2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints: visibility
866 reports, newest first. Show all
Visibility, Feb 15, 2011
THE WINDOW REGULATORS FAILED ON 3 OF THE 4 WINDOWS ON OUR 2004 FORD F150 TRUCK CAUSING THE WINDOWS TO FALL ABRUPTLY AND DROP DOWN INTO THE DOOR PANELS. THE WINDOWS NO LONGER STAY UP AT ALL AND THERE IS NO WAY TO PROP THEM UP INTERNALLY. THE WINDOWS NOW LEAK WHEN IT RAINS. YOU CANNOT GO OVER A POTHOLE, BUMP OR EVEN GO THE SPEED LIMIT ON THE HIGHWAY WITHOUT THE WINDOWS FALLING DOWN AGAIN. *TR
Visibility, Feb 14, 2011
2004 F150 WINDOW REGULATOR AND NYLON CLIP DEFECTIVE. 2 OF 4 WINDOWS HAVE COME CRASHING DOWN SCRATCHING THE TINT AND FORD DEALER CHARGING OUT THE REPAIR TO MY EXTENDED WARRANTY. THESE WINDOW REGULATORS ARE OBVIOUSLY DEFECTIVE AND THE DEALER OR MANF. HAS DONE NOTHING TO RESOLVE. SAFETY HAZARD. *TR
Visibility, Feb 10, 2011
TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS THE RIGHT PASSENGER SIDE WINDOW SUDDENLY FELL INSIDE THE DOOR AND HE WAS UNABLE TO CLOSE IT . THE VEHICLE WAS NOT INSPECTED BY THE DEALER NOR HAD IT BEEN REPAIRED. THIS FAILURE OCCURRED ON THE DRIVERS SIDE WINDOW ONE YEAR PRIOR AND WAS INSPECTED BY A DEALER WHO STATED THAT THE FAILURE WAS DUE TO A DEFECTIVE WINDOW REGULATOR AND NEEDED TO BE REPLACED. THE DRIVERS SIDE WINDOW REGULATOR WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
Visibility, Jan 27, 2011
DRIVER SIDE WINDOW FELL DOWN AFTER I TRIED TO ROLL IT UP, A FEW WEEKS LATER THE BACK PASSENGER WINDOW FELL DOWN BY ITSELF. *TR
Visibility, Jan 24, 2011
I HAVE HAD MY SECOND WINDOW REGULATOR FAILURE ON MY FORD F150 2004 SUPERCREW. THIS AUTO ONLY HAS 80,000 MILES AND THIS HAS HAPPENED TWICE IN 6 MONTHS. I FEEL THIS IS DANGEROUS AND THEY NEED TO BE RECALLED BEFORE SOMEONE GETS HURT OR PROPERTY DAMAGE. *TR
Visibility, Jan 20, 2011
MY GIRLFRIEND & I WERE DRIVING OUR 2004 FORD F-150 ON THE FREEWAY GOING ABOUT 70 MPH WHEN WE HEARD A REALLY STARTLING, LOUD BANG & SAW MY DRIVERS SIDE WINDOW SLAM DOWN INTO THE DOOR. I THOUGHT SOMEONE WAS SHOOTING AT THE TRUCK OR SOMETHING & SWERVED INTO OTHER LANES IN A PANIC. WE WERE ALMOST IN A SERIOUS ACCIDENT BECAUSE OF IT. AFTER TAKING THE DOOR PANEL OFF & SEEING ALL THE WIRE CABLES HANGING THERE & BROKEN PLASTIC PIECES I DID SOME RESEARCH & FOUND THOUSANDS OF COMPLAINTS ABOUT THE SAME THING. THIS IS A SAFETY ISSUE FOR US & OTHERS. WE WERE FORTUNATE ENOUGH TO NOT BE INJURED OR INJURE ANYBODY ELSE. FROM WHAT I HAVE READ, WE SHOULD EXPECT IT TO HAPPEN AGAIN WHICH REALLY BOTHERS ME. WE HAVE 3 SMALL CHILDREN & IF THIS HAD HAPPENED OR HAPPENS AGAIN WHEN THEY ARE IN THE CAR & WE GET INTO AN ACCIDENT, WE ALL COULD GET SERIOUSLY INJURED OR EVEN KILLED. THIS IS COMPLETELY UNACCEPTABLE & NEEDS TO BE RECALLED IMMEDIATELY. FORD NEEDS TO BE HELD ACCOUNTABLE FOR PUTTING OUT FAULTY PARTS BEFORE SOMEONE GETS HURT OR KILLED. WE KNOW THERE IS A PROBLEM, WHY HASN'T ANYBODY DONE ANYTHING ABOUT IT IS BEYOND ME THOUGH. AND TO ADD INSULT TO INJURY THEY ARE ASKING OVER $400 PER WINDOW TO REPLACE WITH THE SAME FAULTY PART. I'M NOT POSITIVE, BUT I BELIEVE IT WILL HAPPEN TO MY PASSENGER SIDE WINDOW SOON TOO BECAUSE IT HAS NOT WORKED RIGHT SINCE THE FIRST COUPLE WEEKS I BOUGHT MY TRUCK, NOT EVEN A FULL YEAR AGO & ITS BEEN MAKING NOISES. RECALL IMMEDIATELY PLEASE! *TR
Visibility, Jan 20, 2011
I HAVE HAD ALL FOUR WINDOW REGULATORS GO OUT ON MY 2004 FORD F150 TRUCK. THIS IS RIDICULOUS THAT THERE HAS NOT BEEN A RECALL BECAUSE THEY ARE OBVIOUSLY DEFECTIVE. TONS OF PEOPLE ARE GOING THROUGH THIS AND I AM FED UP WITH DRIVING WITH TWO BROKEN BACK WINDOW THAT FALL DOWN WHEN THEY ARE NOT TAPED UP. *TR
Visibility, Jan 20, 2011
DATE OF INCIDENT: 1/20/2011 VEHICLE: 2004 FORD F-150 COMPLAINT: PASSENGER WINDOW SUDDENLY DESCENDED INTO DOOR AND SHATTERED. DRIVER SIDE WINDOW HAD THIS ISSUE IN AUGUST OF 2010. REPLACED BY DEALER AT MY COST (APPROX $400). INTERNET SEARCH SHOWED OVER 1000 COMPLAINTS ON THIS ISSUE AND NO RECALL FROM FORD. THIS IS A POTENTIAL SAFETY ISSUE AND NEEDS TO BE ADDRESSED BY FORD!! *TR
Visibility, Jan 20, 2011
WHILE DRIVING AROUND 55 MPH, FRONT PASSENGER WINDOW FELL INTO THE DOOR WITH A LOUD SLAM. UNABLE TO USE THE WINDOW CONTROLS TO RAISE THE WINDOW. THIS IS THE 4TH DIFFERENT WINDOW IN THIS VEHICLE AND FINAL WINDOW TO GO WITHIN A YEAR AND A HALF. THIS IS A 2004 FORD F150 SUPERCREW AND THE DEALER STATES IT IS THE WINDOW REGULATOR AS WAS THE CASE IN THE OTHER WINDOW FAILURES. THEY SAY THE REGULATOR PART (SMALL PLASTIC PIECE) THAT FAILS IS NORMAL WEAR AND TEAR, HOWEVER THEY NO LONGER MAKE THAT PART, THEY HAVE CHANGED MANUFACTURES AND THE NEW PART SHOULD NOT DO THIS. THE MOTOR AND THE REGULATOR ARE STILL GOOD, HOWEVER YOU MUST PURCHASE BOTH OF THESE IN ORDER TO GET THE NEW PLASTIC PIECE, WHICH IS NOW AN ALL INCLUSIVE PART AROUND 200.00 AT DEALER. *TRF
Visibility, Jan 15, 2011
REAR WINDOW FELL CAUSING AIR TO RUSH IN COULD NOT RAISE REAR WINDOW, 1 YEAR OLD CHILD IN BABY SEAT IN BACKSEAT. COULD HAVE BEEN CATASTROPHIC. NO WARNING NO WAY TO RAISE WINDOW. READ NUMEROUS INSTANCES OF THIS SAME EVENT HAPPENING TO THOUSANDS OF OTHERS WITH SAME MODEL YEAR AND MANUFACTURER. *TR
Visibility, Jan 7, 2011
ON THE BELOW DATE MY PASSENGER DOOR WINDOW FELL DOWN IN TO THE DOOR. THIS IS THE 3RD WINDOW TO DO THIS. IT HAPPENED WHILE DRIVING AND SCARED ME SO BAD I ALMOST DROVE OFF THE ROAD. THERE WAS A LOUD POP AND THE WINDOW WAS GONE. *TR
Visibility, Jan 6, 2011
WINDOW REGULATORS FAILING REPEATEDLY. *TR
Visibility, Dec 31, 2010
POWER WINDOW REGULATOR FAILURE. PLASTIC PART CRACKS THAT IS ATTACHED TO THE REGULATOR MOTOR WHICH GUIDES THE WINDOW CABLE. RESULTING IN THE WINDOW DROPPING DOWN INSIDE THE DOOR PANEL. FAILURE OCCURS APPROXIMATELY EVERY 6-12 MONTHS. FAILURE HAS OCCURRED IN ALL FOUR DOORS. NEW REPLACEMENT WINDOW REGULATOR IS REQUIRED TO REPAIR THE PROBLEM. *TR
Visibility, Dec 27, 2010
I HAVE A FORD F150 SINCE NEW AND CONTINUE TO HAVE PROBLEMS WITH MY WINDOWS - THIS IS A 2004 FX4 MODEL CREW CAB / WITH P/W . I HAVE INSTALLED THREE POWER WINDOW SWITCHES NOW AND TODAY HAD MY RIGHT REAR WINDOW FALL OPEN WHEN DRIVING - WITH A VERY LOUD CRASH / BANG NOISE - I THOUGHT SOMEONE HIT ME IN THE NEXT LANE AND ALMOST SWERVED TO AVOID A EMPTY LANE / I COULD HAVE HIT SOMEONE ELSE OR CAUSED INJURY / THIS PROBLEM IS VERY COMMON I AM FINDING OUT AND YET FORD WONT HELP....IF SOMEONE DIES THEN MAYBE.... *TR
Visibility, Dec 24, 2010
I HAVE A 2004 FORD F-150 LARIAT SUPERCREW 4 DOOR TRUCK. EACH OF THE PAST 3 YEARS I'VE HAD 3 WINDOW REGULATORS BREAK. TO THE DAY THEY ARE STILL NOT FIXED BECAUSE OF COST ISSUES,ALMOST $200 EACH NOT INCLUDING THE $140 LABOR BILL. WHAT BREAKS IS THE PLASTIC PART THAT THE CABLE IS CONNECTED TO. THE FIRST 2 WINDOW REGULATORS BROKE QUIETLY WHILE THE 3RD ONE MADE 2 LOUD POPS AND THE WINDOW FELL DOWN. IT IS NOW WINTER AND I HOPE THE 4TH AND FINAL WINDOW DOESN'T BREAK. THE FORD SERVICE DEPARTMENT TOLD ME THEY ARE SOLD AS A WHOLE UNIT,MOTOR,TRACK AND CABLE. THE MOTORS DON'T GO BAD, THE PLASTIC PIECE IN THE TRACK BREAKS. CURRENTLY I HAVE PLASTIC PVC PIPE PROPPING THE WINDOW UP ON THE 3 WINDOWS. VERY MUCH AN INCONVENIENCE WHEN YOU DRIVE UP TO A DRIVE THRU WINDOW AND NEVER KNOW WHEN YOUR WINDOWS GOING TO GIVE OUT. *TR
Visibility, Dec 22, 2010
RECALL 2004 FORD F-150 POWER WINDOW REGULATORS. REAR DRIVERS PASSENGER WINDOW FELL DOWN WHILE PARKED. THE THIRD WINDOW DOWN IN THE LAST 15 MONTHS. *TR
Visibility, Dec 21, 2010
FORD FX4 WINDOW DROPPED BUT WAS LUCKY IT DIDNOT BREAK HAD TO REPLACE THE WINDOW REGULATOR. *TR
Visibility, Dec 15, 2010
TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT NOTICED THAT THE FRONT WINDOWS WOULD OPEN WITHOUT WARNING AND REMAIN STUCK IN THAT POSITION. THE DEALER WAS AWARE OF THE ISSUE, BUT OFFERED NO ASSISTANCE. THE CONTACT DID NOT INFORM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 49,000. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.
Visibility, Dec 9, 2010
TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE FRONT PASSENGER SIDE WINDOW FELL INTO THE DOOR. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Visibility, Dec 9, 2010
THIS IS UNBELIEVABLE THAT FORD CAN GET AWAY WITH THESE JUNK REGULATORS ON MY 2004 FORD F150 SUPERCREW !!!!! MY DAUGHTER WAS LOOKING OUT OVER THE REAR WINDOW HOLDING ON TO IT, AND LAUGHING AT ME WHILE I WAS WASHING THE TRUCK WHEN THE [XXX] THING JUST BROKE CAUSING HER TO FALL AND HIT HER FACE OFF THE DOOR PANEL !!! THEN I GO ONLINE AND FIND 1000'S OF COMPLAINTS THAT FORD WON'T DO ANYTHING ABOUT, SO NOW I HAVE TO REPAIR THIS AT MY OWN EXPENSE. FORD NEEDS TO REPLACE THESE BEFORE SOMEONE ELSE GETS HURT !!!!!!!!!!!!!!!!!!!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)*TR
Visibility, Dec 5, 2010
2004 FORD F-150 POWER WINDOW REGULATOR FAILS ON BOTH WINDOWS. ONE FAILED WHILE I WAS DRIVING AND THE OTHER FAILED WHILE THE TRUCK WAS PARKED. I UNDERSTAND THERE ARE ALLOT OF COMPLAINTS OF THIS HAPPENING BUT,YET YOU HAVE NOT FORCED FORD TO CORRECT THIS PROBLEM. *TR
Visibility, Dec 3, 2010
THE DRIVERS WINDOW REGULATOR FAILED WHILE DRIVING, AND THE WINDOW CAME CRASHING DOWN. I WAS NOT USING OR ADJUSTING THE WINDOW IN ANY WAY PRIOR TO FAILURE. THE WEATHER WAS COLD AND WET LEAVING WATER DAMAGE TO THE INTERIOR AND CAUSING DIFFICULTY DRIVING IN THE ADVERSE CONDITIONS. I WAS NOT DRESSED TO BE IN 60 MPH COLD BLASTING AIR AND MY HANDS WERE HAVING PROBLEMS STEERING. THE DEALER DID NOT ACCEPT RESPONSIBILITY FOR THIS. FORD CONTACTED ME AND ACCEPTED RESPONSIBILITY BUT ONLY WANTED TO PAY FOR 50% OF THE REPAIR COST. THIS IS NOT ACCEPTABLE. MY VEHICLE HAS VERY LOW MILES AND IS IN LIKE NEW CONDITION. AFTER INVESTIGATING THE ISSUE WITH THE REGULATOR, I WAS AMAZED THAT THERE ARE MANY THOUSANDS OF FORD OWNERS WITH THIS SAME ISSUE. AND '04-08 F150'S HAVE THE VAST MAJORITY OF COMPLAINTS ABOUT THIS PROBLEM. MANY HAVE HAD MULTIPLE WINDOWS FAIL. I HAD TO REPLACE THE REGULATOR MYSELF AS THE COSTS TO GET THIS DONE IS OVER $500 AT THE DEALER, AND OVER $400 AT A REPAIR SHOP. WHEN I REMOVED THE REGULATOR I WAS SHOCKED AT HOW POORLY THE PARTS WERE MADE. THE DESIGN LOOKS TO BE FLAWED AS WELL. CLIPS THAT CAN FALL OFF. CABLES THAT CAN FALL OFF SMALL PLASTIC WHEELS. AND THE POWER MOTOR REELS TWO CABLES UP TOGETHER. THIS IS GOING TO BIND UP AND FAIL IN A VERY SHORT PERIOD OF TIME. THE MOTOR REEL HAD BOTH CABLES TANGLED WHEN I PULLED IT OUT. IT APPEARS TO BE DESIGNED TO FAIL. THIS IS A VERY HEAVY PIECE OF GLASS, AND THE MECHANISM SUPPORTING THIS ASSEMBLY IS COMPLETELY INSUFFICIENT. IT IS OBVIOUS THAT IT WAS NOT DESIGNED FOR EXTENDED USE.
Visibility, Dec 3, 2010
PASSENGER SIDE WINDOW IN MY 2004 F-150 XLT CAME CRASHING DOWN. *TR
Visibility, Dec 1, 2010
IN 2009 I HAD A WINDOW REGULATOR REPLACED IN THE REAR OF MY 2004 F150 FX4 BEHIND THE PASSENGER SEAT THIS YEAR IN JUNE THE REAR WINDOW REGULATOR BEHIND THE DRIVER HAD TO BE REPLACED, AND NOW IN NOVEMBER THE REAR PASSENGER REGULATOR HAS AGAIN FAILED IN LESS THAT 18 MONTHS. IN BOTH INSTANCES THEY WERE REPLACED UNDER A WARRANTY I BOUGHT AT HALL FORD IN NEWPORT NEWS AND PAID EACH TIME A $100 DEDUCTIBLE TO HAVE IT REPAIRED. I FIND IT UNREASONABLE THAT A PART WOULD FAIL THREE TIME IN 17 MONTHS AND SINCE FORD IS THE ONLY COMPANY THAT MAKES THE PART I CAN FIND I HAVE NO CHOICE BUT TO GET ANOTHER FORD BRANDED PART THAT I FEEL WILL JUST ONCE AGAIN FAIL ON ME. THERE ARE MANY COMPLAINTS ON THIS ON NOT ONLY FORUMS, BUT THE NHTSA HAS RECEIVED MANY REPORTS OF THIS ISSUE. AFTER CONTACTING FORD DIRECTLY AND GETTING CANNED RESPONSES THAT THERE IS "NO RECALL" "NO PROGRAMS" AND "NO WARRANTY". I FEEL AS IF THERE IS AN ISSUE WITH EITHER THE DESIGN OF THE PART OR THE MATERIALS USED IN THE MANUFACTURING OF THE PART THAT IS CAUSING SOME KIND OF FAULT RESULTING IN THE FAILURE AND ULTIMATELY THE REPLACEMENT OF THE WINDOW REGULATOR WITH A FORD PART ONLY OF THE SAME DESIGN. *TR
Visibility, Nov 29, 2010
I OWN A 2004 F 150 4 DOOR SUPERCREW AND ALL 4 WINDOWS REGULATORS HAVE FAILED ON THEIR OWN. I HAD THREE FAIL WITHIN DAYS OF EACH OTHER ABOUT A YEAR AGO. NOW, TODAY THE FOURTH ONE FAILED. EACH TIME ONE FAILED I WAS DRIVING DOWN THE HIGHWAY AT 65 MPH AND THE WINDOW SLAMS DOWN SCARING THE HECK OUT OF ME. LUCKILY I'VE BEEN ABLE TO MAINTAIN CONTROL OF MY TRUCK. THE PROBLEM IS ALWAYS THE STEEL CABLE GETS KINKED UP ON ITS OWN AND SNAPS OR KINKS UP SO BAD IT CAN NOT BE REUSED. EACH TIME ITS A 300 DOLLAR FIX SO WHEN I REPLACE THIS LAST ONE I'LL BE ABOUT 1200 DOLLARS OUT. I FINALLY LOOKED ON THE INTERNET AND FOUND OUT THAT THIS PROBLEM IS COMMON AND FORD WILL NOT OWN UP TO THEIR RESPONSIBILITY. I DON'T KNOW IT THIS IS A DESIGN FLAW BY FORD OR THE SUPPLIER TO FORD THAT MAKES THE WINDOW REGULATOR BUT I DO KNOW THERE HAS BEEN NO RECALL AND THAT YOU CANNOT BUY THE PARTS YOU NEED EXCEPT AT FORD PARTS DEALERS ONLY. SINCE FORD DOESN'T SEEM TO CARE TO FIX THIS PROBLEM I AM NEVER BUYING ANOTHER FORD. *TR