO A BRAKE SPECIALIST AND THEY SAID THE SAME THING, NOTHING WRONG WITH CYLINDER OR BRAKES, THAT IT WAS THE WIRING UNDER THE DASH. I'M TRULY NOT SAFE USING MY E-BRAKE AS I'M NOT SURE IF IT IS WORKING OR NOT. MY INTERIOR LIGHTS STARTED COMING ON ALSO WHEN I WOULD TURN ON MY HEADLIGHTS, EVERYONE KNOWS YOU SHOULDN'T HAVE THE INTERIOR LIGHTS ON WHILE DRIVING AT NIGHT ANYWAY. I HAVE READ SEVERAL ARTICLES WHERE OTHER FORD F-150 OWNERS ARE HAVING THE SAME PROBLEMS. I THINK THIS NEEDS TO BE LOOKED INTO AND A RECALL SHOULD GO OUT. *TR
Electrical system, Visibility, May 13, 2013
REPLACED TWO WINDOW REGULATORS IN VEHICLE. DRIVER'S WINDOWN AND PASSENGER WINDOW.
Power train, Electrical system, Engine, Apr 18, 2013
AS I WAS BACKING UPWARD INTO MY GARAGE, I SLOWED DOWN AND THE TRUCK ROLLED FORWARD AND I QUICKLY PRESSED THE GAS TO RESUME BACKWARDS. THIS CAUSED THE CHECK ENGINE WARNING LIGHT TO COME ON ALONG WITH MY OD/OFF INDICATORS ON THE DASHBOARD. MY REVERSE GEAR STOPPED PULLING. I'M AFRAID HAD THIS BEEN IN ROUTE IT MIGHT HAVE BEEN MORE SERIOUS OF AN ISSUE. *TR
Electrical system, Visibility, Nov 15, 2012
DRIVER SIDE POWER WINDOW, THIS IS THE FORTH TIME I HAVE TO HAVE WINDOW REPAIR ON MY TRUCK, PREVIOUS TIME BEFORE LAST ONE, WAS IN JULY ONLY 4 MONTHS AGO I HAD TO PAY ALMOST $300 TO REPAIR WINDOW, AND NOW LAST TIME PAID $425 DOLLARS TO REPAIR THAT VERY SAME WINDOW AND THIS TIME IS THE WINDOW REGULATOR. WINDOW WILL MAKE A LOUD NOISE AND DROP, UNABLE TO BRING IT UP OR CLOSED AGAIN. *TR
Electrical system, Visibility/wiper, Aug 24, 2012
PASSENGER SIDE POWER WINDOW COLLAPSED INTO THE DOOR WHILE DRIVING. BRIEFLY HEARD A POP/BANG IN THE DOOR THINKING SOMETHING HIT THE DOOR, THEN THE WINDOW WENT STRAIGHT DOWN WITHOUT CONTROL. NOW I HAVE NO WAY OF RETRIEVING THE WINDOW BACK UP AND SECURING IT. PLUS UNABLE TO SECURE MY VEHICLE OR KEEP THE ELEMENTS OF WEATHER OUT OF MY TRUCK. I WILL NOT USE THE TRUCK TO PICK UP MY YOU CHILDREN IN THIS CONDITION. I PRESUME THAT THIS COULD BE A SIGNIFICANT SAFETY HAZARD IN SIMILAR SITUATIONS WITH A DISTRACTED DRIVER LOOSING ATTENTION TO DRIVING OR IN A SEVERE WEATHER CONDITION. I WILL TAKE IT TO A FORD SERVICE DEALER AND SHARE MY DISPLEASURE WITH THIS INCIDENT. FOR MY SAFETY AND EVERYONE ELSE SAFETY, I WILL GET THIS REPAIR. THIS INCIDENT IS SEVERE ENOUGH TO HURT OR KILL SOMEONE IF IT IS NOT ADDRESSED. I AM STILL SHAKING WITH FEAR WHILE TYPING THIS COMPLAINT. *TR