2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints: engine
231 reports, newest first. Show all
Engine and engine cooling, Apr 12, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT WAS DRIVING AT RELATIVELY LOW SPEEDS WHEN THE BRAKES WERE APPLIED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE ENGINE MASS AIR FLOW SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 90,000.
Engine and engine cooling, Mar 29, 2011
MY 2005 FORD F150 QUIT WHILE DRIVING DOWN THE HIGHWAY WITH MY 12 YR OLD SON. ENGINE BEGAN TO SPIT AND SPUTTER AND STRANDED US ON THE HIGHWAY. AFTER TOWING TO MY LOCAL FORD DEALER. THE DEALER DISCOVERED THE TIMING CHAIN HAD SLIPPED CAUSING THE TRUCK TO JUMP TIME AND RUINING THE ENGINE. THE TRUCK HAS 130,000 HIGHWAY MILES. NOW THEY WANT $7,500 FOR A NEW ENGINE. THE OTHER ISSUE IS MY REAR DRIVER SIDE WINDOW JUST FELL INTO THE DOOR. THEY WANT BETWEEN 200 AND 300 DOLLARS TO REPAIR.
Engine and engine cooling, Mar 24, 2011, fire
2005 FORD F150 SPARK PLUG EJECTED FROM ENGINE. *TR
Engine and engine cooling, Mar 21, 2011
2005 F150 SUPERCREW 4X4 LARIAT; WITH A 5.4 3 VALVE/CYLINDER ENGINE; CHECK ENGINE LIGHT CAME ON AND INDICATED CYLINDER 5; MECHANIC WENT TO PULL THE PLUG WHICH BROKE IN TWO WITH THE BOTTOM PART STILL IN THE BLOCK. HAD TO HAVE IT TOWED TO A FORD DEALER; $150 TO REMOVE THE PLUG PLUS $29 PARTS AND LABOR. PLUG HAS A DESIGN FLAW THAT FORD HAS KNOWN ABOUT SINCE AT LEAST 1997. FOR MOST TRITON EGNINE OWNERS, YOU FIND OUT THE HARD WAY WHEN THE ENGINE LIGHT COMES ON OR WHEN YOU GO IN FOR A TUNE UP; MINIMUM COST $150; FOR EVERY BROKEN PLUG - $150 TO REMOVE IT; IF IT CAN NOT BE REMOVED, THE ENGINE AND/OR FRONT END HAS TO BE PULLED (PER FORD REPAIR BULLETIN) TO REMOVE THE HEAD(S). COST: $1,000 - $3,000. MOST VEHICLES ARE "OUT OF WARRANTY" BY THIS TIME WHICH FORD THEN DISMISSES AS NOT A "WARRANTY PROBLEM" BUT RATHER A "SERVICE ISSUE". THE DEALERSHIPS MAKE A KILLING OFF THE CUSTOMERS BECAUSE OF AN INEPT, INCOMPETENTLY DESIGNED SPARK PLUG. FORD HAS KNOWN ABOUT THIS PROBLEM SINCE THE LATE 1990S BUT REFUSES TO DO ANYTING AS THE NTSB HAS DONE NOTHING TO ISSUE A RECALL. DUH *TR
Engine and engine cooling, Mar 16, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE MECHANIC INFORMED THE CONTACT THAT A SPARK PLUG HAD FRACTURED IN THE HEAD OF CYLINDER FIVE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WERE NO RECALLS FOR THE FAILURE AND SUGGESTED THE CONTACT KEEP ALL RECEIPTS FOR POSSIBLE REIMBURSEMENT IF THERE WAS A RECALL IN THE FUTURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 100,800.
Engine and engine cooling, Mar 7, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO MANEUVER OFF THE ROADWAY AND SHIFTED INTO PARK. HE WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL MINUTES. THE FAILURE RECURRED APPROXIMATELY FIVE TIMES AND THE VEHICLE WAS TAKEN TO BOTH AN AUTHORIZED DEALER AND AN INDEPENDENT MECHANIC WHO WERE BOTH UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 03/24/11*LJ UPDATED 04/05/11*LJ UPDATED 04/05/11
Engine and engine cooling, Fuel system, Other, Feb 23, 2011
I OWN A 2005 FORD F-150 WHICH I RECEIVED A LETTER FROM FORD STATING THAT MY FUEL INJECTORS WERE GIVEN A DEFECT ONLY EXTENDED WARRANTY TO 150,000 MILES. I HAVE HAD A FEW INJECTORS REPLACED SINCE THE LETTER BECAUSE OF DEFECT..I.E WHITE SMOKE FROM EXHAUST AND STUTTER OF ENGINE WHILE DRIVING. RIGHT AFTER MY LAST REPLACEMENT OF A FUEL INJECTOR MY CATALYTIC CONVERTER WAS GIVING A BAD ODOR..AFTERWARDS I HAD A DIAGNOSTIC CHECKED AND THE OUTCOME WAS A BAD CONVERTER. AFTER SEVERAL FORUMS I HAVE READ I HAVE NOTICED THAT SEVERAL....SEVERAL.. PEOPLE HAVE CATALYTIC CONVERTER PROBLEMS AFTER THE REPLACEMENT OF FUEL INJECTORS..SOME EVEN HAVING TWO OR THREE REPLACED WITHIN JUST A FEW THOUSAND MILES AND AFTER HAVING ANOTHER FUEL INJECTOR REPLACED. IS THE FUEL INJECTOR PROBLEM A PROBLEM FOR THE CONVERTER..ITS A BIG COINCIDENCE THAT SO MANY HAVE HAD THE SAME PROBLEMS AFTER REPLACING DEFECTIVE FUEL INJECTORS.. *TR
Engine and engine cooling, Feb 23, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE VEHICLE EXHIBITED AN ABNORMAL GRINDING NOISE FROM THE ENGINE WHETHER THE VEHICLE WAS PARKED OR IN MOTION. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Engine and engine cooling, Electrical system, Other or unspecified, Feb 4, 2011
WHILE DRIVING VEHICLE AT ANY SPEED FROM 10 MPH TO 70 MPH THE TRUCK WILL GO INTO SAFE MODE (LIMP-HOME MODE) GOING DOWN TO 5 MPH AND LOSING ALL POWER STEERING. WHEN DIAGNOSED IT IS THE THROTTLE BODY CONTROL TO ME THIS IS A SAFETY ISSUE WHAT HAPPENS IF I AM DRIVING 70 MPH ON THE HIGHWAY AND IT GOES INTO SAFETY MODE AND I LOSE ALL POWER STEERING. DOES SOMEONE HAVE TO DIE BEFORE THERE IS A RECALL ON THIS??? IT WILL COST ME AROUND $1000.00 TO FIX PER BRONDES FORD IN TOLEDO OHIO AND I AM TOLD FORD HAS 2 OR 3 VEHICLES A WEEK COME IN FOR THE SAME PROBLEM. TO ME THIS IS NOT STANDARD MAINTENANCE.
Engine and engine cooling, Feb 3, 2011
ATTEMPTED TO HAVE SPARK PLUGS CHANGED IN ACCORDANCE WITH VEHICLE MAINTENANCE MANUAL AT 100,000 MILE. WHILE THIS WAS BEING DONE 3 FACTORY INSTALLED MOTORCRAFT SPARK PLUGS BROKE OFF. AS A RESULT I WAS CHARGED A TOTAL OF ALMOST $700 FOR THE REMOVAL OF THESE BROKEN PLUGS. THE DEALERSHIP TECHNICIAN INFORMED ME THAT 100% OF ALL 2004-2007 F150 TRUCKS THAT HAVE THE PLUGS REMOVED AS REQUIRED AT 100,000 MILES HAVE PLUGS THAT BREAK. FORD NOR THE DEALERSHIP WOULD COVER THE COST OF THIS DEFECTIVE PRODUCT AND DEFECTIVE FORD DESIGN. *TR
Engine and engine cooling, Jan 6, 2011
2005 F150 JUST DIES WITHOUT ANY WARNING. DRIVING DOWN THE HWY AND JUST DIES. IT HAPPENS FREQUENTLY, JUST DIES, IT ALWAYS TAKES A FEW TRIES TO GET IT RESTARTED. WE WERE TOLD THAT THE THROTTLE BODY NEEDS TO BE REPLACED. WE KNOW AT LEAST 4 OTHER FAMILYS THAT ALSO HAVE 2005 F150'S AND THEY HAVE EXPERIENCED THE SAME PROBLEM. MY CO-WORKER HAS HERS IN THE FORD SHOP RIGHT NOW AND THEY ARE CHARGING 1300.00 TO FIX IT. IT SEEMS TO ME THAT WITH ALL OF THE COMPLAINTS THIS SHOULD BE A SAFETY RECALL AND REPLACED BY FORD CO. *TR
Engine and engine cooling, Fuel system, Other, Dec 28, 2010
SPARK PLUGS BREAKING OFF IN ENGINE HEAD BECAUSE OF POOR DESIGN. JUST HAPPENED TO ME AND AFTER LOOKING AROUND THE INTERNET IT HAS HAPPENED TO A LOT OF PEOPLE AND NOW THE SERVICE DEPARTMENT OF MY LOCAL FORD DEALERSHIP SAYS IT COMMON AND NOW THEY ARE CHARGING ME BECUASE THEY BROKE IT AND ITS COMMON. *TR
Engine and engine cooling, Dec 21, 2010
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS INTERMITTENT. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT SOMEONE WOULD INSPECT THE VEHICLE. THERE WERE NO WARNING LIGHTS PRIOR TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 71,000 AND THE FAILURE MILEAGE WAS UNKNOWN.
Engine and engine cooling, Nov 17, 2010
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SPARK PLUGS IN THE ENGINE POPPED OUT OF THE CYLINDER HEAD WHICH INDICATED THAT THERE WAS NOT ENOUGH THREAD ON THE SPARK PLUGS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE SPARK PLUGS WERE REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Engine and engine cooling, Oct 29, 2010
MY 2005 FORD F-150 LARIAT 5.4L SOUNDS LIKE A DIESEL, I WAS TOLD THIS IS A VERY COMMON PROBLEM WITH F-150'S WITHIN 2003-2006. THIS IS A RESULT OF EITHER CAM PHASERS OR BAD LIFTERS. *TR
Engine and engine cooling, Oct 3, 2010
WHILE DRIVING, MY 2005 F-150 WOULD SUDDENLY ACT AS IF THE TRANSMISSION WAS IN NEUTRAL. THE WRENCH SYMBOL ON THE GAUGE PANEL WOULD ILLUMINATE, BUT THE ENGINE WAS STILL RUNNING. THE ONLY WAY TO CLEAR THE PROBLEM WAS TO PULL OVER, PUT CAR IN PARK, SHUT ENGINE OFF, RESTART ENGINE AND SHIFT TO DRIVE. LUCKILY THIS NEVER HAPPENED ON THE HIGHWAY, BUT IT COULD HAVE LED TO A SERIOUS ACCIDENT. I HAD THE TRUCK REPAIRED, AND THE DEALERSHIP HAD TO REPLACE THE THROTTLE BODY. THIS IS NOT COVERED UNDER WARRANTY ACCORDING TO THE DEALERSHIP. TRUCK HAS ONLY 58,800 MILES ON IT. I HAVE SEEN THIS ISSUE ON THIS SITE AND OTHERS AND NHTSA REALLY SHOULD INVESTIGATE THIS ISSUE. *TR
Engine and engine cooling, Sep 1, 2010
TL*THE CONTACT OWNS A 2005 FORD F150 TRUCK. WHILE DRIVING 35-40 MPH THE VEHICLE THE VEHICLE WAS SKIPPING AND JUMPING AND IT WAS LATER TOWED TO A LOCAL MECHANIC WHO HAD TO REMOVE THE ENGINE HEAD IN ORDER TO REACH THE SPARK PLUGS. THE MECHANIC COULD NOT GET ALL OF THE SPARK PLUGS OUT OF THE VEHICLE AND REFERRED HIM BACK TO THE DEALER. THE LOCAL MECHANIC REPAIRED THE VEHICLE FOR $900 SINCE THE DEALER WANTED TO CHARGE $2800 TO REPAIR THE VEHICLE. THE CONTACT STATED THAT BECAUSE OF THE DESIGN OF THE VEHICLE THE SPARK PLUGS WERE DIFFICULT TO REACH. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 80,000.
Engine and engine cooling, Electrical system, Equipment, Aug 23, 2010
7 OF 8 SPARK PLUGS BROKE OFF WHILE CHANGING OUT ON MY VEHICAL THIS IS CRAZY HEARD ALOT OF COMPLAINTS. *TR
Engine and engine cooling, Jul 13, 2010, fire
THE F-150 WAS PARKED IN THE CARPORT ATTACHED TO MY SON'S HOUSE. IT HAD BEEN PARKED AND NOT RUNNING FOR AT LEAST 3 HOURS. A PASSERBY NOTICED THE TRUCK ON FIRE AND TRIED TO WAKE ALL OCCUPANTS IN THE HOUSE(DUPLEX). AT 5 A.M ON 9/11/2008. MY SON NEVER LEFT THE HOUSE. HIS BODY WAS FOUND JUST INSIDE THE HOUSE BY THE CARPORT DOOR. THE FIRE WAS COMING FROM SOMEPLACE IN THE ENGINE COMPARTMENT. DUE TO MY SONS EMPLOYMENT WITH THE MILITARY AT THAT TIME AND LIVING ON POST THERE HAS BEEN EXTENSIVE INVESTIGATION INTO THIS INCIDENT. I CAN SUPPLY FURTHER DATA WHEN ASKED. I HADN'T BEEN ALLOWED TO SEE ANY OF THE INVESTIGATIVE INFO UNTIL THE MILITARY COMPLETED THEIR INVESTIGATION. THAT IS THE REASON FOR THE LONG DELAY IN REPORTING THIS INCIDENT. *TR
Engine and engine cooling, Jun 28, 2010
IN THE 2005 FORD F-150 WITH THE 5.4 LITER 3 VALVE THERE IS A DEFECT PERTAINING TO THE SPARK PLUGS. IN THE EVENT THAT YOU TRY TO REMOVE THE SPARK PLUGS THEY TEND TO BREAK OFF IN THE HEAD POSSIBLY DAMAGING THE THREADS OF THE SPARK PLUG HOLE. WHEN THIS OCCURS, FORD IS CHARGING AN OUTSTANDING AMOUNT OF MONEY TO REPAIR IT. THIS PROBLEM IS ALL OVER THE INTERNET AND DOESN'T JUST AFFECT THE 2005 MODEL. IT IS A VERY SERIOUS DEFECT COSTING PEOPLE A LOT OF MONEY THAT I THINK SHOULD BE PLACED ON THE MANUFACTURES PLATE. IT IS ALMOST AS IF THEY DESIGNED THIS PROBLEM ON PURPOSE TO MAKE PEOPLE HAVE TO BRING IT TO THEIR REPAIR SHOP AND HAVE IT FIXED REGARDLESS OF THE PRICE. I HAVE PERSONALLY EXPERIENCED THIS PROBLEM ALONG WITH MANY OTHERS AND I THINK IT IS OBVIOUS THAT THE CUSTOMERS ARE NOT HAPPY WITH THE WAY FORD HAS HANDLED THE ISSUE. SPARK PLUGS ARE CONSIDERED TO BE PART OF PREVENTIVE MAINTENANCE BUT THIS IS SICKENING HOW THEY CAN GET AWAY WITH CHARGING THAT MUCH FOR A SMALL PROBLEM. THE PROBLEM WAS NOT DISCOVERED UNTIL FORD HAD SOLD SO MANY OF THEM THAT IT WOULD PROBABLY TAKE THEM YEARS TO CORRECT EVERY ONE. IT IS PRETTY MUCH GUARANTEED THAT YOU ARE GOING TO BREAK OFF AT LEAST ONE OF YOUR PLUGS WHILE TRYING TO DO THIS SMALL TASK. AS FAR AS I KNOW THE ONLY THING DONE TO CORRECT THE PROBLEM WAS THEY INVENTED A TOOL THAT WILL REMOVED THE BROKEN PART OF THE SPARK PLUG IN THE HEAD, BUT IF THE THREADS GET MESSED UP IN THE PROCESS THAT'S WHEN IT BEGINS TO START COSTING BIG BUCKS AND IT IS TOTALLY THE MANUFACTURES FAULT TO BEGIN WITH. PLEASE TAKE THIS REQUEST FOR A RECALL SERIOUSLY AS I AM NOT THE ONLY ONE WHO FEELS THIS WAY, JUST LOOK ONLINE. *TR
Engine and engine cooling, Fuel system, Other, Jun 28, 2010
NOTIFIED TODAY THAT THERE IS AN ISSUE WITH REMOVING AND REPLACING SPARK PLUGS FOR THE FORD 5.3 TRITON V8 3 VALVE ENGINE. FORD HAS ISSUED A TECHNICAL SERVICE BULLETIN TSB 08-7-6 AND IT IS NOT AVAILABLE ON YOUR WEBSITE. WHY? IF THIS IS INDEED A MANUFACTURERS DEFECT SHOULD IT NOT BE COVERED BY THEIR ORIGINAL WARRANTY OR THE MAGNUSEN-MOSS WARRANTY ACT AND OR THE UCC, ARTICLE 2. THIS PROCEDURE CAN BE BOTH TIMELY AND COSTLY FOR A CONSUMER. I HAVE RECEIVED QUOTES RANGING FROM 250 TO 1600 DOLLARS. SHOULD THE CONSUMER BE EXPECTED TO SHOULDER THE BURDEN OF THIS ISSUE? *TR
Engine and engine cooling, Jun 22, 2010
APPROXIMATELY 2 YEARS AGO I PURCHASED A 2005 FORD F-150 EXTENDED CAB TRUCK. I HAVE HAD NO PROBLEMS WITH THE TRUCK UP UNTIL THIS POINT AND MY TRUCK CURRENTLY HAS APPROXIMATELY 67,000 MILES ON IT. HOWEVER, APPROXIMATELY THREE (3) WEEKS AGO I NOTICED MY TRUCK "SPUTTERING" AND "MISSING" AND HAVING SOME DIFFICULTY STARTING. I TOOK IT TO THE DEALERSHIP (KAMAAINA MOTOR'S) THAT I PURCHASED IT FROM. THE MECHANICS ARE NOW TELLING ME THAT THE SPARK PLUGS BROKE OFF AND FELL INTO THE ENGINE "HEAD". THEY HAVE ATTEMPTED TO RETRIEVE THE PIECES OF THE SPARK PLUGS (TWO AS THEY ARE CURRENTLY REPORTING) BUT THEY FEEL THAT THE IMPACT OF THE SPARK PLUGS FALLING INTO THE HEAD MAY HAVE NOW CAUSED MY MOTOR TO FREEZE UP. AT THIS POINT THEY ARE RECOMMENDING COMPLETE ENGINE REPLACEMENT FOR MY TRUCK WHICH WILL COST THOUSANDS OF DOLLARS. I AM DEVASTATED. THIS IS MY ONLY VEHICLE AND I STILL OWE MONEY TO THE BANK TO PAY IT OFF. I DON'T HAVE THOUSANDS OF DOLLARS TO REPLACE THE MOTOR AND I KNOW CAN'T JUST GET ANOTHER LOAN FOR ANOTHER CAR. I HAVE BEEN READING ONLINE ABOUT THIS REPEATED FAILURE ON FORD'S FAULT OF DEFECTIVE SPARK PLUGS AND THAT THIS IS COMMON AND OF NO FAULT OF THE OWNERS OF THE VEHICLES. AT THIS POINT MY TRUCK IS STILL SITTING AT THE MECHANICS AND IS NOT MOVING AND I AM WITHOUT A CAR. IS THERE NOT ANYTHING THAT THE FORD COMPANY CAN DO TO BE RESPONSIBLE FOR THEIR DEFECTIVE PRODUCTIONS?? I DEVASTATED BY THIS AND HAVE NO IDEA WHAT I AM GOING TO DO TO GET BACK INTO A RUNNING VEHICLE SO I CAN GET TO WORK AND TAKE MY KIDS TO AND FROM SCHOOL. PLEASE HELP????? *TR
Engine and engine cooling, May 25, 2010
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 55 MPH, THE SPARK PLUGS DISBURSED FROM THE ENGINE AND THE VEHICLE LOST POWER AND STALLED. THE DEALER WAS CONTACTED AND THE CONTACT WAS INFORMED THAT THE REPAIRS WOULD BE AT HER EXPENSE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 80,000.
Engine and engine cooling, Power train, Apr 6, 2010
FORD MOTOR COMPANY-THERE WAS A SERVICE BULLETIN PUT OUT SHOW THERE WAS A PROBLEM WITH THE CAM PHASERS AND CAM CHAIN TENSIONER CAUSING THE ENGINE TO MAKE NOISES AND THEN ENGINE FAILURE THERE HAS BEEN LOTS OF COMPLAINTSTO FORD WITH NOTHING BEING DONE IF YOU WHERE DRIVING ONTHE ROAD AND THE ENGINE BLEW COULDCAUSE A ACCIDENT I CONTACT FORD AND THEY HAVE ALL MOST ADMITTED TO IT THAT THEY NEW THERE WAS A PROBLEM I HAVE FOUND THAT THERE HAS BEEN 1092 COMPLAINTS OVER THIS PROBLEM AND NOTHING DONE. I CONTACTED FORD AND THAT'S HOW I FOUND OUT ABOUT YOU THEY KEEP SAYING THERE SENDING THE COMPLAINT TO ANOTHER DEPT..BUT THIS IS APROBLEM THAT COULD HAVE BEEN CORRECT BEFORE THE ENGINE WAS RUINED. *TR
Engine and engine cooling, Apr 3, 2010
2005 FORD F-150 5.4L TRITON HAD 2 BLOWN SPARK PLUGS. FIRST ONE HAPPENED AT 80,000 MILES, SECOND AT 130,000. THE FIRST TIME IT DESTROYED THE EXHAUST MANIFOLD AND COST $3000 TO REPAIR. THE SECOND TIME THIS HAPPENED IT BLEW THE LEFT SIDE EXHAUST AND THE COIL PACK. THIS COST ABOUT $1500 TO REPAIR.