2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: electrical system
1,346 reports, newest first. Show all
Electrical system, Dec 9, 2006, fire
THE CAR HAD BEEN DRIVEN 2-3 MILES, THEN PARKED. ABOUT 15 MINUTES LATER THE FIRE WAS SPOTTED. FLAMES WERE 12 TO 15 FEET HIGH BEFORE THE FIRE DEPT ARRIVED AND PUT IT OUT. *JB
Electrical system, Dec 9, 2006
THIS IS THE 5TH TIME MY IGNITION CYLINDER LOCKED UP ON ME. I AM FED UP WITH HAVING TO REPLACE THIS. THIS IS RIDICULOUS!!!!!!!!!! *JB
Electrical system, Dec 6, 2006
I OWN A 2000 FORD FOCUS AND I AM EXPERIENCING THE IGNITION KEY LOCK. THIS IS THE SECOND TIME THIS HAPPEN TO THIS CAR, BUT THERE ARE NUMEROUS CASES LOGGED ON THE INTERNET. FORD DENIED THE PROBLEM AND DOES NOT MAKE ITSELF RESPONSIBLE FOR THIS DEFECTIVE PART. TEXAS IS A BIG STATE WITH MILES OF EMPTY ROAD AND IF THIS PROBLEM HAPPEN WHILE DRIVING ON THESES ROAD ON A WINTER OR A VERY HOT SUMMER A PERSON CAN DIE. *NM
Electrical system, Dec 5, 2006
MY 2000 FORD FOCUS HAS LESS THAN 26,000 MILES ON THE CLOCK AND THE IGNITION LOCK HAS JAMMED AND HAD TO BE REPLACED TWICE. SECOND TIME WAS AFTER WARRANTY EXPIRED. AAA CERTIFIED LOCKSMITH TOLD ME HE REPLACES HUNDREDS OF THESE LOCKS A YEAR, BECAUSE FORD IS STILL USING THE SAME DEFECTIVE OEM LOCK MADE IN GERMANY BY HUF. LOCKSMITH INSTALLED A STRATTEC #707592 WHICH HE SAID IS VERY RELIABLE AND IN FACT OEM EQUIPMENT ON OTHER FORD VEHICLES SUCH AS EXPLORER. HE SAID FORD DEALERS ARE STILL INSTALLING THE DEFECTIVE HUF LOCK AS A REPLACEMENT. *NM
Electrical system, Dec 1, 2006
TRIED TO START CAR, BUT IGNITION WOULD NOT TURN WITH KEY INSERTED. IGNITION REMAINS LOCKED EVEN WITH NEW KEY. *NM
Electrical system, Exterior lighting, Nov 24, 2006
IGNITION FAILED ON 2000 FORD FOCUS ALSO TURN CANCEL SIGNAL 3 TIMES UNDER WARRANTY AND BROKEN AGAIN OUT OF WARRANTY THE IGNITION FAILED 3000 MILES AFTER WARRANTY EXPIRED. THE TURN CANCEL DURING AND AFTER. I HAVE 1 RELATIVE AND 1 FRIEND THAT HAS HAD THE SAME THING HAPPEN. *NM
Electrical system, Nov 15, 2006
STEERING WHEEL, IGNITION, AND GEAR SHIFT ARE ALL LOCKED. THE KEY WILL NOT TURN IN THE IGNITION. *JB
Electrical system, Equipment, Nov 12, 2006
2 TIMES MY IGNITION FROZE AND THE KEY WOULD NOT TURN TO START THE MOTOR. AND I HAD TO HAVE THE IGNITION REPLACED BOTH TIMES; JULY 16,2002 AND AGAIN ON OCTOBER 13, 2006. *JB
Electrical system, Nov 6, 2006
WITHOUT PREMONITORY WARNING OR OBSERVED MARGINAL BEHAVIOR, IGNITION LOCK FAILED AND KEY COULD NOT BE INSERTED FULLY OR TURNED TO START ENGINE. KEY FINALLY TURNED AFTER A FEW MINUTES OF RE-TRYING, BANGING ON STEERING COLUMN, ETC. LOSS: TIME SPENT RETRYING, AND INTANGIBLE ANXIETY CONCERNING HAVING TO LEAVE KEY IN IGNITION OVER A WEEKEND WHILE INVESTIGATING OPTIONS FOR REPLACEMENT DURING REGULAR BUSINESS HOURS TO REDUCE COST RELATIVE TO REPLACEMENT IN THE FIELD. PROBLEM SOLVED BY PURCHASING NON-OEM AFTERMARKET IGNITION LOCK CYLINDER AT AN INDEPENDENT AUTOMOTIVE LOCKSMITH, AFTER ONLINE LITERATURE SEARCH INDICATED THAT DESPITE 4 RELATED TSBS (14533,15421,02182,13968) AND THOUSANDS OF OWNER REPORTS, FORD HAS NOT ISSUED A RECALL - SO FULL-COST SERVICE WORK DONE AT A DEALER WOULD PROBABLY RESULT IN REPLACEMENT WITH ANOTHER INSTANCE OF THE FAULTY ORIGINAL PART. I PERFORMED ALL LABOR EXCEPT FOR SETTING NEW LOCK TO EXISTING KEY PROFILE. OLD PART RETAINED. *NM
Electrical system, Nov 6, 2006
2000 FORD FOCUS IGNITION CYLINDER LOCKED. *JB
Electrical system, Nov 6, 2006
2000 FOCUS WAGON KEY DOESN'T TURN IN IGNITION THIS IS THE SECOND TIME THIS HAS HAPPENED, WHICH COST ME MONEY IN TIME LOSS FROM WORK AND HAVING A LOCKSMITH COME AND FIX IT UNTIL I CAN GET IT TO A DEALERSHIP TO REPAIR IT AGAIN!*JB
Electrical system, Nov 6, 2006
FORD FOCUS 2000 STEERING WHEEL LOCKED, AT ANY GIVEN TIME. I SPENT 4 HOURS FIVE DIFFERENT PEOPLE TRYING TO GET THIS THING UNLOCKED. THIS IS A MAJOR PROBLEM, IT HAS LOCKED UP ON ME MORE THAN 50 TIMES. THIS NEEDS TO BE FIXED!!!! RECALLED BY FORD ASAP.*JB
Electrical system, Nov 6, 2006
LIKE MANY PEOPLE, MY 2000 FORD FOCUS IS HAVING A PROBLEM WITH THE IGNITION CYLINDER LOCKING UP. IT'S HAPPENED MANY TIMES BEFORE BUT CORRECTED ITSELF AFTER MANY TRIES. HOWEVER, IT LOCKED UP AGAIN THIS PAST SATURDAY AND HAS YET TO UNLOCK. *JB
Electrical system, Nov 2, 2006
DT*: THE CONTACT STATED THE KEY DID NOT GO IN THE IGNITION CYLINDER. THE NATURE OF THE FAILURE WAS PERMANENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE IGNITION CYLINDER.
Electrical system, Oct 30, 2006
THE IGNITION SWITCH CYLINDER LOCKED AND I WAS UNABLE TO TURN THE SWITCH OR REMOVE THE KEY. SWITCH CYLINDER HAD TO BE REPLACED. I UNDERSTAND THIS IS A RECURRING PROBLEM AND HAS NOT BEEN ADDRESSED BY A FORD RECALL.*JB
Electrical system, Oct 26, 2006
2000 FORD FOCUS; IGNITION CYLINDER FAILURE. *NM
Electrical system, Oct 19, 2006
MY DAUGHTER TRIED TO START THE 2000 FORD FOCUS THIS MORNING AND COULDN'T INSERT THE KEY. IT WON'T INSERT ALL THE WAY AND WON'T TURN. THE STEERING WHEEL IS LOCKED UP. WE HAVE TO HAVE THE CAR TOWED TO THE DEALERSHIP NOW AND THEY'VE QUOTED US MORE THAN $300 TO REPLACE THE FAULTY CYLINDER. THE FORD TECH SAID THIS HAPPENS QUITE FREQUENTLY! *NM
Electrical system, Oct 17, 2006
(1) NORMAL OPERATION OF VEHICLE - NO INDICATIONS OF PROBLEMS OR ISSUES (2) IGNITION CYLINDER FAILURE CAUSING INABILITY TO START VEHICLE AND INABILITY TO OPERATE STEERING MECHANISMS TO DIRECT VEHICLE TO A LOCATION OUTSIDE OF TRAFFIC FLOW. VEHICLE WAS LEFT STRANDED AND UNABLE TO START IN A RELATIVELY SAFE LOCATION, HOWEVER, IF FAILURE HAD OCCURRED WHILE VEHICLE WAS IN RIGHT OF WAY (IF ENGINE HAD BEEN TURNED OFF TO SAVE FUEL DURING TRAFFIC JAM - FOR INSTANCE ) COULD HAVE PRESENTED SAFETY ISSUE. (3) REPAIRS IN PROGRESS - REQUIRED DRILLING OUT IGNITION CYLINDER AND COMPLETE REPLACEMENT.
Electrical system, Latches/locks/linkages, Oct 17, 2006
IN 2004 VEHICLE'S IGNITION KEY LOCK FAILS TO WORK PROPERLY. VEHICLE IS TOWED TO FORD AUTHORIZED REPAIR AND THEY CORRECT THE PROBLEM. IN 2006 VEHICLE'S IGNITION KEY LOCK FAILS AGAIN. VEHICLE IS TAKEN TO FORD AUTHORIZED REPAIR AND CORRECTED AGAIN. BOTH TIMES I WAS LEFT STRANDED SINCE THE VEHICLE'S IGNITION KEY WOULD NOT TURN TO START THE VEHICLE AND COULD NOT BE REMOVED FROM THE IGNITION. VEHICLE'S DASH LIGHTS SUDDENLY FAILED WHILE DRIVING AT NIGHT. LIGHTS COME ON AND OFF. SEVERAL TIMES DURING NIGHTIME DRIVING THE LIGHTS FAIL. VEHICLE'S DOOR POWER DOOR LOCKS AND TRUNK LOCKS FAIL AND CANNOT BE OPENED WITH KEYLESS ENTRY. A FUSE CONTINUES TO FAIL POSSIBLY DUE TO A SHORT IN THE WIRING SYSTEM. *NM
Electrical system, Oct 16, 2006
1. NO EVENTS LEADING TO FAILURE. FAILED WITH NO WARNING. 2. KEY WOULD NOT TURN IN THE IGNITION. LEFT STRANDED 30 MINUTES FROM HOME TOWN IN THE MIDDLE OF THE NIGHT. WAIT UNTIL MORNING TO SEEK HELP. 3. STILL SEEKING THE BEST SOLUTION TO THE ISSUE. *NM
Electrical system, Oct 14, 2006
I PURCHASED A 2000 FORD FOCUS SE NEW IN 2000. SINCE THEN I HAVE BEEN MINIMALLY SATISFIED WITH ITS PERFORMANCE DESPITE A STRING OF RECALLS. THIS WEEK, I WENT TO START MY CAR AND THE IGNITION LOCK SEIZED. I TRIED TO TURN IT MULTIPLE TIMES, BUMPING THE STEERING WHEEL TO RELEASE THE LOCK, AND EVENTUALLY THE KEY BROKE OFF IN THE IGNITION. I HAD TO TOW THE CAR TO A DEALER, WHO COULD NOT GET THE LOCK CYLINDER REMOVED WITHOUT DRILLING IT OUT. THE DEALER INSTALLED AN AFTERMARKET IGNITION AS PER FORD'S SERVICE BULLETIN ON THIS PROBLEM. THE TOTAL REPAIR, INCLUDING TOW, COST ME $500. I AM VERY UPSET THAT THIS PROBLEM HAPPENED TO ME DESPITE NHTSA AND FORD'S KNOWLEDGE OF ITS PREVALENCE (BULLETINS AND COMPLAINTS). I ASK FORD TO INITIATE A RECALL AND REIMBURSE ME FOR MY REPAIR EXPENSE. IN THE LEAST, I ASK NHTSA TO INVESTIGATE THIS PROBLEM AND FORCE A MANDATORY RECALL. THANK YOU FOR YOUR TIME. TUDOR HAMPTON CHICAGO, IL. * NM
Electrical system, Oct 14, 2006
2000 FORD FOCUS SE IGNITION SWITCH FAILURE. KEY WILL NOT TURN IN IGNITION, BECOMES LOCKED UP AND CAR WILL NEVER START. I HAVE TO LEAVE A KEY IN IGNITION CONSTANTLY SO THAT I CAN DRIVE IT AND NOT BE STRANDED. SINGLE MOTHER OF 2 CHILDREN WHO WOULD PREFER TO HAVE A SAFE CAR. *NM
Electrical system, Oct 13, 2006
DT*: THE CONTACT STATED THE IGNITION LOCKING MECHANISM FAILED TO DISENGAGE FROM THE LOCKED POSITION. BOTH KEYS WERE TRIED, BUT THE VEHICLE COULD NOT BE STARTED. THE SERVICE DEALER WAS CONTACTED, BUT THE MANUFACTURER WAS NOT.
Electrical system, Oct 11, 2006
I PURCHASED A CAR FROM MEGA MOTORS ON 10/3/06. ON 10/04/6 THE CAR CUT OFF ON ME IN THE MIDDLE OF THE EXPRESSWAY. I TOOK THE CAR TO THE SHOP AND A COMPUTER DIAGNOSTIC TEST PROVED THAT THE SENSORS ARE OUT ON THE CAR AND THAT THE TRANSMISSION IS OUT OF RANGE. I TOOK THE CAR BACK TO MEGA MOTORS ON 10/05/06 AND I ALSO PROVIDED THEM WITH A COPY OF THE DIAGNOSTIC REPORT. THE COMPANY ISN'T DOING ANYTHING TO HELP ME, ALL THEY ARE TELLING ME IS THAT THEY CAN'T FIX THE CAR BUT I CAN COME PICK IT UP. I DIDN'T HAVE THE CAR TWO DAYS BEFORE IT MESSED UP ON ME IN THE MIDDLE OF TRAFFIC. RUIZ AUTO SHOP SAID THAT THE CAR IS NO GOOD. I TRIED CALLING MEGA MOTORS AGAIN BUT THEY JUST KEEP ME ON HOLD FOR A REALLY LONG TIME. AS A PAYING CUSTOMER I FEEL LIKE I WAS IN DANGER FOR MY LIFE AND I CAN'T GET THE COMPANY TO PROVIDE ME WITH ANOTHER CAR NOR GIVE ME MY MONEY BACK, AFTER TWO DAYS OF HAVING THE CAR. I CONTACTED THE BBB AND FOUND THAT THIS COMPANY HAS HAD NINE COMPLAINTS SINCE 2003. *JB
Electrical system, Oct 4, 2006
I HAVE HAD MY 2000 FORD FOCUS FOR 1 YEAR, PURCHASED USED FROM A DEALER. IT HAD 60,000 MILES ON IT. ALTHOUGH I REALIZE THAT IT'S AN OLDER CAR IT'S IN GREAT SHAPE. I'M NOW HAVING IGNITION LOCK-UP PROBLEMS, LIKE SO MANY OTHER FOCUS OWNERS I KNOW. IT'S SITTING IN MY DRIVEWAY, AND I'M GOING TO HAVE TO HAVE IT TOWED BECAUSE THERE'S NO OTHER RECOURSE. THE KEY WON'T GO ALL THE WAY IN FOR ANY OF MY KEYS, AND THE STEERING WHEEL IS LOCKED. *NM