2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
470 reports, newest first. Show all
Engine and engine cooling, Jun 18, 2001
VEHICLE HAS STALLED 4 TIMES AT SPEEDS BETWEEN 45 - 75 MPH IN HOT/ DRY WEATHER. CONSUMER TOOK VEHICLE TO DEALER 3 TIMES SO FAR, AND DEALER COULD NOT REMEDY PROBLEM. *AK
Engine and engine cooling, Jun 12, 2001
WHEN DRIVING AT ANY SPEED AND WITHOUT PRIOR WARNING VEHICLE STALLS OUT, CAUSING LOSS OF POWER. CONSUMER HAS CONTACTED DEALER FOURTEEN TIMES SINCE THE PURCHASE DATE. *AK
Engine and engine cooling, Jun 11, 2001
WHILE TRAVELING NOTICED RADIATOR FLUID LEAKING. CONSUMER HAD VEHICLE SERVICED. TECHNICIAN STATED RADIATOR NEEDED TO BE REPLACED DUE TO A HOLE. PLEASE PROVIDE FURTHER INFORMATION. *AK
Engine and engine cooling, Electrical system, May 30, 2001
ENGINE STALLS WHILE DRIVING, DEALER DOES NOT KNOW WHY THIS HAS HAPPENED AND DOES NOT KNOW HOW TO CORRECT IT, POSSIBLY ENGINE OR COMPUTER RELATED. *SLC
Engine and engine cooling, Power train, Electrical system, May 28, 2001
THIS VEHICLE IS CLEARLY ONE OF MULTIPLE PROBLEMS AND SHOULD BE INVESTIGATED. ENGINE COOLING, TRANSMISSION BRAKING AND STARTER ISSUES. FORD PROTECTING SELF AS USUAL.
Steering, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Visibility, Structure, Equipment, May 16, 2001
WINDSHIELD HAD CRACKED AND WAS REPLACED, APPROXIMATELY ONE MONTH LATER THE WINDSHIELD CRACKED AGAIN IN THE EXACT SAME SPOT, NOTHING HAD HIT THE WINDSHIELD ON EITHER TIMES THAT IT HAD CRACKED. AIR CONDITIONER DRAINS INSIDE THE CAR TO THE DRIVERS SIDE FLOOR. BRAKES SQUEAK, DEALER REPLACED REAR BRAKE SHOES, HOWEVER NOISE IS STILL THERE. STEERING WHEEL WAS PEELING, DEALER REPLACED IT. VEHICLE WILL NOT START AT TIMES, DEALER REPROGRAMMED THE PCM AND REPLACED THE FUEL PUMP. TRANSMISSION SLIPS INTO NEUTRAL WHILE DRIVING, IT WILL NOT SHIFT INTO REVERSE UNTIL AFTER ABOUT 10 SECONDS, DEALER HAS REPLACED THE MLP SENSOR AND TRANSMISSION RANGE SENSOR TO ATTEMPT TO CORRECT PROBLEM YET IT STILL CONTINUES, TRANSMISSION LINES LEAKING AND DEALER REPLACED LINES. NOISE COMING FROM UNDER THE HOOD. HOOD RATTLED, DEALER ADJUSTED AND LUBED THE HOOD STOPS. ENGINE RACES AT TIMES, VEHICLE HESITATES AND FEELS LIKE IT IS GOING TO STALL. *SLC
Engine and engine cooling, Fuel system, Gasoline, May 13, 2001
WHILE DRIVING THIS VEHICLE WILL STALL UNEXPECTEDLY AT ANY GIVEN SPEED WITHOUT WARNING. DEALER HAS ATTEMPTED TO FIX PROBLEM FOR THE THIRD TIME NOW. FIRST ATTEMPT SAID THEY COULD NOT FIND A PROBLEM - SECOND TIME REPLACED MASS AIR FLOW SENSOR - NOW THEY ARE REPLACING THE FUEL PUMP. WE FEEL THIS CAR IS UNSAFE TO DRIVE AND HAVE LOST CONFIDENCE IN THE RELIABILITY OF THIS CAR. WE FEEL LIKE IT IS AN ACCIDENT WAITING TO HAPPEN. WE FEEL THAT THE DEALERSHIP IS NOT COMPETENT TO FIX THE PROBLEM AND WE WOULD LIKE TO PERSUE THE LEMON LAW RIGHTS FOR A REFUND FOR THIS CAR.*AK
Engine and engine cooling, May 3, 2001
I WOULD LIKE TO SUBMIT A COMPLAINT AGAINST CROSSROADS FORD IN RALEIGH, NC WHO HAS ME DRIVINIG A DEATH TRAP. I LEAST THIS VEHICLE LAST YEAR (2000 FORD FOCUS) AND ONLY PUT 9000 MILE ON IT TO DATE. EVEN SO, IT HAS BEEN SHUTTING OFF WHILE DRIVING AT 45+ MILES PER HOUR. WHEN IT SHUTS OFF I DO NOT HAVE STEERING CAPABILITIES. MORE THAN ONCE I WAS IN THE FAST LANE AND WAS IN VERY DANGEROUS SITUATIONS. ONCE I WENT INTO A DITCH WITH MY FOUR YEAR OLD SON IN THE CAR AND TO THIS DAY, HE STILL REMEMBERS IT. FORD HAS REFUSED TO TAKE OWNERSHIP OF THIS PROBLEM AND HAS NOT FIXED IT. THIS IS MY SIXTH LEASE OR PURCHASE FROM FORD AND I AM APPAULED AT THE TREATMENT. I THINK THEY ARE WAITING FOR ANOTHER FIRESTONE INCIDENT, FOR ME TO LOSE MY LIFE, BEFORE THEY RECOGNIZE THE PROBLEM.*AK
Suspension, Engine and engine cooling, Electrical system, Apr 11, 2001
VEHICLE VIBRATED REAL HARD WHEN IT STARTED UP AND CUT OFF. IT HAS BEEN TO DEALER 5 TIMES. DEALER HAS REPLACED COMPUTER, AND CHANGED IGNITION KEY AND MORE. DEALER HAS NEVER SAID WHY, AND DIDN'T HAVE A REMEDY TO PROBLEM. CONSUMER HAS TRIED LEMON LAW, BUT VEHICLE WAS OVER THE MILEAGE AT THAT TIME. CONSUMER CALLED FORD, AND WAS TOLD TO WORK IT OUT WITH DEALER. PROBLEM IS STILL NOT RESOVLED.*AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Apr 11, 2001
I AM NOT PLEASE WITH THIS CAR ,ME AND MY WIFE HAVE BROUGHT TWO OTHER CARS FROM THIS DEALER AND THIS IS THE FIRST ONE THAT HAS GIVEN A LOT OF GRIEF AND SORROR,PLEASE HELP ME BE A CONTINUE CUSTOMER BY ADDRESSING THIS PROBLEM IMMEDIATELY,AND ALSO FOR FUTURE REFERENCES. THANK YOU ,SIGN OFF---SADDEN. NO SAFETY DEFECT MENTIONED. *AK
Steering, Engine and engine cooling, Power train, Electrical system, Visibility, Mar 20, 2001
IGNITION AND STEERING LOCKED UP, KEY WOULD NOT TURN, VEHICLE WAS PARKED. *AK THERE WAS NOISE IN THE RIGHT SIDE OF THE VEHICLE DUE TO REAR OUTSIDE MIRROR FAILURE. THE TRANSMISSION SLIPS ON ACCEL. THERE WAS VIBRATION IN STEERING AT 45 MPH AND UP. THE HIGH SQEALING ON RAINY DAYS WHEN TURNING LEFT OR RIGHT WAS CAUSED BY DRIVE BELT MALFUNCTIONING. THE IGNITION LOCKED DUE TO CYLINDER ASSEMBLY PROBLEM. *YH
Engine and engine cooling, Mar 17, 2001
ON 03/08/01, WHILE DRIVING 65MPH ON FREEWAY, ENGINE STALLED. VEHICLE TOWED TO DEALER AND FUEL PUMP REPLACED ON 03/09/01. PROBLEM BEGAN REOCURRING ON 03/13/01. PROBLEM SEEMS TO START AFTER VEHICLE IS WARM AND HAS BEEN DRIVEN AT HIGHWAY SPEEDS FOR 10-15MINS. ONCE PROBLEM STARTS, IT WILL REOCCUR SEVERAL TIMES WITHIN SHORT DISTANCES (1/4 TO 1/2 MILES), NECESSITATING PULLING TO SIDE OF ROADWAY AND RESTARTING VEHICLE. ONCE PROBLEM STARTS, IT WILL REOCCUR AT BOTH SURFACE STREET AND HIGHWAY SPEEDS.*AK
Engine and engine cooling, Mar 14, 2001
INTERMITTENTLY WHEN BRITE SWITCH IS ACTIVATED ENGINE STALLS OUT AND DIES. ALSO, STARTS UP IMMEDIATELY AFTERWARDS ON ITS OWN WHILE VEHICLE IS IN MOTION. DEALER HAS NOT BEEN ABLE TO DUPLICATE OR CORRECT PROBLEM.*AK
Engine and engine cooling, Feb 22, 2001
NOXIOUS FUMES COMING INTO THE CAR THROUGH THE AIR VENTS, HEATER UNUSABLE, A/C UNUSABLEROUGH THE HEATING AND EXHAUST. *AK
Engine and engine cooling, Feb 21, 2001
VEHICLE CONSISTENTLY STALLS WHEN SLOWING OR BROUGHT TO A STOP WHEN AIR TEMPERATURE IS BELOW 0F, EVEN AFTER ENGINE IS FULLY WARMED UP.
Engine and engine cooling, Feb 20, 2001
VEHICLE HAS STALLED 9 TIMES AND HAS BEEN IN FOR REPAIR, BUT FORD IS UNABLE AND UNWILLING TO DETECT THE PROBLEM. THEY CANNOT "DUPLICATE" THE STALLING THEREFORE IT DOES NOT EXIST. ALTHOUGH I HAVE STALLED ON THE INTERSTATE, WHILE DRIVING 70 MPH AND ON CITY STREETS. I REFUSE TO TAKE MY CHILD IN THE CAR WITH ME BECAUSE I AM SCARED WE WILL BE REAR ENDED. I HAVE CONTACTED THE AZ ATTY GENERAL'S OFFICE AND WAS TOLD THAT FORD REFUSED TO MEDIATE THE SITUATION AND THE STALLING PROBLEM DOES NOT EXIST. THE ATTY GENERALS OFFICE STATED THEIR WORKLOAD IS TOO HEAVY TO ENFORCE THE AZ LEMON LAW AND I WOULD HAVE TO HIRE AN ATTY. AS A SINGLE PARENT I CANNOT AFFORD TO HIRE AN ATTY AND STILL PAY MY CAR PAYMENTS, WHICH FORD EXPECTS ME TO DO, YET THEY WILL NOT HONOR THEIR PRODUCT AND ADMIT THIS CAR HAS A PROBLEM. I BOUGHT A NEW CAR SO THAT I WOULDN'T HAVE THE REPAIR COST OF A USED VEHICLE AND I BOUGHT A FORD BECAUSE THEY HAD BEEN IN BUSINESS FOR A LONG TIME AND I THOUGHT THEY WERE SAFE AND REALIABLE. *AK
Engine and engine cooling, Power train, Feb 2, 2001
WHENEVER DRIVING CAN SMELL FUMES COMING INSIDE VEHICLE THROUH VENTS. SMELLS LIKE BURNING PLASTIC. GEARS WOULD GET STUCK. HARD TO SHIFT FROM ONE GEAR TO ANOTHER GEAR. *AK
Suspension, Engine and engine cooling, Electrical system, Air bags, Jan 30, 2001, crash
WHILE TRAVELING AT 45 A TRUCK PULLED IN FRONT OF CONSUMER'S VEHICLE, AND CONSUMER HIT THE TRUCK. UPON IMPACT, NONE OF AIRBAGS DEPLOYED.*AK THE WIRE HARNESS, MOTOR MOUNT, FRONT AND REAR WHEEL BEARINGS HAD FAILED AND WERE REPLACED. *YH
Engine and engine cooling, Jan 29, 2001
CONSUMER HAS HAD 6 RECALLS ON THIS VEHICLE, HE IS VERY CONCERNED FOR HIS SAFETY. *AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Jan 19, 2001
THESE ARE THE PROBELEMS WITH MY CAR. IT IS ONLY 8 MONTHS OLD, YET THIS CAR HAS HAD REPEATED PROBLEMS. THE FIRST MAJOR PROBLEM IS WITH THE BRAKES. THEY CONTINUALLY SQUEAK AND I WAS TOLD BY FORD THAT IT WAS DUE TO A SAFETY ISSUE. THE BRAKES AND PADS WERE REPLACED YET THE PROBLEM HAS CONTINUED SINCE. I HAVE ALSO MADE NUMEROUS COMPLAINTS AND HAD THE BREAKS DEGLAZED AND SERVICED MANY TIMES ONLY TO HAVE THE PROBLEMS CONTINUE. THE NEXT PROBLEM IS WITH THE VENTALATION. THE ENGINE STRONGLY SMELLS OF BURNING OIL/FUEL. THIS PROBLEM WAS CHECKED AND FIXED THREE TIMES, BUT THIS PROBLEM ALSO CONTINUES. THE SMELL IS SO STRONG INSIDE THE CAR THAT PASSENGERS NOW REFUSE TO RIDE IN THE VEHICLE. THE SMELL IS ALSO VERY STRONG FROM OUT SIDE THE CAR. THE THIRD PROBLEM WITH THE VEHICLE IS WITH THE DRIVER'S SIDE DOOR. THE LOCK AND LATCH ARE VERY TIGHT AND ARE SOME TIMES IMBOSSIBLE TO TURN OR OPEN WITHOUT EXESSIVE FORCE. THE DOOR HINGES ARE ALSO STIFF. THIS IS A LOT OF FRICTION IN THE HINGES MAKING LOTS OF NOISE AND NOT ALLOWING THE DOOR TO MOVE SMOTHLEY. THE LAST PROBLEM I AM REPORTING IS WITH THE SUSPENSION. THIS PROBLEM HAS BEEN FIXED MORE THAN 5 TIMES AND IT IS STILL A VERY BIG PROBLEM. NEW PARTS HAVE BEEN PUT IN AND THE SQUEAKING AND HUMMING IS STILL VERY LOUD. THERE ARE ALSO LOUD CLANKING NOISES COMING FROM THE SUSPENSION.*AK
Engine and engine cooling, Jan 3, 2001
CAR STALLS OUT MULTIPLE TIMES PER DAY WHILE DRIVING, CAUSING THE POWER STEARING TO GO OUT AND ALL OF THE DASH LIGHTS TO GO ON, SCARED FOR MY SAFETY. CONTACTED SALEPERSON AND DEALERSHIP OWNER WITH NO HELP OFFERED BY THEM
Engine and engine cooling, Nov 24, 2000, fire
WHILE DRIVING VEHICLE CAUGHT FIRE IN THE ENGINE COMPARTMENT. DEALER IS INSPECTING VEHICLE.*AK
Engine and engine cooling, Nov 15, 2000
VEHICLE DIES AND STARTS UP AGAIN INSTANTLY IN MID-DRIVE. VERY SPONTANEOUS. WILL HAPPEN EIGHT TIMES IN ONE DAY AND NONE THE NEXT. DEALERSHIP SERVICE DEPARTMENT CONTINUALLY SENDS CAR BACK SAYING THAT THEY CANNOT "DUPLICATE" THE PROBLEM.*AK
Engine and engine cooling, Oct 17, 2000
WHILE DRIVING AT 60 MPH ENGINE SHUT COMPLETELY DOWN. DEALER HAS BEEN CONTACTED.*AK
Engine and engine cooling, Power train, Oct 6, 2000
OVERHEATING/ TRANSMISSION SLIPPING/ VIBRATION. *AK