2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: fuel system
405 reports, newest first. Show all
Fuel system, Gasoline, Jul 6, 2004
WHILE DRIVING CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION AND MECHANIC DETERMINED THAT THE GAS TANK NEEDED TO BE REPLACED DUE TO A CRACK. *AK *NM THE CONSUMER WAS TOLD THAT THE GAS TANK COLLAPSED (IMPLODED), BREAKING THE TANK AT THE O-RING AREA. THE TANK AND O-RING ASSEMBLY WERE REPLACED. *NM
Fuel system, Gasoline, Jun 29, 2004
REFUND DUE FOR THE FUEL PUMP THAT WAS INSTALLED IN 2000 FORD FOCUS PURSUANT TO RECALL PROGRAM 03N01.*MR (LAWYER ON BEHALF OF CONSUMER ANNON SHOMLO) *JB
Fuel system, Gasoline, Seat belts, Jun 7, 2004
CONSUMER RECEIVED RECALL 03V482000 CONCERNING STALLING. THE VEHICLE HAS HAD RECALL REPAIRS DONE IN JANUARY, BUT, THE PROBLEM RECURRED. ALSO, REAR SEAT BELTS WERE STICKING. WHEN CONSUMER NEEDED TO UNDO THE BELTS THE BUCKLE STUCK. *AK
Fuel system, Gasoline, Jun 3, 2004
AFTER THE DEALERSHIP PERFORMED THE ENGINE STALLING RECALL 03V482000, THE VEHICLE STALLS. THE DEALERSHIP INSPECTED THE VEHICLE, BUT CANNOT LOCATE A PROBLEM. *NM
Fuel system, Gasoline, May 28, 2004
WHILE DRIVING UP A HILL, THE VEHICLE WILL SHUT OFF. THE DEALER STATED THAT THE FUEL PUMP IS EFFECTIVE. A RECALL HAS BEEN HONORED FOR THIS VEHICLE AND PART; HOWEVER, CONSUMER STATED VEHICLE IS "WORSE THAN BEFORE." *LA
Fuel system, Gasoline, May 18, 2004
WHILE DRIVING THE VEHICLE STALLED. THE DRIVER TRIED TO RESTART IT, BUT WAS UNSUCCESSFUL. THE DRIVER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC REPLACED THE FUEL PUMP DUE TO A MIXTURE OF GASOLINE AND CORROSION. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
Fuel system, Gasoline, May 15, 2004
OUR 2000 FORD FOCUS HAS HAD SO MANY PROBLEMS.THE MOST RECENT HAS BEEN AN ONGOING PROBLEM THAT HAS BEEN GETTING WORSE. IT STARTED WITH STALLING OUT OCCASIONALLY WHEN COMING TO A STOP OR MAKING A HARD RIGHT TURN AND USUALLY WHEN THERE WAS LITTLE GAS IN THE TANK. ABOUT A MONTH AGO OUR CHECK ENGINE LIGHT CAME ON AFTER WE FILLED THE TANK WITH GAS. SINCE THEN WEMORE FREQUENTLY EXPERIENCED HESITATION PROBLEMS AND STALLING. TWO WEEKS AGO OUR CAR STARTED HESITATING BADLY WHILE IDLING, CAUSING THE WHOLE CAR TO SHAKE AND THEN IT WOULD STALL, NO MATTER HOW MUCH GAS WAS IN THE TANK.IT ALSO HAS POWER SURGES MAINLY AT LOW SPEEDS. WE CALLED THOMASON FORD AND LET THEM KNOW OF THE PROBLEMS WE HAVE BEEN EXPERIENCING AND THAT WE RECIEVED A LETTER FROM FORD REGARDING THE FUEL PUMPBEING DEFECTIVE CAUSING THE FUEL FILTERS TO BECOME CLOGGED. WE TOOK OUR CAR IN TO HAVE THE FUEL PUMP REPLACED. WHEN WE PICKED UP THE CAR IS WORSE THEN WHEN WE TOOK IT IN.*AK
Fuel system, Gasoline, May 7, 2004
I HAVE A 2000 FORD FOCUS THAT IS EXPERIENCE 2 ISSUES THAT RELATE TO SAFTEY RECALLS. FORD IS SAYING THEY WILL NOT REPAIR DUE TO THE CAR HAVING A BRANDED TITLE, THEY WILL ONLY ADDRESS EMISSIONS RELATED ISSUES.*AK SINCE THESE ARE SAFETY RELATED (FUEL PUMP AND REAR BEARING), IS THERE ANYWAY TO HAVE FORD CORRECT THESE ISSUES? I CAN NOT EVEN BUY THE PARTS MYSELF FROM ANY PARTS STORE ONLY FROM FORD.
Fuel system, Gasoline, May 6, 2004
WASHED CAR AT LOCAL CAR WASH, AND CAR RAN FINE. GOT HOME TO DO FINISHING TOUCHES AND KEPT CAR RUNNING. LOW ON FUEL, A LITTLE UNDER THE 1/4 LINE, BUT RAN FINE. WENT BACK OUT ABOUT FOUR HOURS LATER TO GO GROCERY SHOPPING, AND CAR WOULD NOT START. ALL THE LIGHTS AND DINGING WOULD COME ON, BUT THE ENGINE WOULDN'T TURN OVER. FOR 2 DAYS MY CAR SAT IN THE PARKING LOT NOT STARTING. I WOULD GO OUT IN THE MORNING TO TRY AND START IT, AND IT WOULD ALMOST START, BUT WOULDN'T. I HAD AAA TOW MY CAR TO A REPAIR SHOP AND WHEN IT GOT THERE, THEY CALLED ME AND ASKED WHAT I WAS TRYING TO DO. THEY GOT THE CAR OFF THE TRUCK AND IT STARTED RIGHT UP. THEY ARE KEEPING MY CAR OVER NIGHT TO TRY AND START IT IN THE MORNING. I FEEL REALLY DUMB NOW AND BAD FOR WASTING THEIR TIME. WHAT COULD THE PROBLEM BE?
Fuel system, Gasoline, May 5, 2004
WHILE DRIVING CONSUMER SMELLED GAS. ANOTHER PERSON FLAGGED THE CONSUMER TO STOP HER DUE TO FUEL LEAKING FROM UNDERNEATH. CONSUMER IMMEDIATELY CALLED THE FIRE DEPARTMENT. DEALERSHIP REPAIRED THE FUEL PUMP FOUR TIMES.*AK
Fuel system, Other, Apr 23, 2004
I RECEIVED A NOTICE FROM FORD PROGRAM 03N01 POSSIBLE ENGINE STALLING IN MY 2000 FOCUS. IT SAYS THE ENGINE MAY STALL WHILE GOING AROUND CORNERS BECAUSE OF A DEFECTIVE FUEL PUMP FILTER. MY CAR DID STALL OUT ON THE HIGHWAY WHILE TAKING A RIGHT ON A HIGHWAY OFF RAMP. WHEN I TOOK MY VEHICLE DOWN TO MY LOCAL FORD DEALERSHIP, I WAS TOLD THAT SINCE MY CAR HAD A "BRANDED" OR REPAIRED TITLE, I WAS NOT ELIGIBLE FOR THE REPAIR. I THEN CONNECTED FORD DIRECTLY THROUGH THEIR WEBSITE. I RECEIVE A CALL A FEW DAYS LATER AND THEY STILL STATED THAT THEY COULD NOT REPAIR THE VEHICLE FOR ME. I MADE A POINT TO TELL THEM THAT THE DAMAGE TO THE VEHICLE OCCURRED IN THE FRONT, FAR AWAY FROM THE FUEL PUMP FILTER IN THE GAS TANK IN THE REAR OF THE VEHICLE. THEY SAID ONLY RECALLS WITH A S IN THEM, FOR SAFETY, CAN BE DONE ON REPAIRED VEHICLES. I AND MOST PEOPLE WOULD THINK THAT A CAR STALLING ON THE HIGHWAY BECAUSE OF A DEFECT PART IS CONSIDERED A SAFETY ISSUE. I AM DISPUTING THE FACT THAT THIS RECALL SHOULD BE CONSIDERED AN N RECALL INSTEAD OF AN S. I HAD A RECALL REPAIR PREFORMED ON THE CAR A COUPLE MONTHS AGO. I THINK IT MY HAVE HAD SOMETHING TO DO WITH REROUTING THE BATTERY CABLE. HOW CAN THE POSSIBILITY OF A FIRE BE A GREATER RISK THAN A CAR THAT ACTUALLY STALLS ON THE HIGHWAY? I DO NOT UNDERSTAND WHO DESIGNATES THE TYPE OF RECALL THAT A PARTICULAR PROBLEM IS CATEGORIZED AS AND WHY THEY MADE THIS ONE A N AND NOT AN S RECALL. JUST BECAUSE A CAR HAS A REPAIRED TITLE AND HAD BEEN INSPECTED AS SAFE FOR THE ROAD BY THE STATE OF NEW YORK DOES NOT MEAN THAT ITS DRIVER SHOULD BE DISCRIMINATED AGAINST AND NOT ALLOWED TO HAVE REPAIRS MADE THAT CAN PREVENT POSSIBLE ACCIDENTS AND INJURIES. ALSO, I PERSONALLY MADE THE REPAIRS TO THE VEHICLE AND BROUGHT IT THROUGH INSPECTION. I HAVE PICTURES SHOWING EVERY REPAIR MADE AND THEY DO NOT INVOLVE ANY REPAIRS IN THE REAR OF THE VEHICLE.*AK
Fuel system, Other, Apr 21, 2004
I WOULD LIKE TO REPORT THAT MY 2000 FORD FOCUS HAS STALLED MULTIPLE TIMES IN INTERSECTIONS AND ON THE ROAD AND IS NOW BEING SERVICED TO REPAIR THE PROBLEM. I WOULD LIKE TO KNOW IF IT IS SAFE FOR ME TO CONTINUE DRIVING THE CAR CONSIDERING THE PROBLEM?*AK PLEASE LET ME KNOW? BEST WISHES JUDAH.
Fuel system, Gasoline, Apr 20, 2004
VEHICLE WOULD STALL AND LOSE POWER WHILE DRIVING. *PH ADJUSTMENTS WERE MADE, BUT THE CONSUMER WAS INFORMED THAT THE FUEL PUMP MAY BE NEEDED IF THE PROBLEM PERSISTS. RECALL# 03V482000 *SC *JB
Fuel system, Gasoline, Apr 20, 2004
THE VEHICLE'S ENGINE STALLED AND HESITATED. WHEN DRIVING ABOUT 40-45 MPH THE VEHICLE SURGED AND STALLED AGAIN. THIS PROBLEM IS CURRENTLY BEING RECALLED. *NM *MR *SC THE WORKED HAD NOT BEEN PERFORMED, BECAUSE THE CONSUMER WAS TOLD THERE WAS A 75. CHARGE TO PERFORM A TEST ON THE FULE PUMP. *JB
Fuel system, Gasoline, Electrical system, Apr 15, 2004
WHILE DRIVING VEHICLE STALLED. WHEN THIS OCCURRED VEHICLE LOST POWER. ALSO, AT 54,000 MILES BRAKE LIGHT CONTINUOUSLY STAYED ON, EVEN IF THE BRAKE PEDAL HASN'T BEEN DEPRESSED. RECALL 03V482000 WAS ISSUED FOR FUEL SYSTEM, AND RECALL 00V411000 FOR THE WIRING HARNESS . HOWEVER, THIS VEHICLE WAS NOT INVOLVED IN THE RECALLS DUE TO VIN. *AK
Fuel system, Gasoline, Apr 8, 2004
WHILE DRIVING ENGINE CHECK LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER RECEIVED A RECALL NOTICE FOR REPLACEMENT OF THE FUEL RAIL PUMP ASSEMBLY. *AK
Service brakes, Hydraulic, Fuel system, Gasoline, Exterior lighting, Equipment, Apr 3, 2004
THIS IS A CRAP CAR, I CAN ONLY HOPE FOR THE BEST OF THE NEXT FEW YEARS AS I HAVE PAID OFF THE [XXX] THING. 2000 FORD FOCUS. FUEL PUMP FAILED AND REPLACED AT DEALERSHIP WHO IN RETURN REFUSED TO GIVE BACK THE FULL TANK OF GAS I THOUGHT I HAD (I FILLED UP THAT MORNING AND BROUGHT IT STRAIGHT THERE) ANOTHER MALFUNCTION??? THEY SAY I BROUGHT IT IN AT 1/4 TANK???? THE CAR STILL SPUTTERS!!!! WHAT THE [XXX]. ALSO>>>>>PAINT IS HORRIBLY PEELING OFF TRUNK. MY CAR WILL BE GREEN IN NO TIME. AGAIN DEALER WONT EVEN ANSWER PHONE CALLS BECAUSE I AM OFF WARRANTY (AS IF DRIVING MILES WOULD ACTUALLY HAVE ANYTHING TO DO WITH THE PEELING OF PAINT) MOISTURE IN THE FRONT HEADLIGHT NEVER GOES AWAY. AND QUITE FRANKLY I DON'T FEEL LIKE REPLACING THE ROTORS AND PADS EVERY 15000 MILES!!!! CHEVY HERE I COME! *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Apr 1, 2004
FUEL PUMP ASSEMBLY WAS REPLACED UNDER RECALL. *PH PRIOR TO KNOWLEDGE OF THE RECALL, THE VEHICLE BROKE DOWN WHILE THE CONSUMER WAS DRIVING. *JB
Suspension, Fuel system, Gasoline, Electrical system, Apr 1, 2004, crash
WHILE DRIVING, THE VEHICLE STALLED DUE TO ELECTRICAL FAILURE. THERE WERE NO BRAKES OR STEERING. THE VEHICLE CRASHED INTO A TREE. DRIVER DISLOCATED HER SHOULDER AND SUSTAINED A HEAD INJURY. *AK THE REAR WHEEL BEARINGS WAS REPLACED, THE FUEL FILTER WAS REPLACED *JB
Fuel system, Gasoline, Vehicle speed control, Mar 31, 2004
WHILE DEPRESSING THE ACCELERATOR PEDA VEHICLE HESITATED/ STALLED. DEALERSHIP SERVICED THE VEHICLE, AND DETERMINED THAT FUEL PUMP NEEDED REPLACEMENT. *AK
Fuel system, Gasoline, Mar 30, 2004
SMELLED FUEL STRONG SMELL AFTER PARKING THE VEHICLE OVERNIGHT. UNSUCCESSFULLY ATTEMPTED TO START RESULTING IN FUEL SPRAYING FROM THE TOP OF THE FUEL TANK OVER UNDERSIDE OF VEHICLE . *AK
Fuel system, Gasoline, Mar 30, 2004
VEHICLE RUNNING ROUGH - DEALERSHIP SAID FUEL PUMP NEEDED REPLACING; DONE;THEN TWO DAYS LATER THE #3 PISTON BROKE AND THE ENGINE IS NOW UNREPAIRABLE AND MUST BE REPLACED. *AK
Fuel system, Gasoline, Mar 29, 2004
FUEL SYSTEM FAILS, LOSES OF POWER, AND THEN THE ENGINE SHUTS OFF WHILE DRIVING DOWN THE ROAD, VERY DANGEROUS. *AK
Fuel system, Gasoline, Mar 21, 2004
I PURCHASED A 2000 FORD FOCUS JUNE OF 2003. IT CHECKED OUT FINE BUT JUST TO COVER MYSELF I ALSO PURCHASED AN EXTENDED WARRANTY. IN DECEMBER THE CAR BEGAN TO RUN ROUGH SO I BROUGHT THE CAR INTO THE DEALER WHO CHANGED THE SPARK PLUGS AND A HOSE. ALL WORKED FINE FOR ABOUT A MONTH, AT WHICH POINT THE CAR BEGAN TO RUN ROUGH AGAIN. WHEN I WOULD STOP OR SLOW DOWN THE CAR WOULD ACT LIKE IT WAS GOING TO STALL AND MY ENGINE LIGHT WOULD COME ON. AT A STOP LIGHT I WOULD SHIFT INTO NEUTRAL OR PARK TO KEEP IT FROM STALLING. AROUND THIS TIME I RECEIVED A LETTER FROM FORD THAT THE FUEL PUMP HAS CAUSED PROBLEMS JUST LIKE I WAS EXPERIENCING. I WAS HAPPY TO KNOW THIS ISSUE WAS BEING ADDRESSED BY FORD. I MADE AN APPOINTMENT AT THE LOCAL FORD AUTHORIZED DEALER IN TOWN. LATER THAT DAY THEY CALLED TO LET ME KNOW IT WAS NOT MY FUEL PUMP AND THEY NEEDED MY OK TO DIAGNOSIS. WELL THEY TOLD ME THEY COULD NOT FIND ANYTHING SO THEY CALLED FORD. FORD EXPLAINED THERE WAS A DESIGN DEFECT IN THE ENGINE THAT CAUSED CARBON BUILD UP AND SOMETHING TO "STICK" IN THE VALVE. NOW FORD WILL NOT TAKE ANY RESPONSIBILITY, THE WARRANTY COMPANY WON'T COVER IT AND THE REPAIR IS OVER $2000.00! THIS HAS BEEN A NIGHTMARE FOR A SINGLE MOTHER WHO PURCHASE A BASIC, WHAT I THOUGHT ECONOMICAL & RELIABLE CAR. NOW I AM FORCED TO USE EVERY PENNY I HAVE SAVED TO USE TOWARD OWNING A HOME SOME DAY INTO A CAR THAT FORD DESIGNED WRONG. DOES FORD THE BIG COMPANY PAY?NO, THE CONSUMER DOES. THIS CAR ATTRACTS A CERTAIN TYPE OF CUSTOMER, NOT ONE WITH A LOT OF MONEY TO SPARE! ANY ADVICE? *JB
Fuel system, Gasoline, Mar 12, 2004
VEHICLE STALLED UNEXPECTEDLY. CONSUMER FELT VEHICLE WAS UNSAFE TO DRIVE. DEALER REPLACED FUEL PUMP, BUT NOT THE FUEL FILTER WITHOUT A CHARGE. *AK