2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: visibility
866 reports, newest first. Show all
Visibility, Sep 14, 2008
2004 XLT REGULAR CAB: UNDER 14,000 MILES ON THE VEHICLE AND WHEN I GO TO ROLL UP THE WINDOW THE OTHER DAY, I HEAR A POP AND IT SANK BACK INTO THE DOOR. ANOTHER BAD WINDOW REGULATOR! QUOTED $380 TO FIX FROM THE DEALER. IF YOU READ PREVIOUS COMMENTS ON THE 2004 F-150 YOU'LL SEE THAT THIS IS QUITE THE COMMON PROBLEM. AND FOR EVERY POST ABOUT WINDOW PROBLEMS ON THIS WEBSITE, HOW MANY OTHER PEOPLE HAVE THIS PROBLEM AND DON'T REPORT IT HERE - 10X AS MANY? 20X AS MANY? THIS IS OBVIOUSLY A WIDESPREAD PROBLEM THAT FORD MOTOR COMPANY NEEDS TO LIVE UP TO. THE REPLACEMENT PART IS EXACTLY THE SAME, SO I GUESS I CAN EXPECT ANOTHER REPLACEMENT SOON! AND TO THINK THAT I THOUGHT THAT ONLY GETTING A STANDARD CAB WITH 2 WINDOWS MIGHT HELP ME AVOID THIS PROBLEM!!! LUCKILY, MY INCIDENT OCCURRED IN FAIR WEATHER. I CAN ONLY IMAGINE THE SAFETY CONCERNS THAT I WOULD HAVE HAD I BEEN IN INCLEMENT WEATHER. *TR
Visibility, Sep 13, 2008
WHILE ROLLING DOWN MY REAR DRIVER'S SIDE WINDOW, I HEARD A POPPING NOISE AND THE WINDOW FELL INTO THE DOOR. I HAD IT REPAIRED (NEW REGULATOR) AT A COST OF $390. TWO WEEKS LATER, THE EXACT ISSUE OCCURRED WITH MY FRONT DRIVER'S SIDE WINDOW. I HAVE INVESTIGATED A BIT ON THE INTERNET AND DISCOVERED HUNDREDS OF COMPLAINTS DESCRIBING THESE EXACT SYMPTOMS. THIS IS A SECURITY PROBLEM AND A SAFETY ISSUE FOR INDIVIDUALS WHO MAY BE DRIVING IN POOR WEATHER. *TR
Visibility, Sep 9, 2008
REGULATOR ON TWO WINDOWS OF MY FORD F-150 PICK UP FAILED. I GOT THE ONE FIXED AND ABOUT TWO0 MINUTES AFTER I LEFT THE FORD DEALERSHIP, THE OTHER ONE FAILED. *TR
Visibility, Sep 8, 2008
ON AUGUST 8 THE DRIVER'S SIDE WINDOW REGULATOR FAILED AND THE WINDOW FELL INTO THE DOOR. THE DEALERSHIP CHARGED $387.00 FOR THIS REPAIR. ONE MONTH LATER BOTH REAR WINDOW REGULATORS FAILED, AND THE GLASS FELL INTO THE DOORS. NO WARRANTY WAS OFFERED OR IMPLIED. *TR
Visibility, Sep 7, 2008
MY 2004 FORD F150 SUPERCREW HAS HAD A WINDOW FALL DOWN 3 DIFFERENT TIMES SO FAR. ALL THREE TIMES WERE DIFFERENT WINDOWS, BUT THE SAME PROBLEM. THE WINDOW REGULATOR IS CABLE DRIVEN AND THE CABLE GETS STUCK OR COMES OFF OF THE PULLEY, THEN THE WINDOW FALLS INSIDE THE DOOR. *TR
Visibility, Sep 7, 2008
MY PASSENGER POWER WINDOW FELL COMPLETELY DOWN INTO THE DOOR WHILE I WAS PARKED IN MY DRIVE WAY AND MY GRANDSON WHO HAD HIS HANDS ON THE WINDOW WAS PULL OUTSIDE AND ALMOST FELL ON HIS HEAD. LUCKILY I WAS ABLE TO GRAB HIS FEET AND STOP HIM FROM HITTING HIS HEAD ON THE DRIVE WAY. I HAD THE WINDOW FIXED BUT THE MECHANIC WHOM FIXED IT TOLD ME THERE WAS A DESIGN FLAW IN THESE POWER WINDOWS AND THAT IT COULD DO IT AGAIN. SURE ENOUGH ABOUT 3 MONTHS LATER THIS TIME MY DRIVERS SIDE WINDOW FELL. I EMAILED FORD AND THEY SAID THEY COULDN'T HELP ME. I POSTED A COMPLAINT ON CARCOMPLAINT.COM ALONG WITH THE OTHER 114 COMPLAINTS FOR THIS REPONSE. THIS NEEDS TO COME A RECALL BEFORE SOMEONE GETS INJURED. *TR
Visibility, Sep 4, 2008
WHILE PUTTING UP THE DRIVER'S SIDE ELECTRIC WINDOW IN MY FORD 2004 1/2 (NEW STYLE) F-150 SUPERCREW I HEARD A LOUD BANG AND THE WINDOW DISAPPEARED. THE BANG WAS SO LOUD THAT I THOUGHT SOMEONE HAD SHOT OUT MY WINDOW WHILE I WAS DRIVING. IF I HAD BEEN IN BUSY TRAFFIC THIS COULD HAVE CAUSED AN ACCIDENT. FORTUNATELY I WAS ON A 25 MPH ROAD AT THE TIME AND NO ONE WAS HURT NOR WAS THERE AN ACCIDENT. THE PROBLEM WAS WITH THE WINDOW REGULATOR CABLING. THE CABLING SEPARATED FROM THE WINDOW WHICH RESULTED IN THE LOUD BANG I HEARD FROM MY DRIVERS SIDE WINDOW. FROM MY RESEARCH THIS IS AN ONGOING PROBLEM. THIS PROBLEM HAS THE POTENTIAL FOR SOME VERY SERIOUS CONSEQUENCES IF THE DRIVER WERE TO OVERREACT TO THE LOUD "GUN SHOT" SOUND WHEN THE FAILURE OCCURS. *TR
Visibility, Sep 2, 2008
I WAS DRIVING TO THE AIRPORT THIS MORNING TO PICK UP A WORK COLLEAGUE FOR AN IMPORTANT MEETING. AS I WAS DRIVING I HEARD A LOUD POP THAT SOUNDED LIKE SOMETHING HITTING THE DOOR. I SWERVED AND NEARLY HIT THE CAR NEXT TO ME. STARTLED, I PULLED OVER AT THE NEXT EXIT TO SEE IF MAYBE SOMEONE HAD THROWN SOMETHING AT MY TRUCK. THERE WASN'T A SCRATCH OR DENT ANYWHERE. I GOT BACK IN STARTED DOWN THE ROAD WHEN THE WINDOW SUDDENLY DROPPED OUT OF SIGHT SO I PULLED OVER AGAIN AND THE FOUND THAT IT WOULD NOT GO BACK UP. THERE WAS SEEMINGLY NOTHING TO DO AT THAT POINT BUT TAKE MY SUIT JACKET OFF AND HOPE TO NOT SWEAT THROUGH MY SHIRT BEFORE OUT MEETING. I PICKED UP MY COLLEAGUE, LATE, THEN WERE LATE EVERY SUBSEQUENT MEETING THE REST OF THE DAY. AS SOON AS I COULD, I TOOK WENT TO MY LOCAL DEALERSHIP WHO ALREADY SEEMS TO KNOW WHAT'S WRONG BEFORE I CAN FINISH TELLING HIM WHAT'S WRONG. HE TELLS ME IT'S GOING TO PROBABLY BE IN THE RANGE OF $375 TO FIX. AFTER RENTING A CAR TO GET BACK TO MY OFFICE, I CHECKED ONLINE TO SEE IF THIS MIGHT BE A COMMON OCCURRENCE ONLY TO FIND HUNDREDS OF COMPLAINTS ABOUT MULTIPLE WINDOWS ON THE SAME VEHICLES NEEDING TO BE REPLACED. SO, AFTER NEARLY WRECKING MY TRUCK, RUNNING LATE, APPEARING DISHEVELED AT MY OWN CUSTOMER MEETINGS, AND DRIVING AROUND IN 100 DEGREE WEATHER IN A SUIT AND TIE, ALL BECAUSE OF A PROBLEMS THAT MY (PREVIOUS) FAVORITE AUTOMAKER IS FULLY AWARE OF, I'M SO MAD AND FRUSTRATED THAT I CAN HARDLY SEE STRAIGHT! ON TOP OF THAT, IT SOUNDS LIKE CAN PROBABLY LOOK FORWARD TO THE SAME THING HAPPENING 3 MORE TIMES (AT LEAST). THE ONLY THING I CAN THINK TO DO IS TO SEND COMPLAINTS WHEREVER I CAN FIND AND KEEP COPIES OF THOSE COMPLAINTS SO THAT WHEN THE NEXT WINDOW "POPS" AND STARTLES ME INTO ONCOMING TRAFFIC, I'LL AT LEAST HAVE PROOF I DID MAKE EVERYONE AWARE OF MY OWN PERSONAL EXPERIENCE. THIS IS SUCH A POTENTIAL DANGER AND EXPENSIVE INCONVENIENCE TO THE CUSTOMER THAT I REQUEST A RECALL FROM FORD TO REPLACE ALL WINDOW MOTOR/GEARS BEFORE. *TR
Visibility, Aug 28, 2008
WINDOW REGULATOR ON FORD F150 2004 JUST LET WINDOW FALL COULD NOT PARK ANY WHERE UNTIL I GOT HOME TOOK APART AND PROPPED WINDOW UP SO NOBODY WOULD BREAK INTO TRUCK GOOD THING IT WAS NOT RAINING FROM DEALERS NOTES SEEMS THIS IS HAPPENING A LOT. *TR
Visibility, Aug 27, 2008
AS I WAS DRIVING THROUGH MY NEIGHBORHOOD THE PASSENGER SIDE WINDOW SUDDENLY FELL INTO THE DOOR WITH A LOUD THUMP. AFTERWARDS, THE WINDOW FAILED TO OPERATE. 2 DAYS LATER AS I WAS DRIVING ON THE INTERSTATE THE DRIVER SIDE WINDOW SUDDENLY FELL INTO THE DOOR WITH A LOUD THUMP AND AFTERWARDS FAILED TO OPERATE. THIS IS A FAILURE OF 2 WINDOWS WITHIN 2 DAYS IN A CATASTROPHIC FAILURE MODE. I WAS NOT HARMED IN THIS SPECIFIC INCIDENCE BUT THIS OCCURRENCE COULD BE DANGEROUS IN POOR WEATHER. I DO NOT BELIEVE THE MANUFACTURER WILL REPAIR THE FAILURE EVEN THOUGH THIS IS A COMMON COMPLAINT AS EVIDENCED BY A QUICK INTERNET SEARCH. *TR
Visibility, Aug 25, 2008
WINDOWS KEEP FALLING OUT, THIS THE THIRD WINDOW THAT HAS FALLEN (DEFECTIVE REGULATORS). *TR
Visibility, Aug 22, 2008
ROLLING DOWN DRIVERS WINDOWS AND HEARD LOUD BANG THEN GRINDING AND WINDOW SLOWLY SANK DOWN AND WILL NOT GO BACK UP. I REMOVED DOOR PANEL AND FOUND TWISTED WIRES AND BROKEN PLASTIC FROM THE WINDOWS REGULATOR. ONLY 24000 MILES. QUALITY IS CRAP...SHOULD BE RECALLED BEFORE ALL MY OTHER ONES DO THE SAME THING AND I HAVE TO PAY FOR FORD'S INCOMPETENCE. *TR
Visibility, Aug 18, 2008
MY F150 LARIAT SUPERCREW 4X4 ONLY HAS 19,000 MILES ON IT AND IS VERY WELL KEPT. WHILE POWER ROLLING MY WINDOW UP, I HEARD A LOUD BANG, LIKE MY TRUCK HAD BEEN HIT. UPON INSPECTION I NOTED THAT MY DRIVER SIDE FRONT WINDOW WOULD NOT STAY UP. AFTER CONTACTING MY LOCAL FORD DEALER (ADVANTAGE FORD) I WAS INFORMED THAT IT WAS A FAULTY WINDOW REGULATOR UNIT AND THAT IT WAS A COMMON PROBLEM. I CONTACTED FORD IN THE DESIRE FOR THEM TO FIX THIS FREE OF CHARGE (WARRANTY HAD EXPIRED BASED ON YEARS BUT NOT MILES). THEY WOULD NOT DO SO. THE DEALERSHIP CHARGES $365 TO FIX THE WINDOW OR YOU CAN PURCHASE THE PART FOR $150 AND DO IT YOURSELF IF YOU ARE SO INCLINED. I HAVE FOUND NUMEROUS REPORTS OF THIS PROBLEM WITH THESE TRUCKS ONLINE AND THIS PART SHOULD BE RECALLED BY FORD AND FIXED FREE OF CHARGE. *TR
Visibility, Aug 11, 2008
PASSENGER SIDE ELECTRIC WINDOW SLID DOWN INSIDE THE DOOR. THIS HAS ALREADY BEEN REPLACED ONCE AND THE DRIVER SIDE WINDOW DID THE SAME & ALSO HAD TO BE REPLACED. *TR
Visibility, Aug 7, 2008
I HAVE YOU SEEN HOW MANY COMPLAINTS THERE ARE FOR FAULTY POWER WINDOW MOTOR/REGULATORS? I WAS LEAVING MY PLACE OF EMPLOYMENT WHICH WE SCAN OUT AND MY WINDOW WOULD NOT GO BACK UP. WHEN I GOT HOME I REMOVED THE DOOR PANEL AND THE CABLES WERE TWISTED, KINKED AND FRAYED. RIGHT NOW MY WINDOW IS PROPPED TO KEEP WEATHER OUT...SHOULD I HAVE A WRECK HOW WOULD I GET OUT OF THE WINDOW...SURE GO OUT THE PASSENGER SIDE.. THIS WASN'T EXACTLY A CHEAP VEHICLE AND IT DEFINITELY ISN'T THE MOST EXPENSIVE... BUT YOU WOULD THINK IT WOULD LAST LONGER THAN 4 YEARS. I HAVE SEEN VEHICLES 20 YEARS OLD THAT THE POWER WINDOWS STILL WORK. *TR
Visibility, Aug 6, 2008
3 OUT OF 4 OF MY WINDOWS FELL INTO THE DOOR FRAME. KNOWN FAULTY REGULATOR (FORD KNOWS THIS PART IS FAULTY) BROKE. TWO OF THE REGULATORS BROKE WHILE VEHICLE WAS IN OPERATION. *TR
Visibility, Jul 21, 2008
TL*THE CONTACT OWNS A 2004 FORD F150. THE CONTACT STATED THAT THE TWO REAR WINDOWS AND THE DRIVER SIDE WINDOWS ALL FELL DOWN INTO THE DOOR FRAME. THE DEALER STATED THAT THE REGULATOR FAILED. THE CONTACT WENT TO TWO DIFFERENT DEALERS AND EACH ONE REPAIRED ONE WINDOW AT THE CONTACT'S EXPENSE. THE DEALERS STATED THAT THEY WOULD REIMBURSE HER, BUT THE CONTACT HAS NOT YET RECEIVED ANY COMPENSATION. THE DEALERS FURTHER STATED THAT THEY WOULD NOT PAY FOR THE THIRD WINDOW AT ALL, ALTHOUGH THE CONTACT BELIEVES THIS IS THEIR RESPONSIBILITY. THERE ARE NO RECALLS ON THESE WINDOWS. THE FAILURE MILEAGE WAS 58,000.
Visibility, Jul 16, 2008
I WENT TO PUT UP THE PASSENGER SIDE REAR WINDOW, HEARD A SNAP, THEN THE WINDOW SANK INTO THE DOOR. THIS IS A SAFETY ISSUE, BOTH POTENTIALLY FOR THEFT AND FOR INJURY. I AM NO LONGER COVERED UNDER WARRANTY, FOR THIS ISSUE. THERE ARE MANY FORD F150 OWNERS EXPERIENCING THE SAME ISSUE, ON MULTIPLE WINDOWS AND IS AN ONGOING ISSUE. I AM HAVING THE WINDOW REGULATOR REPLACED AT SIGNIFICANT EXPENSE. I'VE OWNED VEHICLES 10 YEARS AND NEVER HAD THIS PROBLEM, AND YES, THEY WERE FORDS TOO. *TR
Visibility, Jul 16, 2008
FAILURE OF PASSENGER, REAR LEFT, REAR RIGHT WINDOWS WHILE DRIVING ON THE FREEWAY. AT DIFFERENT TIMES. TOOK IT TO DEALER FOR REPAIR. COST ABOUT 416.00 EACH TIME. *TR
Visibility, Jul 2, 2008
I PURCHASED MY 2004 F-150 THREE MONTHS AGO AND I HAVE NOW HAD TO REPLACE THE WINDOW REGULATOR THREE TIMES (TWO ON THE SAME WINDOW). I HAVE FOUND MANY COMPLAINTS ONLINE FROM CONSUMERS WITH THE EXACT SAME PROBLEM. FORD NEEDS TO STEP UP AND RECOGNIZE THIS PROBLEM. IT COSTS ANYWHERE FROM $200.00 TO $400.00 TO GET IT REPAIRED EACH TIME. I CANNOT AFFORD THIS ON A MONTHLY BASIS NOR SHOULD I OR ANYONE ELSE NEED TO PUT UP WITH THE OBVIOUS DEFECT WITH FORDS WINDOW REGULATORS. THANK YOU FOR YOUR TIME. *TR
Visibility, Jul 1, 2008
VEHICLE WINDOW REGULATOR FAILS. IT IS ASSOCIATED WITH A LOUD BANG. THE WINDOW THEN FALLS INTO THE DOOR. THE WINDOW IS NOW UNABLE TO BE MOVED. THE VEHICLE IS NOW NOT ABLE TO BE SECURED. THIS IS THE THIRD WINDOW REGULATOR FAILURE ON MY VEHICLE. STARTED WITH DRIVERS SIDE, THEN PASSENGER SIDE, NOW THE PASSENGER SIDE REAR FAILED. DEALER REPORTED THAT THIS IS VERY COMMON AND IS DUE TO A FAULTY PART. FORD WILL NOT ADDRESS THIS PROBLEM AND FAILS TO FIX / REPLACE THE REGULATORS UNTIL THEY FAIL. THIS PART NEEDS TO BE RECALLED AND ALL WINDOWS FIXED PRIOR TO FAILURE. *TR
Visibility, Jun 19, 2008
POWER WINDOW REGULATORS FAIL PREMATURELY CAUSING GLASS TO FALL AND FRACTURE. *TR
Visibility, Jun 17, 2008
TL*THE CONTACT OWNS A 2004 FORD F-150. WHEN THE CONTACT OPENED THE REAR PASSENGER WINDOW TO AIR OUT THE VEHICLE, SHE HEARD A POPPING SOUND. THE WINDOW FELL ALL THE WAY DOWN INSIDE THE VEHICLE DOOR. THIS IS THE THIRD WINDOW TO FAIL IN THIS MANNER WITHIN A YEAR AND A HALF. THE ONLY WINDOW WHICH HAS NOT DONE THIS IS THE FRONT DRIVER'S SIDE. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 70,000.
Visibility, Jun 16, 2008
IN APRIL 2008 THE RIGHT REAR WINDOW FELL DUE TO A BROKEN REGULATOR AND JUST TODAY THE DRIVER WINDOW DID THE SAME. TWO MONTHS FROM EACH OTHER IS NOT RIGHT TWO YEARS MAYBE BUT NOT TOO MONTHS. I WOULD LIKE SOMETHING DONE IMMEDIATELY. *TR
Visibility, Jun 6, 2008
THREE INCIDENTS WITH THE POWER WINDOWS HAVE OCCURRED IN THE PAST TWO YEARS. WINDOWS HAVE FALLEN AND WON'T ROLL BACK UP. THE REGULATORS SEEMS TO KEEP BREAKING WITH NORMAL OPERATION. THE FIRST ONE TO GO WAS THE REAR DRIVERSIDE DOOR, THEN 6 MONTHS LATER, THE FRONT DRIVERS SIDE DOOR, THEN 4 MONTHS LATER THE FRONT PASSENGERS SIDE DOOR. *TR