2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: structure
104 reports, newest first. Show all
Structure, Nov 14, 2016
MY TRUCK HAS 106,XXX MILES ON IT. I HAVE ONLY OWNED IT FOR 9 MONTHS. I TOOK IT TO THE SHOP FOR A REPAIR AND WAS TOLD THE FRAME WAS SO ROTTEN OUT THEY COULDN'T PUT IT ON THE LIFT.
Structure, Nov 10, 2016
WITHIN A COUPLE YEARS OF MANUFACTURE NOTICED OXIDATION APPEARING ON UNDERSIDE OF HOOD, AND SOME PAINT BLISTERING ON FRONT EDGE OF UPPER SIDE OF HOOD. THESE ISSUES HAVE WORSENED OVER TIME
Structure, Nov 10, 2016
MY TRUCK HAS ALWAYS BEEN WELL TAKEN CARE OF HAS 92, 000 MILES ON IT WHICH IS VERY LOW ON A 2004. IT WAS ALWAYS SERVICED AT THE DEALER WHERE WE PURCHASED THE TRUCK. I HAD 2 EXTENDED SERVICE WARRANTIES THROUGH THIS DEALER. THERE IS NO RUST ON THE BODY AT ALL. I TOOK IT TO ANOTHER GARAGE TO HAVE SOME WORK DONE ON IT AND WHEN THEY PUT IT ON THE LIFT THE BOX ON THE TRUCK STARTED TO PULL AWAY FROM THE CAB. WHEN IT WAS LOWERED, AND INSPECTED THE FRAME ON BOTH SIDES OF THE TRUCK WAS COMPLETELY ROTTED THRU. I HAD NO IDEA THAT IT WAS THIS BAD. THE FRAME MUST BE COMPLETELY RECONSTRUCTED AND OF COURSE FORD AND THE DEALER DON'T WANT TO TAKE ANY RESPONSIBILITY FOR IT. SOMEONE COULD HAVE BEEN KILLED NOT KNOWING THE SEVERITY OF THE FRAME. I DEPENDED ON FORD TO CONSTRUCT A SAFE VEHICLE AND FOR THE DEALER TO SERVICE MY TRUCK IN GOOD FAITH. PEOPLE SHOULD BE REIMBURSED BY FORD TO GET THE PROBLEM FIXED AND FOR THEIR LACK OF A QUALITY PRODUCT AND SERVICE. SOMETHING NEEDS TO BE DONE BEFORE SOMEONE LOSES THEIR LIFE.
Structure, Oct 10, 2016
FRAME RUSTED IN HALF,
Structure, Aug 22, 2016
HOOD PAINT AND ROOF PAINT PEELING UP FOR THE LAST 7 YEARS. IT STARTED WITH SMALL BLISTERING AND WHAT APPEARED TO BE JUST A FEW KNICKS ON THE HOOD. HOWEVER IT QUICKLY SPREAD AND THE ENTIRE HOOD AS WELL AS ROOF ARE IN NEED OF A PAINT JOB DUE TO RUST. I AM THE ORIGINAL OWNER AND HAVE APPS 129000 MILES ON IT.
Structure, Aug 1, 2016
THE FRAME UNDER MY F150 IS RUSTED THROUGH. I ONLY HAVE 81K MILES ON IT AND I DON'T UNDERSTAND WHY THE FRAME IS RUSTING SO BADLY. IT HAS ALREADY COST ME 2,400 TO HAVE A CERTIFIED WELDER REPLACE SOME OF THE SECTIONS THAT WERE RUSTED OUT. I KNOW JUST FOUND ANOTHER PART OF THE FRAME THAT IS RUSTED UNDER THE LEAF SPRING. THAT IS NOW GOING TO COST ME ANOTHER $500.00.
Suspension, Structure, Mar 24, 2016
FRAME RUSTING OUT PREMATURELY CAUSING A SAFETY HAZARD.
Structure, Wheels, Nov 3, 2015
BOTH REAR SUICIDE DOORS WILL NOT OPEN, THE LATCH MECHANISM IS BROKEN AND APPARENTLY COST OVER $700.00 TO FIX BOTH. IN ADDITION I HAVE REPLACED THE WHEEL BEARING ON ALL WHEELS TWICE AND NOW ANOTHER ONE IS GOING BAD. IT SEEMS LIKE I NEVER HAVE A PERIOD WHEN ALL THE BEARINGS ARE GOOD.
Structure, Nov 1, 2015
THE FRAME OF MY 2004 F150 IS ALMOST COMPLETELY ROTTEN FROM THE FRONT OF THE LEAF SPRING ALL THE WAY UP TO THE DRIVERS DOOR. THE BED SUPPORTS ARE ALSO ROTTED COMPLETELY OFF MAKING THE BED UNSAFE AND UNABLE TO USE.
Structure, Other or unspecified, Jul 28, 2015
DURING AN OIL CHANGE IT WAS NOTICED THAT THE LEFT HAND FRONT DIFFERENTIAL MOUNTING BRACKET APPEARED TO HAVE A CRACK PURSUANT WITH TSB 06-11-12. HOWEVER UPON CLOSER EXAMINATION IT WAS SHOWN THAT THE DAMAGE WAS MORE EXTENSIVE THEN THE "CONCERN OF THE LEFT HAND FRONT DIFFERENTIAL MOUNTING BRACKET SEPARATING FROM THE FRAME RAIL." MENTION IN THE TSB. INSTEAD OF THE AFOREMENTIONED MOUNT BREAKING, A SECTION OF THE FRAME APPROXIMATELY 1/4 OF AN INCH AROUND THE WELDS FOR THE DIFFERENTIAL MOUNT ON ALL SIDES HAD SEPARATED FROM THE REST OF THE FRAME LEAVING A HOLE IN THE FRAME APPROXIMATELY FOUR INCHES ACROSS.
Structure, Mar 24, 2015
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THERE WAS RUST FORMING ON THE REAR DRIVER AND PASSENGER SIDE TIRE WELLS. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE REAR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,800.
Suspension, Structure, Mar 20, 2015
I OWN A 2004 FORD HERITAGE 4X4 AND THE FRAME IS LITERALLY RUSTING AWAY ON OR ABOUT THE 10TH OF MARCH THE BRACKET THAT HOLDS THE REAR DRIVER SIDE LEAF SPRING ROTTED AWAY AND PUNCHED THROUGH THE BOTTOM OF MY BED. I WAS ONLY GOING 30 WHEN IT HAPPENED SO EVERYONE WAS SAFE. I ALSO HAD TO REPLACE THE TRAILER HITCH LAST YEAR BECAUSE THE FRAME WAS SO ROTTED AWAY. I STOPPED AT A STOP SIGN AND WHEN I WENT TO GO I SAW MY TRAILER JUST GO UP AND SLAM BACK DOWN ON THE GROUND. LUCKILY I WAS NOT GOING 65 MPH OTHERWISE I WOULD HAVE HAD A ACCIDENT. THE BACK OF THE FRAME NOW IS PAPER THIN. FORD SHOULD DO A RECALL ON THESE FRAMES. I HAVE OWNED MANY FORD AND NEVER HAD RUST THIS BAD. *TR
Service brakes, Hydraulic, Structure, Mar 6, 2015
2004 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME RUST PROBLEMS. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE VEHICLE HAD TO BE TOWED TO THE REPAIR SHOP, BECAUSE THE BRAKES WENT OUT. THE REAR BRAKE LINES, HOSES, CALIPERS, MASTER CYLINDER AND PADS WERE REPLACED. UPDATED 03/09/15. *JB
Structure, Feb 9, 2015
WHEN IT RAINS WATER COMES IN AND DRIPS ON THE PASSENGER SIDE REAR SEAT. I HAVE REPLACE THE THIRD BRAKE LIGHT LENS TWICE AND THE REAR WINDOW. I HAVE READ FORUMS AND IT SEEMS LIKE THIS PROBLEM IS COMMON. I HAVE A TRUCK THAT SMELLS LIKE MILDEW. I HAVE TO DRIVE IT NOW WITH THE INTERIOR PULLED OUT. *TR
Visibility, Structure, Nov 8, 2014
THE MIRROR(S) ARE FULL OF CORROSION AND THE DRIVERS SIDE MIRROR FELL RIGHT OFF THE CAR WHILE DRIVING. *TR
Structure, Nov 3, 2014
MY TRUCK IS ONLY 10 YEARS OLD AND THE FRAME IS ALL ROTTEN OUT I THINK IT IS A VERY SERIOUS THING IF YOU ARE DRIVING ALONG AND IT BREAKS. *TR
Suspension, Structure, Oct 13, 2014
I TOOK MY TRUCK TO A GARAGE TO HAVE THE OIL CHANGED. WHILE UP ON THE RACK THE RUST WAS NOTICED BY MY MECHANIC WHO SAID IT WOULD NOT PASS INSPECTION BETTER HAVE IT FIXED. I CONTACTED A PROFESSIONAL WHO CAME TO MY HOUSE AND LOOKED AT IT WITH THE BED OFF. UPON HIS INSPECTION HE FOUND IT WAS UNREPAIRABLE THERE WAS NOT ENOUGH ORIGINAL METAL LEFT TO WELD TO. I HAVE CONTACTED FORD CUSTOMER RELATIONSHIP CENTER ONLY TO BE TOLD THERE IS NO WARRANTY, NO RECALL, SORRY FOR YOUR LUCK AND GOT HUNG UP ON. WHILE RESEARCHING ONLINE I HAVE DISCOVERED THAT FORD HAS A RECALL ON 2004 ESCAPES FOR THIS VERY SAME REASON "THE FRAMES ARE RUSTING OUT" IT WOULD MAKE SENSE TO ME THAT THERE MUST HAVE BEEN A BAD BATCH OF METAL USED IN THE BUILDING OF THESE FRAMES. I WOULD LIKE TO KNOW IF ANY MORE 2004 VEHICLES FROM FORD HAVE REPORTED SIMILAR PROBLEMS AND WHAT CAN WE DO ABOUT THIS? *TR
Suspension, Structure, Oct 6, 2014
-REPAIR SHOP-2004 FORD F150 CREW CAB, FRAME COMPLETELY ROTTED THROUGH, FRAME REPLACEMENT REQUIRED. CUSTOMER WILL NOT HAVE REPAIRED. *TR
Structure, Apr 28, 2014
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE FRAME MEMBERS WERE EXTREMELY CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 109,000.
Steering, Suspension, Structure, Nov 17, 2013
VEHICLE'S BACK WINDOW LEAK NOTED WITHIN 60 DAYS AFTER PURCHASE, RESEALED BY DEALER X2-STILL LEAKS. WITHIN A PERIOD OF ONE YEAR AFTER PURCHASE, THREE OF THE FOUR WINDOW GEAR BOXES WERE REPLACED DUE TO FAILURE. I'VE NOTED SEVERAL COMPLAINTS ABOUT THESE ISSUES, MET OTHER OWNERS WHO HAVE HAD THESE ISSUES FIXED UNDER WARRANTY, YET WE WERE REQUIRED TO PAY FOR REPAIR. AT HIGHWAY SPEEDS, 65MPH, THE VEHICLE BEGINS TO SHIMMY, VIBRATE AND BECOMES DIFFICULT TO MAINTAIN CONTROL OF STEERING. VIBRATION MAKES RIDE UNPLEASANT AND NOISY. *TR
Structure, May 15, 2013
WHEN DRIVING AT RELATIVELY LOW SPEED, THE HOOD LIFTED VIOLENTLY. THE DRIVER WAS ABLE TO STOP THE TRUCK SAFELY. THE PORTION OF THE HOOD WHICH SECURES THE HOOD STRIKER GAVE WAY, ALLOWING THE HOOD TO OPEN SO VIOLENTLY THAT THE GRILLE FLEW OFF. THE HOOD WAS PROPERLY CLOSED/LATCHED BEFORE THE INCIDENT, AND THE STRIKER WAS STILL IN THE LATCH (COMPLETE WITH PIECES OF ALUMINUM TORN OFF OF THE HOOD) AFTER THE INCIDENT. IT APPEARS THAT GALVANIC CORROSION (STEEL STRIKER ON ALUMINUM HOOD) LIKELY CAUSED THE ISSUE. SINCE THIS TRUCK IS IN A FLEET, THE REMAINDER OF THE F-150S OF THE SAME BODY STYLE (MY2008 AND OLDER) WERE CHECKED, 65 OF 580 TRUCKS HAD EITHER CRACKING OR CORROSION AROUND THE STRIKER BAR WHICH MAY LEAD TO THIS ISSUE. NOTE - THIS IS AN ONTARIO, CANADA FLEET BUT THESE ISSUES LIKELY AFFECT US-SOLD VEHICLES. *TR
Structure, Vehicle speed control, Tires, Fuel/propulsion system, Nov 2, 2012
WHILE ATTEMPTING TO ACCELERATE ONTO A HIGHWAY MY VEHICLE SPUTTERED AND I WAS UNABLE TO GET UP TO SPEED IN A REASONABLE AMOUNT OF TIME. FORTUNATELY I WAS ON A 4 LANE HIGHWAY AND THE APPROACHING VEHICLES WERE ABLE TO AVOID ME BY PULLING INTO THE PASSING LANE. I BROUGHT MY VEHICLE IN FOR SERVICE AND A CORRODED FUEL PUMP CONTROL MODULE WAS RESPONSIBLE FOR THE HESITATION. ACCORDING TO MY MECHANIC, HE CATEGORIZED THE PROBLEM AS DEFECTIVE DESIGN. THE MODULE IS MOUNTED IN A AREA SUSCEPTIBLE TO CORROSION. THIS IS A RELATIVELY EASY FIX HOWEVER IN MY CASE THE SPARE TIRE CARRIER HAD TO CUT OFF TO ACCESS THE MODULE. *TR
Structure, Aug 15, 2012
RUST IN THE REAR PASSENGER QUARTER PANEL DUE TO A KNOW FACTORY DEFECT OF A RUBBER PAD BEING INSTALLED IMPROPERLY, CONTACTED FORD ABOUT THE PROBLEM, THEY REFUSE TO REPAIR OR ASSIST IN ANY WAY. *TR
Structure, Aug 15, 2012
REAR PASSENGER SIDE QUARTER PANEL RUST DUE TO RUBBER PANEL BEING IMPROPERLY INSTALLED AT FACTORY. FULL RUST THROUGH IN THE MIDDLE OF THE PANEL, FROM THE INSIDE OUT. *TR
Visibility, Structure, Aug 11, 2012
WAS DRIVING DOWN THE ROAD AT APPROXIMATELY 55 MPH AND THE LEFT DRIVER'S SIDE WINDOW CAME CRASHING DOWN. I THOUGHT A ROCK WAS COMING THROUGH THE WINDOW AND ALMOST WENT OFF THE ROAD. *TR