2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: fuel system
405 reports, newest first. Show all
Fuel system, Gasoline, May 14, 2002
THE FUEL PUMP WENT OUT. I HAVE HEARD OF THIS HAPPENING MANY TIMES WITH THE FOCUS. I CALLED DEALER TO SEE IF IT WAS UNDER WARRANTY - "NO, AND YES IT IS THE FUEL PUMP, WE HAVE DONE 4 IN THE LAST 2 WEEKS."*AK
Fuel system, Other, May 10, 2002
GAS GAUAGE DOES NOT WORK PROPERLY, VEHICLE DOES NOT SHOW CORRECT GAS LEVEL.*AK
Fuel system, Gasoline, May 4, 2002
FUEL TANK MEASURING FLOAT IS WRONG . I HAD A LITTLE MORE THAN A1/4 TANK OF FUEL AND IT WOULD NOT START THETOW TRUCK DRIVER TOLD ME THAT THE FOCUS MODEL IS KNOWN FOR THAT PROBLEM. WE THEN PUT 3GALS OF GAS IN AND IT STARTED RIGHT UP.ALSO WHEEL BEARING IN REAR WENT CAN'T GET INSPECTED TILL FIXED. DEALER SAYS COULD TAKE A FEW DAYS TO FIX. I NEED A RENTAL CAR I MUST BE ABLE TO GET AROUNDTILL IT IS FIXED.PLEASE HELP ME IN THIS PROBLEM.*AK
Fuel system, Gasoline, May 2, 2002
VEHICLE WOULD ACCELERATE ON IT'S OWN EVERYTIME IT WAS DRIVEN, WHEN DRIVING 30 MPH UP TO 51 MPH. MILEAGE AT THE TIME WAS 49361. DEALER REPLACED THE FUEL PUMP, VEHICLE HAS NOT STALLED SINCE.*JB
Fuel system, Gasoline, Apr 30, 2002
VEHICLE WOULD STALL AROUND 30 MPH ON A DAILY BASIS, DEALER REPLACED FUEL PUMP. VEHICLE HAS NOT STALLED SINCE. *AK
Service brakes, Hydraulic, Fuel system, Other, Visibility, Apr 26, 2002
I HAVE TAKEN THE CAR BACK SEVERAL TIMES WHEN I FIRST PURCHASED IT TO FIX THE BRAKES AND HEMBORG FORD TOLD ME, "THAT'S JUST THE WAY FORD BRAKES ARE, METAL ON METAL".. I'VE HAD SO MANY PROBLEMS WITH THIS CAR IT'S UNBELIEVABLE.. I FEEL UNSAFE DRIVING THIS CAR.. AS IT HAS LOCKED ME IN MANY TIMES..THE WINDOWS WILL NOT ROLL DOWN HALF THE TIME.. THE GAS GAUGE ONLY WORKS HALF THE TIME.. I WISH I HAD NEVER PURCHASED THIS HORRIBLE PRODUCT.. I WILL NEVER PURCHASE ANOTHER FORD VEHICLE AGAIN AND I ENCOURAGE FRIENDS AND FAMILY NOT TO BUY THEIR PRODUCT EITHER! *AK
Fuel system, Gasoline, Apr 18, 2002
CONSUMER STATES THAT THE VEHICLE STALLS IN WARM WEATHER ATVARIOUS SPEEDS. THE DEALER HAS DETERMINED THAT THE FUEL PUMP IS RESTRICTING THE FUEL FLOW AND CAUSING THE STALLING. NLM
Fuel system, Gasoline, Apr 18, 2002
CONSUMER STATES THAT THE VEHICLE STALLS IN WARM WEATHER AT VARIOUS SPEEDS. THE DEALER HAS DETERMINED THAT THE FUEL PUMP IS RESTRICTING THE FUEL FLOW AND CAUSES THE STALLING. NLM
Fuel system, Gasoline, Electrical system, Vehicle speed control, Apr 15, 2002
FUEL PUMP PROBLEMS: WHEN MAKING RIGHT HAND TURNS, OR DRIVING AROUND EXTENDED RIGHT HAND CURVES (LIKE FREEWAY ON- AND OFF-RAMPS [AKA CLOVERLEAFS]), THE CAR NEARLY STALLS WHEN ATTEMPTING TO ACCELERATE AFTER THE TURN. WHEN CONSUMER STEPS ON THE GAS PEDAL, THE ENGINE SEEMS TO STOP RUNNING. WHEN CONSUMER LETS OFF THE PEDAL, THE ENGINE RUNS AGAIN AND ONCE THE CAR HAS ROLLED IN A STRAIGHT LINE FOR A SHORT DISTANCE, (50-100 FT.), CONSUMER IS ABLE TO ACCELERATE. THIS PROBLEM BEGINS TO SHOW UP WHEN THE FUEL GAUGE INDICATES THE FUEL TANK IS LESS THAN FULL. AT THAT POINT, THE STALLING PROBLEM ONLY OCCURS AFTER MAKING A HARD TURN. THE STALLING PROBLEM IS EASIER TO REPLICATE AS THE AMOUNT OF FUEL INDICATED BY THE FUEL GAUGE DROPS BELOW 3/8 OF A TANK. THIS PROBLEM HAS NOT OCCURRED WHEN MAKING ANY LEFT HAND TURNS. REAR ELECTRICAL PROBLEMS UP UNTIL ABOUT 38,000 MILES, THESE PROBLEMS WERE INTERMITTENT, AND WERENOT EVIDENT MOST OF THE TIME. CONSUMER HAD THE VEHICLE CHECKED AT A DEALER AND THEY WERE NOT ABLE TO LOCATE (OR EVEN REPRODUCE) THE PROBLEM. RECENTLY, THE PROBLEMS BEGAN TO REOCCUR MORE FREQUENTLY, UNTIL NOW, THEY ARE PRESENT VIRTUALLY ALL THE TIME. THE PROBLEMS OCCUR TOGETHER. IF ONE PART OF THE SYSTEM IS FUNCTIONING PROPERLY, THE OTHER PARTS ARE FUNCTIONING AS WELL. THE PROBLEMS ARE, THE RIGHT TURN SIGNALS FLASH QUICKLY. THE RIGHT TURN SIGNALS FLASH QUICKLY WHEN THE BRAKES ARE APPLIED. IF THE TURN SIGNAL IS ON WITHOUT THE BRAKES (AS IN APPROACHING A TURN OR SIGNALING A LANE CHANGE), THE TURN SIGNAL FLASHES NORMALLY. THE LEFT TURN SIGNAL IS NEVER AFFECTED. THE REAR WINDOW DEFROSTER DOES NOT WORK. THE LIGHT ON THE SWITCH ILLUMINATES WHEN PRESSED ON BUT THE WINDOW DOES NOT CLEAR SO THERE SEEMS TO BE NO POWER GOING TO THE WIRES OF THE DEFROSTER. TAILLIGHTS AND BACK-UP LIGHTS ILLUMINATE. WHEN THE SWITCH OF THE REAR WINDOW DEFROSTER IS ON (AND THE DEFROSTER IS NOT WORKING) THE TAILLIGHTS AND BACK-UP LIGHTS ILLUMINATE.*JB
Fuel system, Gasoline, Apr 4, 2002
STILL IN MANUFACTURER'S WARRANTY, BUT CONTINUES TO LEAK, NO FIX FOR IT. *AK
Fuel system, Gasoline, Electrical system, Apr 2, 2002
MY WHOLE IS MY PROBLEM. I LEASE THIS CAR FOR THREE YEARS AND THEY COULD NOT TELL WHAT THE PROBLEM IS. I SPEND MORE TIME AT THE DEALERSHIP THEN I DID ON MY JOB. I AM STILL HAVING PROBLEM WITH FORD FOCUS AND THEY STILL DON'T KNOW WHAT THE PROBLEM IS. THE CUSTOMER SERVICE AT ADAMSON FORD IS VERY POOR . THIS WHERE MY FIRST TIME DRIVING A AMERICAN CAR. THEY DID NOT WANT TO GET ME OUT OF THE CAR AND THEN I CALL THE OWNER OF ADAMSON FORD HE DID NOT CALL ME BACK AT ALL THE ONLY THING I COULD TRY TO DO IS FILE LEMON LAW BUT IT WILL TAKE SO LONG FOR IT TO TAKE ACTION I DROP THE CASE. THIS SHOULD BE TAKING OFF THE MARKET AND PEOPLE SHOULD GET THERE MONEY BACK. BECAUSE I ALMOST GOT HIT TWO TIME BY 18 WHEELER WITH MY BABY GIRL IN THE BACK IN A CAR SEAT THEY DON'T GIVE A [XXX] ABOUT THAT AT ALL. THIS CAR IS HAVING PROBLEMS RIGHT AS I TYPE YOU THIS LETTER. I AM VERY UP SET ON THIS CAR I HAVE 12 MONTHS LEFT AND THEY STILL WILL HAVE PROBLEM WHEN I FINISH WITH IT. I HAVE MANY MORE PROBLEMS BUT I AM AT WORK AND IT WILL HAVE TO TYPE THEM LATER TODAY. PLEASE DO SOMETHING ABOUT THIS BEFORE IT IS TO LATE AND SOMEONE WILL GET KILL INJURED REALLY BAD. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Visibility, Structure, Seats, Equipment, Other or unspecified, Feb 28, 2002
THERE IS A VERY BAD SQUEAKING NOISE WHEN BRAKING, AND WHEN CONSUMER LETS OFF THE BRAKE THERE IS A GRINDING NOISE. DRIVER STATES MORE THAN TWICE BRAKE PEDAL WAS APPLIED, AND PEDAL WENT TO THE FLOOR. FORD HAS BEEN CONTACTED.*AK.ALSO CONSUMER WAS COMPLAINING OF THE TRANSMISSION SLIPPING, THE CIGARETTE LIGHTER WAS NOT WORKING, CUP HOLDER BUBBLING, SERPENTINE BELT WAS REPLACED DUE TO A SQUEAL COMING FROM UNDER THE HOOD, GAS LIGHT WAS COMING ON WHEN THE TANK WAS FULL OF GAS, DOOR AJAR LIGHT WAS COMING ON, STARTER AND BATTERY WERE REPLACED, DRIVER SIDER MIRROR KNOB FELL OFF, RPM RUNS HIGH, HEADLAMP MOLDING WAS REPLACED, SUNVISOR WAS BROKE, REAR CHILD SEAT LATCH COVER WAS BROKE, AIR CONDITIONER AND HEATER WERE REPLACED, PASSENGER DOOR TRIM, DRIVER SEAT METAL BAR, REWIND BUTTON FOR AM/FM CASSETTE WAS INOPERATIVE, CARPET LOOSE, PILLAR TRIM WAS COMING OFF, TICKING NOISE WAS COMING FROM THE FRONT OF VEHICLE, THE EGR VALVE WS REPLACED, REAR TAIL LIGHT WAS OUT, THE BULB WAS REPLACED, DECK LID WIRE HARNESS, A NEW FUEL TANK WAS INSTALLED DUE TO THE ENGINE LIGHT ILLUMINATING, THE FRONT AND REAR BRAKES HAVE BEEN REPLACED DUE TO WARPAGE, ALSO THE SPEEDOMETER STOPPED WORKING.*JB
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Visibility, Structure, Seats, Equipment, Child seat, Feb 26, 2002
WHEN APPLYING BRAKE PEDAL IT WOULD GO TO THE FLOOR, ALSO BRAKES WILL GRIND. ROTORS HAD TO BE TURNED, AND BRAKES WERE REPLACED 7 TIMES, BUT THE PROBLEM REOCCURRED. *AK TRANSMISSION SLIPS AND JERKS AND RPMS JUMP. NO PROBLEM FOUND. CONSUMER HEARS LOOSE GRAVEL SOUND FROM RIGHT FRONT WHEEL AREA. DEALER FOUND WHEEL WELL LOOSE. DEALER FOUND SERPENTINE BELT FAILED CAUSING WHISTLE SQUEAL UNDER HOOD. GAS LIGHT ON WITH FULL TANK AND DOOR AJAR LIGHT IS ON. DEALER REPLACED BATTERY. EVAPORATIVE HOSE LOOSE. DEALER REMOVED AND INSTALLED FUEL TANK. CIGARETTE LIGHTER NOT WORKING. R-CUP HOLD BUBBLING. DRIVER SIDE MIRROR KNOB FALLS OFF. REAR CHILD SEAT LATCH COVER IN BROKE. FRONT DRIVER SEAT METAL FELL OUT. BOTH HEADLAMPS MOULDING FALL OUT. SUNVISOR MIRROR/BRACKET MOULDING ON PASSENGER SIDE BETWEEN DOOR / DASH LOOSE. BROKEN. RIGHT OUTER AC VENT BROKEN. LOOSE CARPET ON RIGHT FRONT FLOOR. PILLAR TRIM COMING OFF. DECK LID WIRE HARNESS HAD TP BE REPLACED. CLICKING NOISE FROM L/H FRONT OF VEHICLE. EGR VALVE REPLACED. LEFT REAR TAIL LAMP IS OUT. ENGINE LIGHT IS ON. PROBLEMS WITH REWIND BUTTON FOR AM/FM CASSETTE. *TT
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Other, Feb 26, 2002
BRAKES SQUEAK WHEN APPLIED. AFTER 4TH TRIP INTO DEALERSHIP, SERVICE ADVISOR SAID THIS IS A COMMON PROBLEM FOR THE FORD FOCUS BUT THAT FORD IS NOT DOING ANYTHING ABOUT IT. ENGINE HAS FAILED ON ME 4 TIMES IN THE 18MONTHS THAT I HAVE HAD IT. THE DEALERSHIP JUST REPLACED THE FUEL SENDING UNIT AND SAID THAT IT "SHOULD TAKE CARE OF THE PROBLEM." I DOUBT IT! IF THIS HAPPENS AGAIN, I WILL BE CHECKING WITH CALIFORNIA LEMON LAW. THIS WAS MY FIRST FORD AND DEFINITELY MY LAST!
Service brakes, Hydraulic, Fuel system, Other, Electrical system, Visibility, Latches/locks/linkages, Feb 25, 2002
CONSUMER STATED THE GAS GAUGE FAILED, THE BRAKES WERE SQUEAKING, THE MIRROR WAS TORN OFF BY REPEATED CAR WASHES, GAS LEAKED ON THE BOTH DRIVER AND PASSENGER SIDE CARPET, AND THE TRUCK LATCH WAS BROKE, ALSO THE FUES BURST ON LOCKS. *YH
Fuel system, Gasoline, Feb 9, 2002, crash
FORD NEW ENGLAND REGIONAL SERVICE MANAGER ANDY GEORGESCU 508-490-6172 AND 781-431-1883 ACKNOWLEDGED THAT THE FORD MANUFACTURING PROCESS CAN CAUSE SLAG BUILD UP RESULTING IN DAMAGED FUEL PUMPS THAT CAUSES THE ENGINE TO STALL AT ANY TIME. THIS HAS CAUSED ONE ACCIDENT FOR ME AND NEARLY CAUSED OTHERS. THE FUEL PUMP HAS TO BE REPLACED AND THE SLAG REMOVED. NOTE: THE DATE OF THE ACCIDENT IN THIS REPORT IS APPROXIMATE. I WILL NEED TO VERIFY.
Fuel system, Gasoline, Jan 16, 2002
THIS CAR STOPS RUNNING AND CAUSES SEVERE THREAT OF AN ACCIDENT. *AK
Fuel system, Gasoline, Jan 13, 2002
CAR DIES WHILE IN MOTION. HAD CAR IN SHOP ON NOV 8, 2001 FOR 1 AND 1/2 WEEKS. FUEL PUMP AND FUEL LINE WERE REPLACED. ON JANUARY 13, 2002 THE CAR DIED AGAIN WHILE TURNING ALMOST CAUSING A CRASH. *AK
Fuel system, Gasoline, Nov 7, 2001
3 OCCURRENCES: VEHICLE RECEIVES NO FUEL AND STALLS TO ALMOST A STOP WHEN ENTERING INTERSTATE HIGHWAYS FROM ENTRANCE RAMPS. OCCURS WHEN FUEL IS BETWEEN EMPTY AND 1/4 FULL. TANK HAS AT LEAST 3-4 GALLONS IN IT. MUST PULL OFF TO SHOULDER AND LET CAR SIT UNTIL IT WILL REACCELERATE. VERY DANGEROUS IN THAT IF CAR ENTERS LANE OF TRAFFIC CANNOT ACCELARATE VEHILCE AT ALL.*AK
Engine and engine cooling, Fuel system, Gasoline, Oct 4, 2001
FORDS DEALERSHIP ARE RUDE, WORKER BROKE OTHER PARTS ON YOUR CARS AND DON'T LET YOU KNOW. YOU ARE NOT ABLE TO TRUST THE SALEMAN , THE QUOTE YOU AGREED TO PAY WAS CHANGE ON THE WAY INTO THE FINANCIAL PERSON. I WILL NEVER BUY ANOTHER FORD. THEY DO NOT STAND BEHIND THEIR CARS. I HAVE NEVER HAD THIS EXPERIENCE BEFORE. I CHANGED DEALSHIPS AND THE SAME BUSINESS. I DID FINE ONE NICE PERSON TONI. I HAVE A 2000 FORD FOCUS FOR ANYONE WHO WANT O BUY IT FOR THE BALANCE. *AK
Fuel system, Gasoline, Oct 3, 2001
CONSUMER EXPERIENCING PROBLEMS WITH GAS MILEAGE, CURRENTLY GETTING APPROXIMATELY 15 MILES PER GALLON WHEN PREVIOUSLY GETTING AROUND 29 MILES PER GALLON, THE DEALER WAS CONTACTED THREE TIMES BUT DIAGNOSTIC TEST SHOW NO PROBLEMS.*JB
Engine and engine cooling, Fuel system, Gasoline, Oct 2, 2001
THE FIRST TIME THAT THIS HAPPENED I WAS TRAVELING AT 50MPH. MY CAR BEGAN TO LOSE POWER AND BECOME HARD TO CONTROL, THEN IT STALLED LEAVING MY COASTING TRYING TO FIND A SAFE PLACE TO PULL OVER. I TOOK MY CAR INTO THE DEALER AND THEY REPLACED THE FUEL PUMP AND SEVERAL OTHER PARTS. THE SECOND TIME IT HAPPENED I WAS AGAIN TRAVELING AT 50MPH, WHEN AGAIN I LOST POWER TO THE CAR AND WAS LEFT COASTING. I BELIEVE THAT THIS IS A SERIOUS PROBLEM AND A VERY UNSAFE PROBLEM WHEN YOU HAVE A CAR WITH POWER STEERING AND YOU LOOSE POWER IT MAKES IT EATREMELY HARD TO CONTROL THE VEHICLE AS WELL AS A CAR THAT JUST COASTS. I WOULD LIKE TO SEE SOMETHING DONE ABOUT THIS SERIOUS DEFECT IN THESE CARS. *AK
Fuel system, Gasoline, Oct 1, 2001
WAS DRIVING 50MPH WHEN VEHICLE STARTED TO LOSE POWER. HAD MANAGED TO PULL TO SIDE OF ROAD. HAD VEHICLE TOWED TO MECHANIC. WAS INFORMED FUEL PUMP WAS DEFECTIVE AND NEEDED REPLACING. THIS PROBLEM HAS HAPPENED ONCE BEFORE.*AK
Engine and engine cooling, Fuel system, Gasoline, Electrical system, Aug 20, 2001
VEHICLE STALLS WITHOUT WARNING AT VARIOUS SPEEDS. LOSING ALL POWER AND STEERING WHEEL LOCKS UP. DEALER NOTIFIED 4 TIMES. FIRST 3 TIMES THEY DID NOTHING, FOURTH TIME THEY SAID THEY REPLACED AIR INTAKE VALVE. THE MORNING AFTER WE GOT THE CAR OUT OF THE SHOP IT STALLED AGAIN WHILE DRIVING 55MPH. WE ARE TIRED OF GETTING THE RUN AROUND AND ARE HESITANT TO CONTACT DEALER AGAIN CONCERNING THIS PROBLEM. 2ND PROBLEM- PUT KEY INTO IGNITION AND KEY WOULDN'T TURN. CAR HAD TO BE TOWED TO DEALER WHERE THEY KEPT IT FOR A WEEK. I WAS TOLD IT HAD TO DO WITH THE IGNITION CYLINDER AND KEY HAD TO BE CODED. THESE ARE ONLY 2 OF THE MANY PROBLEMS WE HAVE HAD WITH OUR VEHICLE, BUT IT IS RIDICULOUS FOR A NEW CAR TO HAVE SO MANY MALFUNCTIONS AND PROBLEMS.*AK
Suspension, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Exterior lighting, Structure, Tires, Aug 14, 2001
WHILE CONSUMER WAS DRIVING GAS TANK COVER BLEW OFF THE TANK AND GAS WAS SPILLING EVERY WHERE.*AK CONSUMER STATES VEHICLE HAS EXPERIENCED PROBLEMS WITH THE SENDING UNIT AND GAS GAUGE. WHEEL BEARINGS ON THE LEFT REAR FAILED. TRANSMISSION FLUID LEAKS, CONSUMER STATES THIS IS CAUSING SLIPPAGE AND SHIFTING PROBLEMS. VEHICLE EXPERIENCES A BURNING OIL SMELL. WIRING HARNESS FAILURE. LIGHT FAILURE (CONSUMER DID NOT SPECIFY). GAS LEAKS. FAILED SUSPENSION PARTS (CONSUMER DID NOT SPECIFY). TIRES WEAR PREMATURELY (CONSUMER DID NOT GIVE TIRE INFORMATION). SPLASH SHIELDS BROKE. BROCKING WIRES IN CENTRAL LOCKING SYSTEM. *SLC