2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: suspension
118 reports, newest first. Show all
Suspension, Apr 23, 2014
TL* THE CONTACT OWNS A 2004 FORD F150. THE CONTACT STATED THAT BOTH FRONT SUSPENSION SPRINGS WERE BROKEN. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 93,000.
Suspension, Feb 4, 2014
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED, THE TECHNICIAN DISCOVERED THAT BOTH FRONT COIL SPRINGS WERE FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 90,000.
Suspension, Jan 3, 2014
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THERE WAS A RECURRING FAILURE OF THE HUB AND CALIPERS AS WELL AS THE FRONT AND REAR AXLE SPORADICALLY BECOMING FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 79,000. *TR
Suspension, Dec 2, 2013
ON PREPARING TO CHANGE THE BRAKE PADS, I NOTICED THE FRONT LEFT COIL SPRING HAS SNAPPED. AFTER CHECKING ON LINE AND MY LOCAL FORD DEALERSHIP, IT SEEMS THIS IS NOT UNCOMMON ON 2004 FORD F150 VEHICLES, AND IT INDICATES THAT FORD IS NOT PREPARED TO ASSIST CUSTOMERS, EVEN THOUGH THEY REALIZE THIS IS A MANUFACTURING DEFECT. PHOTOGRAPH AVAILABLE IF NEEDED. THE FORD DEALERSHIP ADVISES THEY NEED TO REPLACE BOTH FRONT ROAD SPRINGS AT A COST OF $575.00, BUT THE SHOCK ABSORBERS MIGHT NEED REPLACING ALSO WHICH WOULD BE ADDITIONAL MONIES. A BROKEN ROAD SPRING ON THE FRONT CAN SEVERELY EFFECT THE HANDLING AND SAFETY OF THE DRIVER AND OTHERS ON THE ROAD, AND I BELIEVE FORD SHOULD DO SOMETHING ABOUT IT. *TR
Steering, Suspension, Structure, Nov 17, 2013
VEHICLE'S BACK WINDOW LEAK NOTED WITHIN 60 DAYS AFTER PURCHASE, RESEALED BY DEALER X2-STILL LEAKS. WITHIN A PERIOD OF ONE YEAR AFTER PURCHASE, THREE OF THE FOUR WINDOW GEAR BOXES WERE REPLACED DUE TO FAILURE. I'VE NOTED SEVERAL COMPLAINTS ABOUT THESE ISSUES, MET OTHER OWNERS WHO HAVE HAD THESE ISSUES FIXED UNDER WARRANTY, YET WE WERE REQUIRED TO PAY FOR REPAIR. AT HIGHWAY SPEEDS, 65MPH, THE VEHICLE BEGINS TO SHIMMY, VIBRATE AND BECOMES DIFFICULT TO MAINTAIN CONTROL OF STEERING. VIBRATION MAKES RIDE UNPLEASANT AND NOISY. *TR
Suspension, Jul 30, 2013
BROUGHT TRUCK IN FOR SERVICE DUE TO HIT PULLING TO THE RIGHT AND SEEMED TO BE SITTING LOW. WHEN THE DEALERSHIP REMOVED FRONT WHEELS IT WAS DISCOVERED THE BOTH FRONT COIL SPRINGS HAD BEEN BROKEN. BOTH SPRINGS WERE BROKEN DIAGONAL AT THE BASE WHERE IT SITS IN THE STRUT. WAS TOLD THAT THE SPRINGS NEEDED TO BE REPLACED IN ORDER FOR A PROPER ALIGNMENT TO BE COMPLETED. FURTHER RESEARCH ONLINE SHOWS THAT THIS IS A VERY COMMON ISSUE IN THE FORD F-150. TRUCK HAS NEVER BEEN TAKEN OFF ROAD OR DRIVEN HARD. TRUCK IS TAKEN WELL CARE OF. *TR
Suspension, May 14, 2013
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICE FOR REGULAR MAINTENANCE, THE DEALER DIAGNOSED THAT THE REAR AXLE NEEDED TO BE REPLACED DUE TO A DESIGN FLAW. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,938. *TR
Steering, Suspension, Mar 19, 2013
DRIVING ON THE INTERSTATE @ 55MPH THE TRUCK HAS A VIBRATION -BEGINS TO SHAKE- RETURNED TO DEALER NO PROBLEM FOUND, THIS STORY GOES ON AND ON I HAVE REPLACED OUT OF MY POCKET ROTORS, CALIBERS TWO WHOLE SET OF TIRES AND STILL TO THIS DAY IS STILL WILL SHAKE @ AND AROUND 52 MPH TO 57 MPH NOBODY WILL HELP ME FIND THE PROBLEM NOW IT IS OUT OF WARRANTY FORD DOESN'T CARE. *TR
Suspension, May 9, 2012
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING APPROXIMATELY 42 MPH, THE CONTACT NOTICED THE FRONT END OF THE VEHICLE BEGAN TO SHAKE ABNORMALLY. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE FRONT COIL SPRINGS WERE FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.
Suspension, Feb 2, 2012
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS HAVING UNRELATED REPAIRS PERFORMED BY AN AUTHORIZED DEALER, WHEN THE DEALER STATED THAT THE FRONT END COULD NOT BE ALIGNED PROPERLY BECAUSE THE BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 24,500. THE VIN WAS NOT AVAILABLE.
Suspension, Feb 1, 2012
WHILE MY TRUCK WAS BEING SERVICED, IT WAS BROUGHT TO MY ATTENTION THAT I HAD A BROKEN FRONT PASSENGER SIDE COIL SPRING. THEIR WAS A 2 INCH PIECE OF COIL SPRING HANGING ON BY THE PLASTIC COVERING OF THE SPRING. THE PIECE WAS CORRODED, WHICH TELLS ME THAT IT HAD BEEN BROKEN FOR SOME TIME. I HAVE NOTICED ONLINE THAT THIS IS NOT A UNCOMMON OCCURRENCE. *TR
Suspension, Service brakes, Hydraulic, Power train, Jan 23, 2012
I'M DRIVING MY TRUCK WHEN ALL OF A SUDDEN IT WILL START VIBRATING HORRIBLY, LIKE DRIVING OVER A WASHBOARD TYPE OF ROAD. THE ONLY WAY TO GET IT TO STOP IS TO PULL OVER TO THE SIDE OF THE HIGHWAY, PUT IT IN PARK, WAIT, AND THEN TRY TO RESUME DRIVING. BUT THIS DOES NOT ALWAYS WORK. YOU SOMETIMES HAVE TO STOP AND CHANGE TO PARK, OR REVERSE, A COUPLE OF TIMES, BEFORE DRIVING AGAIN SO THAT THE VIBRATION GOES AWAY. I HAVE COMPLAINED ABOUT THIS BEFORE, AND I SEE HUNDREDS OF COMPLAINTS FOR THE SAME ISSUE ON "FORD OWNER WEBSITES", AND EVERYBODY IS PISSED. NOBODY CAN GET AN ANSWER FROM FORD SERVICE AS TO WHAT IS WRONG. MANY PEOPLE HAVE REPLACED MANY DIFFERENT THINGS (I.E. TRANSMISSION, CLUTCH PADS, BEARINGS, U-JOINTS, EMERGENCY BRAKE CABLE OR PADS), ALL TO NO AVAIL. THEY HAVE WASTED THEIR TIME AND MONEY, AND FORD REFUSES TO LIVE UP TO THIS AWFUL AND VERY DANGEROUS PROBLEM. APPARENTLY, FORD KNOWS THIS IS A BIG PROBLEM WITH 2004 F-150 TRUCKS, ESPECIALLY, BUT WILL NOT ACKNOWLEDGE IT. SOMEONE WROTE ON THE WEB THAT FORD KNOWS THEY HAD A RETOOLING PROBLEM WITH THESE TRUCKS, AND LET THE TRUCKS GO OUT FOR SALE ANYWAY. I AM NOW HAVING THIS PROBLEM MORE OFTEN, AND I AM AFRAID TO DRIVE IT. I DO NOT HAVE ANY MONEY TO FIX MY TRUCK, SINCE OUR ECONOMY IS SO BAD AND HAVE BEEN UNEMPLOYED FOR YEARS. MAKE FORD TAKE OWNERSHIP OF THIS RECALL PROBLEM! *TR
Suspension, Oct 24, 2011
DURING ACCELERATION THERE IS A SEVERE VIBRATION AND SHAKING. IT ALSO HAPPENS WHEN DRIVING DOWN THE ROAD. THE SHAKING IS SO BAD THAT YOU ALMOST LOSE CONTROL OF THE VEHICLE. *TR
Suspension, Jul 28, 2011
NO EVENT LEADING TO FAILURE - TO MY KNOWLEDGE POOR HANDLING, UNEVEN TIRE WEAR, DISCOVERED BOTH FRONT SPRINGS BROKEN AT 120,000 MILES TRUCK IS USED PRETTY MUCH AS A PASSENGER VEHICLE CURRENTLY REPLACING BOTH FRONT SPRINGS. *TR
Suspension, Jun 9, 2011
TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THE FRONT END OF THE VEHICLE WOULD VIOLENTLY SHAKE WHILE DRIVING APPROXIMATELY 45 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE CONTINUED TO RECUR WHILE DRIVING APPROXIMATELY 45 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED BOTH FRONT COIL SPRINGS WERE FRACTURED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 57,200.
Suspension, Structure, May 31, 2011
2004 FORD F150 SUPERCREW STARTS SHAKING HORRIBLY AT HIGHWAY SPEEDS WHEN PULLING A TRAVEL TRAILER. IT DOESN'T MATTER IF YOU SLOW DOWN, SPEED UP, OR TAKE OUT OF GEAR THE ONLY WAY TO MAKE IT QUIT IS TO COME TO A COMPLETE STOP. THIS HAS HAPPENED 3 TIMES TO ME SO FAR AND IT FEELS AS IF ALL THE WHEELS ARE ABOUT TO FALL OFF. I CALLED MY DEALER AND THEY SAID THAT THEY HAVEN'T HEARD OF THIS PROBLEM, BUT IF YOU DO A SEARCH ON IT THERE IS A LOT OF PEOPLE CONCERNED OF THIS DANGEROUS ISSUE. LUCKILY I HAVEN'T BEEN ON AN INTERSTATE WITH MY TRAVEL TRAILER BECAUSE I WOULD BELIEVE THAT THIS COULD CAUSE ME TO POSSIBLY LOSE CONTROL AT THOSE KIND OF SPEEDS. *TR
Suspension, Feb 28, 2011
MY TRUCK IS A 2004 FORD F150 FX4, THE SUSPENSION ON THE FRONT IS BAD. I BOUGHT IT WITH 65,000 MILES AND IT WAS BAD. I HAVE HAD TO REPLACE IT AFTER NEARLY HITTING A SEMI HEAD-ON AFTER HITTING A BUMP AND IT ABOUT BOUNCED ME OFF OF THE ROAD. THIS HAS BEEN AN ONGOING PROBLEM THAT I COULDN'T FIGURE OUT AT FIRST. I HAVE CALLED FORD CORPORATE OFFICE WITH NO RETURN PHONE CALL. AFTER LOOKING ON THE INTERNET AT THE FORUMS ABOUT THIS TRUCK AND YEAR, I DETERMINED THAT THIS IS COMMON. I DON'T KNOW IF FORD KNOWS BUT THEY SHOULD. IT HAS COST ME OVER $850 TO GET THE SWAY BAR BUSHINGS REPLACED, TIE ROD ENDS, UPPER AND LOWER CONTROL ARM AND SHOCKS. I DRIVE ALOT A MILES IN A YEAR. *TR
Suspension, Nov 14, 2010
WHILE ROTATING THE TIRES ON MY 2004 F-150 I NOTICED THE DRIVERS SIDE FRONT COIL SPRING WAS BROKEN. I THEN LOOKED AT THE PASSENGER SIDE AND SEEN THAT ONE WAS BROKEN ALSO. I WAS BROKE IN THE EXACT SAME SPOT AS THE OTHER ONE. I HAVE NEVER TAKEN THIS TRUCK OFF THE ROAD. IT ONLY HAS 75000 MILES ON IT I THINK THESE SPRINGS SHOULD NOT BE BROKEN AND THERE IS A PROBLEM WITH THEM. WHILE LOOKING ONLINE I NOTICED ALOT OF OTHER PEOPLE WITH THE SAME PROBLEM. *TR
Suspension, Nov 12, 2010
TL*THE CONTACT OWNS A 2004 FORD F-150. WHILE EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE INSIDE OF BOTH FRONT TIRES WAS WEARING UNEVENLY. THE CONTACT REPLACED THE TIRES AND TOOK THE VEHICLE TO AN AUTHORIZED DEALER TO HAVE AN ALIGNMENT PERFORMED. THE CONTACT WAS INFORMED THAT THE ALIGNMENT COULD NOT BE DONE BECAUSE BOTH FRONT BALL JOINTS WERE WORN. THE BALL JOINTS WERE NOT REPLACED BUT THE TIRES WERE BALANCED AND ALIGNED. THE CURRENT AND FAILURE MILEAGES WERE 64,460.
Suspension, Oct 19, 2010
TL*THE CONTACT OWNS A 2004 FORD F150. DURING ROUTINE MAINTENANCE THE MECHANIC NOTICED THAT THE LEFT LOWER CONTROL A-FRAME WAS CRACKED. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHERE THEY CONFIRMED THAT THE LOWER CONTROL ARM WAS CRACKED AND THEY COULD NOT TELL IF IT WAS ONLY CRACKED ON THE SIDE. THEY INFORMED HER THAT SHE WOULD BE RESPONSIBLE FOR THE REPAIR SINCE THERE WAS NO WARRANTY OR RELATED RECALL. THE MANUFACTURER WAS NOTIFIED AND INFORMED HER THERE WAS NOTHING THEY COULD DO SINCE THE WARRANTY HAD EXPIRED. THE FAILURE MILEAGE WAS 23,650. UPDATED 02/09/11*LJ THE CONSUMER STATED FORD FINALLY AGREED TO HELP PAY FOR THE REPAIRS. UPDATED 05/06/11
Suspension, Parking brake, Power train, Feb 19, 2010
MY 2004 FORD F 150 FX 4 REGULAR CAB FLARESIDE PICKUP WHICH CURRENTLY HAS 36,000 MILES HAS A MASSIVE VIBRATION / SHUDDERING WHILE UNDER ACCELERATION PAST FORTY MILES PER HOUR ; I HAVE ALREADY TAKEN THE VEHICLE TO THE DEALER WHERE THEY TOLD ME THAT IT WAS AN EMERGENCY BRAKE PROBLEM AFTER GETTING FIXED THE PROBLEM OCCURRED LESS THAN A WEEK LATER ; IT IS GOING BACK INTO THE DEALER AGAIN TO GET REDIAGNOSED AND COST EVEN MORE MONEY PLEASE MAKE FORD MOTOR COMPANY ACCOUNTABLE FOR THIS ISSUE !!! *TR
Suspension, Parking brake, Oct 3, 2009
I HAVE A 2004 FORD F150 THAT HAS HAD A TERRIBLE VIBRATION AND SHAKING PROBLEM TO THE POINT THAT THE WINDSHIELD WIPERS JUMP UP AND DOWN EVERYTIME I HAVE SAID ANYTHING TO THE DEALERSHIP THEY SAY THEY DONT WHAT IT IS AND THEY HAVEN'T HEARD OF ANYTHING LIKE THIS AND EVEN THE LAST TIME I TOLD THEM IT WAS LIKE SOMETHING WAS SEIZING UP WE WENT ONLINE AND STARTED INVESTIGATING THE PROBLEM AND FOUND THAT ALL KINDS OF PEOPLE ARE HAVING THE SAME PROBLEM AND ALOT OF THEM SEEM TO THINK IT IS IN THE EMERGENCY BRAKE SYSTEM THERE IS TWO METAL PARTS THAT RUST TOGETHER AND WONT LET IT WORK IS THERE ANYTHING I CAN DO ABOUT THIS TO GET FORD TO REPLACE IT EVEN THOUGH IT IS 5 YRS OLD BECAUSE THIS IS VERY DANGEROUS LAST WINTER I WAS DRIVING IN SNOW AND THE BACK END SLID AROUND ON ME AND THIS WAS CAUSED BY THE BRAKE TRYING TO SEIZE UP. *TR
Suspension, Jun 22, 2009
2004 FORD F-150... TRUCK STARTS TO SHAKE HORRIBLY WHEN ACCELERATING. THE PROBLEM IS RANDOM (ONCE EVERY 2-3 DAYS?), BUT ONLY STOP S AFTER THE CAR COMES TO A COMPLETE STOP. MOST OF THE TIME THE PROBLEM ARISE WHEN ACCELERATING ON THE INTERSTATE. IT FEELS LIKE DRIVING OVER A WASHBOARD, WHICH IS VERY UNNERVING WHEN TRAVELING AT 60 MPH. I HAVE REPEATEDLY HAD TO PULL OF THE INTERSTATE, STOP COMPLETELY (MAYBE TWICE), BEFORE THE ISSUE IS RESOLVED. THE ISSUE HAS NOT YET BEEN DIAGNOSED BY THE DEALER. OTHER PEOPLE SAY IT HAS TO DO WITH THE REAR DIFFERENTIAL, BUT NOT SURE YET, SINCE IT HAS NOT BEEN REPAIRED. NO INJURIES YET, BUT THE PROBLEM SEEMS VERY UNSAFE AND WIDESPREAD. PROBLEM STARTED IN OCTOBER 2007, AND HAS PROGRESSIVELY GOTTEN WORSE.*TR
Suspension, May 4, 2009
SINCE PURCHASE THE F150 HAS HAD TERRIBLE SHAKING IN THE FRONT AT 55-60 MPH. REPEATED ATTEMPTS TO FIX HAVE BEEN NEGATIVE. DEALERS, REPAIR SHOPS HAVE FAILED. REPLACED ALL FOUR TIRES, REPEATED BALANCING HAVE NOT HELPED. *TR
Suspension, Jun 26, 2008
2004/5 FORD F150, 33,000 ROAD MILES (NEVER BEEN OFF ROAD) PARKED AT TRAFFIC LIGHTS IN MY TRUCK WHEN THE FRONT DRIVERS SIDE COILS SPRING COLLAPSED. HAVING INSPECTED THE FAILED PART, IT HAS NOT FAILED IN THE NORMAL FRACTURE STRAIGHT THROUGH THE COIL BUT DIAGONALLY THROUGH IT, SURELY THIS MUST BE A MANUFACTURING FLAW. SO GLAD I WAS STATIONARY WHEN IT HAPPENED. *TR