2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: electrical system
1,346 reports, newest first. Show all
Electrical system, Jun 25, 2003
CONSUMER STATES CANNOT FULLY INSERT KEY INTO IGNITION CYLINDER DUE TO IT BEING DEFECTIVE. THE IS THE 3RD CYLINDER REPLACEMENT FOR THIS VEHICLE.*AK
Electrical system, Jun 20, 2003
KEY GETS JAMMED IN THE IGNITION. DEALER NOTIFIED.*AK
Power train, Electrical system, Exterior lighting, Latches/locks/linkages, Jun 19, 2003
VEHICLE HAS A MAJOR ELECTRICAL PROBLEM. WHILE DRIVING VEHICLE GAUGES WILL GO "BESERK". DOOR CHIME ACTIVATES, ALL LIGHTS FLICKER ON AND OFF, TRANSMISSION CHANGES GEARS,AND THE VEHICLE STALLS.*AK
Electrical system, Jun 19, 2003
THIS MORNING MY IGNITION CYLINDER WENT BAD. WENT TO GO START THE CAR AND IT WOULDN'T TURN. *NLM
Electrical system, Jun 16, 2003
WHILE PLACING THE KEY INSIDE OF THE IGNITION SWITCH VEHICLE WILL NOT START UP AT ALL. *AK
Electrical system, Jun 16, 2003
ON JUNE 1, 2003, MY CAR HAD TO BE TOWED TO THE DEALER FOR REPLACEMENT OF THE IGNITION CYLINDER WHICH WAS DONE ON JUNE 2, 2003 AT STONEHAM MOTOR CO. I PREVIOUSLY HAD THE CAR TOWED TO THE DEALER FOR THE SAME PROBLEM AND SAME REPAIR ON TWO OTHER OCCASIONS -- FEBRUARY 11, 2003 AND APRIL 21, 2003. THIS WAS PREVIOUSLY REPORTED IN A COMPLAINT TO YOUR AGENCY (CONFIRMATION NO. 10018431). THE DEALER ATTEMPTED TO REPLACE THE STEERING COLUMN SO THAT I WOULD NOT HAVE THIS PROBLEM AGAIN, BUT WAS UNABLE TO ACCOMPLISH THIS SUCCESSFULLY. ALTHOUGH A NEW IGNITION CYLINDER WAS INSTALLED, I UNDERSTAND THAT THIS PROBLEM MAY CONTINUE TO OCCUR REPEATEDLY BECAUSE OF A DESIGN DEFECT WHICH DOES NOT REQUIRE THE KEY TO BE INSERTED FULLY. THE TOW TRUCK DRIVER TOLD ME THAT ONE CONSUMER WITH A SIMILAR PROBLEM LEAVES HIS KEY IN THE IGNITION, THINKING THAT IF THE CAR GETS STOLEN THAT WILL SOLVE THE PROBLEM. HE SAID THAT ANOTHER CONSUMER HAS A HAMMER IN HIS CAR WHICH HE USES TO TAP THE KEY BEFORE TURNING IT. I HAVE NO COMPLAINT WITH THE DEALER WHO PERFORMED ALL THREE REPAIRS AT NO CHARGE, BUT I BELIEVE THAT THE MANUFACTURER SHOULD HAVE SOME RESPONSIBILITY FOR THIS PROBLEM, BOTH TO ME AND MY DEALER. *NLM
Electrical system, Jun 16, 2003
TURNED OFF CAR, GOT OUT, PUT IN GAS, GOT BACK IN CAR, KEY WOULD ONLY GO IN HALF WAY. *NLM
Electrical system, Jun 13, 2003
NHTSA 00-V-411-000 VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECK LID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS. CONSUMER HAS THE SAME PROBLEM. HOWEVER THIS VEHICLE WAS NOT PART OF RECALL DUE TO VIN. *AK
Electrical system, Jun 12, 2003
AFTER RECALL REPAIRS WERE PERFORMED VEHICLE WOULD NOT START. DEALER STATED IT WAS NOT THEIR PROBLEM. *AK
Engine and engine cooling, Electrical system, Jun 11, 2003
ENGINE CHECK LIGHT COMES ON, AND VEHICLE STARTS TO SHAKE ,AND THEN SHUTS OFF. DEALER NOTIFIED. *AK
Power train, Electrical system, Visibility, Tires, Jun 9, 2003
CONSUMER CONCERNED ABOUT THE AMOUNT OF RECALLS ON VEHICLE. *MR THE CONSUMER HAD TO REPLACE THE CABLE SHIFTER WHEN THE VEHICLE WAS ONLY 2 YEARS OLD. THE ALTERNATOR HAD TO BE REPLACED, THE DOOR LOCK ACTUATORS, TIRES, SUN ROOF CONTROL. *JB
Electrical system, Jun 9, 2003
WHILE PLACING THE KEY INSIDE OF THE KEY IGNITION VEHICLE WILL NOT START.*AK
Electrical system, Jun 3, 2003
WHILE DRIVING AT ANY SPEED AND NO WARNING THE VEHICLE WILL SHUT OFF, CAUSING CONSUMER TO PULL OVER AND IT WILL BE HARD TO GET THE VEHICLE BACK STARTED.DEALER NOTIFIED. *AK
Electrical system, May 30, 2003
IGNITION SWITCH WOULD NOT TURN WHEN PLACING KEY INTO STARTER SWITCH HAD BROKEN. DEALER HAD REPAIRED VEHICLE TWICE. PLEASE PROVIDE FURTHER INFORMATION.*AK
Electrical system, May 19, 2003
KEY WILL GO INTO THE IGNITION BUT IGNITION WILL NOT TURN, SECOND TIME. *JB
Electrical system, May 16, 2003
PUT KEY IN IGNITION AND KEY WOULD NOT TURN IN IGNITION SWITCH. HAD TO REPLACE IGNITION CYLINDER. 8NLM
Electrical system, May 15, 2003
PLACED KEY IN IGNITION WOULD NOT TURN. MANY TSB'S ON SAME PROBLEM. HAVE EXTENDED WARRANTY. IGNITION SWITCH COVERED WITH NO SPECIFIC PART # LISTED. DEALER SAYS PART # FOR DEFECT NOT COVERED. HAD FIXED. RESEARCH WITH NHTSA LISTS 7 TSB'S AND MANY COMPLAINTS FOR SAME DEFECT. REFERRED TO FORD CUSTOMER SERVICE THEY SAID NOTHING COULD BE DONE. EXTENDED WARRANTY DOES NOT LIST SPECIFIC PART #S WHEN PURCHASED BUT WHEN WARRANTY WORK IS REQUESTED IT BECOMES PART NUMBER SPECIFIC. ALSO IF THERE ARE SO MANY TSB'S AND CUSTOMER COMPLAINTS WHY DOESN'T FORD DO SOMETHING ABOUT THIS. *JB
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Latches/locks/linkages, May 13, 2003
-2000 FORD FOCUS LX - BOUGHT USED ON APRIL 14TH. BOTH INTERIOR AND EXTERIOR OF CAR IN EXCELLENT CONDITION, RAN EXTREMELY WELL, ONE OWNER REPO, CLEAN TITLE. -WAS REAR-ENDED IN VERY LOW SPEED, LOW IMPACT COLLISION, NO FRAME BUCKLING, BENDING, OR DAMAGE TO CAR OTHER THAN SCRATCHED REAR BUMPER - TRUCK LID WILL NOT LATCH NOW. MULTIPLE MECHANICS AND APPRAISERS - UNABLE TO FIND PROBLEM. -WHILE DRIVING, DASH GAUGES AND CAR SPEAKERS WILL SUDDENLY STOP WORKING (SPEEDOMETER GOES TO 0, ODOMETER GOES BLANK, FUEL GAUGE GOES TO 0) AND THEN SPONTANEOUSLY COME BACK ON WITH NO AFTER EFFECTS. CAR STALLED WHILE STOPPING AFTER ONE OF THESE EPISODES. OCCASIONALLY WHEN CAR IS STARTED, THE ODOMETER WILL SPONTANEOUSLY RESET WITHOUT PROMPTING (NOT THE MAIN ONE, THE RESETABLE ONE). -RANDOM CODES BEING THROWN TO COMPUTER - CAR HAS HAD TWO DIAGNOSTICS RUN IN TWO WEEKS, THE FIRST FOR TWO CODES: 1. A MECHANICAL ISSUE, 2. FOR ELECTRICAL DIFFICULTIES IN THE DASHBOARD - THE CAR WAS THOROUGHLY INSPECTED AND NO DEFECTS WERE FOUND. SEVEN DAYS LATER THE COMPUTER REPORTED AN "EVAPORATIVE SYSTEM LEAK" - ONCE AGAIN THE CAR WAS THOROUGHLY INSPECTED AND NO DEFECTS WERE FOUND. AFTER THE FIRST DIAGNOSTIC, A REAR BRAKE LIGHT WENT OUT - AFTER REMOVING THE LIGHT AND "FIDDLING" WITH THE WIRING, THE MECHANIC GOT ITS NORMAL FUNCTION TO RESUME. -THE CAR HAS 36,000 MILES, I HAD THE BRAKES INSPECTED THE DAY AFTER THE CAR STARTED SHAKING VIOLENTLY WHEN I PRESSED THE BRAKE PEDAL. THE ROTORS ARE WARPED TERRIBLY AND I WILL HAVE TO HAVE THE ENTIRE BRAKE SYSTEM REPLACED, INCLUDING THE REAR DRUMS - I DO NOT CONSIDER THIS NORMAL, ESPECIALLY IN SUCH A YOUNG CAR. -IT HAS HAD TWO RECALLS FILLED IN THE LAST MONTH, ONE FOR A PINCH BOLT AND THE OTHER FOR A WHEEL BEARING. NO OTHER RECALL CAMPAIGNS WERE OPEN. THESE PROBLEMS HAVE CONTINUED SINCE THE RECALLS WERE COMPLETED. -I'VE OWNED THIS CAR FOR LESS THAN A MONTH. THE CARS PRE-PURCHASE INSPECTION CAME UP CLEAN. THE CAR IS NO LONGER UNDER ANY KIND OF FACTORY WARRANTY.*JB
Electrical system, May 8, 2003
ON BOTH FEBRUARY 11, 2003 AND APRIL 21, 2003, MY CAR HAD TO BE TOWED TO THE DEALER FOR REPLACEMENT OF THE IGNITION CYLINDER IN MY FORD FOCUS 2000. I WAS TOLD BY THE MECHANIC THAT THE IGNITION DESIGN MADE THE IGNITION CYLINDERS PRONE TO BREAKING, I BELIEVE BECAUSE IT DOES NOT REQUIRE THE KEY TO BE INSERTED FULLY. I HAVE NO COMPLAINTS WITH THE DEALER WHO PERFORMED BOTH REPAIRS AT NO CHANGE, BUT FROM THE MECHANICS COMMENTS, IT APPEARS THAT A DESIGN DEFECT COULD EXIST. *NLM
Electrical system, May 7, 2003
THE KEY WOULD NOT GO INTO IGNITION. THE DEALER INDICATED THAT THE CYLINDER HAD TO BE REPLACED. *NLM
Suspension, Engine and engine cooling, Power train, Electrical system, May 7, 2003
WHILE WORKING ON THE VEHICLE, THE MECHANIC DISCOVERED A SEAL LEAK IN THE ENGINE, AND A LEAK IN TRANSMISSION COOLER LINES. LATER,WHILE ON THE ROAD, THE VEHICLE STARTED TO FISHTAIL IN THE BACK DUE TO A BOLT WHICH HELD THE REAR SUSPENSION HAD LOOSENED. IN ADDITION, THE VEHICLE HAD STALLING PROBLEMS, AND SEVERE CORROSION BUILDUP ON THE BATTERY. *AK *JB
Electrical system, May 5, 2003
IGNITION CYLNDER IS STUCK. *JB
Electrical system, Apr 30, 2003, fire
CAR BURNED IN MY DRIVEWAY. WE JUST FOUND OUT IT CAME FROM UNDER THE DASHBOARD, A PROBLEM WITH THE WIRING(ELECTRICALLY)IN THE HEATING SYSTEM.
Electrical system, Apr 23, 2003
WHILE DRIVING THE TRACTION CONTROL MODULE FAILED. *NLM WHICH FAILED EVERY FEW DAYS. THE VEHICLE WOULD SHUT DOWN WITH DASH LIGHT WARNINGS. *SCC
Electrical system, Apr 22, 2003
WHEN THE KEY WAS PLACED INSIDE OF THE IGNITION, THE VEHICLE FAILED TO TURN OVER. *JB