2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: visibility
866 reports, newest first. Show all
Visibility, Nov 30, 2009
2004 FORD 150 LARIAT POWER WINDOW FAILURE AT 65MPH. *TR
Visibility, Nov 25, 2009
MY DRIVER SIDE FRONT DOOR POWER WINDOW REGULATOR FAILED TODAY AND MY WINDOW CAME CRASHING DOWN INSIDE MY DOOR AND WAS UNABLE TO PUT WINDOW UP. *TR
Visibility, Nov 25, 2009
WINDOW REGULATOR WENT OUT ON MY FORD F-150 FOR THE SECOND TIME AND HAS BEEN REPLACED. MY CHILDREN WERE NOT IN THE CAR AT THE TIME MY PASSENGER SIDE WINDOW DROPPED RAPIDLY BUT I DID THINK IT WAS GOING TO SHATTER. *TR
Visibility, Nov 24, 2009
MY WINDOW REGULATORS IN MY F-150 HAVE FAILED THREE TIMES IN THE LAST 15 MONTHS. *TR
Visibility, Nov 23, 2009
PASSENGER AND DRIVER SIDE REAR DOOR POWER WINDOW GLASS FELL INSIDE THE DOOR WITHOUT WARNING OR PROVOCATION. REGULATOR ASSEMBLY WAS REPLACED 10/27/08 FOR PASSENGER SIDE FOR $304.83 AND 10/21/09 FOR DRIVERS SIDE FOR $294.48 BY LOCAL FORD DEALERSHIP. THE FIRST FAILURE OCCURRED DURING AN LSU FOOTBALL GAME, WE THOUGHT WE HAD BEEN ROBBED WITH THE WINDOW BROKEN, WE WERE LUCKY NOTHING WAS STOLEN! SECOND TIME WAS WHEN MY HUSBAND WAS DRIVING IN TOWN IN SPEEDS OF 0-45 MPH, LUCKILY HE DIDN'T CRASH DUE TO THE SURPRISE OF THE NOISE AND QUICK INFLUX OF AIR. I REPORTED THE FIRST PART FAILURE TO FORD, THEIR ONLY RESPONSE WAS A REQUEST TO FILL OUT A CONCERN HANDLING SURVEY SO I HAVE TAKEN THIS NEXT STEP AFTER A SECOND PART FAILURE FOR THE EXACT SAME THING. *TR
Visibility, Nov 23, 2009
MY WINDOW ROLLED UP THEN I HEARD A LOUD POP, AND THE WINDOW FELL DOWN INTO THE HOUSING. THE BUTTON WILL NOT ROLL UP THE WINDOW. *TR
Visibility, Nov 21, 2009
THIS IS A FAILURE OF THE DRIVER'S SIDE WINDOW FALLING DOWN INTO THE DOOR WHILE DRIVING. THIS SEAMS TO BE A VERY COMMON PROBLEM FOR THE FORD F-150 PICKUP. WHILE IT HAS NOT LEAD TO A CRASH TO MY KNOWLEDGE, THE POTENTIAL IS THERE. IMAGINE DRIVING DOWN THE INTERSTATE IN CROWED TRAFFIC AND YOUR WINDOW DROPS DOWN WITHOUT WARNING. YOUR ATTENTION WILL DEFINITELY BE DISTRACTED FROM YOUR DRIVING AND DURING INCLEMENT WEATHER THIS COULD BE EVEN MORE DANGEROUS. EVERYTHING I HAVE READ POINTS TO THE SAME PRODUCT FAILURE. A RECALL SHOULD BE MANDATORY BEFORE SOMEONE GETS HURT. *TR
Visibility, Nov 17, 2009
I'M AN OWNER OF A 2004 FORD F150. I HAD A SITUATION WHERE MY DRIVERS SIDE WINDOW SLID DOWN ALL OF SUDDEN. FOUND THAT THE POWER WINDOW REGULATOR WENT BAD. I SAW OTHER COMPLAINTS REGARDING THE SAME YEAR TRUCK AND FAULTY WINDOW REGULATORS. *TR
Visibility, Nov 16, 2009
WHILE DRIVING APPROXIMATELY 70 MPH (SPEED LIMIT), I HEARD A LOUD POP (SOUNDED LIKE A GUNSHOT) THAT MADE ME SWERVE AND ALMOST LEAVE THE HIGHWAY. AFTER STABILIZING MY TRUCK, I REALIZED THAT THE CAUSE OF THE LOUD POP WAS A BROKEN WINDOW REGULATOR ON THE PASSENGER SIDE. *TR
Visibility, Nov 15, 2009
DRIVING 35 MPH ON SMOOTH ROAD, PASSENGER ATTEMPTED TO LOWER SIDE WINDOW AND THE WINDOW DROPPED TO THE BOTTOM OF THE DOOR (INSIDE) AND WOULD NOT OPERATE UP. *TR
Visibility, Nov 13, 2009
WIDOW REGULATOR BREAKS AND WINDOW FALLS INTO DOOR. IT HAS HAPPENED ON THREE OF THE FOUR WINDOWS ON FORD F150 CREWCAB. TWO OF THE INCIDENTS HAVE OCCURRED WHILE VEHICLE WAS IN MOTION AND ONE INCIDENT OCCUR WHEN VEHICLE WAS PARKED AND UNATTENDED. CORRECTIVE ACTION, TAKE VEHICLE TO DEALERSHIP, PAY DEDUCTIBLE ON EXTENDED WARRANTY, AND WINDOW GETS FIXED. THE DATE ON THIS FORM IS OF THE LATEST INCIDENT. *TR
Visibility, Nov 13, 2009
THE FORD F150 I BOUGHT NEW IN 2004 HAS DEFECTIVE WINDOW REGULATORS. I HAVE HAD TO REPLACE THREE SO FAR, TWO UNDER WARRANTY AND THE THIRD RECENTLY AT THE COST OF $435. THESE REGULATORS GO OUT AND THE WINDOW DROPS INTO THE DOOR. IT IS ALWAYS SUDDEN AND UNEXPECTED AND IS QUITE A DISTRACTION. I AM FORTUNATE THIS HAS NEVER RESULTED IN MY HAVING AN ACCIDENT. *TR
Visibility, Nov 13, 2009
REAR WINDOW REGULATOR BROKE AND WINDOW DROPPED INDOOR. HAVING CHILDREN IT IS NOT SAME TO HAVE A WINDOW DOWN WHILE DRIVING AND NOT TO MENTION IT COULD HAVE BROKE WINDOW AND HIT MY KIDS. *TR
Visibility, Nov 11, 2009
I WAS DRIVING ON THE INTERSTATE WHEN THE RIGHT REAR WINDOW FELL INTO THE DOOR. THIS IS THE THIRD TIME THIS HAS HAPPENED. I TOOK THE FORD F150 TO THE DEALERSHIP AND PAID OVER $400 TO REPLACE THE WINDOW REGULATOR. *TR
Visibility, Nov 11, 2009
1. NONE 2. 2004 FORD F150 SUPER CREW POWER WINDOW REGULATOR FAILURE. 3. REPLACED PART AND YES I SAVED THE OLD PARTS. *TR
Visibility, Nov 10, 2009
I PRESSED THE BUTTON TO OPEN THE DRIVER'S SIDE WINDOW ON MY 2004 F150 TRUCK. THE WINDOW FELL COMPLETELY DOWN INTO THE DOOR AND WOULD NOT COME BACK UP WHEN I PRESSED THE "UP" BUTTON. I TOOK THE TRUCK TO A FORD DEALERSHIP AND THEY REPLACED THE WINDOW REGULATOR. *TR
Visibility, Nov 9, 2009
2004 FORD F-150 CREW CAB POWER WINDOWS SO FAR THREE OF THE FOUR POWER WINDOWS HAVE FAILED IN THE SAME WAY. THE FAILURE IS AS FOLLOWS: WINDOWS GO DOWN BUT WILL NOT GO UP. THE FIRST WAS THE FRONT DRIVERS SIDE; PLASTIC "PULLEYS' SHATTERED IN WINDOWS MECHANISM SECOND WAS THE FRONT PASSENGERS SIDE; PLASTIC "PULLEYS' SHATTERED IN WINDOWS MECHANISM THE THIRD WAS THE REAR PASSENGERS SIDE; PLASTIC "PULLEYS' SHATTERED IN WINDOWS MECHANISM. *TR
Visibility, Nov 9, 2009
SAME AS EVERYONE ELSE ... THE WINDOW JUST COMES CRASHING DOWN WITHOUT EVEN TOUCHING IT WHILE WE WERE DRIVING ALONG. *TR
Visibility, Nov 6, 2009
MY FRONT PASSENGER WINDOW FELL INTO THE DOOR AS I WAS STOPPED AT A STOPLIGHT WAITING TO GET ON THE HIGHWAY. FROM THE SOUND OF IT I THOUGHT THE WINDOW HAD BROKEN. IT WAS A GOOD THING I WASN'T DRIVING DOWN THE HIGHWAY DURING THAT TIME. IT PROBABLY WOULD HAVE CAUSED A MAJOR ACCIDENT. *TR
Visibility, Nov 3, 2009
I HAVE A 2004 FORD F-150 CREW CAB. WITH MY CREW CAB THE REAR WINDOWS ARE CAPABLE OF BEING LOWERED TO THE TOP PORTION OF THE DOOR, AT ARM LEVEL. BOTH MY REAR WINDOWS AND NOW MY DRIVERS DOOR WINDOW REGULATOR HAVE GONE OUT WITH THE WINDOWS SLAMMING DOWN WITHIN THE DOOR. I HAVE FOUR SMALL CHILDREN, 9, 7, 5, AND 3. AS THE WINDOWS HAVE FALLEN DOWN WITHOUT WARNING A SHADE FELL ONTO MY YOUNGEST, ALL DUE TO THE DEFECT OF THE REGULATOR IN THE F-150. THIS IS A MAJOR HAZARD AND I THINK THAT A RECALL IS IN PLACE TO MANDATE THAT FORD RECALL THIS ITEM AND FIX THE PROBLEM. *TR
Visibility, Nov 2, 2009
3 OUT OF 4 WINDOWS ON MY 2004 FORD F150 HAVE FALLEN DOWN BECAUSE OF WINDOW MOTOR REGULATOR FAILURE. NOTHING HAS BEEN DONE TO FIX THE PROBLEM! *TR
Visibility, Oct 31, 2009
PASSENGER SIDE DOOR REGULATOR FAILED CAUSING THE DOOR GLASS TO FALL INTO THE DOOR .THE WINDOW FELL WHILE THE VEHICLE WAS AT HIGHWAY SPEED. IT FELL ALL OF A SUDDEN ON ITS OWN. THIS HAPPENED DURING A HEAVY RAIN. IT IS MY UNDERSTANDING AFTER INTERNET RESEARCH THAT THIS IS A COMMON FAILURE FOR THIS MODEL FORD TRUCK AND I THINK IT IS A SAFETY HAZARD. *TR
Visibility, Oct 30, 2009
3 OF THE 4 WINDOW REGULATORS HAVE FAILED IN THE PAST 6 MONTHS. *TR
Visibility, Oct 28, 2009
WHILE DRIVING, HEARD A LOUD "POP", "KLUNK". AFTER ROLLING DOWN MY WINDOW, TRIED TO ROLL IT BACK UP, BUT NOW WON'T ROLL UP. THIS HAS HAPPENED TO 3 OF MY WINDOWS. THE PROBLEM WITH 1ST WINDOW OCCURRED 1 YR AGO--OTHER 2 WINDOW BROKE W/IN A FEW WEEKS OF EACH-OTHER. I'VE HAD ONE WINDOW REPAIRED. THE DEALER SAID A SMALL PLASTIC PART BROKE AND THAT IT IS A COMMON PROBLEM. COST TO REPAIR ONE WINDOW: 360.00!!! THIS IS A SAFETY PROBLEM---IF YOU CANNOT ROLL YOUR WINDOW UP, IT LEAVES THE DRIVER VULNERABLE. WHY WOULD FORD USE A SMALL PLASTIC PART ON SUCH A BIG COMPONENT OF A TRUCK? IS THERE A RECALL ON THIS PART? IF NOT, CAN YOU PLEASE EXPLAIN WHY NOT? I WOULD NOT BE SO UPSET IF THIS PROBLEM OCCURRED IN 1 WINDOW, BUT THREE?? NOW I'M WAITING FOR THE 4TH WINDOW TO GO. AND AT 360.00 A POP! SOMETHING JUST ISN'T RIGHT. *TR
Visibility, Oct 26, 2009
UNEXPECTED FAILURE OF POWER WINDOW REGULATOR. THIS HAS OCCURRED 4 TIMES. AT THE TIME OF FAILURE THE WINDOW GLASS FREE FALLS INTO WINDOW CHANNEL, CAUSING AN EXPECTED RUSH ON AIR TO ENTER THE PASSENGER COMPARTMENT. R & R THE WINDOW REGULATOR. PARTS WILL BE AVAILABLE. *TR