2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: visibility
866 reports, newest first. Show all
Visibility, Aug 27, 2011
2004 FORD F150 LARIAT. RIGHT REAR WINDOW SUDDENLY DOPPED INTO THE DOOR. THW WINDOW WILL NOT GO UP. THIS IS A SAFTEY HAZARD. WHNN THE WINDOW WENT DOWN THE NOISE WAS DISTRACTING AND I HAD NO IDEA WHAT HAPPENED. I HAD TO LOOK FOR A PLACE TO STOP. AFTER STOPPING, I EXITED THE TRUCK. I THOUGHT I HAD A TIRE TREAD SEPERATION. AFTER CHECKING ALL OF THE TIRES I DECIDED TO LOOK OVER THE VEHICLE. SINCE I HAD NO IDEA WHAT HAPPENED I WAS PREPARED TO HAVE THE VEHICLE TOWED TO S SHOP. IT WAS THEN THAT I NOTICED THAT THE RR WINDOW WAS DOWN. I TRIED TO PUT IT UP AND COULD NOT DO SO WITH EITHER THE DRIVER WINDOW CONTROLL OR THE RR DOOR CONTROL. *TT
Visibility, Aug 26, 2011
PASSINGER WINDOW FELL INTO THE DOOR WHILE DRIVING ON THE FREEWAY. *TT
Visibility, Aug 24, 2011
WHILE DRIVING ON THE INTERSTATE THE DRIVERS SIDE WINDOW, WITHOUT WARNING, FELL DOWN INTO THE DOOR. I HEARD A POPPING SOUND AND THE WINDOW DISAPPEARED. I FEEL THIS IS A SAFETY ISSUE BECAUSE OF THE SUDDEN DISTRACTION COULD HAVE CAUSED ME TO LOOSE CONTROL OF THE VEHICLE. I LOOKED AT YOUR WEB SITE AND DISCOVERED THIS A COMMON PROBLEM WITH THIS TRUCK AND BELIEVE FORD SHOULD BE REQUIRED TO ADDRESS THE ISSUE.
Visibility, Aug 9, 2011
2004 FORD F150 LARIAT WINDOW REGULATORS FAILING. I HAVE HAD TWO WINDOW REGULATORS FAIL WHILE DRIVING MY TRUCK WHICH CAUSES THE WINDOW TO DROP UNEXPECTEDLY INTO THE DOOR CAVITY WHICH CAUSES ALARM TO THE DRIVER POSSIBLY CONTRIBUTING TO LOSS OF CONTROL OF THE VEHICLE. FORD IS AWARE OF THIS CONDITION AND REFUSES TO CORRECT THE ISSUE. IT IS A SERIOUS SAFETY RISK. THE WINDOWS WERE NOT BEING OPERATED AT THE TIME OF FAILURE. THEY JUST DROPPED LEAVING THE WINDOW OPEN AT 75 MPH ON THE HIGHWAY. *TR
Visibility, Aug 2, 2011
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE DRIVERS SIDE POWER WINDOW DROPPED DOWN INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPAIRED. THE SAME FAILURE OCCURRED APPROXIMATELY TWO YEARS LATER ON THE FRONT PASSENGER SIDE WINDOW. THE MANUFACTURER WAS NOTIFIED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR REPAIRS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE 71,000. UPDATED 08/31/11 *BF UPDATED 09/12/11
Visibility, Jul 31, 2011
I HAVE HAD MY 2004 F150 XLT SUPERCREW FOR A YEAR NOW AND THE POWER WINDOW REGULATOR IN ALL 4 WINDOWS HAVE BROKEN DURING THAT SHORT PERIOD OF TIME. THE MOST RECENT FAILURE HAPPENED ON THE FRONT PASSENGER WINDOW LAST NIGHT. SEARCHING THE INTERNET SHOWS THAT THIS IS A WELL KNOWN ISSUE WITH THESE VEHICLES, BUT FORD WILL NOT ISSUE A RECALL. *TR
Visibility, Jul 25, 2011
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED WHILE DRIVING 10 MPH THE REAR DRIVER AND PASSENGER SIDE WINDOWS FELL INSIDE THE DOOR. THE REGULATOR WAS FAULTY AND CAUSED THE WINDOW TO FALL OFF TRACK. THE CONTACT DID NOT TAKE THE VEHICLE TO A MECHANIC OR DEALER FOR A DIAGNOSTIC TEST. THE CONTACT CALLED THE MANUFACTURER WHO STATED THEY WOULD DO SOME RESEARCH ON THE WINDOW REGULATOR FOR THAT YEAR, MAKE, AND MODEL VEHICLE. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 90,000.
Visibility, Jul 25, 2011
WINDOW FAILURE. THE LEFT REAR WINDOW JUST DROPPED OUT OF THE TRACK DUE TO A WINDOW REGULATOR FAILURE. *TR
Visibility, Other or unspecified, Jul 19, 2011
2004 FORD F-150 ... ALL 4 OF MY WINDOW REGULATORS HAVE FAILED ! ALSO MY 5TH REAR WINDOW IS GOING OUT TOO ...I'M TIRED OF PAYING OUT SO MUCH MONEY FOR THEM TO JUST FAIL AGAIN ! 2 OF MY WINDOWS WON'T EVEN GO UP ANYMORE AND THE INSIDE OF MY TRUCK IS GETTING DIRTY DIRTY DIRTY! I HOPE NOTHING FLIES INTO MY TRUCK WHEN IM DRIVING OR SOMEONE IS GOING TO BE HURT! THE WINDOWS JUST STOP WORKING NO REASON AT ALL! PLEASE HELP THIS IS OUT OF CONTROL AND FORD NEEDS TO STEP UP BEFORE SOMEONE GETS HURT NOT AFTER!!! *KB
Visibility, Jul 15, 2011
TL * THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE TRYING TO CLOSE THE POWER WINDOW, HE HEARD A POPPING NOISE AND THE WINDOW FELL INTO THE DOOR PANEL. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ON THREE OF THE FOUR WINDOWS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CABLES AND THE ACTUATOR ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 9/13/11 *CN THE VEHICLE HAS SINCE BEEN REPAIRED. UPDATED 09/30/11*JB
Visibility, Jul 15, 2011
THERE ARE OVER 450 COMPLAINTS LISTED HERE IS MINE I OWN A 2004 FORD F150 AND HAVE HAD 3 WINDOW REGULATOR FAILURES, 2 WHILE DRIVING. THE DANGEROUS ONE WAS ON THE DRIVERS SIDE AT NIGHT DURING A RAIN STORM. FORD DEALER STATES HE REPLACES 1-2 A WEEK BUT IS NOT YET A RECALL. HE SAYS IT WONT GET A RECALL UNTIL SOMEONE DIES. I THINK IT IS A KNOWN DANGEROUS PROBLEM THAT FORD NEEDS TO TAKE CARE OF BUT WONT UNTIL A RECALL IS MANDATORY. PLEASE RECALL THIS PROBLEM BEFORE "SOMEONE DIES" AND "ONLY THEN" MANDATES A RECALL. THANK YOU FOR YOUR TIME. *TR
Visibility, Jul 12, 2011
TL* THE CONTACT OWNS A 2004 FORD F150 SD. THE CONTACT STATED THAT ALL FOUR OF THE WINDOW REGULATORS FAILED, CAUSING THE WINDOWS TO BECOME LODGED INTO THE DOOR PANEL. THE DEALER WAS CONTACTED WHO ADVISED THAT THE WINDOW REGULATORS WOULD NEED REPLACING. THERE WERE NO RECALLS AND FOR THE FAILURE. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 176,123.
Visibility, Jul 6, 2011
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT WAS ATTEMPTING TO CLOSE THE DRIVER SIDE WINDOW WHEN THE WINDOW FAILED AND FELL INTO THE DOOR PANEL. THE WINDOW WAS INOPERABLE AND THE CONTACT WAS ADVISED BY THE DEALER THAT THE PLASTIC REGULATOR HAD CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 69,000. THE VEHICLE WAS REPAIRED JULY 6,2011. UPDATED 08/31/2011
Visibility, Structure, Jul 4, 2011
WINDOW REGULATOR ON 2004 F 150 LARIAT DRIVERS DOOR BROKE ALLOWING THE WINDOW TO DROP SCARING ME SO BAD THAT I WENT OFF THE ROAD JUST MISSING CRASHING INTO SEVERAL TREES. IT SOUNDED LIKE SOMEONE HAD SHOT OUT MY WINDOW, WHILE I WAS DRIVING IN A THUNDER STORM. THE ROADS WERE WET, BUT THERE WAS KNOW WARNING WHEN THE WINDOWBROKE, THEN I WAS GETTING HIT IN THE FACE WITH RAIN IT FELT LIKE GLASS HITTING ME IN THE FACE. THIS SHOULD BE A RECALL BY FORD, I HAVE RESEARCH THIS PROBLEM AND HAVE FOUND IT TO BE MASSIVE IN NUMBERS WITH A BIG EXPENSE TO FORD CUSTOMERS. THIS MANY CASES SEEMS MORE THAN JUST A FLUKE INCIDENT. THIS SHOULD BE LOOKED INTO, I'M SO LUCKY TO BE HERE NOW I JUST MISSED THOSE TREES AND MY WIFE IS NOW SCARED THAT IT MAY HAPPEN TO ONE OF MY OTHER REMAINING WINDOWS AND DOES NOT WANT TO RIDE WITH ME ANYMORE.. *TR
Visibility, Jun 29, 2011
THE WINDOW STARTED MAKING NOISE WHILE ROLLING UP AND DOWN AND SEEMED LIKE IT WAS COMING OFF THE TRACK.. WHILE DRIVING DOWN THE ROAD THE WINDOW FELL COMPLETELY IN THE DOOR. WE REPLACED THE WINDOW REGULATOR AND SEEMS TO WORK FINE, UNTIL 3 MONTHS LATER ANOTHER WINDOW DID THE SAME THING. I CANNOT AFFORD TO KEEP REPLACING THE SAME PART ON MY TRUCK WHEN THERE ARE OBVIOUSLY DEFECTS IN THE PARTS. I SEE MANY OTHER FORD OWNERS WITH THE SAME PROBLEM AND THINK THAT SOMETHING NEEDS TO BE DONE! GOD FORBID THE WINDOW SHATTER WHILE MY CHILDREN ARE IN THE TRUCK. *TR
Visibility, Jun 23, 2011
TL* THE CONTACT OWNS A 2004 FORD F150. WHILE DRIVING APPROXIMATELY 50 MPH, THE FRONT DRIVER SIDE WINDOW SUDDENLY DROPPED INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN ADVISED THAT THE WINDOW TRACK INSIDE THE DOOR NEEDED TO BE REPLACED. THE FAILURE LATER RECURRED ON THE FRONT PASSENGER SIDE WINDOW AND REAR DRIVER SIDE WINDOW. THE FRONT DRIVER AND PASSENGER SIDE WINDOW TRACKS WERE REPLACED. THE REAR DRIVER SIDE WINDOW TRACKS WERE NOT REPLACED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Visibility, Jun 22, 2011
AFTER A PROFESSIONAL BASEBALL GAME.. I WALKED BACK TO MY TRUCK IN A HUGE PARKING LOT TO FIND MY RIGHT REAR WINDOW DOWN. MY FIRST THOUGHT WAS MY TRUCK WAS BROKEN IN TO.. BUT AFTER LOOKING AROUND, I FIND THAT MY WINDOW REGULATOR BROKE "AGAIN"!! THIS IS THE THIRD WINDOW THAT HAS DONE THIS!! I NEVER EVEN ROLL THE BACK WINDOW DOWN SO IT CANT BE FROM ABUSING THE HARDWARE.. FORD NEEDS TO DO SOMETHING ABOUT THIS SOO!! MY BROTHER HAS THE SAME YEAR TRUCK AND HE HAD TWO WINDOW REGULATORS GO OUT!! *TR
Electrical system, Visibility, Jun 19, 2011
WHILE I WAS DRIVING, THE REAR DRIVERS SIDE WINDOW MADE A LOUD POP AND THE WINDOW JUST FELL DOWN. THE WINDOW WILL NOT GO BACK UP. IT IS STUCK DOWN. I COULD NOT FIND ANY RECALL ON THE WINDOW BUT GOOGLED AND FOUND THAT IS A PROBLEM FOR A LOT OF FORD F150 OWNERS. *TR
Visibility, Jun 17, 2011
TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS THE DRIVERS SIDE FRONT AND REAR WINDOW WOULD SUDDENLY FALL WITHOUT ANY WARNING. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY HAVE NOT DIAGNOSED THE FAILURE. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,000.
Visibility, Jun 13, 2011
WINDOW REGULATOR PROBLEM. WINDOWS FALLS WHILE DRIVING. REPLACE IT ONCE AT DEALERSHIP UNDER WARRANTY. ... IT FAILED AGAIN WHILE DRIVING. *TR
Visibility, Equipment, Jun 3, 2011
DOOR WINDOW WILL NOT OPERATE UP OR DOWN. *TR
Visibility, Equipment, Jun 3, 2011
DOOR WINDOWS DO NOT OPERATE UP OR DOWN WHEN PRESSING ROCKER SWITCH - 2ND TIME FOR REPAIR OF PROBLEM. *TR
Visibility, Jun 1, 2011
WHILE DRIVING ON THE HIGHWAY MY DRIVERSIDE WINDOW CAME CRASHING DOWN CAUSING ME TO FISHTAIL INTO THE RIGHT LANE CAUSING OTHER CARS TO SLAM ON THEIR BRAKES LUCKILY NO ONE WAS HURT. WHEN I CALLED FORD AND SOME OTHER MECHANICS THEY SAID ALLOT OF PEOPLE HAD THE SAME PROBLEM AND ITS PROBABLY GOING TO HAPPEN AGAIN TO THE OTHER WINDOW. BUT THERE'S NO RECALL BECAUSE ITS NOT A EMISSION OR SAFETY PROBLEM. ??? WINDOWS FALLING WHILE DRIVING ON THE HWY NOT A SAFETY CONCERN. WELL IM JUST GONNA HAVE TO KEEP PAYING $400 FOR WINDOW REGULATORS TO KEEP MY FAMILY SAFE.... *TR
Visibility, Jun 1, 2011
SECOND POWER WINDOW REGULATOR HAS FAILED NOW IN THE LAST TWO WEEKS. IN BOTH CASES, THE WINDOW SUDDENLY DROPPED COMPLETELY WHILE I WAS DRIVING ON THE HIGHWAY AT HIGHWAY SPEEDS. *TR
Visibility, May 25, 2011
I OWN A 2004 F-150 CREW CAB FORD TRUCK. I HAVE HAD TO REPLACE 3 OF THE 4 WINDOW REGULATORS IN THIS VEHICLE. EACH ONE HAS BROKEN AT DIFFERENT TIMES. THE FORD DEALERSHIPS REPLACED THEM AT A COST OF ALMOST A THOUSAND DOLLARS FOR ALL THREE. THE DRIVER SIDE WINDOW REGULATOR IS THE ONLY ONE SO FAR NOT TO BREAK. CURRENTLY IT IS MAKING A GRINDING SOUND. ALL THREE HAVE BROKEN WITHIN THE PAST TWELVE MONTHS. THIS IS A GREAT EXPENSE TO ME AS WELL AS A GREAT DANGER. WHILE DRIVING DOWN THE ROAD ONE WINDOW REGULATOR BROKE AND THE WINDOW FELL INTO THE BOTTOM OF THE DOOR. ONE BROKE WHILE THE VEHICLE WAS NOT MOVING AND THE OTHER ONE BROKE WHILE I WAS RAISING THE WINDOW UP FROM BEING DOWN. I HAVE CONTACTED THE FORD DEALERSHIP ABOUT THE PROBLEM. THE SERVICE DEPARTMENT ADMITS THAT THERE NEEDS TO BE A RECALL DUE TO THEIR BEING A WIDE SCALE PROBLEM WITH THE WINDOW REGULATORS BREAKING. AT THE SAME TIME FORD REFUSES TO ISSUE A RECALL ON THE PROBLEM. FORD MOTOR COMPANY SHOULD BE FORCED TO ISSUE A RECALL ON THE WINDOW REGULATORS AND BE FORCED TO REIMBURSE OWNERS OF THE EXPENSES FOR HAVING TO REPLACE THE WINDOW REGULATORS. ONCE AGAIN, I HAVE SPENT ALMOST A THOUSAND DOLLARS TO REPLACE THREE WINDOW REGULATORS. AND THE LAST WINDOW APPEARS TO BE MALFUNCTIONING NOW. *TR