2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: suspension
118 reports, newest first. Show all
Suspension, Aug 31, 2004
CONSUMER WAS CONCERNED THAT THE VEHICLE WOULD SHIMMY / SHAKE WHEN DRIVING 55 MPH. VEHICLE HAS BEEN TO THE DEALER AND THE PROBLEM STILL RECURRING. *AK
Suspension, Aug 10, 2004
INTERMITTENTLY FRONT AND REAR END OF VEHICLE SHUTTERED AND VIBRATED. THE PROBLEM BECAME WORSE WHEN VEHICLE'S SPEED REACHED AND EXCEEDED 52 MPH. DEALERSHIP INSTALLED A DAMPTER KIT, BUT THE PROBLEM RECURRED. *AK
Suspension, Aug 5, 2004
FRONT SUSPENSION VIBRATES VIOLENTLY ENOUGH THAT THE WINDSHIELD WIPERS COME OFF THE GLASS. PROBLEM OCCURS AT ALL SPEEDS BUT IS WORSE AT ABOUT 40 MPH. IT LAST ANY WHERE FROM ONE QUARTER OF A MILE TO FOUR MILES AND THEN STOPS. IT COMES AND GOES WITH NO WARNING AND THERE IS NO BUILD UP TO THE VIOLENT SHAKIN. IT STOPS AS FAST AS IT STARTS.*AK
Suspension, Jul 19, 2004
WHILE DRIVING FRONT END VIBRATED HEAVILY. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Suspension, Jun 30, 2004
WHILE DRIVING VEHICLE WOULD SHIMMIED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Steering, Suspension, Jun 29, 2004
WHILE DRIVING AT HIGHWAY SPEEDS, THE STEERING WHEEL VIBRATED VIOLENTLY. *AK THE ENTIRE VEHICLE WOULD SHAKE. *SC *JB
Suspension, Jun 18, 2004
LEFT FRONT END , WHEN I BACK OUT OF A PARKING SPOT AFTER LETTING THE TRUCK SIT FOR OVER A MINUTE, AS I START TO DRIVE I CAN FEEL AND HEAR A ROUGH NOISE, I CAN FEEL IT ON THE DRIVERS FLOORBOARD, IT VIBRATES FOR A SECOND OR TWO AND ITS ALSO AUDIBLE, I TOOK IT INTO MY DEALER HAD HE SAID HE HEARD NOTHING BUT I HAVE LET FRIENDS DRIVE AND THEY SAY THEY HEAR AND FEEL IT TOO, THE SOUND IS LIKE SOMETHING MAY BE RUBBING OR SETTING BACK INTO PLACE. MY TRUCK IS A 2004 F150 AND STARTED DOING THAT ABOUT 2 MONTHS AFTER I BOUGHT IT. *AK
Suspension, Jun 15, 2004
WHILE DRIVING 30-55 MPH THE ENTIRE VEHICLE WOULD VIBRATE/SHIMMY HEAVILY. SOMETIMES WHEN THE VEHICLE WAS TURNED OF THE VIBRATION WOULD SUBSIDE, OTHER TIMES IT WOULD NOT. THE DEALERSHIP WAS NOTIFIED BUT THE CAUSE COULD NOT BE DETERMINED. *LA *NM
Suspension, Jun 14, 2004
VEHICLE BOUNCED AND WAS UNSTABLE WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE MECHANIC INSTALLED A DAMPENING ON THE SUSPENSION SYSTEM. THE VEHICLE WAS STILL UNSTABLE. ANY OBJECTS LOADED IN THE VEHICLE BED MAY FALL OUT BECAUSE THE VEHICLE BOUNCED . *AK THIS PROBLEM CAUSED SICKNESS IF THE VEHICLE WAS DRIVEN FOR A LONG PERIOD. *SC *JB
Suspension, Electrical system, May 24, 2004
I HAVE A 2004 FORD F-150 FX4 SUPERCAB. I AM EXPERIENCING TWO PRIMARY PROBLEMS WITH THE VEHICLE. FIRST, THE VIBRATION AND STEERING WHEEL "NIBBLE". THE VIBRATION IS PRESENT AT NEARLY ALL SPEEDS. IT FEELS LIKE THE VEHICLE IS ROLLONG OVER SMALL BUMPS IN THE ROAD. DEALER HAS HAD VEHICLE TWICE AND WILL HAVE IT AGAIN (3RD TIME) TOMORROW. CLAIM TO BE ABLE TO FIX THE PROBLEM. THE STEERING WHEEL "NIBBLE" HAPPENS AROUND 75-80MPH AND DID IMPROVE SLIGHTLY WITH REBALANCING THE TIRES. THE OTHER PROBLEM IS WITH THE A/C SYSTEM. THE SYSTEM IS NOT COOLING THE CAB OF THE TRUCK WHEN THE OUTSIDE TEMP IS 85 OR HIGHER. THE CONDICTION IS PARTICULARLY BAD WHEN THE VEHICLE IS AT IDLE. THE DEALER SAYS THE SYSTEM IS OPERATING AT SPEC. I TALKED TO A FRIEND WHO HAS THE SAME VEHICLE AND HE SAYS HE HAS THE SAME PROBLEM AND HE IS BRINGING HIS TO THE DEALER TO HAVE IT CHECKED. THE A/C IN MY FRIEND'S 1997 RANGER COOLS BETTER THAN MY NEW F-150. *AK
Steering, Suspension, Power train, Structure, May 13, 2004
TEST DROVE NEW F-150 SUPER-CREW-CAB 4X2, AT 60 MPH EXPERIENCED A TERRILBE SHIMMY IN STEERING WHEEL AND BAD VIBRATION FROM LEFT REAR OF TRUCK. RETURNED TRUCK TO LOT AND TEST DROVE NEW F-150 SUPER-CREW-CAB 4X4, EXPERIENCED THE SAME PROBLEM AT 30 MPH AND 60 MPH. BOUGHT 4X4, SALESMAN SAID THE TRUCK MOST LIKELY NEEDED WHEEL BALLANCING, OR IT WAS OUT OF ROUND. WE MADE AN APPOINTMENT FOR TWO DAYS LATER TO ADDRESS THE SHIMMY/VIBRATION PROBLEM.THE MECHANIC HAD THE TRUCK ON LIFT FOR TWENTY MINUTES. RESULT, DEALER HAS TO ORDER A PART FOR A SERVICE BULLETIN THAT REQUIRES A VIBRATION DAMPENING DEVICE TO BE INSTALLED. THIS IS INTERESTING, THER IS A WHOLE LOT OF NEW F-150 TRUCKS AT THIS DEALERSHIP. I DROVE TWO AND BOTH HAD SAME PROBLEM. THEY (FORD), HAVE A KNOWN SERVICE BULLETIN FOR THIS PROBLEM AND YET AS PLENTIFUL AS THIS PROBLEM IS ON THE LOT THEY HAVE TO ORDER THE PART, AGAIN FOR A KNOW PROBLEM DOCUMENTD BY THEIR BULLETIN THAT THIS PART IS REQUIRED AND THEY DON'T HAVE IT IN STOCK TO FIX MY TRUCK OR THE OTHER ONE I TEST DROVE ON THEIR LOT OR THE NEXT ONE AND SO-ON AND SO-ON.....AFTER READING ALL OF THESE COMPLAINTS THERE HAD BETTER BE A FIX FOR THIS OR I WILL SURELY DELIVER MY $40,000 WORTH OF INQUIRIES AND ADVERTISEMENTS. MOTOR TREND TRUCK OF THE YEAR...OR NOT!!! *AK
Suspension, Power train, Apr 28, 2004
VIBRATION IN 2004 F150 FORD TRUCK
Suspension, Apr 20, 2004
WHILE DRIVING BETWEEN 45-60 MPH THERE WAS SEVERE VIBRATION. DEALERSHIP SERVICED VEHICLE 4 TIMES, BUT COULD NOT LOCATE THE CAUSE OF THE VIBRATION. *AK *LA
Steering, Suspension, Mar 16, 2004
MY STEERING WHEEL IS SHAKING BACK AND FORTH AT APPROXIMATELY 55 MPH SINCE PURCHASING THE VEHICLE. THE BALANCE JOB, TRIP TO THE DEALER, AND NEW RIMS AND TIRES HAVE NOT FIXED THE PROBLEM. *JB
Suspension, Mar 15, 2004
WHILE DRIVING AT HIGHWAY SPEEDS STEERING WHEEL VIBRATED. THE TIRES WERE ROTATED AND ALIGNED, BUT THE PROBLEM RECURRED. DEALER INFORMED THE CONSUMER THAT THE PROBLEM COULD NOT BE FIXED. *AK
Suspension, Mar 15, 2004
A VIBRATION IS LEFT IN THE STEERING AS WELL AS THE FLOORBOARD OF THE VEHICLE FROM 30 TO 65 MPH. THE VIBRATION IS WORST AROUND 38 AND 58 MPH. VIBRATION IS MOST PROMINENT BUT NOT LIMITED TO ACCELERATION.*AK
Suspension, Mar 8, 2004
I HAVE A SUPER CREW 4X4 W/ 3.73 LTD SLIP REAR. IM HAVING THE SAME PROBLEMS MANY OF US HAVE EXPERIENCED WITH THE STEERING WHEEL VIBRATION "NIBBLE" AT HIGHWAY SPEEDS AND THE REAR END SHUDDERS FROM A STANDSTILL UPON ACCELERATION OR WHILE MAKING TURNS. I BROUGHT THE TRUCK IN THIS WEEK AND THE SERVICE WRITER HAD THE SERVICE MANAGER TAKE A TEST DRIVE WITH ME SO I COULD SHOW HIM WHAT I WAS TALKING ABOUT. HE FELT THE EXACT SAME THINGS I DID, ACKNOWLEDGED THE VIBRATION AND THE SLIPPING "SHUDDERING" REAR END FEELING. THE DEALERSHIP HAS BEEN TRYING DIFFERENT SETS OF WHEELS AND TIRES ON MY TRUCK BUT PROBLEM STILL EXISTS. AS FOR THE REAR END PROBLEMS, THEY HAVE YET TO COME UP WITH A SOLUTION TO FIX THE PROBLEM; NO ATTEMPT HAS BEEN MADE TO TRY TO FIX IT. I AM NOT ALONE WITH THESE PROBLEMS. *AK
Suspension, Feb 10, 2004
VERY NOTICEABLE STEERING WHEEL VIBRATION AT 65 MPH & VERY BAD STEERING WHEEL SHIMMY WHEN BUMPS ARE ENCOUNTERED DURING EVERY DAY DRIVING. THE TIRES FEEL LIKE THEY LOSE CONTACT WITH THE ROAD & FEEL VERY UNSTABLE. *AK