2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: electrical system
1,346 reports, newest first. Show all
Engine and engine cooling, Power train, Electrical system, May 28, 2001
THIS VEHICLE IS CLEARLY ONE OF MULTIPLE PROBLEMS AND SHOULD BE INVESTIGATED. ENGINE COOLING, TRANSMISSION BRAKING AND STARTER ISSUES. FORD PROTECTING SELF AS USUAL.
Electrical system, May 25, 2001, fire
VEHICLE CAUGHT FIRE WHILE DRIVING. SMOKE & FIRE FIRST NOTICED IN REAR SEAT AREA. TOTAL LOSS WITH FIRE MOVING FROM BACK TO FRONT. *AK
Suspension, Fuel system, Gasoline, Electrical system, May 22, 2001
RIGHT REAR WHEEL BEARING CAUSED CAR TO SWERVE VIOLENTLY AT 55MPH, DRIVER SLOWED TO 20MPH TO AVOID BEING PULLED OFF ROAD. DRIVER TRIED TO SLOWLY DRIVE TO REPAIR STATION BUT CAR KEPT WOBBLING ON ROAD SO STOPPED AND HAD CAR TOWED INTO GARAGE..IGNITION /LOCK SYSTEM FAILED IN JANUARY AND LEFT DRIVER STRANDED. CAR COULD NOT BE STARTED. IN ANOTHER PROBLEM THAT OCCURED IN OCTOBER 2000 THE FUEL ASSEMBLY RECALL WAS NOT PROPERLY REPAIRED AND CAUSED CAR ACCELERATOR TO NOT FUNCTION. THE CAR WOULD ONLY GO 1-3MPH AT FULL ACELLERATION. THIS WAS VERY DANGEROUS IN TRAFFIC. I DO NOT HAVE PAPERWORK ON THIS INCIDENT BUT PROBLEM WAS CORRECTED AT BERGSTROM FORD, NEENAH, WI 54956*AK
Electrical system, Apr 17, 2001
WHEN PUTTING KEY IN IGNITION VEHICLE LOCKS UP, AND THERE IS NO POWER TO START VEHICLE. LIGHTS COMES ON AND THE DEALERSHIP IS AWARE OF PROBLEM.*AK
Electrical system, Apr 17, 2001
WHILE PUTING KEY IN IGNITION SWITCH IT WOULD NOT TURN, AND KEY WOULD NOT FIT ALL THE WAY. PLEASE PROVIDE FURTHER INFORMATION.*AK
Suspension, Engine and engine cooling, Electrical system, Apr 11, 2001
VEHICLE VIBRATED REAL HARD WHEN IT STARTED UP AND CUT OFF. IT HAS BEEN TO DEALER 5 TIMES. DEALER HAS REPLACED COMPUTER, AND CHANGED IGNITION KEY AND MORE. DEALER HAS NEVER SAID WHY, AND DIDN'T HAVE A REMEDY TO PROBLEM. CONSUMER HAS TRIED LEMON LAW, BUT VEHICLE WAS OVER THE MILEAGE AT THAT TIME. CONSUMER CALLED FORD, AND WAS TOLD TO WORK IT OUT WITH DEALER. PROBLEM IS STILL NOT RESOVLED.*AK
Electrical system, Mar 22, 2001
WHEN TRYING TO START ENGINE IGNITION SWITCH WILL NOT TURN, AND CONSUMER WILL NOT BE ABLE TO START ENGINE. SOMETIMES WHILE DRIVING WILL MAKE A LOT OF NOISE.*AK
Steering, Engine and engine cooling, Power train, Electrical system, Visibility, Mar 20, 2001
IGNITION AND STEERING LOCKED UP, KEY WOULD NOT TURN, VEHICLE WAS PARKED. *AK THERE WAS NOISE IN THE RIGHT SIDE OF THE VEHICLE DUE TO REAR OUTSIDE MIRROR FAILURE. THE TRANSMISSION SLIPS ON ACCEL. THERE WAS VIBRATION IN STEERING AT 45 MPH AND UP. THE HIGH SQEALING ON RAINY DAYS WHEN TURNING LEFT OR RIGHT WAS CAUSED BY DRIVE BELT MALFUNCTIONING. THE IGNITION LOCKED DUE TO CYLINDER ASSEMBLY PROBLEM. *YH
Electrical system, Tires, Mar 15, 2001
EMERGENCY FLASHERS CANNOT BE USED FOR MORE THAN A FEW MINUTES WITHOUT OVERHEATING THE COMPONENT THUS CAUSING A COMPLETE FAILURE OF EMERGENCY FLASHERS, TURN, PARKING, BRAKE LIGHTS,RUNNING LIGHTS. TIRES DEVELOP MAJOR CUPPING AND FEATHERING THUS CAUSING SEVERE BOUNCE AND VIBRATIONS IN THE STEERING AND HANDLING. (DOT NUMBER: 71532B TIRESIZE: 19.5)
Electrical system, Wheels, Seats, Feb 27, 2001
00 V 418 000/SEAT HINGE: 00 V 411 000/WIRE HARNESS: 00 V 303 000/REAR WHEEL HUB NUTS: 00 V 218 000/FMVSS 201: WHILE VEHICLE WAS IN THE DEALER SHOP FOR IS ROUTINE CHECK UP CONSUMER WAS INFORMED OF FOUR RECALLS, AND ,WAS UNWILLING TO GIVE A APPOINTMENT FOR REPAIRS, CONSUMER CALLED ON TWO OTHER OCCASIONS, AND STILL DEALER, HERTIGE FORD, BURINGTON, VT; PHONE# 802/865-8150 REFUSED TO HELP IN THESE RECALL REPAIRS. SEEKING HELP FROM NHTSA IN THESE MATTER.*AK
Electrical system, Structure, Feb 23, 2001
THERE WERE NO PARTS AVAILABLE FOR RECALLS OOV-218 AND 00V-411. NLM
Electrical system, Interior lighting, Feb 20, 2001
VEHICLE STALLS INTERMITTENTLY AT ANY SPEED. BEFORE VEHICLE STALLS DASH LIGHTS COME UP. FREQUENCY IS INCREASING. TAKEN VEHICLE TO DEALER WHO CANNOT REMEDY SITUATION. *AK
Electrical system, Feb 19, 2001
KEY COULD ONLY BE INSERTED HALF WAY INTO THE IGNITION. *AK
Electrical system, Structure, Wheels, Feb 12, 2001
RECEIVED RECALL NOTICE (00V-303) OCTOBER 2000, PART(S) NOT AVAILABLE TO CORRECT CAMPAIGN, RECEIVED RECALL NOTICES (00V-218) & (00V-411) DECEMBER 2000, APPOINTMENT MADE FOR JANUARY 2ND TO CORRECT ALL 3 CAMPAIGNS, WAITED FOUR HOURS AT DEALERSHIP, CLAIMED VEHICLE, INVOICE SHOWING "PARTS NECESSARY TO CORRECT" RECALL CAMPAIGNS (00V-218) & (00V-411) NOT THERE. CJ
Electrical system, Feb 2, 2001
KEY FAILED/COULD NOT BE INSERTED INTO IGNITION. KEY IN HALF WAY , BUT COULD NOT BE RELEASED. WHEN FINALLY IT WAS RELEASED, IT COULD NOT BE REINSERTED FULLY. HAD VEHICLE TOWED TO DEALERSHIP. MECHANIC WAS ORDERING NEW PARTS FOR IGNITION. *AK
Electrical system, Feb 1, 2001
CONSUMER WAS TRAVELING ON HIGHWAY AND VEHICLE CUT OFF WITHOUT PRIOR NOTICE. DEALERSHIP WAS AWARE OF PROBLEM.*AK
Electrical system, Equipment, Feb 1, 2001
WAS PULLING INTO DRIVEWAY WITH TURN SIGNAL ON WHEN VEHICLE SHUT DOWN. WHEELS LOCKED UP. VEHICLE WAS TOWED TO DEALERSHIP. MECHANIC COULD NOT LOCATE CAUSE OF SHUT DOWN. CONTACTED MANUFACTURER & WAS INFORMED IT WAS A "HOT IGNITION SWITCH" PROBLEM. *AK MAKING RIGHT HAND TURN INTO DRIVEWAY STARTED DECRASING SPEED FROM 35 MPH TO MAKE TURN, NOTICED THAT THE STEREO WENT SILENT ,LOST DASH LIGH S INCLUDING SIGNALS AND STEERING WHEEL DIFFICULT TO TURN. *YH
Service brakes, Hydraulic, Electrical system, Feb 1, 2001
CAR STALLS REPEATEDLY, AND BRAKES WHINE LOUDLY. WE HAVE HAD THE CAR IN THE SERVICE CENTER A TOTAL OF 14 DAYS ON FOUR SEPARATE OCCASIONS WITH NO RESOLUTION. FORD TELLS US THAT THEY CAN NOT FIND THE PROBLEM AND WE SHOULD CONTINUE TO SERVICE THE CAR UNTILL FURTHER NOTICE. I AM VERY UPSET AT FORD AS A COMPANY, THEY ARE NOT STANDING BEHIND THEIR PRODUCT, AND THEY ARE ENDANGERING THE LIVES OF MY FAMILY MEMBERS. I AT NO TIME FEEL SAFE DRIVING THIS CAR, IT SHAKES, SQUEAKS, AND MOST IMPORTANTLY STALLS AT ANY GIVEN TIME WHILE DRIVING DOWN THE ROAD. I HAVE RECORDS FOR ALL SERVICE REPAIRS AND DOCUMENTED PROOF THAT THEY ATTEMPTED TO FIX THE IDENTICAL PROBLEM TO NO AVAIL. I HAVE ALREADY TAKEN FURTHER LEGAL ACTION AGAINST FORD, BUT I HOPE THIS COMPLAINT WILL HELP ME IN MY LEGAL BATTLE. *AK
Electrical system, Jan 30, 2001
WHILE TRYING TO START VEHICLE IT WOULD NOT START OR MOVE. DEALER CANNOT FIND CAUSE. *AK
Suspension, Engine and engine cooling, Electrical system, Air bags, Jan 30, 2001, crash
WHILE TRAVELING AT 45 A TRUCK PULLED IN FRONT OF CONSUMER'S VEHICLE, AND CONSUMER HIT THE TRUCK. UPON IMPACT, NONE OF AIRBAGS DEPLOYED.*AK THE WIRE HARNESS, MOTOR MOUNT, FRONT AND REAR WHEEL BEARINGS HAD FAILED AND WERE REPLACED. *YH
Electrical system, Jan 29, 2001
IGINITION SWITCH KEEPS LOCKING UP INTERMITTENTLY. DEALER NOTIFIED, AND REPLACED TWO IGNITION SWITCHS ON TWO SEPARATE OCCASIONS, BUT PROBLEM STILL OCCURS. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
Service brakes, Hydraulic, Electrical system, Jan 23, 2001
IGNITION SWITCH WENT OUT, CAUSING VEHICLE NOT TO START. DEALER HAS BEEN CONTACTED. *AK BRAKES ALSO FAILED, CONSUMER HAD TAKEN VEHICLE TO DEALER FOR SOFT BRAKES, HOWEVER DEALER FOUND NO PROBLEMS AND ONE MONTH LATER BRAKE FAILURE OCCURED. *SLC
Electrical system, Jan 16, 2001
WHILE DRIVING VEHICLE STALLS UNEXPECTEDLY WHICH MAY CAUSE A CRASH. ALSO WHILE STARTING VEHICLE THERE IS A NO START CONDITION. DEALER CANNOT DETERMINE CAUSE AND NOT WILLING TO ASSIST CONSUMER. PLEASE PROVIDE FURTHER INFORMATION.*AK
Electrical system, Dec 28, 2000
INTERMITTENTLY VEHICLE WILL STALL AND DIE WITHOUT WARNING. DEALER INSPECTED VEHICLE . *AK
Suspension, Service brakes, Hydraulic, Power train, Electrical system, Dec 27, 2000
BRAKES DO NOT WORK AND DRIVER USES HIS CLUTCH TO SLOWDOWN VEHICLE. ALSO, FRONT BRAKE DRUMS, AND FRONT SHOCKS BROKE/ VEHICLE STALLS UNEXPECTEDLY, AND THE CV AXLE BROKE. DEALER CANNOT DETERMINE CAUSE ANY OF THESE PROBLEMS. PLEASE PROVIDE FURTHER INFORMATION. *AK