2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints: steering
55 reports, newest first. Show all
Steering, Jan 11, 2023
When is some one going to do something about the faulty steering column in 2006 Ford F150 pick ups and similar model years? It is all over the internet about the grinding and catching of the steering column. In some cases can't steer at all. There is tons of information on this problem. I have a 2006 Ford F150. It is starting with the problem and it only has 82,000 miles. This should not be happening some one is going to get hurt or killed !
Steering, Structure, Other or unspecified, Jul 25, 2021
My truck was sounding like it was going to fall apart, I brought it to my sons attention and u can see the truck sagging between front and bed of truck. We looked under vehicle and the frame is split in two all the way across. [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Steering, Sep 8, 2020
THE STEERING LOWER SHAFT GETS FAULTY IN THIS YEARS TRUCK DO TO BEING CHEAP MADE AND GETS CORRODED WIN SALT FROM THE ROADS BARELY TOUCHES IT WHEN DRIVING YOU HAVE TO TURN EXTREMELY HARD TO MAKE IT STEER AND IT DOESN'T TAKE MUCH FOR IT TO BRAKE WHEN GOING DOWN A HIGHWAY ONE OF THE MOST IN SAFE DESIGNS I HAVE EVER SEEN IN A NEWER TRUCK THAN 2000 THERE WAS A RECALL ON THEM THE EXACT SAME DESIGN IN THE CROWN VICS FROM 2004 TO 2008 MINE BROKE WHEN GOING DOWN THE CITY ROAD GOING ABOUT 45MPH
Steering, Nov 11, 2018
THE U JOINT ARE FREEZING UP AND IT IS HARD TO TURN AND IT GETS WORSE
Steering, Sep 8, 2018
HARD STEERING ON INITIAL START UP AND DRIVING . STEERING WOULD NOT GO BACK TO CENTER BY ITSELF HAD TO MANUALLY CORRECT..STEERING GETS BETTER THE LONGER YOU DRIVE IT.
Steering, Sep 6, 2018
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE ATTEMPTING TO MAKE A TURN, THE STEERING WHEEL SEIZED. THE FAILURE PREVENTED THE VEHICLE FROM TURNING AND ALMOST DROVE OFF A BRIDGE INTO A RIVER. THE VEHICLE WAS ABLE TO BE VEERED TO SAFETY. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
Steering, Service brakes, Engine, Dec 25, 2016
WAS DRIVING MY 2006 F-150 OVER A MOUNTAIN PASS IN CANADA. THERE WAS COMPACT SNOW AND ICE ON THE ROADWAY AND I WAS TRAVELING WITH OTHER VEHICLES AROUND ME AT APPROXIMATELY 40 MPH. THE VEHICLES AHEAD OF ME BEGAN TO BRAKE, I AS WELL TRIED TO BRAKE ONLY TO FIND MY TRUCK HAD LOST POWER AND WAS NO LONGER RUNNING. I HAD LOST POWER TO MY BRAKES AND STEERING. THIS CAUSED MY TRUCK TO BEGIN SLIDING ON THE SNOW AND ICE AND I WAS UNABLE TO CONTROL MY VEHICLE. THE CARS AROUND ME WERE SLOWING AND STOPPING AND I COULD NOT. I BEGAN TO FISH TAIL IN BOTH DIRECTIONS WHILE TRYING DESPERATELY TO CONTROL MY TRUCK WITH NO BRAKES OR POWER STEERING, I EVENTUALLY DID A COMPLETE 360 DEGREE SPIN AND SOMEHOW MANAGED TO GET THE TRUCK UNDER CONTROL WITH OUT ROLLING OVER AND INTO THE DITCH OR SMASHING INTO THE OTHER VEHICLES AROUND ME. WHEN I CAME TO A STOP MY TRUCK WAS NOT RUNNING AND THE DASH LIGHTS WERE ON. I PLACED THE TRANSMISSION INTO DRIVE AND RESTARTED THE TRUCK WITHOUT ISSUE AND CONTINUED ON WITHOUT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED WITH THIS TRUCK, THE FIRST TIME I WAS ON A RESIDENTIAL STREET AND I WAS ABLE TO JUST COAST TO A STOP AND RESTARTED THE TRUCK. THIS LAST INCIDENT ON THE MOUNTAIN PASS HAS CONFIRMED TO ME THAT I WILL NOT OWN ANOTHER FORD AS I HAVE RESEARCHED THIS PROBLEM TO FIND THAT THIS IS A COMMON ISSUE WITH FORD TRUCKS. I AM CERTAIN THIS HAS CAUSED MAJOR ACCIDENTS IF NOT DEATHS AND THE FACT THERE ARE NO ERROR CODES LEFT BEHIND FROM THE EVENTS TO VERIFY THIS HAS HAPPENED WE MAY NEVER KNOW. THE FACT IT HAS HAPPENED TO ME TWICE AND ONCE ONLY A MIRACLE A SERIOUS ACCIDENT DIDN'T OCCUR I AM DONE WITH THE FORD MOTOR COMPANY. *TR
Steering, Structure, Engine, Sep 25, 2016
POWER STEERING HOSE RUST AND LEAKING-TRANSMISSION HOSES RUSTED AND LEAKING - SPARK PLUG BREAKING OFF WHEN HAVING THEM REPLACED
Steering, Apr 23, 2016
STEERING BECAME INTERMITTENTLY STIFF WHILE DRIVING. TRUCK HAD ABOUT 80000 MILES ON IT AND 9 YEARS OLD WHEN SYMPTOMS STARTED. STIFFNESS WOULD OCCUR SOMETIMES AT HIGHWAY SPEEDS WHEN I STARTED A LANE CHANGE, AND AT SLOW SPEEDS WHEN I WAS TURNING (FOR INSTANCE ON COMMUNITY STREETS). AS I WAS TURNING IT WOULD CYCLE FROM HARD TO REGULAR EFFORT, AS WOULD BE IF A UNIVERSAL JOINT WAS GOING BAD. MY NON-FORD MECHANIC DIAGNOSED IT AS A BAD LOWER STEERING SHAFT. I INSPECTED THE BAD SHAFT AND AGREED THAT ONE UNIVERSAL SHAFT WAS TIGHT AND THE OTHER WAS EXTREMELY TIGHT. $557 REPAIR.
Steering, Mar 2, 2016
THE STEERING WHEEL FREEZES UP IN COLD WEATHER. MY MECHANIC DIAGNOSED A FAILED LOWER STEERING COLUMN THAT IS EXPOSED TO ROADWAY SPLASH AND CORROSION. THIS IS ALSO A TELESCOPING SECTION OF THE STEERING COLUMN DESIGNED TO PROTECT THE DRIVER IN CASE OF FRONTAL CRASH. SO OVERNITE IT FREEZES UP AND SLOWLY LOOSENS. WHILE DRIVING BECOMES STIF AND RESULTS IN DIFFICULT STEERING. 45,000 MILES ON ODOMETER.
Steering, Mar 1, 2016
DROVE F-150 NORMALLY DURING WEEK. ON WEEKEND MORNING WHILE PULLING OUT OF DRIVEWAY STEERING WHEEL SUDDENLY AND SPORADICALLY BEGAN RESISTING EFFORT TO TURN CAUSING TRUCK TO SWAY UNPREDICTABLY DURING TURNS. RESISTING DRIVER INPUT. WAS TOO DANGEROUS TO DRIVE. AFTER REVIEWING BLOGS ONLINE I REALIZED A LOT OF OTHER PEOPLE WHO DRIVE THIS ERA F-150 HAVE THE SAME PROBLEM. IT TURNS OUT THE LOWER STEERING COLUMN SHAFT CONTAINING THE U-JOINTS USES DEFECTIVE MATERIALS OR HAS BAD DESIGN. THE U-JOINTS ARE BINDING UP DURING DRIVING CAUSING THE DRIVER TO LOSE PARTIAL CONTROL OVER DIRECTION OF VEHICLE. TEMPORARY FIX MAY BE TO SPRAY WITH ANTI-CORROSIVE SPRAY, THEN LUBRICATING SPRAY, WHICH I DID. THIS LASTS ONLY A SHORT TIME SO THE LOWER SHAFT WITH U-JOINTS MUST BE REPLACED. FORD KNOWS OF THE DEFECT FOR THIS ERA F-150 AND HAS REDESIGNED THIS LOWER SHAFT TO ELIMINATE THE BINDING. THIS NEW DESIGN IS WHAT THEY SELL YOU AS A REPLACEMENT, NOT THE ORIGINAL DESIGN. IF YOU TRY TO BUY ONE ONLINE IT COSTS AT LEAST $245 FOR THE O.E.M. PART. IF YOU BUY ONE OF THE 2 AFTERMARKET KNOCKOFFS IT'LL SET YOU BACK APPROX $125. THE AFTERMARKET SHAFT ADVERTISING TOUTS THE FACT THAT IT HAS A DESIGN THAT WILL NOT BIND LIKE THE ORIGINAL FORD SHAFT DOES. THIS TRUCK HAD APPROX 69,700 MILES ON IT WHEN THE SHAFT BEGAN BINDING UP.
Steering, Dec 21, 2015
LAST WEEK I STARTED NOTICING MY STEERING STARTING TO GET STIFF AND THE WHEEL DOES NOT RECENTER AFTER A STEER TO THE LEFT OR RIGHT. IVE HAD TO DO SOME QUICK MUSCLING TO RECENTER THE WHEEL. I'VE JUST FINISHED RESEARCHING SOME OTHER FORD FORUMS FOR THIS VEHICLE AND MANY OWNERS HAVE REPORTED THE SAME ISSUE WITH THE U JOINTS ON THE STEERING COLUMN RUSTING OR SEIZING. I WILL TRY SPRAYING SOME ANTI SEIZE ON THE U JOINTS TOMMOROW UNTIL I CAN GET IT TO A GARAGE.MY TRUCK HAS APPROXIMATELY 103,000 MILES ON IT . THIS IS DANGEROUS AND WITH THE AMOUNT OF COMPLAINTS ON THIS IT SHOULD BE RECALLED BY FORD TO CORRECT.
Steering, Other or unspecified, Nov 30, 2015
LAST WEEK TRUCK SUDDENLY BECAME VERY HARD TO TURN GOING AROUND CORNERS. STEERING WHEEL LOCKED UP AND I ALMOST WENT OVER AN EMBANKMENT. HIT OR MISS SO I NEVER KNOW WHEN IT WILL GO OUT. THANKFULLY DID NOT HAVE MY 2 YOUNG CHILDREN! A WEEK LATER (11/29/15), TRUCK SUDDENLY STARTS TO VIOLENTLY SHAKE IF I GO OVER 50 MPH! SCARED THE DICKENS OUT OF ME! HOPING TO LIMP IT TO A DEALERSHIP AND TRADE IT IN. NOT SAFE FOR ME TO DRIVE. I HAVE PUT 20K MILES ON IT IN 2 YEARS AND HAS BEEN REGULARLY SERVICED. WHAT GIVES?!?
Steering, Nov 29, 2015
MY STEERING STARTED TO BIND WHILE DRIVING . COULD NOT MAKE FULL RIGHT OR LEFT TURNS. VERY UNSAFE. THE TRUCK HAS LEFT THAN 30,000 MILES. RARELY DRIVEN.
Steering, Oct 13, 2015
WHILE MY VEHICLE WAS IN THE SHOP FOR A FOUR WHEEL ALIGNMENT THE MECHANIC NOTED THAT THE U-JOINT IN INTERMEDIATE STEERING SHAFT IS GOING BAD AND THEREFORE THE REASON THERE IS SOME PLAY IN THE STEERING WHEEL. COST TO REPAIR IS GOING TO BE APPROXIMATELY $700
Steering, Wheels, Oct 5, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 35 MPH AND COMING TO A COMPLETE STOP, THE REAR DRIVER SIDE TIRE SEPARATED AND ROLLED INTO TRAFFIC. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR ROTOR AND STUDS FAILED AND NEEDED TO BE TIGHTENED. THE CONTACT ALSO STATED THAT HE HAD TO ALSO REPLACE THE STEERING RACK AND PINION DUE TO THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.
Steering, Power train, Electrical system, Feb 5, 2015
FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES. *TR
Steering, Jan 11, 2015
NOTICED STEERING WHEEL VERY HARD TO TURN. CHECKED POWER STEERING FLUID WHICH WAS OK. RESEARCHED PROBLEM ONLINE AND FOUND DOZENS OF SIMILAR COMPLAINTS REPORTED ON FORD CUSTOMER FORUMS AND ELSEWHERE ONLINE MENTIONING THAT THE U-JOINT(S) ON THE LOWER STEERING SHAFT POSSIBLY RUST AND CORRODE AND BECOME VERY STIFF. WHEN TURNING CORNERS WHEEL DOES NOT READILY RECENTER ITSELF. FEARFUL THAT STEERING JOINTS COULD FAIL, SEIZE OR BREAK RESULTING IN A COMPLETE LOSS OF STEERING AND SERIOUS INJURY OR DEATH. SAW THAT FORD REDESIGNED THE STEERING SHAFT AFTER 2006 AND THE NEW FORD PART LOOKS MUCH DIFFERENT THAN THE ORIGINAL SHAFT IN MY 2006 TRUCK. SPRAYED SOME PENETRATING OIL ON BOTH U-JOINTS YESTERDAY AND STEERING WAS NOTICEABLY MUCH EASIER WITHIN 5 MINUTES. THEN SPRAYED SOME LIQUID WRENCH LUBRICATING OIL (LIGHTWEIGHT AEROSOL OIL) ON BOTH JOINTS AND DROVE THE TRUCK. STEERING WAS LIKE NEW AND STEERING WHEEL EASY TO TURN. DO NOT KNOW HOWEVER IF THIS "OILING FIX" WILL LAST. FORD IS AWARE OF THIS ISSUE AS THEY REDESIGNED THE STEERING SHAFT/U-JOINTS AND HAD HUNDREDS OF COMPLAINTS. DEFECT IN DESIGN OF CRITICAL STEERING COMPONENT, FORD IS AWARE AND REDESIGNED STEERING SHAFT AND U-JOINTS. NOTE: OTHER CUSTOMERS WITH NON-FORD VEHICLES AND FORD VEHICLES OTHER THAN THE F-150 HAVE REPORTED NUMEROUS SIMILAR COMPLAINTS. *TR
Steering, Suspension, Dec 18, 2014
FRONT END BUSHINGS DETERIORATION - REPLACEMENT COST ESTIMATE $750.00
Steering, Oct 3, 2014
MY STEERING WHEEL IS STIFF. AND HARD TO TURN THE MECHANIC SAID IT IS A RECALLED RACK AND PINION. *TR
Steering, Tires, Sep 18, 2014
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE TIRES NEEDED TO BE REPLACED AND ALIGNED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,270.
Steering, Jul 11, 2014
AT VERY LOW MILEAGE I CANNOT UNDERSTAND WHY I WAS HEARING A WHINING NOISE THAT APPEARED FROM COMING THE REAR OF MY TRUCK. I WAS ADVISED THAT THE GEARS WERE BREAKING DOWN AND SHOULD BE REPLACED. THE GEAR AND PINION WERE REPLACED. SEEMS TO BE FIXED. AGAIN AT 57814 MILES? *TR
Steering, Jun 1, 2014
DRIVING WITH MY 2 KIDS ON US 23 I FELT THE STEERING GET TIGHT. STOPPED CHECK EVERYTHING LOOKED GOOD. STARTED BACK DRIVING AND ROAD CURVED TO LEFT AS I WAS DRIVING IT DID NOT WANT TO TURN BACK TO THE RIGHT. ALL MOST CAUSING TO HIT A VEHICLE HEAD ON. FINALLY GOT BACK TO THE HOUSE AND DONE SOME RESEARCH AND FIGURED OUT IT WAS LOWER STEERING SHAFT. *TR
Steering, May 20, 2014
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED MAKING THE STEERING WHEEL DIFFICULT TO TURN AND CAUSING THE VEHICLE TO LOSE CONTROL AND DRIVE INTO ON COMING TRAFFIC NEARLY CAUSING A CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED THAT A LOWER JOINT IN THE STEERING COLUMN SHAFT SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 58,000.
Steering, Mar 17, 2014
TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME UNSTABLE WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MULTIPLE TIMES. THE DIAGNOSIS WAS TO REPLACE THE STEERING SHAFT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.