2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: electrical system
1,346 reports, newest first. Show all
Electrical system, Engine, Jan 27, 2020
2000 FORD FOCUS SE. CONSUMER WRITES IN REGARDS TO ENGINE AND ELECTRICAL PROBLEMS. *LD *JS *BF
Electrical system, Equipment, Dec 14, 2016
THE KEY WOULD NO LONGER TURN IN THE IGNITION, LEAVING ME AND MY BABY NIECE STRANDED FAR AWAY FROM HOME. WE PARKED THE VEHICLE AND WHEN WE RETURNED, WE FOUND OURSELVES STRANDED, BECAUSE THE IGNITION LOCK COULD NO LONGER BE OPERATED. APPARENTLY THIS IS A KNOWN PROBLEM WITH FORD FOCUS LOCKS! *TR
Electrical system, Exterior lighting, Vehicle speed control, May 12, 2015
I WAS DRIVING AND MY HEADLIGHTS AND INTERIOR LIGHTS STARTED TO FLICKER AND THE CHECK ENGINE LIGHT CAME ON AND THEN THE CAR JUST QUIT RUNNING AFTER 10 MINUTES I WAS ABLE TO START THE CAR AND GET HOME I HAVE HAD THIS CAR (2000 FORD FOCUS) FOR A LITTLE OVER A YEAR THE PLACE I PURCHASED IT FROM DID NOT TELL ME ABOUT ANY PROBLEMS BUT I HAVE HAD PROBLEMS FOR THE WHOLE TIME AND THEY HAVE ONLY GOTTEN WORSE I HAVE PUT AN ALTERNATOR ON IT AND CHANGED A COUPLE OF WIRES THAT WERE MELTED BUT IT DID NOT HELP! I AM AFRAID TO DRIVE THE CAR NOW ESPECIALLY WITH MY 2 YEAR OLD IN IT WITH ME THIS CAR IS NOT SAFE TO DRIVE!!!
Electrical system, Apr 17, 2015
THE IGNITION LOCK CYLINDER (WHERE THE KEY INSERTS/TURNS ON THE STEERING COLUMN) LOCKED UP ON ME WITHOUT WARNING, STRANDING ME WHERE I LAST PARKED THE CAR. NO AMOUNT OF LUBRICATION OR QUICK FIXES HELPED. FROM WHAT I HAVE READ, THIS SEEMS TO BE A VERY COMMON ISSUE WITH THE FORD FOCUS IN THAT YEAR RANGE. I'M GETTING QUOTES FROM LOCKSMITHS IN THE $250 RANGE. LUCKILY I WASN'T STRANDED IN A BAD PLACE! *TR
Electrical system, Oct 27, 2014
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT AFTER CLOSING THE REAR HATCH, THE RUNNING LIGHTS, POWER LOCKS, AND THE INSTRUMENT PANEL LIGHTS FAILED TO ACTIVATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 214,000.
Electrical system, Vehicle speed control, Engine, Aug 11, 2014
WHILE DRIVING THE VEHICLE THE ELECTRIC DASH CLUSTER QUIT WORKING AND THE VEHICLE CUT OFF IN THE MIDDLE OF TRAFFIC. THE ALTERNATOR WAS REPLACED THEN THE VEHICLE DID THE SAME THING A FEW MONTHS LATER. THE BATTERY CABLES WERE REPLACED AND THE BATTERY AND THE ALTERNATOR WERE REPLACED AS A PRECAUTION. THE VEHICLE AFTER 4 DAYS AND NO DRIVING LONGER THAT 35 MILES A DAY THE SAME THING HAPPENED AGAIN WHILE TRAVELING DOWN THE INTERSTATE. *TR
Electrical system, Jun 5, 2014
THE KEY WILL NOT TURN. THE STEERING WHEEL AND IGNITION ARE LOCKED. *TR
Power train, Electrical system, Exterior lighting, Latches/locks/linkages, Fuel/propulsion system, Apr 29, 2014
I HAVE OWNED THIS CAR SINCE DECEMBER OF 2003 AND IT HAS BEEN A VERY LARGE MONEY PIT. THIS TIME THE CAR JUST STOPPED RUNNING. I HAD TAKEN IT TO AUTOZONE AND THEY TOLD ME IT NEED AN EGR SENSOR OR HOSING FOR IT. WHEN I WAS TURNING AT A LIGHT THE CAR JUST STOPPED RUNNING WHEN I HAD JUST TURNED ONTO A MAIN HIGHWAY. THERE HAS BEEN MAJOR ELECTRICAL PROBLEMS WITH IT SINCE DAY ONE. THIS CAR HAS HAD 5 CLUTCHES IN IT AND I HAVE COMPLAINED ABOUT THAT ALL IN ITSELF BECAUSE A CAR SHOULD NEVER NEED THAT MANY CLUTCHES WITHIN 100,000 MILES. THAT IS RIDICULOUS AND VERY EXPENSIVE AND I HAVE GOTTEN NO WHERE WITH THAT EVEN THOUGH THERE ARE OTHER 2000 FORD FOCUS'S WITH THE SAME ISSUE. MY ONE HEAD LIGHT IS NOT RIGHT IT NEVER HAS BEEN THERE IS CORROSION ON THE INSIDE OF THE HEADLAMP. THE REAR DOOR LATCH DOES NOT WORK ON THE PASSENGER SIDE OF THE VEHICLE. THE PASSENGER SIDE FRONT DOOR ALSO DOES NOT LATCH CORRECTLY AND NO LONGER LOCKS AT ALL. THE TRUNK LATCH IS NOT RIGHT EITHER. IT WILL NOT ALWAYS UNLATCH AND THEN CLOSE AGAIN. IT OFTEN REQUIRES SEVERAL MORE TIMES OF PUSHING THE TRUNK RELEASE AND IT WILL FINALLY UNLOCK AFTER SEVERAL ATTEMPTS. I HAVE PUT THOUSANDS OF DOLLARS INTO THIS LEMON. I HAVE ALL THE REPAIR PAPERWORK, IT HAS A BRAND NEW BREAKING SYSTEM, BRAND NEW TRANSMISSION, BRAND NEW ENGINE, BRAND NEW CLUTCH, BATTERY. WE HAVE REPLACED EVERYTHING IN THIS CAR AND HERE WE GO AGAIN....THIS CAR HAS SAT MORE THAN IT HAS BEEN DRIVEN!!! I HONESTLY FEEL THAT WE SHOULD BE REIMBURSED FOR THE MONEY WE SPENT ON BUYING THE CAR BECAUSE IT WAS AND IS STILL A LEMON SINCE DAY ONE...... *JS
Electrical system, Engine, Mar 21, 2014
CAR WAS DRIVING NORMALLY, PARKED MY CAR, TRIED TO RESTART IT AND KEY WOULD NOT TURN. POSSIBLY A BROKEN IGNITION SWITCH. *TR
Electrical system, Exterior lighting, Other or unspecified, Aug 23, 2013
I WAS PULLED OVER ON MY WAY HOME FROM WORK ALMOST MIDNIGHT, AND WAS NOTIFIED BY THE OFFICER THAT I HAD NO TAILLIGHTS, BUT MY TURN SIGNALS AND HAZARD LIGHTS WERE WORKING. THE LICENSE PLATE LIGHT AND RUNNING LIGHTS ARE NOT WORKING EITHER. IN ADDITION, SEVERAL MONTHS AGO THE DASHBOARD LIGHTS BLEW A FUSE, AND HAVE REPEATEDLY BLOWN THE SAME FUSE. I SAW THAT THE WIRES ON TOP OF THE HATCHBACK, INSIDE THE RUBBER TUBE, ARE CRACKED AND BROKEN. I SAW ONLINE THAT THIS IS A RECURRING PROBLEM. THERE COULD HAVE BEEN AN ACCIDENT, AS I WORK SECOND SHIFT AND ALWAYS DRIVE IN THE DARK. I DON'T KNOW HOW LONG THE LIGHTS HAVE BEEN OUT. *TR
Electrical system, Exterior lighting, Apr 2, 2013
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT THE PASSENGER SIDE TAIL LIGHT WOULD NOT ILLUMINATE. SHE ALSO EXPERIENCED OTHER ELECTRICAL FAILURES ON THE PASSENGER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE BULB WAS CHANGED BUT THE FAILURE RECURRED. THE MANUFACTURED WAS NOTIFIED BUT THEY OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 224,000.
Electrical system, Feb 24, 2013
VERY HARD TO PUT KEY INTO OR REMOVE FROM IGNITION, HAVE NOT REMOVED KEY IN 8 YEARS. *TR
Electrical system, Jan 18, 2013
I WAS STARTING MY CAR, ON FIRST START DID NOT START WHEN RETRIED STARTING THERE WAS NOTHING TRIED AGAIN NOTHING OPENED HOOD AND SMOKE WAS COMING OUT FROM BATTERY COVER. REMOVED COVER AND BATTERY CABLES AND BATTERY WERE VERY HOT THE POSITIVE AND NEGATIVE CABLES STARTED MELTING. WHEN HAD COOLED ENOUGH TO TOUCH REMOVED POSITIVE CABLE AND WHEN TRIED REPLACING CABLE THERE WAS A LOT OF SPARKING, CALLED MY MECHANIC WHO PICKED THE CAR UP INSPECTED CABLES FOUND THEM TO BE DEFECTIVE CONTACTED FORD AND THE SAID THEY KNEW OF THIS PROBLEM BUT BECAUSE OF THE DATE AND MANUFACTURING PLACE OF THE CAR IT IS NOT COVERED UNDER THE RECALL FOR THIS PROBLEM. *TR
Electrical system, Nov 26, 2012
TL* THE CONTACT OWNS A 2000 FORD FOCUS. WHILE PARKED, THE CONTACT INSERTED THE KEY IN THE IGNITION BUT THE KEY COULD NOT BE TURNED. THE VEHICLE WAS TOWED AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING HOWEVER, THE MECHANIC ADVISED THAT THE VEHICLE WOULD HAVE TO BE TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 01/09/13*LJ
Electrical system, Jul 16, 2012
THE BATTERY CABLE COMING FROM THE POSITIVE TERMINAL IS MELTED. UPON INVESTIGATION I FOUND THAT THIS WAS A RECALL: NHTSA CAMPAIGN #02V288000. HOWEVER FORD IS CLAIMING THAT MY VIN IS NOT PART OF THE RECALL, EVEN THOUGH IT IS SPECIFIC FOR MY MODEL AND YEAR, AND EVEN THOUGH MY CAR IS EXPERIENCING THE EXACT ISSUE THAT THE RECALL IS FOR: FAULTY ELECTRICAL WIRING THAT CAN LEAD TO A FIRE. I HAVE NOT HAD A FIRE IN MY VEHICLE, BUT A MELTED CABLE IS CLOSE ENOUGH FOR MY LIKING. BATTERY TERMINAL CABLES SHOULD NOT BE MELTING, PERIOD. *TR
Electrical system, Latches/locks/linkages, Jun 26, 2012
TL* THE CONTACT OWNS A 2000 FORD FOCUS. WHILE PARKED, THE CONTACT PLACED THE KEY IN THE IGNITION AND WAS UNABLE TO TURN THE KEY. THE VEHICLE WAS TOWED TO THE DEALER FOR A DIAGNOSTIC TEST. THE TECHNICIAN STATED THAT THE IGNITION WOULD HAVE TO BE REPLACED. THE CONTACT ALSO NOTICED THE FRONT DRIVER?S DOOR HANDLE WAS LOOSE AND ABOUT TO FRACTURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,000. ....UPDATED 08-24-12 *BF THE CONSUMER STATED THE DOOR HANDLES BROKE. UPDATED 08/30/2012 *JS
Electrical system, Jun 11, 2012
THE IGNITION SWITCH JAMMED AS I HEAR HAPPENS ALOT WITH THESE FORDS DUE TO INFERIOR PARTS . THE DEALER CHARGED ME WITH 3.5 HOURS SHOP TIME TO FIX THIS WHEN FORD HAS ISSUED TECHNICAL SERVICE BULLITAN # 02-18-2 WHICH CALLS FOR 1.1 HOURS TO FIX AS WELL AS THE $135.05 LIST PRICE OF THE REPLACEMENT CYLINDER KIT. IF THIS IS SUCH A COMMON PROBLEM KNOWN TO FORD SHOULDN'T IT BE SUBJECT TO A NTSB RECALL? *TR
Electrical system, Exterior lighting, Feb 25, 2012, fire
PLASTIC INSULATION OF ELECTRICAL CONNECTOR THAT CONNECTS RIGHT HEADLIGHT BULB WITH WIRING OVERHEATED, MELTED AND CAUSED SMOLDERING FIRE THAT LED TO DAMAGING SMOKE DEPOSITS IN HEADLIGHT ASSEMBLY. FIRE STAYED CONTAINED TO HEADLIGHT HOUSING. *TR
Electrical system, Feb 17, 2012, fire
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT NOTICED THAT THE BATTERY WIRING AND CASE WERE MELTED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 02V288000 (ELECTRICAL SYSTEM:BATTERY:CABLES) BUT WAS ADVISED BY THE DEALER THAT THE VIN WAS NOT INCLUDED IN THE RECALL AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 42,650 AND THE FAILURE MILEAGE WAS 42,400.
Electrical system, Jan 16, 2012
THE KEY LOCK CYLINDER IN MY CAR FAILED TO TURN OVER ONE DAY. I WAS STRANDED FOR 3 HOURS DUE TO A FAULTY LOCK CYLINDER AND HAD TO PAY $540 DOLLARS TO GET THE PART REPAIRED. I CALLED THE FORD DIRECT LINE FOR ASSISTANCE AND THEY REFUSE TO ACCEPT RESPONSIBILITY FOR THE ISSUE. THEY ACKNOWLEDGED TO ME ON THE PHONE THAT THEY KNOW THIS IS A COMMON ISSUE, YET NOTHING CAN BE DONE UNTIL A LAWSUIT, OR RECALL IS ISSUED. I WILL NEVER BUY ANOTHER FORD VEHICLE. *TR
Electrical system, Latches/locks/linkages, Dec 12, 2011
TL* THE CONTACT OWNS A 2000 FORD FOCUS. THE CONTACT STATED THAT THE AUTOMATIC LOCKS WERE DEFECTIVE AND THE REAR DRIVER SIDE DOOR COULD NOT BE OPENED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 103,000. UPDATED 02/03/12*LJ THE CONSUMER STATED ALL OF THE DOORS BECAME SLUGGISH. THE FUSE FOR THE POWER DOOR LOCKS FAILED. THE FUSE WAS REPLACED AND FAILED AGAIN. THE DRIVER'S SIDE DOOR STOPPED OPENING AND WOULD NOT UNLOCK. UPDATED 02/10/12
Electrical system, Nov 10, 2011
I HAVE BEEN RESEARCHING THE ISSUE AND WHILE IT DOESN'T FIT WITHIN THE TRADITIONAL CONSTRAINTS OF A SAFETY COMPLAINT, IT IS INDEED A SAFETY HAZARD. THE IGNITION COLUMN OF THE 2000 FORD FOCUS WILL "LOCK" AS I WAS TOLD BY THE SERVICE REPRESENTATIVE AT A FORD DEALERSHIP. LUCKILY, THIS HAPPENED TO ME IN MY DRIVEWAY. HOWEVER, IF THIS WERE TO HAPPEN TO SOMEONE IN A REMOTE AREA, THEY WOULD BE STRANDED BY A PROBLEM THAT THEY HAVE NO CONTROL OF OR ANY IDEA THAT IT MAY HAPPEN. THE SERVICE REP TOLD ME THAT THERE WAS NOTHING I COULD HAVE DONE TO PREVENT THIS PROBLEM, AND THERE WAS NO WAY I COULD FIX UNLESS I CAME TO A DEALERSHIP. IF SOMEONE HAS A FAMILY OF FOUR (SUCH AS THE PEOPLE I BOUGHT THIS FROM) AND THEY ARE STRANDED IN THE MIDDLE OF NOWHERE, BASICALLY A DEFAULT WITH A KEY TUMBLER IS TO BLAME. THIS SEEMS UNFAIR TO THE CONSUMER. *TR
Steering, Electrical system, Oct 20, 2011
THE IGNITION ON MY 2000 FORD FOCUS IS DEFECTIVE IN THAT THE KEY DOES NOT GO ALL THE WAY INTO THE IGNITION. THIS PROBLEM APPEARS TO BE SYSTEMIC WITH THE FOCUS. THE CAR IS STRANDED IN THE PATH OF ONCOMING CARS AND PRESENTS A DANGER TO THE PUBLIC. SYSTEMIC ISSUES ACROSS A LARGE SPAN OF VIN NUMBERS PRESENT A SAFETY ISSUE AND A GENERAL PUBLIC NUISANCE. CARS ARE STRANDED IN INTERSECTIONS AND PLACES OF BUSINESS BECAUSE OF DEFECTIVE IGNITIONS THAT ARE KNOWN TO FORD. THESE ISSUES ARE ON BLOG SITES IN LARGE NUMBERS. I TRUST THE TRANSPORTATION AND SAFETY BOARD WILL RECOGNIZE THE SIGNIFICANCE OF THIS PROBLEM. I AM REQUESTING AN INVESTIGATION THAT I AM SURE WILL REVEAL PUBLIC SAFETY CONCERNS BY THE SHEER NUMBER OF INCIDENTS OF THIS IGNITION FAILURE. *TR
Electrical system, Oct 20, 2011
PUT THE KEY IN IGNITION WOULD NOT TURN. TRIED FOR OVER 2 HOURS. HAD CAR TOWED TO FORD DEALER. AFTERWARD SAW ONLINE THIS PROBLEM HAPPENS ALOT ON THIS MODEL. THIS IS A USED CAR WE BOUGHT FOR OUR DAUGHTER. SHE WAS STRANDED OVER 3 HOURS AND 50 MILES AWAY. FORD KNOWS OF THIS PROBLEM AND DOES NOT ADDRESS IT. THIS IS UNACCEPTABLE. *TR
Electrical system, Aug 26, 2011, fire
TL* THE CONTACT OWNS A 2000 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE BATTERY CABLES HAD MELTED. AFTER MOVING THE BATTERY CABLES THE VEHICLE RESTARTED AND THE CONTACT WAS ABLE TO DRIVE WITH CONSTANT DECELERATION. THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. THE CONTACT STATED THAT THE WIRES HAD COMPLETELY BURNT WITH TIME AND HE HAD THE WIRES REPLACED. THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 02V288000 (ELECTRICAL SYSTEM:BATTERY:CABLES) BUT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.