2007 Ford F-150
Problems, recalls and owner-reported issues
Engine is the leading concern among 492 owner complaints filed for this model year. This is the 7th highest complaint count among 26 F-150 model years with reports.
Of the 2007 reports, 40 involved a crash and 13 involved a fire. 38 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Engine and engine coolingOct 8, 2008
ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
Campaign 08V523000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 28, 2007
ON CERTAIN TRUCKS BUILT WITH 26 GALLON FUEL TANKS, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK (NOT VISIBLE FROM OUTSIDE THE FUEL TANK). IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR A "SERVICE ENGINE SOON" INDICATOR LIGHT.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JUNE 25, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Campaign 07V278000 on NHTSA.gov
Representative owner complaints: engine
148 reports, newest first. Show all
Engine, Feb 23, 2026
I have had a coolant leak but haven't been able to find it until now. It is below the thermostat housing, between the manifolds and the metal tube that hooks the bottom of the thermostat to the manifold. I know there is a recall issued for this but it doesn't seem to come up on my truck. In my opinion it should.
Engine, May 9, 2024
The contact owns a 2007 Ford F-150. The contact stated that while her husband was driving at an undisclosed speed, there was an abnormal knocking sound coming from the vehicle. The contact's husband turned off and restarted the vehicle and the vehicle was driven to the residence. The contact stated that the vehicle failed to start the next two days. The contact stated that when the vehicle was started, the knocking sound had returned, and the vehicle was shaking abnormally. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 106,614.
Engine, Dec 8, 2023, fire
While driving lost power from 70 mph to 45 mph drove it slow home Once I parked check engine light and noticed smoke coming from behind and lower part of engine after checking for heat source noticed glowing areas it was the insulation between engine and floor I had to use extinguisher in 4 areas to extinguish I disconnected battery power
Engine, Mar 14, 2023
The phasers and the timing chain and tensioners is failing. This is premature failure due to engineering mistakes in the design. This is a safety critical walk home failure. Failure will destroy the engine (interference engine). Complete loss of all power and lock up of engine. Mechanic said the only remedy is a rebuilt engine. A reputable engine rebuilder states in their ad on the internet that they have corrected the Ford Motor Company engineering design mistakes in the 5.4l Triton engine.
Engine, Fuel system, Gasoline, Mar 6, 2023
The contact owns a 2007 Ford F-150. The contact stated while driving 70 MPH, the vehicle lost motive power and stalled with the power steering and braking functions inoperable. There was no warning light illuminated. The vehicle was towed to the residence. The contact stated that after retrieving the vehicle, he became aware that the fuel module was defective. The vehicle was repaired. The contact stated that the vehicle also experienced a premature timing belt failure. The vehicle was diagnosed by an independent mechanic and the contact was informed that the engine needed to be repaired or replaced. The engine was not repaired or replaced. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was 108,000. The consumer stated the fuel module and timing chain/phasers fail without warning.
Engine, May 31, 2022
The contact owns a 2007 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced rough driving. The vehicle was taken to an independent mechanic who diagnosed that there was a cylinder #1 misfire and that the spark plugs and coil pack needed to be replaced. The dealer was made aware of the failure and referred the contact to the manufacturer for assistance. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately over 100,000.
Engine, May 31, 2022
We are having constant problems with cylinders misfiring. Once we get one fixed, another one breaks. It’s a constant issue.
Other or unspecified, Service brakes, Engine, Apr 23, 2021
STARTED TO DRIVE MY VEHICLE BUT IT IS STUCK IN PARK
Engine, Feb 22, 2021
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE VIBRATED AND SHUDDERED UNCONTROLLABLY WITHOUT WARNING. THE CONTACT ALSO MENTIONED THAT ON OTHER OCCASIONS THE VEHICLE SHUT-OFF WITHOUT WARNING DUE TO THE FAILURE. THE CONTACT STATED THAT AFTER RESTARTING THE VEHICLE, THE RPM'S DROPPED VERY LOW. THE CONTACT REVVED THE ENGINE TO RESUME NORMAL VEHICLE OPERATION. THE CONTACT USED A SCAN TOOL TO DETERMINE THE FAILURE AND DISCOVERED THAT CHAFING ON THE WIRING HARNESS HAD CAUSED THE FAILURE. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000.
Electronic stability control (ESC), Engine, Fuel/propulsion system, Jul 9, 2020
WHEN IDLE IT HAS A ROUGH SOUND CHANGED FADERS AND SENORS STILL SAME...IT HAS A SO TRYING GAS SMELL AROUND IT AND WHEN DRIVING IT IT MAY SHUT OFF AND ALSO IT DRIVES LIKE IT NEEDS A TUNE UP BUT HAS RECENTLY HAD ONE....THE WHEEL HUB ASSEMBLY IS ALSO ACTING UP
Engine, Nov 29, 2019
EXHAUST SMELL/RAW GAS SMELL COMING THROUGH THE HEATING DUCT SYSTEM INTO THE CAB OF TRUCK. ONLY HAPPENS WHEN USING THE HEATING/DEFROST SYSTEM. DOESN'T MATTER IF THE VEHICLE IS MOVING OR AT REST. MUST CRACK WINDOW FOR FRESH AIR OR TURN OFF HEATING/DEFROST SYSTEM. THIS HAS BEEN OCCURRING SINCE MID NOVEMBER BUT ONLY WHEN TURNING ON THE HEATING/DEFROST SYSTEM. HAPPENS AT HWY SPEEDS AND LOCAL DRIVING SPEED BETWEEN 30-50 MPH.
Engine, Nov 15, 2019
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT EVERY TIME HE ATTEMPTED TO STOP THE VEHICLE, IT MISFIRED. THE CONTACT OCCURRED DAILY SINCE MAY OF 2019. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CAMSHAFT, TENSIONERS, TIMING CHAIN, VCT VALVES, AND SPARK PLUGS WERE CHANGED BY THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Power train, Engine, Fuel/propulsion system, Oct 30, 2019
EVERY VEHICLE THAT FORD PUT OUT WITH A CAM PHASER IS EXPERIENCING ISSUES WITH THE CAN PHASER. ANY SAE CERTIFIED MECHANIC WILL VERIFY THIS. THIS IS A HORRIBLE DESIGN. WHY HASN'T FORD STEPPED UP TO THE PLATE AND FIXED THIS ISSUE? I BELIEVE THEY ARE TRYING TO BURY IT SO THAT THEY DON'T HAVE TO INCUR THE COST OF FIXING THEIR MISTAKE. DUE TO THIS ISSUE I'VE BEEN STRANDED ON THE HIGHWAY. THE TRUCK LOOSES POWER, WON'T GO INTO GEAR....ETC....THIS HAPPENS AFTER THE CAN PHASER HAS ACTIVATED AND THEN I COME TO A STOP. THEN IT'S MISFIRING STALLING NOT GOING INTO GEAR...YOU NAME IT IT'S AN ISSUE. A COMPUTE READ ON THE OBD2 STAYED THAT I HAD MISSES IN IGNITION COILS 1,3 AND 7 REPLACED THEM THEN THE TEACHING STAYED MISFIRED IS 2,4 AND 5 REPLACED THEM AND ALL THE SAME ISSUES... EVERY MECHANIC I'VE SPOKEN TO SAYS ABSOLUTEY THE PHASES AND THAT THEY HAVE TO PUT A CAM PHASER DELETE KIT IN THESE VEHICLES DO GET RID OF THESE PROBLEMS. WHY HASN'T FORD BEEN HELD RESPONSIBLE FOR SUCH A TERRIBLE DESIGN?
Engine, Aug 7, 2019
TRUCK LOOSING POWER AND TAPPING AND KNOCKING NOISE, WAS TOLD IT IS PHAZERS AND TIMING CHAINS AND VCT'S AND COULD JUST STOP RUNNING WHILE DRIVING IF THE PHAZERS LOCK UP. NOW I FEEL UNSAFE DRIVING IT HAS 1700000 MILES AND FORD IS NOT STANDING BEHIND EVEN THO I HAVE TALKED TO DOZENS OF PEOPLE THAT HAVE THE SAME PROBLEM.
Power train, Engine, Jul 31, 2019
FIRST THE TRANS WENT OUT IN THE MIDDLE OF NO WHERE AT 1130 AT NIGHT WITH MY NEWBORN. THEN THE ENGINE WENT AS I WAS DRIVING TO WORK. WE FOUND OUT IT WAS THE CAM PHASERS WHICH WE HAD TO REPLACE THE ENGINE FOR. WE HAVE DONE $8000 IN REPAIRS AND IT'S NOT RECALLED??
Engine, Fuel/propulsion system, Oct 2, 2018
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED AN ABNORMAL ODOR COMING FROM THE FUEL TANK AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. NO LEAKS WERE FOUND. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO CALL NHTSA AND FILE A COMPLAINT. THE FAILURE MILEAGE WAS 142,000.
Power train, Electrical system, Engine, Sep 21, 2018
DRIVING AND STARTED TO SHAKE, HAS NASTY RATTLE (DEATH RATTLE) THREW CODE P0355. FIXED THE CODE BY INSTALLING NEW WIRES $500.00. FIXED FOR 2 WEEKS THEN STARTED DOING IT AGAIN AND CODE P0355 CAME UP AGAIN. HAS LACK OF POWER AND SHAKES BAD. VERY MUCH A HAZARD TO DRIVE.
Engine, Sep 6, 2018
THE TIME CHAIN SKIPS A TOOTH. I HAVE BEEN HAVING ISSUES WITH THIS LEADING TO INJECTORS AND CONSTANT MISFIRES. I WAS DRIVING WHEN ALL OF THE SUDDEN THE CAR STARTED LOOSING POWER AND A RATTLING NOISE STARTED.
Engine, Aug 7, 2018
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS LOW SPEEDS, THE VEHICLE BEGAN SHAKING AND A KNOCKING NOISE SOUNDED FROM THE ENGINE. THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC TEST DROVE THE VEHICLE AND DETERMINED THAT THE ROCKER ARMS NEEDED TO BE REPLACED. IN ADDITION, THE INDEPENDENT MECHANIC STATED THAT THE "VARIABLE VALVE TIMINGS" WERE FAULTY AND CREATED A MISFIRE WITHIN THE ENGINE. AN UNKNOWN FORD DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.
Other or unspecified, Engine, Jul 21, 2018
REAR DRIVER SIDE DOOR RATTLES AS IF NOT COMPLETELY SHUT WHEN DRIVING. SUN/MOON ROOF NOT OPENING.
Engine, Jul 2, 2018
MY VEHICLE HAS A 4.6L V-8 ENGINE. THE REAR SPARK PLUG ON THE PASSENGER SIDE OF THE VEHICLE EJECTED FROM IT'S CYLINDER. I WAS DRIVING AT ABOUT 50 MPH ON THE HIGHWAY WHEN THE EJECTION OCCURRED.
Engine, May 17, 2018
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE CAM PHASER SENSORS FAILED, WHICH CAUSED THE ENGINE TO SHAKE ABNORMALLY AND THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS WHERE IT WAS DIAGNOSED THAT THE CAM PHASER SENSORS NEEDED TO BE REPLACED. THE DEALER (FAIRWAY FORD OF EVANS, 4333 WASHINGTON RD, EVANS, GA 30809, (706) 854-9200) DIAGNOSED THAT THE CAM PHASER SENSORS HAD AN INTERNAL FAULT AND RECOMMEDED THAT THE ENGINE ASSEMBLY BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT HAD NOT ISSUED AN ENGINE RECALL TO ADDRESS THE FAILURE. THERE WERE NINE TSBS ON THE ENGINE AND ENGINE ASSEMBLY. THE VEHICLE REMAINED PARKED DUE TO THE INTERMITTENT FAILURES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Engine, Apr 2, 2018
VEHICLE LOSES POWER AT 45 TO 60 MPH OR ON A BUMPY ROAD DASHBOARD LIGHTS COME ON. IT HAS DONE THIS APPROX.3 TIMES.IT USUALLY STARTS BACK UP BUT I THINK ITS A SAFETY HAZARD.
Steering, Vehicle speed control, Engine, Feb 20, 2018
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS SPEEDS AND WITHOUT DEPRESSING THE ACCELERATOR OR BRAKE PEDALS, THE VEHICLE INADVERTENTLY ACCELERATED AS THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE REVVED. THE CONTACT STATED THAT THE FAILURES ALSO OCCURRED WHILE MAKING A LEFT TURN AND THE STEERING WHEEL SEIZED, WHICH MADE IT DIFFICULT TO MAKE THE LEFT TURN. THE BRAKE PEDAL WAS DEPRESSED IN ORDER TO STOP THE VEHICLE. AFTER STOPPING, TURNING OFF AND RESTARTING THE VEHICLE IT WAS ABLE TO OPERATE NORMALLY. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AT LEAST THREE OTHER TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS OPENED. THE CONTACT WAS REFERRED TO NHTSA BY THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.
Power train, Engine, Feb 9, 2018
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE ENGINE FAILED TO FUNCTION PROPERLY AND THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE SPARK PLUGS AN INJECTORS WERE REPLACED, AND AN OIL PRESSURE TEST WAS PROVIDED. THE CONTACT ALSO STATED THAT THE ENGINE MISFIRED AND WAS DIAGNOSED BY MCLARTY FORD (3232 SUMMERHILL RD, TEXARKANA, TX 75503, (903) 792-7121). THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE AND TRANSMISSION NEEDED TO BE REPLACED. THE MECHANIC REBUILT THE TRANSMISSION AND THE STARTER WAS REPLACED. THE MANUFACTURER HAD NOT ISSUED A RECALL, BUT ISSUED EIGHT TSBS FOR THE ENGINE. THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO SOLUTION OTHER THAN HAVING THE VEHICLE REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 87,402. *TT *TR