2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: service brakes
122 reports, newest first. Show all
Electrical system, Service brakes, Visibility/wiper, Jun 24, 2025
Electrical malfunction with fuses , problems with brake light, engine light and air bag light . Some fuses blown out after brake light fuse popped wipers don't work at all air bog turns on and off every day not sure why
Service brakes, Jun 23, 2024
I have a suspect that keeps adding air in brake lines of this vehicle. Police gave me permanent case number, but the guy is still breathing. Idk what to do, as he has done it on all our cars and on this F150 about 4 different times. The name of suspect is [XXX] , [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Suspension, Service brakes, Sep 14, 2023
THERE ARE LARGE HOLES IN THE FRAME, AND THE SHACKLES ARE READY TO FALL OFF. SUSPENSION IS FALLING APART. BRAKES ARE NOT SAFE FOR STOPPING POWER FOR THE VEHICLE. MASTERTECH AT ZIEGLER TIRE.
Other or unspecified, Service brakes, Engine, Apr 30, 2023
Truck stalls in traffic. Also when hitting the brake. it stalls in reverse. it stalls while idling. Worst truck ever!! Severe safety issue
Service brakes, Aug 22, 2018
BRAKE MASTER CYLINDER LOST FLUID. LEAK WAS INTO THE BRAKE VACUUM BOOSTER. COULD CAUSE LOSS OF BRAKES IF IT OCCURRED WHILE DRIVING.
Service brakes, Aug 3, 2018
BRAKE PEDAL FADES TO FLOOR REPLACED ABS SAME PROBLEM. NOTICED A LOT OF F150 HAVING BRAKE PROBLEMS. FORD SHOULD STEP UP SAY WE HAVE A PROBLEM. FORDMAN BUT GETTING PISSED OFF. MAY TRY TOYOTA.
Service brakes, Jun 6, 2018
WHEN DRIVING ABS LIGHT COMES ON AND THE BRAKES WON'T WORK PROPERLY
Steering, Wheels, Service brakes, May 11, 2018
TRUCK WAS SOLD WITH DEFECTIVE PARTS ON THE DRIVER SIDE OF VEHICLE. STEERING KNUCKLE, ABS SENSORS, ETC. HAVING TO BE REPLACED 2 WEEKS AFTER BUYING. REPAIR SHOP SAID VEHICLE WAS NOT MAINTAINED, SOLD IN THIS CONDITION WHEN IT COULD'VE BEEN NOTICED AND FIXED. WHILE DRIVING A WEEK AFTER PURCHASE TRUCK LOST STEERING AND BRAKING FUNCTIONALITY ON THE HIGHWAY AND HAD TO BE PULLED TO THE SIDE OF THE ROAD.. TOWED TO MECHANIC, OILS NOT BE DRIVEN
Suspension, Other or unspecified, Service brakes, Nov 14, 2017
WHEN BRAKING SPRINGS MADE NOISE AND IT TAKES SEVERAL BRAKES TO STOP.
Other or unspecified, Service brakes, Fuel/propulsion system, Jul 18, 2016, fire
I WAS PULLING A TRAILER OVER THE CONTINENTAL DIVIDE WITH MY FAMILY AND STOPPED TO GET GAS IN LEADVILLE, COLORADO. AS I WAS PUMPING GAS I SAW SMOKE COMING FROM UNDER MY TRUCK BED. I LOOKED UNDER THE TRUCK AND SAW FLAMES NEAR MY SPARE TIRE. I STOPPED PUMPING GAS AND RAN TO GET A FIRE EXTINGUISHER. AFTER THE FIRE WAS OUT I OBSERVED THAT MY TAIL-PIPE HAD BROKEN AWAY FROM MY MUFFLER. THE HEAT FROM MY EXHAUST HAD MELTED THE RUBBER COATING ON MY REAR RIGHT BRAKE CABLE. THE HEAT HAD ALSO MELTED SOME PLASTIC NEAR MY SPARE TIRE. THE MECHANIC IN LEADVILLE WHO WELDED MY TAIL PIPE BACK TO THE MUFFLER TOLD ME THE MELTED PLASTIC CAME FROM AN EVAPORATIVE FUEL EMISSIONS SYSTEM MOUNTED NEAR MY SPARE TIRE. (BAD PLACE TO PUT IT IF YOU ASK ME) MY TRUCK BED-LINER ALSO STARTED TO MELT FROM THE HEAT. I CALLED FORD TO NOTIFY THEM OF THE SAFETY PROBLEM AND THEY ONLY RECOMMENDED THAT I TAKE IT TO A FORD DEALER AND HAVE IT LOOKED AT. I DOUBT I WILL EVER HEAR FROM THEM AGAIN. I'M NOT GOING TO PAY OUT OF MY POCKET TO HAVE THIS PROBLEM OFFICIALLY DIAGNOSED. I GUESS I'M JUST LUCKY TO BE ALIVE AND THAT THE WHOLE GAS STATION DIDN'T BLOW UP.
Service brakes, Hydraulic, May 23, 2016
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH AND ATTEMPTING TO SLOW DOWN, THE BRAKES FAILED TO ENGAGE. THE CONTACT DISCOVERED THAT THE BRAKE VACUUM HOSE SEPARATED DUE TO A DEFECTIVE CLAMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS 226,000. ....UPDATED 07/05/16 *BF *CN
Service brakes, Mar 25, 2016
MASTER CYLINDER LEAKED BRAKE FLUID INTO BOOSTER (JUST LIKE THE CURRENT INVESTIGATION ON FOOD F150) . CAUSING SUDDEN LOSS OF BRAKING ABILITY WHILE DRIVING. NEARLY CAUSED A WRECK. $700 SPENT ON REPAIRS.
Vehicle speed control, Service brakes, Mar 8, 2016
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE INVOLUNTARY ACCELERATED. IN ADDITION, THE BRAKE SYSTEM FAILED. THE CONTACT HAD TO SWITCH THE VEHICLE TO NEUTRAL AND THE RPMS INCREASED. THE CONTACT HAD TO PULL OVER TO THE SIDE OF THE ROAD TO A COMPLETE STOP. THE CONTACT PULLED THE FUSES TO THE THROTTLE AND CRUISE CONTROL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED EVEN WITH THE CRUISE CONTROL DEACTIVATED. THE CONTACT RECURRED SEVEN OTHER TIMES. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.
Service brakes, Mar 4, 2016
HARD BRAKE PEDAL , ROUGH IDLING CHECK ENGINE LIGHT WENT TO STEP ON BRAKES IT WAS A HARD BRAKE PEDAL HAD TO TAKE IT OUT OF GEAR TRIED USING 2 FEET TO PRESS ENDED UP USING EMERGENCY BRAKE TO STOP. CHECKED BRAKE BOOST LINE HAVE NO VACUUM ON LINE CAN PUSH AIR IN AND HEAR IT BEHIND THE MANIFOLD.
Service brakes, Mar 4, 2016
WHILE DRIVING, I TRIED TO STOP AND BRAKE PEDAL WENT TO FLOOR AND I HAD NO BRAKES.I HAD TO USE PARKING BRAKE TO STOP AND AVOID AN ACCIDENT. FORD DEALER TECH. SAID THE BRAKE FLUID WAS REMOVED FROM MASTER CYL.TO BRAKE BOOSTER DUE TO FAULTY SEAL.
Air bags, Vehicle speed control, Service brakes, Nov 6, 2015, crash
TL* THE CONTACT OWNED A 2004 FORD F-150. AFTER THE GEAR SHIFT WAS SWITCHED INTO THE DRIVE POSITION WITH THE BRAKE PEDAL ENGAGED, THE VEHICLE ACCELERATED INDEPENDENTLY. AS A RESULT, THE CONTACT CRASHED INTO A DITCH AND THE VEHICLE ROLLED OVER MULTIPLE TIMES. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A BROKEN HAND AND ARM, A SEVERED FINGER, AND BRUISING ON THE BODY THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Service brakes, Oct 27, 2015
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE THE VEHICLE WAS PARKED, THE BRAKE LINES FRACTURED MORE THAN TWICE. THE CONTACT MENTIONED THAT THE BRAKE LINES HAD EXTENSIVE RUST AND CORROSION. THE CONTACT STATED THAT THE REAR DRIVER SIDE BRAKE LINE FRACTURED ON THE FIRST OCCASION. ON THE SECOND OCCASION, THE REAR PASSENGER SIDE BRAKE LINE FRACTURED. THE PARTS WERE REPLACED, BUT THE FAILURE RECURRED WITH BOTH REAR BRAKE LINES. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Service brakes, Jun 23, 2015
ABS BRAKE SYSTEM. MY BRAKE SYSTEM BEGAN TO FAIL IN MAY 2015 AND HAS DONE IT EVER SINCE. WHEN I PUSH THE BRAKE PEDAL BRAKES FADE TO FLOOR. I HAVE NEARLY HAD SEVERAL ACCIDENTS DUE TO BRAKE FAILURE. I TOOK IT TO MY LOCAL DEALER (SACKELARIS FORD IN CAMDENTON, MO) AND THEY ANALYZED IT FOR AN OUTRAGEOUS FEE AND STATED THE PROBLEM WAS EITHER THE MASTER CYLINDER OR THE HAYDRAULIC CONTROL UNIT ON ABS. I HAD THE MASTER CYLINDER REPLACED WITH A NEW MC AND IT HASN'T HELPED. MY BRAKE PEDAL STILL FADES TO FLOOR. I CHECKED ON THE INTERNET TO SEE IF THIS PROBLEM WAS A 2004 F150 F4 COMMON PROBLEM. IT IS AND A SHOCKING PERVASIVE ONE. NUMEROUS ACCOUNTS OF THIS PROBLEM WERE POSTED ON THE INTERNET. SO I ASKED THE DEALER IF THERE WERE ANY RECALLS FOR THIS AND THERE ISN'T. I CALLED THE FORD CUSTOMER SERVICE DEPARTMENT AND THEY CORROBORATED THERE WERE NO RECALLS. MY MECHANIC STATED THERE WAS A THECNICAL SERVICE BULLETIN FOR THIS REOCCURING PROBLEM (TSB REFERENCE # 17750, NHTSA REFERENCE # 10008234) AND FORD SHOULD FIX IT UP TO 100,000 MILES. I AGAIN CONTACTED THE FORD CUSTOMER SERVICE DEPARTMENT AND THEY AT FIRST DENIED THE TSB. ON A SUBSEQUENT CALL I GAVE THEM THE TSB NUMBER AND THEY STATED IT DID NOT COVER PAYMENT FOR THE REPAIR. THIS IS A FRIGHTENING EXPERIENCE AND I AM AMAZED THERE HASN'T BEEN A RECALL ON THE ABS ISSUE. I WILL NOT DRIVE MY TRUCK UNTIL I CAN GET THIS REPAIRED. THE ABS SYSTEM IS SUPPLIED BY BOSCH.
Service brakes, Hydraulic, Structure, Mar 6, 2015
2004 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME RUST PROBLEMS. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE VEHICLE HAD TO BE TOWED TO THE REPAIR SHOP, BECAUSE THE BRAKES WENT OUT. THE REAR BRAKE LINES, HOSES, CALIPERS, MASTER CYLINDER AND PADS WERE REPLACED. UPDATED 03/09/15. *JB
Service brakes, Aug 18, 2014
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE SERVICE ENGINE SENSOR ILLUMINATED INTERMITTENTLY AND THE BRAKES FAILED TO WORK WHEN THE BRAKE PEDAL WAS APPLIED. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL TO COMPLETELY STOP THE VEHICLE. THE BRAKE PEDAL WAS DIFFICULT TO DEPRESS TO NO AVAIL. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
Suspension, Wheels, Service brakes, Jun 20, 2014
IM SURE OF THE EXACT DATE ORIGINALLY BOUGHT MY TRUCK IN 2004 BRAND NEW WITH 60 MILES ON IT I HAD IT LESS THAN A WEEK AND THEY REPLACED THE TIRES AND TOLD ME IT WAS BECAUSE THEY WERE EGG SHAPED. AND THIS IS WHY IT SHOOK OR VIBRATED AT 55/70 MPH IT WENT AWAY FOR AWHILE. THEN I KEPT ROUTINE OIL AND TIRE ROTATIONS AND BALANCING ON IT BUT THE VIBRATION KEPT COMING BACK. THE REAR BRAKES WERE REPLACE ON THE TRUCK WITH LESS THAN 30,000 MILES COST ME A FORTUNE WHICH ARE SUPPOSED TO LAST UNTIL 150,000. THE SHOCKS, STRUTS, BRAKES, AND ROTORS AND BEARINGS WERE ALL REPLACES TWICE NOW FIRST FOR VIBRATION IN 2007/2008 SPENT THOUSANDS DIDN'T WORK REPLACED TIRES AND RIMS WENT AWAY FOR ABOUT SIX MONTH THEN CAME BACK AGAIN EVERY TIME WE ROTATE THE TIRES THE VIBRATION GOES AWAY FOR LIKE A DAY OR TWO THEN COMES BACK IN 2010 I HAD TO REPLACE THE REAR BRAKE AND EMERGENCY BRAKE AND BEARINGS AND SEALS FOR A SECOND TIME BECAUSE THEY LOCKED UP IN 2011 I HAVE REPLACED THE BRAKES, SHOCKS, ROTORS AND STRUTS, BECAUSE OF VIBRATION GUESS WHAT DIDN'T WORK NOW WERE LOOKING AT TIRES AND RIMS AGAIN AND FORD TELLS ME THAT MY REAR SEALS AND BEARINGS NEED REPLACED FOR LEAKAGE AND THE POSSIBLE SHAKING IS MY DRIVE SHAFT I BOUGHT A 30,000 TRUCK THAT I HAVE PUT 10,000 GRAND IN JUST ESTIMATING OH AND THEY JUST FIXED THE RECALL FOR THE AIRBAG HARNESS AND TELL ME THE AIRBAG LIGHT IS FLASHING BUT IT ISN'T COVERED IN THE RECALL AND IT WASN'T FLASHING WHEN I DROPPED IT OFF. I HAVE TWO FORDS I HAVE A FORD ESCAPE I BOUGHT AT THE SAME DEALER IN 2005 THAT THEY KEPT A REVOLVING DOOR FOR IN SERVICE BECAUSE OF ALL ITS PROBLEMS AND EVERYONE TELLS ME IT SHOULD HAVE BEEN REPLACED I WILL NEVER BUY ANOTHER FORD AGAIN NOW I KNOW WHY PEOPLE JOKE ABOUT THE FIX OR REPAIR DAILY. *TR
Service brakes, May 1, 2014
IT APPEARS THAT THERE WAS AN ISSUE WITH THE PARKING BRAKE LINKAGE. THERE HAD BEEN SMALL NOTICEABLE SHIMMY WITH THE BRAKES, WHICH HAVING BEEN FAIRLY RECENTLY REPLACED, DID CONCERN ME. HOWEVER, ON THE WAY HOME, I TAPPED THE BRAKE AT APPROX 35 MPH, I GOT A VERY LARGE CLUNK IN THE REAR. I CONTINUED TO DRIVE, VERY CONCERNED OVER WHAT MAY HAVE OCCURRED. HOWEVER, I WAS ON OPEN ROAD, 40 MILES FROM HOME. AS I CONTINUED TO DRIVE, I COULD TELL THERE WERE MAJOR ISSUES. IT WAS BAD WEATHER, AND I WAS IN MIDDLE OF NOWHERE. I CONTINUED HOME TO MY REPAIR SHOP. THEY INFORMED ME THE NEXT DAY, THAT THE PARKING BRAKE LINKAGE GOT FOULED UP, WRAPPED AROUND A BRAKE OR SOMETHING, EVENTUALLY TEARING IT ALL UP. THIS IS COSTING ME APPROX $500 TO REPLACE. AFTER RESEARCH, I SEE A TSB 08-11-1 WAS ISSUED. WHY NOT OWNERS NOTIFIED? THIS IS AN ISSUE THAT SHOULD HAVE BEEN SENT TO OWNERS FOR A FIX. I BLAME FORD. *TR
Service brakes, Aug 7, 2013
I HAD TO REPLACE MY BRAKE ROTORS AND CALIPERS DUE TO CORROSION AFTER ONLY 18000 MILES, AND AGAIN AFTER ABOUT 35,000 AND 60,000 MILES DUE TO CORROSION. ON TWO OCCASION, THIS PROBLEM WAS DISCOVERED WHEN THE BRAKES COMPLETELY LOCKED UP AND THE VEHICLE COULD NOT MOVE. MUCH OF MY DRIVING IS ON SNOW-COVERED ROADS WITH ROAD SALT, BUT I ROUTINELY USE A CAR WASH WITH UNDERCARRIAGE WASH FREQUENTLY -- ABOUT ONCE PER WEEK. IS THERE NO TECHNOLOGY TO INCREASE THE CORROSION RESISTANCE OF THESE CRITICAL SAFETY PARTS? *TR
Electrical system, Exterior lighting, Service brakes, Aug 4, 2013
I OWN A 2004 FORD F-150. IN 2012 I HAD MY E-BRAKE LIGHT START FLASHING AT ME. I BROUGHT IT INTO THE MECHANIC AND HAD THEM LOOK IT OVER, THEY SAID THEY COULDN'T FIND ANYTHING WRONG OTHER THEN THE WIRING UNDER THE DASH WAS PROBABLY BAD, SO I BROUGHT IT TO A BRAKE SPECIALIST AND THEY SAID THE SAME THING, NOTHING WRONG WITH CYLINDER OR BRAKES, THAT IT WAS THE WIRING UNDER THE DASH. I'M TRULY NOT SAFE USING MY E-BRAKE AS I'M NOT SURE IF IT IS WORKING OR NOT. MY INTERIOR LIGHTS STARTED COMING ON ALSO WHEN I WOULD TURN ON MY HEADLIGHTS, EVERYONE KNOWS YOU SHOULDN'T HAVE THE INTERIOR LIGHTS ON WHILE DRIVING AT NIGHT ANYWAY. I HAVE READ SEVERAL ARTICLES WHERE OTHER FORD F-150 OWNERS ARE HAVING THE SAME PROBLEMS. I THINK THIS NEEDS TO BE LOOKED INTO AND A RECALL SHOULD GO OUT. *TR
Service brakes, Jul 9, 2013
I HAVE HAD BRAKE PROBLEMS SINCE VEHICLE WAS PURCHASED. THE LATEST IS THE BRAKES LOCKING UP (MOSTLY FRONT) AND THE WHEELS GETTING SO HOT YOU CAN SMELL THEM BURNING AND YOU CAN'T TOUCH THE WHEEL. I HAVE HAD THE VEHICLE SERVICED SEVERAL TIMES AT SEVERAL DIFFERENT SERVICE STATIONS STARTING AT THE DEALER AND THE PROBLEM KEEPS RETURNING. I HAVE HAD NEW ROTORS INSTALLED SEVERAL TIMES (5), NEW CALIPERS TWICE, NEW BRAKE HOSES, FLUSH AND FILL BRAKE FLUID AND HAD THE MASTER CYLINDER PUSH ROD ADJUSTED ONLY TO HAVE THE SAME PROBLEM CONTINUE. I HAVE LOOKED ONLINE AT THE FORUMS ABOUT F-150'S AND I AM NOT ALONE AND NO ONE HAS ANY ANSWERS. I EMAILED FORD ASKING FOR HELP AND THEY ADVISED ME TO SEE THE DEALER WHICH I ALREADY HAVE SEVERAL TIMES AND EVERY TIME THEY SAY THEY CAN'T DUPLICATE THE PROBLEM AND THE LAST TIME THEY ADJUSTED THE PUSH ROD WHICH LASTED A LITTLE WHILE. I HAVE SPENT THOUSANDS TRYING TO FIX THIS PROBLEM AND I'M AFRAID TO DRIVE IT. *TR