2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: electrical system
1,346 reports, newest first. Show all
Electrical system, May 18, 2005
1: ONE INCIDENT OF INSERTING KEY INTO IGNITION 2: TOTAL LOCK UP OF IGNITION,NO INJURY LOSS OF MONEY TO FIX THE PROBLEM 3: REPLACE IGNITION, IGNITION DRILLED AND NEW ONE INSTSALLED, HAVE OLD PART.
Electrical system, May 17, 2005
IGNITION SWITCH HAS SEIZED THREE TIMES EACH TIME REPLACED BY DEALERSHIPS. NEVER WARRANTIED. PLEASE NOT THE QUANTITY OF THESE FAILURES. DUE TO THE PATS SYSTEM, MOST MECHANICS WILL NOT TOUCH IT.
Electrical system, May 17, 2005
IGNITION SWITCH FAILURE. CAR UNABLE TO START. HAD TO BE TOWED TO DEALER TO HAVE IGNITION SWITCH REPLACED.
Electrical system, May 10, 2005
I HAVE A LOT OF PROBLEMS WITH MY FORD FOCUS. THE INGINITON FROZE UP ON ME AND I COULDN'T GET THE KEY OUT. IT COST $500 TO GET IT FIXED,
Electrical system, Exterior lighting, Visibility, Interior lighting, May 8, 2005
WATER LEAKING THROUGH WINDSHIELD INTO ELECTRONIC SYSTEM (GEM MODULE). THIS HAS CAUSED VEHICLE TO HAVE PROBLEMS WITH THE FOLLOWING DURING RAINY WEATHER, AND SOMETIMES LONGER, EVEN IN BEAUTIFUL WEATHER. WIPERS QUIT WORKING DURING RAINY WEATHER WHILE DRIVING DOWN HIGHWAY IN THE MIDDLE OF RAIN STORM. HEAD LIGHTS, PARKING LIGHTS AND HIGH BEAMS DON'T WORK AT ALL IN RAIN. INTERIOR LIGHTS INCLUDING DASH BOARD LIGHTS QUIT WORKING. HEAD LIGHTS AND WIPERS ALL QUIT WORKING IF RADIO IS TURNED ON. REMOTE KEYLESS ENTRY WON'T WORK. 4 X4 WON'T TRANSFER IF USED, STAYS IN ONE GEAR AND GETS STUCK, WHICH I AM SURE IS CAUSING DAMAGE TO TRANSMISSION. TWO DAYS AFTER A RAIN STORM, MY EXPEDITION WAS OUTSIDE TRYING TO START ITSELF. I WAS INSIDE WHEN I HEARD THE NOISE. IT WAS LIKE SOMEONE WAS OVER STARTING THEIR VEHICLE. IT WAS THAT GRINDING SOUND OF THE STARTER BEING OVER TURNED. WHEN I WENT OUT SIDE TO MY DISBELIEF IT WAS MY EXPEDITION!
Electrical system, May 6, 2005
THE IGNITION LOCK SEIZED. CONSUMER PUT THE KEY INTO THE IGNITION BUT IT WOULD NOT TURN OVER. THE FLOOR SHIFTS WAS STILL IN PARK. CONSUMER HAD THE VEHICLE TOWED HOME BECAUSE OF THIS DEFECT. *AK *BF *NM
Electrical system, May 5, 2005
THERE WAS NO PRIOR PROBLEMS WITH THE KEY AND THE IGNITION , THEN ON 5/4/05 THE KEY WENT INTO THE IGNITION AND WOULD NOT TURN OR START THE CAR , I TRIED MY SECOND KEY AND THAT ALSO WOULD NOT TURN . I HAD TO HAVE THE CAR TOWED TO LOCAL DEALER , TOTAL COST FOR REPAIR AND TOW WAS A WOOPING $350.00 .THE DEALER DID NOT SEEM SURPRISED THAT MY FORD FOCUS HAD THIS DEFECT , THE TOW DRIVER SAID IT IS COMMON TO HAVE THIS PROBLEM WITH FOCUS AND I SPOKE TO A FEW LOCAL LOCKSMITHS AND THEY ALSO SAY IT IS COMMON FOR FOCUS . I SEE ON THE INTERNET THAT HUNDREDS OF PEOPLE ALSO ENDURED THIS HIGH EXPENSE FOR THE SAME REPAIR . IT DOES NOT SEEM FAIR THAT THERE IS A DEFECT AND FORD DOES NOT HAVE A RECALL FOR THIS ISSUE , PLESE HELP ALL US OWNERS AND PUSH FOR A RECALL .. THANK YOU
Electrical system, May 4, 2005
FORD FOCUS 2000 IGNITION PROBLEMS. FIRST, THE KEY WOULD NOT INSERT FULLY INTO THE IGNITION AND WOULD GET STUCK PREVENTING IT TO TURN. WHEN THE MECHANIC SHOOK THE KEY AROUND A BIT IT WOULD LOOSEN UP AND WOULD THEN INSERT FULLY ALLOWING THE CAR TO BE STARTED. THAT WAS ONLY A TEMPORARY SOLUTION. THE SECOND PROBLEM WAS WHEN THE KEY WOULD INSERT FULLY BUT WOULD NOT TURN THE IGNITION. AFTER HEARING THAT TWO OF MY FRIENDS WHO OWN FORD FOCUS' FROM THE SAME YEAR HAD THE SAME EXACT PROBLEM, I BEGAN TO RESEARCH. I HAVE FOUND THAT THIS IS NOT AN ISOLATED INCIDENT, OR NORMAL "WEAR AND TEAR." THIS SEEMS TO BE A WIDESPREAD PROBLEM WITHIN VEHICLES OF THIS YEAR, MAKE AND MODEL. I FEEL THAT IT IS UNFAIR THAT THE CONSUMER MUST PAY FOR A PROBLEM THAT EXISTED WHEN THE CAR WAS ON THE SHOWROOM FLOOR. HAVING AN IGNITION REPLACED IS NOT CHEAP CONSIDERING THE LABOR AND PART CHARGES COMBINED.
Electrical system, May 3, 2005
REPLACED THE IGNITION SWITH TWICE KEY GETS STUCK AND SOME CASES STEERING LOCKS.
Electrical system, May 2, 2005
WHEN KEY IS PUT IN IGNITION THE KEY WILL NOT TURN TO ALLOW THE VEHICLE TO START. ALSO ONCE THE KEY IS IN IT WILL NOT COME OUT.*AK
Electrical system, Apr 26, 2005
HAD IGNITION LOCK UP. VEHICLE HAD TO BE TOWED. FOUND OUT ON INTERNET A LOT OF PEOPLE HAVING THE SAME TROUBLE. *AK
Electrical system, Apr 22, 2005
ON TWO SEPARATE OCCASIONS THE IGNITION SWITCH WOULD NOT TURN, TO ALLOW THE CONSUMER TO START THE VEHICLE. JB
Electrical system, Apr 20, 2005
DEFECTIVE IGNITION SWITCH CYLINDER, FAILED CYLINDERS RESULTED FROM A SUB STANDARD MANUFACTURED CYLINDER WHICH RAPIDLY DETERIORATES WITH USE AND EVENTUALLY FRACTURES AND JAMS. FORD IS WELL AWARE THAT THESE FRAGILE CYLINDERS ARE MADE OF SUB STANDARD MATERIALS AND ARE BREAKING AND JAMMING AT AN ALARMING RATE. *AK
Electrical system, Apr 19, 2005
MY WIFE WAS DRIVING THE CAR AND STOPPED TO GET A DRINK. WHEN SHE GOT BACK INTO THE CAR, THE KEY WOULD NOT GO INTO THE IGNITION. AFTER I LOOKED AT IT, THE KEY WENT IN A BIT FURTHER, BUT WAS NOT ENOUGH TO TURN THE IGNITION. THE KEY STILL WILL NOT GO IN ALL THE WAY OR TURN.*AK
Electrical system, Apr 19, 2005
HAVE A 2000 FORD, FOCUS SE. OCCASIONALLY THE CARS IGNITION WILL LOCK UP. SOMETIMES THE IGNITION WILL TURN AND GAUGES, RADIO WILL WORK, BUT CAR WILL NOT START. IT WILL NOT MAKE ANY SOUNDS, JUST DOES NOT START. HAVING DIFFICULTY EVEN TURNING IGNITION SWITCH. BEEN IN SHOP SEVERAL TIMES, BUT DEALER COULD NOT FIND ANY PROBLEMS UNTIL 04-19-05 WHEN THE IGNITION TUMBLER NEEDED TO BE REPLACED. NEVER HAVE SEEN THIS BEFORE ON A 4-5 YEAR OLD CAR. NOT COVERED UNDER ANY WARRANTY. THIS FAILURE VERY OFTEN HAS LEFT ME AND MY 3 YEAR OLD SITTING IN THE CAR IN EXTREME TEMPERATURES UNABLE TO START VEHICLE. CURRENTLY, I AM STUCK WITH A $250 BILL, THAT THE FORD MECHANIC STATED PROBABLY HAD NOTHING E TO DO WITH THE VEHICLE NOT STARTING!!!*AK
Electrical system, Apr 17, 2005
FROZEN IGNITION LOCK, TUMBLERS FALL INTO LOCK SPACE AND PREVENT KEY FROM ENTERING. *AK
Electrical system, Apr 7, 2005
WHEN STARTING THE VEHICLE STEERING WHEEL WOULD NOT UNLOCK WITH THE IGNITION KEY. VEHICLE WAS TOWED. DEALERSHIP WAS NOTIFIED. CONSUMER HAD THE STEERING WHEEL LOCK REPAIRED. *AK
Electrical system, Apr 6, 2005
IGNITION CYLINDER LOCKED UP. THE KEYS WON'T TURN IN THE IGNITION CYLINDER. HAD TO CALL THE LOCKSMITH AS PER LOCKSMITH ,ITS A KNOWN ISSUE WITH FORD FOCUS 2000/2001 MODELS. IGNITION CYLINDER REPLACED TO FIX THE PROBLEM. CHECK THIS FOR SIMILAR ISSUES: HTTP://WWW.AUTOMOTIVETALK.NET/SHOWMESSAGES.PHP?ID=1275
Electrical system, Apr 6, 2005
THE IGNITION LOCK IS HARD TO TURN AND HARD TO REMOVE THE KEY. YOU HAVE TO JIGGLE THE KEY TO GET IT TO WORK. IT HAS NEARLY LEFT ME STRANDED SEVERAL TIMES. I WAS QUOTED A PRICE TO FIX IT AT $300. I HAVE YET TO FIX IT DUE TO FINANCAL DIFFICULTIES.*AK
Steering, Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Visibility, Air bags, Seat belts, Latches/locks/linkages, Equipment, Apr 6, 2005, crash, fire
FATALITY VEHICLE FIRE, DEC. 8 2004. MY HUSBAND IS THE ORIGINAL OWNER OF A 2000 FORD FOCUS, SUBJECT TO NUMEROUS SERVICE VISITS TO BILL BROWN FORD, LIVONIA MI FOR: IGNITION, STEERING COLUMN, WHEEL BEARING, BRAKE, REAR WINDOW CONTROL, SEAT BELT &TRUNK LATCHES, OVERHEAD LIGHT AND ENGINE LIGHT. THE VACUUM LINE & FUEL PUMP & VALVE ASSEMBLY WERE REPLACED 2/03, FOLLOWED BY STALLING. IN 6/03, A/C COMPRESSOR & MANIFOLD LINE REPLACED. FUEL LINE & PUMP FAILURE IN 8/03, RESULTED IN GASOLINE SPILL ON RESIDENTIAL STREET MINUTES AFTER PARKING. BOGGING FOLLOWED REPAIRS, PCM REPROGRAMMED & LEAKING PVC TUBE REPLACED 1/04. FUEL PUMP AGAIN REPLACED. IN 8/04, OUR 24 YEAR OLD SON TOOK OWNERSHIP OF THIS PROBLEMATIC CAR. WE ARE UNCERTAIN AS TO WHETHER VEHICLE MALFUNCTION CAUSED A 35 MPH COLLISION WITH A FIRE HYDRANT. AN IMMEDIATE ENGINE EXPLOSION AND FUEL FED FIRE TRAPPED MY SON AND HIS PASSENGER. DESCRIBED BY POLICE AS A RELATIVELY MINOR CRASH WHICH WOULD NOT BE EXPECTED TO CLAIM LIVES, THE SUBSEQUENT UNEXPLAINED ENGINE FIRE CLAIMED TWO YOUNG LIVES. A MALFUNCTIONING DRIVER'S AIRBAG WAS ALSO DETECTED. THIS INCIDENT WAS ORIGINALLY REPORTED TO NHTSA BY MY HUSBAND (#10104088). I AM SUPPLYING THESE ADDITIONAL FACTS FOR YOUR CLARIFICATION. PLEASE CORRECT YOUR POSTING OF "0" INJURIES AS THERE WERE 2 FATALITIES. PLEASE TAKE EFFECTIVE ACTION TO SAVE LIVES, AS THESE TROUBLE PLAGUED VEHICLES SEEM TO BECOME MORE LETHAL AS THEY AGE. CONFIRMATION OF RECEIPT OF THIS INFORMATION IS REQUESTED. *NM *SC *JB
Electrical system, Apr 5, 2005
WHEN KEY IS INSERTED IN THE IGNITION THE KEY WON'T TURN. CONSUMER TOOK VEHICLE TO DEALER NUMEROUS TIMES, AND DEALER FIXED IT, BUT PROBLEM RECURRED. *AK
Electrical system, Apr 4, 2005
CONSUMER IS UNABLE TO REMOVE KEY FROM IGNITION WITHOUT EXCESSIVE FORCE BEING USED, REGARDLESS OF LENGTH OF TIME VEHICLE IS DRIVEN . DEALERSHIP REMOVED THE IGNITION CHAMBER, INSPECTED IT, BUT FOUND NO PROBLEM. ALSO, THEY HAVE LUBRICATED IT. THE PROBLEM RECURRED. *AK
Electrical system, Apr 4, 2005
KEY WON'T FULL SLIDE INTO THE IGNITION LOCK CYNLIDER. AS A RESULT CAN'T START THE CAR. IT APEARS, ONE OR MORE TUMBLERS HAVE FALLEN OUT OF PLACE. AUTO HAS APPROXIMATELY 62,000 MILES. WHEN I HAD A LOCK SMITH LOOK AT THE LOCK, I WAS INFORMED THAT IS WAS A FAIR COMMON PROBLEM WITH THE 2000-2002 FORD FOCUS MODEL. *AK
Electrical system, Apr 2, 2005, fire
UPON EXITING THE GROCERY STORY ON TUESDAY MARCH 29, 2005 I FOUND MY 2000 FORD EXPEDITION ON FIRE. FORTUNATELY, THERE WAS A BATTALION OF FIREMEN SHOPPING AT THE TIME & THEY WERE ABLE TO PUT OUT THE FIRE VERY QUICKLY. BECAUSE THEY WERE THE FIRE CAPTAIN ASKED ME IF I HAD HAD THE CAR SERVICED, IN PARTICULAR THE MASTER BRAKE CYLINDER, AS THAT WAS OBVIOUSLY THE POINT OF ORIGIN. I SAID NO. A PASSERBY MENTIONED THE RECALL (WE HAD ONLY JUST RECEIVED A LETTER IN THE MAIL) AND AFTER REMEMBERING THE CONTENTS OF THE LETTER WE RECEIVED DID WE REALIZE THIS FAULTY PART WAS THE CAUSE. WE HAD OUR CAR TOWED TO THE FORD DEALER WHERE WE BOUGHT IT AND HAD ONLY GOTTON THE RUN AROUND SINCE. THE FIRE DAMAGE WAS LIMITED TO OUR VEHICLE ENGINE COMPARTMENT AS WELL AS LEFT FRONT TIRE AND AREA BETWEEN THE ENGINE & TIRE. THIS WAS DUE TO THE CLOSE PROXIMITY OF THE FIREMEN WHEN FIRE BROKE OUT.*AK
Electrical system, Mar 31, 2005
2000 FORD FOCUS - KEY WILL NOT GO INTO IGNITION AND START CAR