2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
470 reports, newest first. Show all
Engine and engine cooling, Jun 10, 2002
VEHICLE WAS GOING 45MPH ON A BRIDGE AND STALLED AS VEHICLE WAS SHIFTING TO 4TH GEAR. STEERING LOCKED AND BRAKES FAILED WHILE MOTOR SHUTDOWN. AIR CONDITIONER AND RADIO CONTINUED TO WORK. VEHICLE RESTARTED, BUT THE ENGINE CHECK LIGHT CAME ON, AND VEHICLE STALLED AGAIN. CRANKSHAFT WAS REPLACED BY FORD DEALER. *AK *YH
Engine and engine cooling, Fuel system, Gasoline, Jun 10, 2002
CAR STARTED STALLING BEFORE IT RAN OUT OF WARRANTY. DEALER REPLACED FUEL PUMP THAT WAS ALL THEY COULD FIGURE OUT. THAT LASTED AS LONG AS THE WARRANTY DID. I PERSONALY REPLACED THE FUEL TANK AND FUEL PUMP AND FUEL FILTERS EACH TIME. THE CAR HAS CONTINUED TO STALL SENSE UNDER WARRANTY. THE DEALER CAN'T FIGURE OUT THE PROBLEM ,THEY SAID THAT THEY HAVE NOTHING BUT PROBLEM WITH THE FORD FOCUS. I'VE CONTACTED FORD CORP. AND YOU GET NO HELP FROM THEM. THE CAR HAS STALLED ON SEVERAL OCCASION AS LONG AS THE CAR SIT FOR A LONG PERIOD OF TIME IT WILL START AND RUN FOR AWHILE THEN IT WILL DO IT AGAIN. I CANNOT AFFORD TO TAKE IT THE DEALER EACH TIME TO TELL ME NOTHING IS WRONG WITH IT. THIS PROBLEM COULD END IN AN ACCIDENT AND POSSIBLE INJURY. I HOPE THIS DOESN'T TAKE A CLASS ACTION SUIT AGAINST FORD TO GET THIS PROBLEM CORRECTED.*AK
Engine and engine cooling, Jun 10, 2002
DRIVING ALONG THE FREEWAY AND THE ENGINE STALLED. WAS ABLE TO REFIRE THE MOTOR AND CONTINUE CAR CONTI NUED TO RUN ROUGH.*AK
Engine and engine cooling, Jun 8, 2002
THIS STALLING WHILE DRIVING PROBLEM HAS OCCURRED ON TWO OCCASIONS, BOTH TIMES AT LOW SPEED. ONCE WHILE MAKING A RIGHT 90DEG TURN AND ONCE WHILE SLOWLY ROLLING TO A STOP AT AN INTERSECTION. THE SECONED TIME THE CAR WAS HARD TO RESTART.*AK
Engine and engine cooling, Jun 7, 2002
APPROX, 1 MONTH AGO THE ENGINE STALLED OUT WHILE DRIVING ON THE HIGHWAY. 6/6/02 THE ENGINE STALLED OUT ON HIGHWAY OFFRAMP. 6/7/02 CAR STALLED OUT WHILE GOING APPROX 35MPH ON A CITY STREET. THIS SOUNDS ALARMINGLY LIKE THE "FOCUS" OF ONE OF THE TWO NEW INVESTIGATIONS BEING OPENED. I AM GOING TO TRY TO GET MY DEALER TO LET ME OUT OF MY LEASE. THANKS.*AK
Engine and engine cooling, Exterior lighting, Jun 7, 2002
THE ENGINE STALLS WHILE DRIVING AS IF IT IS GOING TO SHUT DOWN. THE SIGNAL LIGHTS WILL NOT STOP BLINKING WHEN MAKING LEFT OR RIGHT TURNS. THIS WAS REPAIRED BY EAST FORD IN FEB 2001 AND THIS PROBLEM IS BACK AGAIN. I FEEL THAT THESE ARE MORE DEFECTS IN THE FOCUS. *AK
Engine and engine cooling, Jun 7, 2002
ENGINE STALLED WHEN MAKING A CLOCKWISE HAIRPIN TURN (FREEWAY TRANSITION) WITH APPROX. 1/4 TANK OF GAS. *AK
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Jun 7, 2002
SIX WEEKS PREVIOUSLY, ENGINE STALLED ON FREEWAY. DEALER SAID COULDN'T FIND A PROBLEM AND LET THEM KNOW IF IT HAPPENED AGAIN. 5/31/02 COULD NOT GET CAR TO GO; HAD TOWED TO DEALER. AFTER SEVERAL DAYS THEY FINALLY THOUGHT IT WAS THE AIR INTAKE VALVE CAUSING THE PROBLEM. TODAY I HEAR ABOUT THE FOCUS STALLING PROBLEM POSSIBLY BEING CAUSED BY DEBRIS IN GAS TANK. I AM AFRAID TO DRIVE THIS CAR FOR FEAR IT WILL STALL AGAIN ON THE FREEWAY. I WAS LUCKY THE LAST TIME THAT I WAS ABLE TO COAST TO THE SHOULDER AND DID NOT GET INTO A CRASH. I WAS ABLE TO RE-START THE CAR AND GET IT OFF THE FREEWAY. OTHER CONTINUING PROBLEMS THAT I HAVE HAD THE DEALER FIX OVER 3 TIMES EACH: SQUEAKING BRAKES AND MOLDING AROUND THE DOORS FALLING OFF.
Engine and engine cooling, Jun 5, 2002
WHILE DRIVING, VEHICLE WILL JERK, ON ONE OCCASION IT WOULD NOT GO MORE THAN 35MPH AND THEN IT STALLED, VEHICLE HAS ALSO STALLED AT HIGHWAY SPEEDS. THIS HAS HAPPENED NUMEROUS TIMES. CONTACTED DEALER WHO CANNOT FIX THE PROBLEM.*AK *SLC
Engine and engine cooling, Power train, Equipment, May 15, 2002
VEHICLE DIED. PISTON RINGS STICK IN VALVE AND THE SHUTS DOWN. CONSUMER HAS FIVE RECALLS ON HER CAR. ALSO, SHE HAD TO REPLACE HEAD GASKET. *AK CONSUMER STATES THAT THE TRANSMISSION AND AIR CONDITIONER LEAKED, AN O-RING WAS REPLACED IN THE AIR CONDITIONER, HOWEVER IT STILL DOES NOT WORK. *SLC
Engine and engine cooling, May 14, 2002
VEHICLE STALLS INTERMITTENTLY, MOSTLY AROUND 35 MPH. DEALER CANNOT REMEDY PROBLEM.*AK
Engine and engine cooling, Electrical system, May 10, 2002
ENGINE STALLED AT 30 TO 35 MPH. VEHICLE WAS TOWED TO A MECHANIC, AND MECHANIC STATED THAT BATTERY WAS DEFECTIVE. DEALER REPLACED BATTERY. CONSUMER STATED THAT PROBLEM STILL OCCURING.
Engine and engine cooling, May 6, 2002
MY DAUGHTER, WHO IS THE PRIMARY DRIVER OF THIS VEHICLE, REPORTED THAT WHILE DRIVING ON ADAMS ROAD THE ENGINE STARTED TO LOSE POWER. SHE PRESSED THE ACCELERATOR BUT THE ENGINE CONTINUED TO SLOW DOWN. SHE THEN PULLED THE CAR OFF THE MAIN ROAD AND THE ENGINE STALLED. SHE WAS ABLE TO RESTART THE NEGINE AND PROCEED. THE FUEL TANK WAS 1/2 FULL. NO WARNING LIGHTS (IE. "CHECK ENGINE") WERE ILLUMINATED PRIOR TO THE STALLED ENGINE CONDITION. WE CONTACTED THE DEALER ON APRIL 18, 2002 ABOUT THIS PROBLEM BUT THEY INDICATED THEY COULD NOT DIAGNOSE THE CONDITION AND THAT WE "SHOULD WAIT FOR IT TO HAPPEN AGAIN" BEFORE BRINGING IT IN FOR A CHECK. I AM CONCERNED ABOUT THIS INCIDENT REPEATING ITSELF IN A HIGHWAY SITUATION.*AK
Engine and engine cooling, Apr 22, 2002
WHEN VEHICLE COMES TO A COMPLETE STOP, IT WILL STALL OUT , ENGINE CHECK LIGHT COMES ON WHICH WAS CAUSED BY A DEFECT IN THE CYLINDER HEAD. *AK
Engine and engine cooling, Apr 19, 2002
CONSUMER STATES WHILE TRAVELING AT 65 MPH WITHOUT ANY INDICATION VEHICLE LOSSES ALL POWER CAUSING CONSUMER TO PULL OVER. DEALER HAS BEEN CONTACTED. NLM
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Power train, Electrical system, Apr 18, 2002
CONSUMER STATES ONGOING PROBLEM WITH ENGINE STALLING WHILE DRIVING AT ANY SPEED, DEALER WAS NOTIFIED. NLM DEALER REPLACED COIL PACK AND FUEL PUMP 6 TIMES. VEHICLE IS UNDER WARRANTY HOWEVER WARRANTY IS NOT VALID. THE WHEEL BEARINGS FAILED CAUSING THE REAR WHEEL TO FALL OFF. THE MAIN BELT BROKE. THE TRANSMISSION COOLING LINES BROKE. IGNITION SWITCH HAD TO BE REPLACED. THE REAR BRAKES SQUEAK ESPECIALLY WHEN THERE IS MOISTURE IN THE AIR. *TT
Engine and engine cooling, Apr 18, 2002
THE CONSUMER STATES THAT THE VEHICLE STALLS IN WARM WEATHER AT VARIOUS SPEEDS. THE DEALER HAS DETERMINED THAT THE CAUSE WAS THE FUEL PUMP RESTRICTING THE FUEL FLOW. FUEL PUMP WAS REPLACED.
Engine and engine cooling, Apr 18, 2002
CONSUMER STATES THAT INTERMITTENTLY WHEN ACCELERATING THE VEHICLE HESITATES. THE DEALER HAS INSPECTED THE VEHICLE. NLM
Engine and engine cooling, Apr 17, 2002, fire
ON THE MORNING OF MARCH 26 2002 I AWOKE AT 5:30 AM TO DISCOVER MY CAR ENGULFED IN FLAMES ACCORDING TO FIRE DEPT IT HAD STARTED UNDER THE DASH OR IN ENGINE. THE CAR HAD BEEN PARKED IN MY YARD SINCE ABOUT 6:00 PM THE PREVIOUS EVENING. *TS *NLM ****DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS****760797
Engine and engine cooling, Apr 17, 2002
CONSUMER STATES THAT WHILE MAKING A TURN VEHICLE WILL SHUT OFF. NLM
Service brakes, Hydraulic, Engine and engine cooling, Vehicle speed control, Apr 10, 2002
WHILE DRIVING AND FOOT IS REMOVED FROM ACCELARATOR, MOTOR RACES, LOSES POWER DIES OUT.*AK BRAKES SQUEAL INTERMITTENTLY. *TT
Engine and engine cooling, Apr 3, 2002
THIS IS THE SECOND FAILURE, OF THE SAME PARTS. THESE STUDS FAILED IN FEBRUARY OF 2001. THIS IS NOT EXACTLY 12/12,000 FOR THE WARRANTY TO COVER THE REPAIR, BUT IT IS PRETTY DARN CLOSE. I PURCHASED AN EXTENDED WARRANTY THROUGH MY CREDIT UNION, THEY SAID THEY WILL NOT COVER THE REPAIR BECAUSE I ADDED TWO AFTERMARKET MODIFICATIONS TO THE ENGINE. FORD SAID THEY WILL NOT COVER THE REPAIR, BECAUSE THE EXTENDED WARRANTY COVERAGE REFUSED TO FIX THE PROBLEM. WHAT THEY KEEP STEPPING AROUND IS THE FACT THAT THIS SAME FAILURE HAPPENED A YEAR AGO, BEFORE I MADE ANY MODIFICATIONS. THE ENGINE WAS STILL STOCK.*AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Visibility, Mar 12, 2002
BRAKES HAVE SQUEALED FRON ABOUT 1500 MILES. HAVE HAD PADS REPLACED, BUT SQUEALS DID NOT GO AWAY. FRONT BRAKES GRIND, AT SHOP NOW. IN NOVEMBER 2001 HAD TO HAVE STRUTS REPLACED WHILE HAVING RECALL WORK DONE. STRUTS LITTLE OVER A YEAR OLD. ENGINE MAKES A CHIRPING NOISE AT ABOUT 1000-2500 RPM, BUT DEALER UNABLE TO DUPLICATE. ALSO SQUEALS OR WHINES WHEN MAKING RIGHT TURNS. WINDSHIELD CRACKED WHEN A SMALL STONE HIT IT. WILL HAVE INSURANCE REPLACE. OVERALL, NOT HAPPY WITH CAR. BEEN IN THE SHOP THREE TIMES IN THE LAST YEAR!!
Engine and engine cooling, Mar 11, 2002
WHILE DRIVING 20 MPH, CAR COMPLETE SHUT OFF CAUSING CONSUMER TO LOSE COMPLETE CONTROL OF VEHICLE AND MANUVERING OF STEERING WHEEL, MANUFACTURER CONTACTED. *TT
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Visibility, Structure, Seats, Equipment, Other or unspecified, Feb 28, 2002
THERE IS A VERY BAD SQUEAKING NOISE WHEN BRAKING, AND WHEN CONSUMER LETS OFF THE BRAKE THERE IS A GRINDING NOISE. DRIVER STATES MORE THAN TWICE BRAKE PEDAL WAS APPLIED, AND PEDAL WENT TO THE FLOOR. FORD HAS BEEN CONTACTED.*AK.ALSO CONSUMER WAS COMPLAINING OF THE TRANSMISSION SLIPPING, THE CIGARETTE LIGHTER WAS NOT WORKING, CUP HOLDER BUBBLING, SERPENTINE BELT WAS REPLACED DUE TO A SQUEAL COMING FROM UNDER THE HOOD, GAS LIGHT WAS COMING ON WHEN THE TANK WAS FULL OF GAS, DOOR AJAR LIGHT WAS COMING ON, STARTER AND BATTERY WERE REPLACED, DRIVER SIDER MIRROR KNOB FELL OFF, RPM RUNS HIGH, HEADLAMP MOLDING WAS REPLACED, SUNVISOR WAS BROKE, REAR CHILD SEAT LATCH COVER WAS BROKE, AIR CONDITIONER AND HEATER WERE REPLACED, PASSENGER DOOR TRIM, DRIVER SEAT METAL BAR, REWIND BUTTON FOR AM/FM CASSETTE WAS INOPERATIVE, CARPET LOOSE, PILLAR TRIM WAS COMING OFF, TICKING NOISE WAS COMING FROM THE FRONT OF VEHICLE, THE EGR VALVE WS REPLACED, REAR TAIL LIGHT WAS OUT, THE BULB WAS REPLACED, DECK LID WIRE HARNESS, A NEW FUEL TANK WAS INSTALLED DUE TO THE ENGINE LIGHT ILLUMINATING, THE FRONT AND REAR BRAKES HAVE BEEN REPLACED DUE TO WARPAGE, ALSO THE SPEEDOMETER STOPPED WORKING.*JB