2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: power train
233 reports, newest first. Show all
Power train, Nov 16, 2004
NOISE IN REAR END ABOUNT 60 TO 70 MILES A HOUR.WHINNING NOISE.*AK
Power train, Nov 12, 2004
THE VEHICLE WAS PARKED WHEN IT BEGAN TO ROLL ACROSS A PARKING LOT. THE DRIVER MANAGED TO UNLOCK THE DOOR, JUMP INTO THE VEHICLE AND PUT THE BRAKE ON BEFORE IT ROLLED ONTO A MAIN STREET. *NM VEHICLE WAS ONLY 20 DAYS OLD AND WOULD NOT RESTART. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALERSHIP ONLY TO FIND FROM THE SERVICE MANAGER THAT THE CLIP TO BRACKET FROM THE FACTORY WAS MISSING. WHEN THE CONSUMER CALLED IN TO COMPLAIN SHE WAS TOLD BY A SALES REPRESENTATIVE THAT IT'S NOT THEIR FAULT THEY DID NOT BUILD THE TRUCK. NO LOANER CARS AVAILABLE. THE CONSUMERS NAME WAS NOT PUT INTO THE SYSTEM FOR ROADSIDE ASSISTANCE. *TC *JB
Power train, Nov 12, 2004
FORD F150 EX CAB 2 WHEEL DRIVE AT 1400 MILES LOUD NOISE FROM REAR END DURING TURNS OR ACCELERATION. DEALER REPLACED PARTS IN DIFFERENTIAL. SINCE DEALER FIX, LOUD "HUMMING" NOISE FROM REAR END OVER 35 MPH. VIBRATION FROM REAR END WHILE GOING 40 MPH+. *JB
Power train, Nov 11, 2004
REPORTED TO DEALER SERVICE DEPT. THAT MY NEW 2004 FORD F150 FX4 TRUCK HAD WHINE AND CLUNKING NOISE COMING FROM REAR AXEL/DIFFERENTIAL ASSEMBLY AT TAKE OFF FROM STOP AND SPEEDS BETWEEN 45 AND 55 MPH. DEALER WAS INSTRUCTED BY FORD MOTOR COMPANY ENGINEERING DEPT. NOT TO ATTEMPT REPAIR. 1000 MILES LATER THE PROBLEM HAS GOT WORSE. *JB
Power train, Nov 10, 2004
I PURCHASED NEW FORD F150, THE FIRST TIME UP TO HIGHWAY SPEEDS THE VEHICLE HAD A VIBRATION BETWEEN THE SPEED OF 55 AND 65 MPH. *AK
Power train, Nov 6, 2004
HAVE A 2004 FX4 SUPERCREW 4X4. HAVE TWO PROBLEMS. FIRST, THE SPEEDO READS 4 TO 5 MPH FAST, HAVE HAD IN SHOP TWICE STILL NO FIX, WAS TOLD THAT WAS THE BEST THEY COULD DO. SECOND, WHEN TAKING OFF FROM DEAD STOP REAR END MAKES 2 SLIPPING CLUNKS, WAS TOLD FROM DEALER IT IS THE LEAF SPRINGS SO THEY GREASED THEM. PROBLEM WENT AWAY FOR A DAY MAYBE AND IS BACK LOUDER THEN EVER. ONLY 5000 MILES ON TRUCK. WISH FORD WOULD STEP UP TO THE PLATE AND TAKE CARE OF SOME OF THESE "KNOWN" PROBLEMS. *JB
Power train, Nov 1, 2004
TRUCK HAS REAREND VIBRATION @55-60 MPH. TRUCK ALSO HAS STEERING WHEEL SHAKE AT HIGHWAY SPEED (ABOVE 45 MPH). FORD STATES THAT THEY NO THEY HAVE A PROBLEM AND ARE WORKING ON A FIX.*AK
Power train, Oct 11, 2004
I PURCHASED THE TRUCK LESS THAN 30 DAYS AGO. VIBRATION IN THE DRIVE TRAIN STARTED WITHIN THE FIRST 1000 MILES. DEALER SAYS THAT THE VIBRATION IS "NORMAL" OPERATION FOR THE VEHICLE. VIBRATION COULD REPRESENT A SAFETY ISSUE IF NOT CORRECTED. *NM
Power train, Oct 2, 2004
I HAVE TWO MAIN PROBLEMS WITH MY FORD F150, MY VEHICLE HAS A VIBRATION WHICH IS AT ITS WORSE BETWEEN 40 TO 60, WHICH IS GETTING WORSE, CONSTANT AT AROUND 50MPH, AND TO A LESSER EXTENT THROUGHOUT THE 0 TO 40 MPH AND A STRONG VIBRATION IS SOMETIMES FELT ON DECELERATION, JUST BEFORE STOPPING, I ALSO HEAR A LOUD BOOMING WHICH COINCIDES WITH THE VIBRATION SPEEDS AND I THINK THAT THIS VIBRATION IS SETTING UP A RESONANCE OR REVERBERATION IN THE VEHICLE AND WITH THE WINDOWS IN OPEN POSITIONS, ON THE SECOND DAY I NOTICED SCRATCHES AND INDENTATIONS ON ROOF, APPROX 5 OF THEM RUNNING ON A DIAGONAL, CALLED AND LEFT MESSAGE WITH SALESMAN, NO RESPONSE, THURSDAY 9/23/04 HAD SALES MANAGER AND BODY SHOP MANAGER LOOK AT DENTS, TRUCK WAS TAKEN BACK AND BUFFED OUT, SCRATCHES AND DENTS STILL VISIBLE. APPOINTMENT WAS MADE FOR A SPECIALIST TO TRY TO MASSAGE DENTS OUT, BUT IN CASE RESULTS WERENT SATISFACTORY, THEN BODY FILLER COULD BE APPLIED AND PAINTED, TOLD THEM REPEATEDLY I DONT WANT BODY FILLER ON MY NEW TRUCK.I ALSO MADE A COMPLAINT ABOUT A VIBRATION BETWEEN 40 TO 60 MPH, AND THAT I BELIEVED THAT THIS WAS SETTING UP A RESONANCE OR REVERBERATION AND CAUSING BOOMING SOUND IN TRUCK, SERVICE MANAGER TOOK RIDE IN VEHICLE AND SAID IT WAS WIND BUFFETING, SAID HE WOULD CHECK WITH FORD ENGINEERS AND SEND ME A TRANSCRIPT OF FINDINGS, NEVER DID. SAT 9/25 I CALLED FORDS COMPLAINT NUMBER THAT IS LISTED IN THE MANUAL, EXPLAINED THAT THE TRUCK WAS DELIVERED DAMAGED AND REQUESTED A REPLACEMENT TRUCK, ALSO EXPLAINED THAT I FELT PRESSURED TO ACCEPT BODY FILLER AND VIBRATIONS IN MY NEW TRUCK, WAS TOLD THAT A TRANSCRIPT OF THE CONVERSATION WOULD BE SENT TO THE COMPLAINT MANAGER, HE WOULD RECEIVE THE TRANSCRIPT ON MONDAY, 10AM THURSDAY 9/30/04, I EXPECTED A CALL REGARDING THIS TRANSCRIPT, AFTER RECEIVING NONE, I CALLED THE COMPLAINT MANAGER AND I WAS ASKED IF IT WAS ALRIGHT FOR THEM TO CALL ME BACK, I SAID THAT WOULD BE FINE, 5:30PM SAT 10/02/04, HAVE NOT RECIEVED A CALL BACK, DESPITE REQUEST MADE.*AK
Power train, Oct 2, 2004
I PURCHASED A FORD F150 NEW IN JANUARY OF 2004. ON MANY OCCASIONS, WHEN ATTEMPTING TO MERGE INTO TRAFFIC, PASS ANOTHER VEHICLE, ETC., THE TRANSMISSION FEELS LIKE IT SLIPS INTO NEUTRAL. THE ENGINE SPEED INCREASES BUT THE VEHICLE DOES NOT ACCELERATE. THIS HAS RESULTED IN A FEW NEAR-MISSES WHEN I MERGED INTO FREEWAY TRAFFIC AND HAVE NEARLY BEEN HIT BY ONCOMING TRAFFIC. THE SERVICE REP AT MY DEALERSHIP SAYS THAT HE CAN'T DUPLICATE THE PROBLEM. THIS IS VERY ANNOYING AND VERY DANGEROUS.*AK
Power train, Sep 30, 2004
2004 F150 WITH THE 4.6 LITER V8 ENGINE AND LIMITED SLIP DIFFERENTIAL. WHEN THE TRUCK IS RUNNING @ 2100 RPM AT HIGHWAY SPEEDS SOMETHING IN THE REAR END MAKES A STRANGE "WARBLING" TYPE OF HIGH PITCHED NOISE. IT ONLY DOES IT @ 2100 RPM. LOCAL DEALER TRIED TO TELL ME IT WAS EXZHAUST RESONANCE. THEY REPLACED MY EXHAUST SYSTEM AND THE PROBLEM PERSISTS. THEY ARE INVESTIGATING TO DETERMINE TRUE CAUSE.*AK
Suspension, Engine and engine cooling, Fuel system, Gasoline, Fuel system, Other, Power train, Electrical system, Exterior lighting, Structure, Sep 16, 2004
THE EMISSION LIGHT CAME ON. THE VEHICLE WAS TAKEN TO THE DEALER, AND CONSUMER WAS TOLD THAT FUEL PUMP WAS DEFECTIVE. THE GAUGE WENT OUT OF CONTROL. AFTER FILLING THE TANK, THE GAUGE READ EMPTY. *AK THE BRAKE LIGHT WIRING WAS INOPERATIVE, ALIGNMENT WAS OUT, THE VEHICLE HAD STUCK IN PARK, THE RIGHT PASSENGER DOOR WAS INOPERATIVE, THE SPEEDOMETER READ WRONG, AND THE VEHICLE WOULD DIE OUT. *SC
Power train, Tires, Sep 14, 2004
TIRES REPLACED AT LESS THAN1,000 MILES. REAR END REPLACED AT LESS THAN 5,000 MILES STEERING WHILLE VIBRATION AT HIGH SPEEDS REPORTED FROM DAY ONE. TIRES REBALANCED AND FRONT END CHECKED MORE THAN 3 TIMES AND STILL HAVE VIBRATION AT HIGH SPEEDS. REAR ELECTRIC SLIDEING GLASS MOTOR BAD AT 6,000 MILES
Power train, Sep 2, 2004
WHEN SHIFTING GEARS THE AUTOMATIC TRANSMISSION SHIFTS VERY HARD I UNDERSTAND THIS IS DUE TO THE OVERDRIVE NOT OPERATING CORRECTLY. I HAVE HAD OTHER PEOPLE TELL ME THEIRS TRUCKS (FORD F150) DO THE SAME THING. IS THEIR A RECALL ON THIS PROBLEM?*AK
Power train, Aug 25, 2004, crash
WHILE PARKED WITH THE KEY IN THE IGNITION VEHICLE CAME OUT OF GEAR. AS RESULT, VEHICLE ROLLED BACKWARDS DOWN AN EMBANKMENT. *AK
Power train, Aug 25, 2004, crash
ON 3 DIFFERENT OCCASIONS,VEHICLE WAS PARKED IN PARK WITH ENGINE RUNNING,AND TRUCK BEGAN TO MOVE.THIRD TIME WAS UNDABLE TO CATCH IT AND TOTALED THE TRUCK. VEHICLE WAS ONLY 4 MONTHS OLD.*AK
Power train, Aug 21, 2004
PURCHASED NEW FX4 02/04. NOTICED TERRIBLE VIBRATION, OCCASIONAL HESITATION, AND TRANSMISSION SLIPAGE. TOOK TO DEALER 7 TIMES, VARIOUS PARTS REPLACED. PROBLEMS NOT FIXED. THEY FINALLY SAID THEY KNEW ABOUT THE PROBLEM BUT IT COULDN'T BE FIXED. *JB
Power train, Tires, Aug 19, 2004
DRIVELINE/TRANSMISSION SLIPS AND CLUNKS WHEN ACCELERATING ON 2004 F150 4X4. REQUENCY: INTERMITTENT ROUGHT INTO 2 DIFFERENT DEALERS AND BOTH SAID COULD NOT DUPLICATE THEREFORE COULD NOT FIX. CONSEQUENCES OF FAILURE: IF HAPPENS WHILE ACCELERATING INTO MERGE TRAFFIC OR INTERSECTION COULD CAUSE LOSS OF POWER TO VEHICLE. *AK
Service brakes, Hydraulic, Power train, Aug 17, 2004
WHILE DRIVING AND COMING TO COMPLETE STOP AUTOMATIC TRANSMISSION DIDN'T SHIFT PROPERLY FROM THE FIRST TO THE SECOND GEAR, FINALLY THE STICK SHIFT DIDN'T MOVE FROM PARK TO A DRIVE GEAR. ALSO BRAKES VIBRATED WHILE DRIVING AT ANY SPEED . *AK
Steering, Fuel system, Other, Power train, Seat belts, Structure, Tires, Aug 16, 2004
TAILGATE STRAPS ARE THE SAME LENGTH, BUT WHEN YOU PUT PRESSURE ON THE TAILGATE, ONLY THE LH TAILGATE STRAP SUPPORTS THE TAILGATE. THE TRUCK HAS VIBRATION AND STEERING WHEEL NIBBLE PROBLEMS. THEY HAVE BALANCED THE TIRES 4 TIMES, REPLACED THE TIRES. THE FSE FROM FORD TOOK THE VEHICLE FOR A RIDE AND SAID IT NEEDS A NEW DRIVESHAFT. THE BRAKE DUST IS A BIG PROBLEM. YOU NEED TO WASH THE WHEELS DAILY. FORD NOW HAS UPDATED PADS. I HOPE THEY REPLACE THEM UNDER WARRANTY. TWO OF THE ROTORS ARE ALSO GROOVED. THE TRUCK HAS 3000 MILES ON IT. IT HAS BEEN IN 5+ TIMES NOW! THE AC UNIT ONLY HAD 22 OUNCES OF FLIUD IN IT. IT IS SUPPOSED TO HAVE 30+. MY AIR WAS VERIFIED TO BE 8-10 DEGREES WARMER THAN SPEC. THE GAS DOOR (SPRING) BROKE. THE PAINT ON THE HOOD IS FLAWED. IT DIDN'T GET FULLY SPRAYED ON THE RIGHT FRONT OF THE HOOD. BOTH SIDES OF THE REAR DIFF. ARE WET. SOMETHING IS LEAKING. THE SEATBELT STITCHING IS COMING APART.*AK
Power train, Visibility, Jul 26, 2004
CONSUMER NOTICED THAT AFTER THE WINDSHIELD WIPERS WENT OFF THE FRONT WINDSHIELD BECAME BLURRY. THIS CAUSED POOR VISIBILITY TO THE DRIVER. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC REPLACED THE WINDSHIELD THREE TIMES. HOWEVER, THE PROBLEM RECURRED. *AK CONSUMER ALSO HAD CONCERN WITH VIBRATION UNDER THE VEHICLE. DEALER FOUND THAT THE VIBRATION IS COMING FROM THE DRIVERSHAFT, WHICH WAS REPLACED BY THE DEALER. *LA
Power train, Jul 16, 2004, crash
THE VEHICLE WAS PARKED IN OUR DRIVEWAY AND LEFT RUNNING. WE HAD 3 COOLERS IN THE BACK SEAT, SO WE LEFT IT RUNNING WITH THE AIR ON. WE HAD DRIVEN APPROXIMATELY 300 MILES TOTAL THAT DAY WITH THE AIR CONDITIONING ON HIGH. WE UNLOADED THE COOLERS 1 AT A TIME. THIS TOOK APPROXIMATELY 30 MINUTES. WE WERE STANDING IN OUR KITCHEN WHEN ALL OF A SUDDEN SOMETHING SMASHED INTO THE HOUSE AND THEN WE SEE OUR VEHICLE "DRIVING" BY THE WINDOW UP OUR DRIVEWAY. IT SLID ALONG THE HOUSE AND HIT THE GARAGE (GARAGE IS DETACHED). MY HUSBAND JUMPED IN THE VEHICLE AND PUT IT IN REVERSE AND TURNED IT OFF BEFORE IT WENT THROUGH THE GARAGE. IT HAD HIT THE CENTER POLE, AND WAS STOPPED BY THAT. THERE WAS NO ONE OUTSIDE WHEN THIS OCCURRED. WE CONTACTED THE FORD DEALER AND WERE TOLD IT WAS IMPOSSIBLE FOR THE VEHICLE TO COME OUT OF PARK BY ITSELF. I HAVE BEEN RESEARCHING THIS, AND FOUND THAT FORD HAS HAD THIS PROBLEM IN THE PAST, SO I THINK IT IS POSSIBLE. THERE IS NO OTHER EXPLANATION FOR THIS HAPPENING. THERE WAS NO ONE AROUND OUTSIDE, AND WE WERE IN THE HOUSE. THE VEHICLE HAD BEEN SITTING IN THE DRIVEWAY FOR OVER 30 MINUTES AND WE HAD BEEN IN IT 4 DIFFERENT TIMES (IN THE BACK SEAT) UNLOADING STUFF, SO THERE IS NO WAY IT WAS NOT IN PARK. WE TESTED THIS TOO, IF YOU LEAVE IT IN DRIVE, AS SOON AS YOU STEP OFF THE BRAKE IT ROLLS FORWARD RIGHT AWAY. WE ALSO DO NOT BELIEVE IT WAS A "PRANK" BY ANYONE, AS THERE WAS NO ONE AROUND OUTSIDE AND MY HUSBANDS WALLET WAS ON THE DASH AND MY PURSE WAS IN THE PASSANGER SEAT AND BOTH WERE NOT TOUCHED. I AM VERY CONCERNED THAT THERE IS SOMETHING WRONG WITH THE VEHICLE, BUT LIKE I SAID THEY KEEP INSISTING IT ISN'T POSSIBLE. WHICH IS NOT TRUE, AS I SEE THEY HAVE HAD THIS PROBLEM IN THE PAST. I'M NOT SURE WHAT ELSE I CAN DO AT THIS POINT SINCE THE FORD DEALER WON'T EVEN ACKNOWLEDGE THAT THIS COULD BE A PROBLEM. *AK
Power train, Jul 7, 2004
TRANSMISSION SLIPPED WHILE DRIVING ACROSS AN INTERSECTION. CONSUMER WAS STUCK IN THE MIDDLE TO THE ROAD. WHEN ACCELERATING IT SHIFTED OUT OF GEAR. METAL WAS FOUND IN THE TRANSMISSION. FORD SAID SEND IT BACK TO MANUFACTURER. *AK *NM
Power train, May 17, 2004
I HAVE AN 2004 FORD F-150 SUPERCAB 4X4. A FEW DAYS AFTER I BOUGHT IT, IT DEVELOPED A SLIPPING / SHUDDERING PROBLEM IN THE REAR END WHEN YOU STARTED FROM A STOP AND WHILE TURNING. SUNSTATE FORD SAID THAT THE SLIP YOKE HAD NO LUBRICATION. SO THEY LUBED IT. WITHIN 2 DAYS THE PROBLEM RE-OCCURRED. THE SHUDDERING HAPPENS HOT OR COLD BUT BECOMES WORSE THE MORE THE TRUCK IS DRIVEN. WHEN I BROUGHT IT BACK TO SUNSTATE FORD TO LET THEM TRY TO FIX IT AGAIN, THEY SAY THE PROBLEM IS NORMAL. I OWNED ALOT OF TRUCKS IN MY LIFE AND NOT 1 OF THEM DID THIS. FROM TALKING TO ONE OF THE SERVICE EMPLOYEES I LEARNED THAT THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS PROBLEM. ADDITIONAL INFO: TRUCK HAS 4.6L ENGINE, AUTOMATIC TRANSMISSION, AND A 3.73 LIMITED SLIP REAR AXLE. *AK
Power train, Exterior lighting, Equipment, May 17, 2004
WHILE DRIVING VEHICLE STOPPED ACCELERATING. VEHICLE WAS TOWED TO THE DEALERSHIP, WHO INDICATED THAT AUTOMATIC TRANSMISSION LINE BROKE. DEALERSHIP REPAIRED THE LINE. A MONTH LATER, THE PROBLEM RECURRED. *AK DEALER ALSO REPLACED FUSE FOR THE BACK-UP SENSOR. ALSO, VEHICLE'S TAIL LIGHTS DOESN'T WORK. *AK