2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: electrical system
100 reports, newest first. Show all
Electrical system, Visibility, Sep 28, 2010
CURRENTLY OWN A 2004 FORD F150 FX4. THE DRIVER SIDE WINDOW SUDDENLY FELL OFF THE TRACK WHILE DRIVING AND INTO THE DOOR, THANKFULLY IT DIDN'T SHATTER. TOOK IT TO THE DEALERSHIP, WASN'T COVERED UNDER WARRANTY. IT WAS THE WINDOW REGULATOR. COST AROUND $500 TO FIX IT. A YEAR LATER THE DRIVER SIDE WINDOW FELL OF TRACK WHEN SHUTTING THE DOOR AND FELL DOWN INTO IT. DON'T REALLY HAVE THE MONEY TO FIX IT, SO WE RIGGED IT TO STAY UP, HOWEVER IT FALLS SLOWLY WHILE DRIVING AND WE HAVE TO KEEP PUSHING IT UP. NOW THE REAR PASSENGER WINDOW HAS FALLEN DOWN- WHERE OUR CHILD SITS AND THIS IS BECOMING A PROBLEM. $1500 TO FIX 3 WINDOWS IN 2 YEARS IS NOT ACCEPTABLE ON SOMETHING THAT IS CLEARLY A DEFECT. FORD CLAIMS THEY ARE WAITING FOR THE NHTSA TO REQUIRE THE RECALL FROM FORD, UNTIL THAT HAPPENS THEY WONT CORRECT THE PROBLEM. THIS IS A SAFETY ISSUE AS WELL AS A CONSUMER ISSUE. PLEASE CONTINUE TO ADVISE FORD OF THIS DEFECT AND URGE THE RECALL. *TR
Electrical system, Visibility, Sep 20, 2010
NO SIGNIFICANT EVENTS LEAD UP TO.... 3 OUT OF 4 WINDOWS ON MY 2004 FORD F150 FX4 HAD TO BE REPLACED BECAUSE OUT OF THE BLUE THEY COME CRASHING DOWN. I HAVE SPENT ABOUT 700 DOLLARS SO FAR ON THIS DEFECT AND HAVE TO GO IN TOMORROW TO GET MY PASSENGER SIDE WINDOW FIXED WHICH WILL PUT ME OVER 1000. FORD NEEDS TO RECALL THESE WINDOW REGULATORS AND I SHOULD GET EVERY PENNY I HAVE SPENT ON THESE PATHETIC DEVICES BACK. COME ON FORD, REALLY? I FEEL LIKE I AND EVERYBODY ELSE IN THIS SAME SITUATION HAVE BEEN TAKEN ADVANTAGE OF FOR FORD TO MAKE AN EXTRA BUCK. WHO IS GOING TO BE THE ONE TO RAISE THE [XXX] FLAGGED AND TAKE FORD TO THE BANK ON THIS ONE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Visibility, Sep 9, 2010
WHILE I WAS DRIVING THE TRUCK ON LOCAL ROADS, THE PASSENGER SIDE ELECTRICALLY CONTROLLED WINDOW WHICH WAS FULLY UP SUDDENLY SLOWLY RECEDED DOWN INTO THE DOOR OF THE TRUCK AND NOW CANNOT BE RAISED BACK UP. THE WINDOW IS NOT BROKEN, AND THE NOISE WHEN I PRESS THE WINDOW CONTROL SEEMS TO INDICATE THAT THE MOTOR IS STILL WORKING PROPERLY. I HAVE CALLED SEVERAL REPAIR SHOPS (AND THE DEALER), AND THE CONCLUSION SO FAR (HEARING THE DESCRIPTION BUT WITHOUT INSPECTING THE VEHICLE) IS THAT THE WINDOW REGULATOR NEEDS TO BE REPLACED. *TR
Electrical system, Visibility, Sep 8, 2010
WAS DRIVING HOME FROM WORK AND MY REAR DRIVER'S SIDE WINDOW DROPPED TO THE BOTTOM FOR NO APPARENT REASON. I DON'T EVEN USE THE WINDOW MUCH. PULLED OFF DOOR COVER AND FOUND CABLE APART AND WOUND AND TANGLED BEHIND MOTOR. CALLED MY BUDDY TO SEE IF HE HAD IT HAPPEN TO HIS AND BEFORE I COULD SAY ANYTHING HE SAID HE JUST CAME IN FROM CRAMMING A BOARD IN HIS REAR WIDOW MAKE IT HOME. THEY SEEM TO BE REALLY POORLY MADE. *TR
Electrical system, Visibility, Sep 7, 2010
IN 2008 I PURCHASED A 2004 FORD F-150 LARIAT( 4 DOOR). IN MARCH OF THIS YEAR ( 2010) THE POWER WINDOW MECHANISM ON THE FRONT DRIVERS SIDE FAILED, CAUSING THE WINDOW TO DROP INTO THE DOOR PANEL. THE FRONT DRIVERS SIDE PASSENGER DOOR FAILED IN JUNE OF THIS YEAR WITH THE SAME RESULT. TODAY, SEPT 7, THE REAR PASSENGERS SIDE DOOR WINDOW MECHANISM FAILED CAUSING THE WINDOW TO DROP INTO THE DOOR. I HAVE DONE SOME RESEARCH ON THE INTERNET AND I FIND THE FAILURE OF THE POWER WINDOW MECHANISM TO BE FAIRLY COMMON. THIS IS A DEFINITE SAFETY HAZARD AS AN UNEXPECTED LOWERING OF THE WINDOW CAN CAUSE ITEMS INSIDE THE TRUCK TO FLY AROUND INSIDE THE CAB AND CREATE A SAFETY HAZARD TO THE DRIVER. IT WOULD SEEM THAT FORD HAS HAD AN UNUSUAL NUMBER OF THIS FAILURES AND SHOULD MAKE THE REPAIRS AT THEIR COST IN ORDER TO PREVENT SERIOUS ACCIDENTS. *TR
Electrical system, Aug 12, 2010
I OWN A FORD F-150,2004. I HAD A SLIGHT MISS IN THE ENGINE. I TOOK IT TO MY LOCAL FORD DEALER AND HE SAID I NEEDED TO REPLACE THE PLUGS,PROJECTED COST WAS 300.00 TO 350.00, AND WOULD TAKE THREE HOURS. (IT TOOK 8 HOURS &COST ME 496.00) I WATCHED THE MECHANIC FOR OVER 4 HOURS AND HE BROKE OFF 4 PLUGS IN THE HEAD,THE DEBRIS GOING INTO THE HEAD,HE TOOK AN AIR HOSE AND ATTEMPTED TO BLOW THE TRASH OUT. I LEFT THE FORD DEALER AND DROVE APPROXIMATELY 25 MILES ON THE INTERSTATE AND THE TRUCK STARTED JUMPING, MISSING, AND WOULD NOT RUN. I HAD IT TAKEN TO A GARAGE AND WAS TOLD I HAD INTERNAL ENGINE PROBLEMS. I FOUND A USED ENGINE WITH 15,000 MILE AND HAD IT INSTALLED.(IT WAS CHEAPER THAN REBUILDING THE OLD ONE)WHEN THE ENGINE WAS REMOVED WE FOUND PARTS OF THE PLUG THAT WAS TWISTED OFF HAD FELL ON THE VALVE SPRING AND BROKEN IT. I HAVE E-MAILED FORD AND MADE NUMEROUS CALLS TO THEM ,THEY HAVE NEVER RESPONDED IN ANY WAY.ON THE ENGINE THAT WAS INSTALLED,AFTER 52000 MILES I DEVELOPED A MISS IN THIS ENGINE,I TOOK IT TO ANOTHER FORD DEALER,THEY REPLACED THREE (3) PLUGS ,IT TOOK THEM THREE& HALF DAYS TO DO THIS AT A COST OF $360.00. I WAS TOLD THAT FORD HAD SENT A SERVICE NOTICE OUT STATING THAT THE PLUGS SHOULD BE REPLACED @50,000 MILE. I WAS ALSO TOLD BY THE SERVICE MANAGER THAT IT WAS NOT UNCOMMON TO COST OVER $1000. TO REPLACE THE PLUGS,AND THAT FORD HAD ALL DEALERS A SPECIAL TOOL TO DEAL WITH THE PLUGS REMOVAL AFTER THEY BROKEN OFF. IS THIS A BETTER IDEA ?. I NOW HAVE ANOTHER MISS IN THE ENGINE BUT I AM RELUCTANT TO HAVING IT WORKED. I AM SO DISGUSTED WITH FORD THAT I SOLD A 2007 F150 KING RANCH THAT I OWNED WITH ONLY 19,000 MILES ON IT. I CAN ASSURE YOU THAT HAVING SPENT OVER $5,000 ON THIS TRUCK THAT I WILL NEVER BUY ANOTHER ONE. I'M ALSO SELLING MY 1969 MACH 1 MUSTANG AND MY 1985 SALEEN MUSTANG. THIS IRRELEVANT TO MY PROBLEMS, HOWEVER I JUST HAD TO MENTION IT. PERHAPS YOU CAN GET THIS TO FORD BECAUSE THEY SURE DON'T LISTEN TO ME. THANK YOU, SINCERELY *TR
Electrical system, Visibility, Jul 31, 2010
DRIVING ON THE FREEWAY MY DRIVERS DOOR WINDOW STARTING COMING DOWN ON ITS. I LOOKED TO SEE WHAT WAS GOING ON NEXT THING IT CAME CRASHING DOWN AND ALL I HEARD WAS GLASS SHATTER. NOT A GOOD THING TO HAPPEN DRIVING DOWN THE FREEWAY. *TR
Fuel system, Gasoline, Electrical system, Jun 28, 2010
2004, 4.6 FORD EXPLORER PICKUP SPARK PLUGS BREAK OFF, CAN'T GET THEM OUT, CAUSES MUCH DAMAGE, COST $$$$ TO GET REPAIRED THAT I DON'T HAVE! THERE ARE MANY MANY PEOPLE ON WEBSITE FORUMS WHO HAVE THIS SAME PROBLEM. SOME EVEN SAY THE FORD DEALERSHIP THEY TOOK THEIR TRUCK TO COULDN'T EVEN GET THE SPARK PLUGS OUT EITHER. IS THERE A RECALL? *TR
Electrical system, Jun 26, 2010
2004 FORD F150 HERITAGE ANTI-THEFT SYSTEM CAN CAUSE ENGINE TO QUIT WHILE DRIVING OR PREVENT FROM STARTING. DURING FAILURE THE 'THEFT' LIGHT ON THE DASHBOARD WILL BLINK RAPIDLY. VEHICLE HAS COMPLETELY STOPPED ON INTERSTATE HIGHWAY NEARLY CAUSING ACCIDENT DUE TO LOSS OF STEERING CONTROL AND BRAKING. CONTACTED FORD DEALER WHO SAID I SHOULD REPLACE THE BATTERY. THE BATTERY WAS REPLACED AND DID NOT CORRECT PROBLEM. HAD COMPLETE ELECTRICAL SYSTEM CHECKED AND NO PROBLEMS WITH SYSTEM. *TR
Electrical system, Visibility, Apr 14, 2010
2004 FORD F150 SUPERCREW 4 DOOR - WINDOW MOTOR/CABLE FAILURE. I STARTED TO "ROLL" THE PASSENGER DOOR FRONT WINDOW DOWN AND IMMEDIATELY THE WINDOW JUST DROPPED ALL THE WAY INSIDE THE DOOR LEAVING NO WINDOW AVAILABLE ON THAT DOOR. NO WINDOW, NO PROTECTION FROM THE WEATHER, NO SECURITY, ETC. THE WINDOW WOULD NOT COME UP AND REMAINED DOWN INSIDE THE DOOR. I'VE READ ABOUT THIS AS A COMMON PROBLEM THAT LOOKS LIKE A REAL OBVIOUS RECALL SITUATION. PLEASE MAKE FORD RESPONSIBLE FOR THIS FAILURE AS IT APPARENTLY CAN HAPPEN OVER AND OVER BECAUSE OF INFERIOR PARTS. THIS IS MY FIRST OCCURENCE IN MY 23 MONTHS OF OWNERSHIP - THANK GOODNESS. THERE ARE SO MANY SIMILAR REPORTS AND I ASK THAT YOU BE FAIR TO THE CONSUMERS AND FORCE FORD TO RECALL THESE PARTS WITH A SUITABLE REPLACEMENT PART. PLEASE TREAT THEM EQUAL WITH TOYOTA AND ANY OTHER MANUFACTURER. FORD HAS A BAD DOOR CABLE OR MECHANISM AND THEY SHOULD BE HELD RESPONSIBLE FOR THIS ISSUE. *TR
Electrical system, Feb 25, 2010
WE HAVE A 2004 150 FORD TRUCK WITH LESS THAN 25000 MILES AND THAT IS GUESSING SINCE THE DASH DOES NOT WORK. ALSO THE WINDOW HAS FALLEN OUT AND LAST BUT NOT LEAST THE PASSENGER WINDOW WILL NOT ROLL UP. SINCE IT IS OUT OF WARRANTY THEY WILL NOT REPAIR ANY OF THESE PROBLEMS. HAVE ANY OTHER COMPLAINTS COME IN ON THIS MODEL. FORD SAYS THEY HAVE NO DASH AND WINDOW PROBLEMS IN THEIR TRUCK. WE WILL BE OUT AT LEAST 1200.00 DOLLARS ON REPAIRS ON A TRUCK WITH VERY LOW MILEAGE. *TR
Electrical system, Oct 25, 2009
NORMAL DRIVING, DRY, CLEAR, DAYTIME. GOING THRU PARKING LOT 5-8MPH, BUMP AND POT HOLES. MY 2004 FORD F150, SUPERCREW CAB, DIED. NO POWER TO RESTART. TOWED TO LOCAL AUTOMOTIVE SHOP. THEY FOUND A BLOWN MAXI 20 AMP FUSE (#102 IN FUSE BOX) REPLACED IT. TWO DAYS LATER, AGAIN GOING UP A HILL WITH SOME WASH BOARD RIPPLES IN ROAD, TRUCK DIES/FUSE BLOWN. TOW IT HOME, REPLACE SAME FUSE AS BEFORE, ATTEMPT TO START TRUCK, FUSE BLOWN AGAIN & AGAIN. CALL FORD MOTOR DEALER, THEY SUGGEST TO REPLACE "IGNITION SWITCH", I DO SO AND NEW FUSE, ATTEMPT TO START TRUCK, FUSE BLOWN AGAIN, CALL FORD DEALER, THEY SAY TO REPLACE "TRANSMISSION RANGE SENSOR", I UNPLUG THAT CONNECTOR-DUE TO A NEW PART IS VERY COSTLY AND YOU CAN NOT RETURN ELECTRICAL PARTS. NEW FUSE, ATTEMPT TO START W/O CONNECTION TO TRS. FUSE BLOWN. SO TRANSMISSION RANGE SENSOR, NOT THE PROBLEM. THIS IS A COSTLY ONGOING REPAIR WITH NO SATISFACTION. (NOW LUCKILY WHEN THE "FUSE" BLOWS, I HAVE NOT BEEN IN LOS ANGELES RUSH HOUR TRAFFIC) HOW EVER I WAS ON A VERY BUSY UP HILL GRADE WHEN THE SECOND TIME IT BLOWN THE FUSE AND MY FAMILY AND I WERE NEARLY HIT SEVERAL TIMES DUE TO TRAFFIC THAT COULDN'T SEE OVER THE HILL TOP, NOR WOULD THE SAME DIRECTION OF TRAFFIC FROM BEHIND SLOW DOWN. WE WERE LUCKY, I RESEARCHED WEB SITES FOR ANSWERS TO A FIX. I FOUND OTHER INDIVIDUALS WITH F150 TRUCKS HAVE THE SAME ISSUE. FORD MOTOR CO. HAS NO TECHNICAL SERVICE BULLETINS FOR THIS PROBLEM, WHY NOT? I HAVE SPENT 5 WEEKS RESEARCHING MY WIRES, PARTS AND INFORMATIONAL SITES AND MECHANICS, VERY UNSUCCESSFUL. I HEARD THAT TOYOTA MADE THEIR PCM SO IT WOULD MALFUNCTION AFTER SO MANY MILES, COULD THIS BE WHAT FORD IS DOING TO COLLECT MONEY FOR REPAIRS? I AM A CERTIFIED MECHANIC & SMOG TECH IN CALIFORNIA, I AM LOST AS FAR AS HOW TO REPAIR THIS PROBLEM, BEFORE I PAY TO TOW TO A FORD DEALER AND GET REAMED ON EXPENSE FOR AN ELECTRICAL PROBLEM THAT IS PROBABLY AN EASY FIX. CAN YOU HELP? THANK YOU FOR YOUR VALUABLE TIME. *TR
Electrical system, Aug 17, 2009
DRIVER SIDE WINDOW FELL INTO DOOR WHILE DRIVING DUE TO POWER WINDOW REGULATOR FAILURE. *TR
Electrical system, Vehicle speed control, Aug 17, 2009, fire
TL*THE CONTACT OWNS A 2004 FORD F150. THE CONTACT STATES WHILE HE WAS IN HIS HOME. HE WAS INFORMED THAT HIS VEHICLE HAD CAUGHT ON FIRE. HE NOTICED THAT THE FLAMES WHERE COMING FROM UNDER THE HOOD. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT DID NOT NOTICE ANY DIFFERENCE PREVIOUSLY. THE CURRENT AND FAILURE MILEAGE IS 54900. UPDATED 09/16/09 *BF UPDATED 09/17/09.*JB
Electrical system, Visibility, Jul 23, 2009
STARTED IN JUNE 2008 WITH DRIVER'S WINDOW DROPPING INTO DOOR. JULY 2008 REAR DRIVER'S SIDE WINDOW DID SAME. NOW JULY 18, 2009 REAR PASSENGER'S WINDOW DID SAME. EACH TIME DEALER REFUSES TO SAY THAT ITS A PROBLEM. SAY MINE IS THE ONLY TRUCK DOING THIS. TRUCK ONLY HAS 36,000 MILES. *TR
Electrical system, Jun 9, 2009
FIRST NOTICED TICKING NOISE IN MY 2004 5.4L 3V V8 ENGINE. OIL WAS AT CORRECT LEVEL. I WENT DOWN A ROAD I ROUTINELY GO, AND STARTED HEARING A VERY LOUD CLANKING. SPARK PLUG BLEW OUT OF THE HOLE AND NOW TRYING TO FIX. HOPEFULLY WONT HAVE TO REPLACE THE HEAD. APPARENTLY I AM NOT THE ONLY OWNER OF THIS ENGINE WITH THE SAME PROBLEM!! THIS IS JUST THE ONE CYLINDER, BUT I HAVE 7 MORE! AM I GOING TO HAVE TO DO THIS WITH ALL OF THEM? I HAD TO HAVE IT TOWED TO THE ONLY PEOPLE WHO WILL TRY TO FIX IT. OTHER REPAIR STATIONS SAY THEY WOULDN'T TOUCH IT AND THAT THEY HAD, OR HAVE BEEN THREATENED BY, A LAWSUIT FROM THE VEHICLES OWNER. THIS HAS ALREADY COST ME THE REPLACEMENT OF THE IGNITION COIL, A AN EXPENSIVE SPARK PLUG, AND A LOT OF DOWN TIME. *TR
Electrical system, Other or unspecified, Mar 30, 2009
WE OWN A 2004 F150 LARIAT 4X4 PICKUP WITH JUST OVER 50K MILES ON IT. IN LESS THAN 3 MONTHS TWO (2) OF THE FOUR (4) POWER WINDOWS HAVE DROPPED WITHOUT WARNING. THESE WINDOWS HAVE SIMPLY FALLEN DOWN DRIVING THE VEHICLE WITHOUT ANY BUMPS OR ACCIDENTS PRECEDING THEM FALLING. WHAT IS WORSE IS THAT MY TWO YEAR DAUGHTER WAS IN CAR SEAT YESTERDAY NEXT TO THE BACK WINDOW THAT DROPPED AS WE WERE DRIVING. WHAT IF SOME DEBRIS FROM PASSING TRAFFIC OR SEMI TRAILER HAD BLOWN BY...THIS WOULD HAVE BEEN A MAJOR CATASTROPHE. AND ALL FORD CAN SAY IS..."SORRY, IT WILL COST YOU $400 TO FIX." WELL, THAT ISN'T GOOD ENOUGH. SOMETHING NEEDS TO BE DONE ABOUT IT. FAR TOO MANY INCIDENTS LIKE THIS ARE HAPPENING. SEE THE FOLLOWING HYPERLINK FOR OTHERS WITH SIMILAR PROBLEMS. HTTP://WWW.CARCOMPLAINTS.COM/FORD/F-150/2004/WINDOWS_WINDSHIELD/WINDOW_DOES_NOT_ROLL_UP.SHTML. *TR
Electrical system, Mar 28, 2009
I HAVE A 2004 FORD F150, WITH A 5.4L ENGINE. I WENT TO HAVE BATTERY REPLACED AND AFTER REPLACEMENT THE ENGINE WOULD NOT IDLE. THE REPAIR FIRM I HAD TAKEN IT TO, CALLED CHAMPION FORD IN SANDY, UTAH AND THE TECHNICIAN TOLD THEM FORD HAD A SERVICE BULLETIN OUT SAYING THAT THE VEHICLE MIGHT NOT IDLE AND THE ENGINE WILL SHUT DOWN AFTER THE BATTERY HAS BEEN DISCONNECTED AND REPLACED. THEY HAD TO TAKE MY TRUCK OVER THERE AND THE COMPUTER HAD TO BE REPROGRAMMED. WHAT IS A PERSON TO DO, HAVE THE COMPUTER REPROGRAMMED EVERY TIME THE BATTERY DIES OR IS REPLACED? SOUNDS TO LIKE FORD SHOULD HAVE HAD A RECALL TO CORRECT THE PROBLEM. THAT'S A NASTY SURPRISE FOR ANYONE. *TR
Engine and engine cooling, Electrical system, Mar 28, 2009
THE VEHICLE WRENCH LIGHT CAME ON AND THE ENGINE QUIT. HAD I BEEN ON A FREEWAY, A SERIOUS ACCIDENT MIGHT HAVE OCCURRED. I CALLED THE WARRANTY SERVICE FOR A WRECKER AS IT WAS STILL IN WARRANTY. ABOUT 40 MINUTES LATER, THE WRECKER ARRIVED AND THE DRIVER ASKED ME IF I HAD TRIED TO RESTART THE ENGINE. I HADN'T, TRIED, AND IT STARTED. I RESEARCHED THE INTERNET AND FOUND SOME INFORMATION INCLUDING A SUGGESTION TO DISCONNECT THE BATTERY TO RESET THE COMPUTER. UNFORTUNATELY, I DID THAT AND WHEN I TOOK IT TO THE DEALER THE FOLLOWING TUESDAY THEY COULDN'T TELL WHAT CAUSED THE PROBLEM. IT HAPPENED AGAIN ON MARCH 25, 2009. AGAIN, I WAS GLAD I WAS ON A SIDE STREET. I WILL TAKE THE TRUCK TO THE DEALER TUESDAY EVEN THOUGH THE WARRANTY HAS EXPIRED AS THIS COULD BE A VERY SERIOUS PROBLEM ON A HIGHWAY. *TR
Power train, Electrical system, Jun 20, 2008
TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT ATTEMPTED TO PLACE THE VEHICLE INTO REVERSE AND HEARD A LOUD NOISE. AFTERWARDS, THE VEHICLE WOULD ONLY MOVE FORWARD. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE TRANSMISSION GEARS FAILED. THE DEALER REPLACED THE GEAR POSITION INDICATOR; HOWEVER, THE VEHICLE WOULD NOT START AFTER THE REPAIR WAS MADE. THE CONTACT HAD TO RECHARGE THE BATTERY IN ORDER TO START THE VEHICLE. THE VEHICLE WAS RETURNED TO THE DEALER AND THEY STATED THAT THE ALTERNATOR FAILED. THE ALTERNATOR WAS REPLACED; HOWEVER, ON JUNE 16, 2008, THE VEHICLE WOULD NOT START AGAIN. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 30,000 AND CURRENT WAS MILEAGE 46,000.
Electrical system, Apr 20, 2008
FORD DESIGN ON 3VALVE ENGINES IN MY CASE F150 WITH 5.4 AND MUSTANG WITH 4.6 HAS CAUSED PLUGS TO BREAK IN CYLINDER HEAD. FORD HAS ISSUED 3 TSB'S. THIS IS THEIR PROBLEM AND THEY ARE MAKING CONSUMER FOOT THE BILL WHICH CAN RUN IN THOUSANDS. *TR
Electrical system, Visibility, Dec 10, 2007
TL*THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING 20 MPH, THE BATTERY LIGHT ILLUMINATED AND THE ALTERNATOR GAUGE DROPPED. THE DEALER STATED THAT THE ALTERNATOR CAUSED THE FAILURE AND THEY MADE THE REPLACEMENT. APPROXIMATELY ONE YEAR LATER, WHILE DRIVING 20 MPH, THE FAILURE RECURRED. THE DEALER REPLACED THE ALTERNATOR AGAIN. THE CONTACT STATED THAT THE FAILURE OCCURRED TWO MORE TIMES UNDER THE SAME CIRCUMSTANCES. THE DEALER STATED THAT THE ALTERNATOR WAS THE CAUSE OF EACH FAILURE. THE FAILURE MILEAGE WAS 8,100 AND CURRENT MILEAGE IS 26,200. UPDATED01/07/08 *BF THE WINDSHIELD WIPER BLADES AND A FUSE WAS REPLACED
Electrical system, Aug 9, 2007, fire
TL*THE CONTACT OWNS A 2004 FORD F150. WHILE DRIVING 25 MPH THE ENGINE SHUT OFF WITHOUT WARNING AND HE WAS UNABLE RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE #5 IGNITION COIL CAUGHT FIRE AND BLEW A RELAY FUSE. THE FAILURE PREVIOUSLY OCCURRED WITH THE #6 IGNITION COIL. THE FAILURE MILEAGE WAS 191,361 AND THE CURRENT MILEAGE WAS 191,461.
Electrical system, Jun 18, 2007
I PURCHASED A 2004 FORD F-150 TRUCK NEW, AND I AM HAVING ELECTRICAL PROBLEMS, WHICH STARTED AT APPROXIMATELY15000 MILES AND HAVE BEEN CONSISTENT. . CURRENTLY, I HAVE 33000 MILES ON THIS VEHICLE. DEALER MAINTAINED SINCE NEW. *AK
Electrical system, Apr 24, 2007
1. VEHICLE FAIL SAFE LIGHT LUMINATED VEHICLE HAD HALF POWER. 2. VEHICLE WOULD NOT START FUSE KEEPS BLOWING. 3. FIRST OCCASION DEALER SERVICED VEHICLE FOUND NO MECHANICAL PROBLEMS. SECOND OCCASION DEALER HAD TO TRAVEL TO THE VEHICLE SINCE VEHICLE WAS IN A PARKING GARAGE AND A TOW TRUCK COULD NOT GET INTO THE GARAGE. DEALER STATED THEY FOUND A LEAK AND SILICONED THE LEAK. DROVE VEHICLE 3 TIMES. THIRD TIME VEHICLE WOULD NOT START. FUSE IS BLOWN AGAIN VEHICLE WAS TOWED TO DEALER AND IS STILL THERE. *TR