2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: fuel system
405 reports, newest first. Show all
Engine and engine cooling, Fuel system, Gasoline, Jul 7, 2003
ON 7/5/2003 WHILE DRIVING AT 85 MPH ON THE HIGHWAY ENGINE STALLED. THE VEHICLE HAD THIS SAME PROBLEM LAST YEAR ,AND THE FUEL PUMP WAS DEFECTIVE. THE VEHICLE WILL BE TAKEN TO THE DEALER ON 7/8/2003. *AK
Fuel system, Gasoline, Jul 3, 2003
NOV OF 2002 TOOK TO DEALER THE CAR WAS PURCHASED FROM, TOLD THEM IT WAS RUNNING SLUGGISH AND THE GAS GUAGE DIDN'T ALWAYS REGISTER. TOLD NOTHING WRONG, COULD NOT DULPIATE PROBLEM. TOOK TO NEIGHBORHOOD DEALER FOR SAME PROBLEM, REPLACE FUEL FILTER. HAD ALL THIS WORK DONE BEFORE WARRANTY EXPIRED IN FEB 2003. NEVER WAS NOTIFIED ABOUT POSSIBLE FUEL PUMP. I FEEL THIS WAS LEFT OUT SO THE FORD DEAERSHIP AND COMPANY DIDN'T HAVE TO COVER THIS PART. I HAVE HAD PROBLEMS WITH BOTH LOCATE DEALERSHIP ON GETTING REPAIRS COMPLETED. HAVING TO RETURN THE CAR TWO OR THREE TIMES TO ONE DEALERS. I HAVE FILED COMPLAINTS ABOUT THE LEAK OF SERVICE WITH FORD. MY MILAGE IS 39,400, I HAVE MY SERVICE DONE REGULARLY BY FORD. WENT TO TAKE MY DAUGHTER TO SCHOOL ON JUNE 27TH,2003. MY CAR STARTED THEN DIED, THEM WOULDN'T START AGAIN FOR ABOUT 30 MINUTES. DROVE TO DEALER VERY SLUGGISH. I HAVE SPOKE TO FORD ABOUT PAYING FOR THE REPAIRS WITH NO LUCK. THEIR SERVICE MANAGERS WAS THE ONE WHO BOUGHT IT TO MY ATTENTION THIS WAS A COMMON PROBLEM WITH THE FOCUS. THEN I STARTING TO INVESTIGATE IT MYSELF AND HIS RIGHT. HE TOLD ME OF ABOUT 10 FUEL PUMPS HIS REPLACED IN LESS THEN 2 MONTHS. I PERSONALLY FOUND OTHER FOCUS OWNERS WITH THE SAME PROBLEM. FORD NEEDS TO RECALL FUEL PUMP AND MAKE THIS CAR SAFE. *AK
Fuel system, Gasoline, Jun 27, 2003
I'M LOSING POWER WHILE DRIVING, WORSE WHILE MAKING TURNS. IT OCCASIONALLY STALLS OUT, MOSTLY WHILE MAKING HARD RIGHT TURNS. I TALKED WITH SOMEONE IN THE SERVICE DEPT. OF A FORD DEALERSHIP AND SHE SAYS IT'S THE FUEL PUMP WHICH WILL COST $480. SHE ALSO STATED THAT THERE HAVE BEEN A LOT OF PROBLEMS WITH THEM. I HAVE FOUND THAT MANY FOCUS OWNERS ARE HAVING THE SAME PROBLEM AND FORD IS AWARE OF IT, BUT STILL THEY HAVE MADE NO RECALLS. *JB
Fuel system, Gasoline, Jun 24, 2003, fire
WHILE DRIVING VEHICLE STARTED TO LEAK FUEL IN THE ENGINE, THEN, VEHICLE CAUGHT ON FIRE. AS A RESULT VEHICLE WAS TOTALED. CONSUMER STATES FORD MOTOR COMPANY REFUSES TO TELL HER WHAT EXACTLY HAPPENED. DEALER NOTIFIED. *AK
Fuel system, Gasoline, Jun 21, 2003
I HAVE A 2000 FORD FOCUS W/ 2.0 ZETEC ENGINE THAT STARTED HAVING PROBLEMS IN MAY OF 2002 WHEN I WAS DRIVING HOME ON THE EXPRESSWAY. SYMPTOMS INCLUDED THE CAR LURCHING IN HIGHER RPMS (NECESSARY TO MAINTAIN SPEED) AND EVENTUALLY THE CAR WAS UNABLE TO MAINTAIN 55 MPH AND STALLED ON THE EXPRESSWAY. IT STARTED UP HALF AN HOUR LATER, AND I WAS ABLE TO LIMP HOME AT 50 MPH ON THE E-WAY. THAT PROBLEM DISAPPEARED AFTER A WEEK, AND SHOWED NO SIGNS OF COMING BACK UNTIL THE NEXT TIME I MADE A LONG CAR TRIP, WHEN IT DID THE SAME THING, BUT THANKFULLY DID NOT STALL. THE CAR CONTINUED TO DO THIS, AND FORD DEALERS NEVER DID FIND ANYTHING WRONG WITH THE CAR, ALTHOUGH ONE DEALER CHARGED ME $400 TO DRAIN AND CLEAN THE TANK BECAUSE OF DEBRIS IN THE TANK CAUSING THE CAR TO STALL ON RIGHT TURNS. IF NOT FOR THE FOCALJET.COM WEBSITE, I WOULD BE STUCK WITH AN OUT-OF-WARRANTY DEFECTIVE CAR THAT FORD FLATLY REFUSED TO COVER DURING THE WARRANTY, BUT WAS HAPPY TO SPLIT THE COST 50-50 ONE DAY AFTER THE WARRANTY ENDED. AFTER MAKING ANOTHER LONG TRIP AND HAVING THE CAR SPUTTERING AT 4000 RPMS, I DROPPED THE FUEL TANK, REMOVED 2 CLOGGED FILTERS FROM INSIDE THE GAS TANK FUEL-SENDING UNIT, AND THE CAR HAS WORKED PERFECTLY SINCE THEN. I NOW HAVE MORE POWER, SMOOTHER POWER DELIVERY, NO STALLING OR STUMBLING ON THE E-WAY OR ON RIGHT-HAND TURNS, AND THE CAR NO LONGER HESITATES WITH THE A/C ON. THESE CLOGGED FILTERS HAVE COST ME COUNTLESS HOURS, TRIPS TO THE DEALER, AND $400 WHEN THE FIX IS JUST TO LET THE EXTERNAL (AND USER-SERVICEABLE) FUEL FILTER DO ITS JOB. I HAVE KEPT THE 2 FILTERS THAT I REMOVED AND TAKEN PICTURES OF THE FUEL CANISTER THAT CONTAINED THE CLOGGED FILTERS, IN CASE THERE IS ANY NEED TO INVESTIGATE THEM. *NLM
Fuel system, Gasoline, Jun 21, 2003
FOCUS HAS AROUND 60,000 MILES. BUT NOW ALL OF A SUDDEN THE MOTOR WILL SPUTTER AFTER YOU START THE CAR AND JUST DIE OUT. I HAD ONE OF THE EGR SENSOR REPLACE ITS LOCATED ON THE FIREWALL AND ALSO I HAD AN OIL CHANGE AND JUST INSTALLED NEW SPARK PLUGS, WIRES, AIR FILTER AND FUEL FILTER AND I HAD A FRIEND HAVE A QUICK LOOK AT THE FUEL RAIL AND THE VACUUM HOSE THEY LOOK FINE. I HERE THAT THE FUEL PUMP IS THE ISSUE WITH LATE MODEL FOCUS. I JUST NOTICE WHEN PARKING THE CAR BACKWARDS AT AN INCLINE IN THE DRIVEWAY, IT WOULD START BUT REV-UP VERY HIGH FOR ABOUT 5-10 SECONDS AND STILL DIE OUT. MY NEXT STEP IS TO HAVE OBD II TEST DONE AT AAA TO SEE IF THEY CAN HELP OUT, IF NOT MY LAST CHOICE IS FORD BUT I RATHER NOT THE HELL THEM FORD, WELL MY POINT IS I ALSO HAVE ACURA 90 WITH 183,000 MILES AND NOT EVEN CLOSE TO THE REPAIRS. *NLM
Fuel system, Gasoline, Jun 20, 2003
DEALER REPLACED ON SEPTEMBER 2002 THE FUEL PUMP BECAUSE THE FUEL RAIL WAS LEAKING. IN JUNE VEHICLE HAS BEEN TWICE AT THE DEALER WITH THE SAME PROBLEM.*AK
Fuel system, Gasoline, Jun 16, 2003
FUEL PUMP FAILED IN MY 2000 FORD FOCUS. THE PUMP WENT OUT AS I WAS COMING TO A STOP CAUSING THE CAR TO STALL AND THE POWER STEERING TO GO OFF. I WAS UNABLE TO STEER, AND WAS FORTUNATE THAT THERE WAS A RED LIGHT SO I COULD RESTART THE VEHICLE. THIS WAS THE FOURTH TIME THAT HAPPENED. *NLM
Fuel system, Gasoline, Jun 16, 2003
WAS DRIVING SOUTH ON I44 WHEN FUEL PUMP QUIT WORKING. CAR STALLED ON HIGHWAY GOING 75 MPH. I PULLED OVER TO THE SHOULDER AS SOON AS POSSIBLE. THERE COULD OF BEEN A WRECK IF THERE WAS MORE TRAFFIC OR NO SHOULDER. VERY DANGEROUS. *NLM
Fuel system, Gasoline, Jun 9, 2003
2000 FORD FOCUS FUEL PUMP PROBLEMS. I THINK THAT THIS IS SOMETHING THAT FORD NEEDS TO RECALL. THE AMOUNT OF PEOPLE THAT ARE HAVING TO PAY RIDICULOUS AMOUNTS OF MONEY TO FIX THIS IS STUPID. I KNOW THAT FORD IS A BETTER COMPANY THAN THIS AND I BELIEVE THAT THEY NEED TO SHOW THEIR TRUE COLORS AND STEP UP TO THE PLATE AND RECALL THIS PART ON THE FOCUSES. IT'S ALSO A SERIOUS SAFETY ISSUE AS WELL. THE CAR WILL JUST DIE WHEN YOU ROUND A CORNER. I DON'T THINK THAT'S EXACTLY SAFE. I CAN'T SEE PAYING ALMOST 500.00 TO HAVE SOMETHING REPLACED THAT'S HAPPENING ON SO MANY CARS. I COULD SEE PAYING THAT MONEY IF IT WAS A SCARCE PROBLEM, BUT IT'S NOT. EVERY FOCUS OWNER THAT I KNOW HAS HAD TO REPLACE THE FUEL PUMP AT LEAST ONCE. SOME HAVE HAD TO DO IT 2 OR 3 TIMES. THIS NEEDS TO BE A RECALL AND FORD KNOWS IT. *JB
Fuel system, Gasoline, Jun 6, 2003
WHEN TURNING RIGHT IT SEEMS THE FUEL PUMP STOPS WORKING. *AK
Fuel system, Gasoline, Jun 3, 2003
ENGINE CUTTING OUT ON 2000 FORD FOCUS WHILE DRIVING. *NLM
Fuel system, Gasoline, May 29, 2003
WHEN I STARTED MY CAR TO GO HOME FROM WORK I STARTED TO SMELL GAS. I DIDN'T THINK MUCH OF IT UNTILL I GOT HOME. WHEN I TURNED THE CAR OFF, I LIFTED THE HOOD THINKING THERE WOULD BE A PROBLEM IN THERE. I COULD HERE WHAT SOUNDED LIKE SOMETHING BOILING. THEN I WALKED AROUND THE CAR UNTILL I GOT TO THE GAS TANK. THATS WHERE I COULD REALLY SMELL THE GAS. I LOOKED UNDER THE CAR AND THERE WAS GAS DRIPPING FROM THE GAS TANK. MY CAR ONLY HAS 24000 MILES ON IT, AND ONLY A MONTH OUT OF WARRANTY. SO I HAD THE CAR TOWED TO A LOCAL GARAGE THINKING THAT MAYBE IT WAS JUST A CRACK IN THE FUEL LINE. WHAT WAS FOUND OUT IS MY CAR HAS A PLASTIC GAS TANK AND HAS BROKEN AT THE SEAMS. THE BOILING NOISE I HEARD WAS THE GAS SPITTING ON THE EXHAUST. THE MECHANIC SAID I WAS LUCKY THAT THE CAR DID NOT CATCH ON FIRE. SO I CALLED FORD TO SEE WHAT THEY COULD DO SINCE IT WAS OBVIOUS THAT THE GAS TANK WAS FAULTY. THEY SAID THEY WOULD NOT DO ANYTHING UNTILL I GOT THE CAR TO MY FORD SERVICE STATION. I WILL HAVE TO CALL THEM AND SEE WHAT THEY WILL HAVE TO SAY. I HOPE I DON'T HAVE TO PAY FOR FORDS MISTAKE. HOW CAN THEY EXPECT A PLASTIC GAS TANK TO LAST, WHEN MINE HAS BUSTED AT ONLY 24000 MILES.
Fuel system, Gasoline, May 24, 2003
I AM AN OWNER OF A 2000 FORD FOCUS THAT HAS BEEN TO THE DEALER FOR 10 PROBLEMS/RECALLS. THE LATEST AND MY MAJOR CONCERN IS MY DAUGHTER WAS DRIVING DOWN THE ROAD AT A VERY LOW SPEED JUST AFTER LEAVING A PARKING LOT SHE HIT A VERY SMALL POTHOLE AND IMMEDIATELY THE CAR STALLED. LUCKLY A GENTLEMAN STOPPED AND HELPED HER GET THE CAR OFF THE SIDE. WE HAVE 40K MILES ON THE CAR. WE HAD THE CAR TOWED TO VICTORY FORD IN LAGRANGE GA. THE CAR WAS THERE FROM MAY 10-MAY 23 FINALLY REPAIRED AT A COST OF 670.00. MY CONCERN IS THAT I HAVE HEARD AND READ OF HUNDREDS IF NOT THOUSANDS OF THESE FUEL PUMP FAILURES AND AFTER MANY NICE BUT INEFFECTIVE ANSWERS FROM FORD I FEEL THAT SOMEONE WILL BE INJURED SERIOUSLY OR DIE DUE TO THESE FAULTY AND POSSIBLY DANGEROUS FUEL SYSTEMS. ALSO MY DEALERSHIP PREVIOUSLY WORKED ON THIS FUEL SYSTEM UNDER WARRANTY. AFTER FILLING THE GAS TANK THE ONLY WAY IT REGISTERED WAS AFTER SLAMMING THE CAR DOORS. THAT WAS REPAIRED IT SEEMS. *NLM
Fuel system, Gasoline, May 20, 2003
THE VEHICLE STALLED WITHOUT WARNING. THE DEALER STATED THE FUEL PUMP FAILED. *JB
Steering, Fuel system, Other, May 12, 2003
THE DEALERSHIP REFUSED TO HONOR THE RECALL FOR THE PINCH BOLT 02 V 289 000 DUE TO A DISCREPANCY. *JB THE STEERING WHEEL STARTED TO VIBRATE AND THE WHEEL SHOOK. THE VEHICLE WAS TAKEN IN FOR THE RECALL, BUT THE CONSUMER WAS TOLD THAT THERE WAS ANOTHER PROBLEM WHICH WAS WITH THE OIL. *SCC
Fuel system, Gasoline, May 10, 2003
2000 FORD FOCUS ZX3 PERSISTENT FUEL PUMP ISSUES. STALLING UNDER HARD RIGHT TURNS. LONG TURNOVER AND STARTING TIMES. *NLM
Fuel system, Gasoline, May 7, 2003
MY 2000 FORD FOCUS WITH 45,000 MILES ON IT HAD BEEN EXPERIENCING DRAMATIC HESITATION PROBLEMS AROUND HIGHWAY EXIT CURVES/CORNERS. THIS HAPPENED ABOUT 4 SEPARATE TIMES, WITH IT FINALLY JUST STALLING AND BREAKING DOWN THE LAST TIME. THANK GOD THE CARS BEHIND ME WERE NOT SPEEDING AND DIDN'T CRASH INTO MY REAR END. I WAS ABLE TO ROLL SAFELY A FEW FEET AWAY TO A SMALL SHOULDER AREA. I TURNED THE CAR OFF AND WAITED A SECOND BEFORE STARTING IT AGAIN. IT STARTED RIGHT UP WITH NO PROBLEM. ALSO A FEW WEEKS EARLIER THE CAR WOULDN'T START ONE MORNING. I HAD IT TOWED TO MY LOCAL FORD DEALER, WHO SAID IT SIMPLY NEEDED TRANSMISSION FLUID, THEY ADDED IT AND IT STARTED UP. BUT IN THE NEXT TWO WEEKS IS WHEN IT BEGAN HESITATING ON CURVES AND FEELING LIKE IT WAS GOING TO CUT OFF. BUT IT HAD HAPPENED ONCE PRIOR TO THAT, IT HESITATED AFTER THE CURVE AND WOULDN'T ACCELERATE EVEN THOUGH I WAS STEPPING ON THE GAS. WHEN I TOOK IT BACK TO FORD, THEY DID A FULL INSPECTION AND TOLD ME I NEEDED A NEW FUEL DELIVERY MODULE, A NEW FUEL FILTER AND INJECTION CLEANING (THE LATTER 2 BEING REGULAR MAINTENANCE). BUT THIS FUEL DELIVERY MODULE WAS MAJOR. AND MY EXTENDED WARRANTY (NOT THROUGH FORD, BUT WITH GM MAJOR GUARD) ALMOST DIDN'T COVER IT, BUT DECIDED TO COVER MOST OF IT. THE FORD DEALER TOLD ME THAT THE CAUSE FOR THE FUEL DELIVERY MODULE GOING BAD WAS JUST BASIC WEAR AND TEAR OVER TIME. I FIND THIS HARD TO BELIEVE, ESPECIALLY AFTER READING OTHER CUSTOMER'S COMPLAINTS OF THE SAME PROBLEM ON THIS WEB SITE AND AN ARTICLE ON WWW.CARTALKS.CARS.COM. PLEASE RECOMMEND TO FORD TO ADDRESS THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY INJURED. *JB
Suspension, Service brakes, Hydraulic, Fuel system, Gasoline, Tires, Apr 29, 2003
60000 MILES ON CAR, 4 SETS OF TIRES, 7 RECALLS, DEFECT IN GAS TANK COVER FILLER, 2 SETS OF BRAKES, REAR ALIGNMENT NOT ADJUSTABLE (ADVISED BY INDEPENDENT SHOP) AND HORRIBLE SHAKING AT HIGHWAY SPEEDS AFTER ALL THIS. DEALER HAS BEEN NO HELP WITH TIRE PROBLEM. NEVER BUYING A FORD AGAIN. *JB
Fuel system, Gasoline, Apr 24, 2003
CAR STALLING DURING RIGHT HAND TURNS. *NLM
Fuel system, Gasoline, Apr 17, 2003
WHEN THE GAS TANK WAS HALF FULL THE VEHICLE WOULD STALL ON RIGHT TURNS AND HILLS. *NLM
Fuel system, Gasoline, Apr 16, 2003
WHILE DRIVING THE VEHICLE STALLED. THE DEALER STATED THAT THE PROBLEM WAS DUE TO FUEL INJECTOR FAILURE. *NLM *SCC
Fuel system, Gasoline, Apr 15, 2003
WHILE DRIVING UP HILL WITH LESS THAN A QUARTER TANK OF GAS THE ENGINE LOST. WHEN THE ACCELERATOR WAS PRESSED THE VEHICLE REACTED LIKE IT WAS OUT OF GAS. *NLM
Fuel system, Gasoline, Apr 15, 2003
LOSS OF POWER, STALLING WHEN FUEL TANK IS LESS THAN ONE QUARTER FULL. ACCORDING TO FORD SERVICE EMPLOYEE THIS RESULTS FROM PROBLEMS WITH EITHER FUEL PUMP OR FUEL FILTER(DUE TO BUILD UP OF SLUDGE AND/OR DEBRIS IN FUEL TANK. *JB
Fuel system, Gasoline, Apr 13, 2003
ENGINE STALLS OR SHUDDERS WHEN FUEL LEVEL REACHES A QUARTER OF A TANK. *NLM