2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: fuel system
405 reports, newest first. Show all
Fuel system, Gasoline, Mar 11, 2004
THE DEALERSHIP WANTED TO RUN A DIAGNOSTIC TEST TO DETERMINE IF THE ENGINE HESITATION WAS DUE TO THE FUEL DELIVERY MODULE (FDM) BEFORE INSTALLING A NEW FDM. IF THE FDM WAS NOT DEFECTIVE. THE DEALERSHIP WOULD CHARGE THE CONSUMER FOR THE DIAGNOSTIC TEST. *AK *SC
Fuel system, Gasoline, Mar 10, 2004
VEHICLE STALLED AT INTERSECTIONS, NEARLY RESULTING IN AN COLLISION. DEALER HAS REPLACED SEVERAL FUEL PUMPS, BUT PROBLEM STILL EXISTS. *AK
Fuel system, Gasoline, Mar 9, 2004
ON SEVERAL OCCASIONS THE VEHICLE STALLED CAUSING LOSS OF POWER. (NAR) *PH FUEL PUMP REPLACED TWICE. *CB
Fuel system, Gasoline, Mar 8, 2004
CONSUMER RECEIVED RECALL 03V482000 CONCERNING FUEL DELIVERY MODULE: DEALER CLAIMED THAT THE CONSUMER NEEDED TO PAY A DIAGNOSTIC FEE BEFORE THE RECALL WORK WAS DONE. THE RECALL NOTICE CLEARLY STATED THAT THE FUEL FILTER WAS TO BE REPLACED FREE OF CHARGE IF THE VEHICLE WAS EXPERIENCING CERTAIN SYMPTOMS. *AK
Fuel system, Gasoline, Mar 8, 2004
WHILE DRIVING VEHICLE SURGES FORWARD. DEALERSHIP HAS NOT HAD THE PARTS FOR 2 MONTHS TO PERFORM FUEL INJECTION RECALL 03V482000 REPAIRS. *AK
Suspension, Fuel system, Gasoline, Mar 3, 2004
CONSUMER RECEIVED RECALL 03V482000 CONCERNING FUEL PUMP FAILURE. WHILE DRIVING AT ANY SPEED, THE CONSUMER FELT A HESITATION IN THE ENGINE, AND THEN VEHICLE STALLED. EVEN THOUGH THERE WAS A RECALL FOR THIS VEHICLE, THE MANUFACTURER WOULD NOT HONOR IT BECAUSE IT WAS A SALVAGED VEHICLE.*AK THE CONSUMER STATED THE COIL SPRINGS FAILED. UPDATED 05/11/09. *JB
Fuel system, Gasoline, Mar 2, 2004
THE CONSUMER RECEIVED A RECALL CONCERNING A FUEL DELIVERY PROBLEM FROM THE FORD MANUFACTURER, NHTSA RECALL 03V482000, FUEL PUMP. THE VEHICLE WAS TAKEN TO THE DEALER AND DEALER REFUSED TO HONOR THE RECALL UNLESS $75.00 WAS PAID UP FRONT TO PERFORM A DIAGNOSTIC TEST. *JB *LA
Fuel system, Gasoline, Feb 25, 2004
WHILE DRIVING VEHICLE STALLED. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC REPLACED THE FUEL PUMP DUE TO A DEFECTIVE PART. A WEEK LATER, CONSUMER RECEIVED A RECALL NOTICE FOR THE REPLACEMENT OF THE FUEL PUMP. DOWNTOWN FORD, 809 SOUTH FIFTH STREET, LOUISVILLE, KY 40203 . 502-584-9731. SERVICE MANAGER KEVIN WHEAT. *AK
Fuel system, Other, Feb 24, 2004
CONSUMER RECEIVED NHTSA RECALL 03V482000 CONCERNING FUEL DELIVERY PROBLEM. DEALER INDICATED THEY WILL REPLACE THE FUEL PUMP AT NO COST. ALSO, FILTER NEEDS TO REPLACED. IT WILL COST $75.00 TO REPLACE IT. *AK *MR
Fuel system, Gasoline, Feb 23, 2004
FORD IS AWARE OF THE FAULTY FUEL PUMP AND COULD CAUSE VEHICLE TO STALL. CONSUMER EXPERIENCED STALLING SEVERAL TIMES AND IT DID NOT ALWAYS IMMEDIATELY START AGAIN. WHICH LED TO FUEL FILTER REPLACEMENT. *LA THE CONSUMER RECEIVED A RECALL LETTER REGARDING THE FUEL PUMP, HOWEVER WHEN HE ARRIVED AT THE DEALERSHIP, HE WAS TOLD THERE WAS A $100.00 DIAGNOSTIC CHARGE. THE CONSUMER HAD THE FUEL PUMP REPLACED PREVIOUSLY AND BELIEVED IT WAS JUST REPLACED WITH ANOTHER FAULTY FUEL PUMP. *JB
Fuel system, Other, Feb 23, 2004
WHILE DRIVING 30 MPH VEHICLE STALLED , CAUSING LOSS OF STEERING AND BRAKES. *AK
Fuel system, Gasoline, Vehicle speed control, Feb 19, 2004
WHILE DRIVING AT MODERATE SPEED VEHICLE EXPERIENCED UNWANTED ACCELERATION, TOOK THE VEHICLE TO A REPAIR SHOP, AND THEY REPLACED THE IDLE SPEED CONTROL SENSOR. THE VEHICLE WAS STILL EXPERIENCING UNWANTED ACCELERATION. THE CONSUMER RECEIVED A RECALL NOTICE FOR THE FUEL PUMP THAT A DEALERSHIP DECLINED TO REPAIR UNLESS THE PROBLEM RECURRED. *AK *NM
Fuel system, Gasoline, Feb 17, 2004
SHORTLY AFTER PURCHASE, VEHICLE STARTED STALLING. VEHICLE STALLS OUT DUE TO EXCESSIVE FUEL. *PH *MR
Fuel system, Other, Feb 16, 2004
THE FUEL PUMP FAILED WHILE GOING UPHILL WHILE LOW ON GAS. I ADDED 2 GALLONS OF GAS AND THIS MADE IT 1/4 TANK, BUT IT FAILED TO START. I COASTED TO A REPAIR SHOP AND CALLED EAST HILLS FORD AND WAS TOLD THAT THEY DID NOT HAVE A FUEL PUMP IN STOCK. THE REPAIR SHOP FOUND ONE AND I HAD THE CAR REPAIRED .*AK
Fuel system, Gasoline, Equipment, Feb 12, 2004
MULTIPLE PROBLEMS WITH 2000 FORD FOCUS. (NAR) *PH *CB
Fuel system, Gasoline, Feb 12, 2004
CONSUMER RECEIVED NHTSA RECALL 03V482000 CONCERNING A FUEL DELIVERY PROBLEM. CONSUMER TOOK VEHICLE TO DEALER, AND THEY HONORED THE RECALL. LEFT THE VEHICLE AT 9:00 AM, AND AT 10.00 AM CONSUMER PICKED UP THE VEHICLE. FIVE MINUTES LATER, THE VEHICLE STALLED. CONSUMER TOOK BACK THE VEHICLE TO THE DEALER, THE FLOOR MANAGER INDICATED NOTHING THEY COULD DO. *AK
Fuel system, Gasoline, Feb 12, 2004
RECAL 03V482000 CONCERNING STALLING. DEALER PERFORMED THE RECALL REPAIRS ON 2/04/2004. BEFORE THE REPAIRS VEHICLE STALLED ONLY AT A COMPLETE STOP. AFTER THE REPAIRS VEHICLE STALLED AT LEAST THREE TIMES A DAY. DRIVER HAD TO WAIT FOR THE VEHICLE TO STOP ON ITS' OWN. SHIFTED INTO PARK, AND RESTART THE VEHICLE. FUEL TANK WAS FULL WHEN VEHICLE STALLED. *AK
Fuel system, Other, Feb 11, 2004, fire
2000 FORD FOCUS CAUGHT FIRE DUE TO MANUFACTURING DEFECT. *AK
Fuel system, Gasoline, Feb 9, 2004
AFTER PARKING CONSUMER RETURNED AND ATTEMPTED TO START THE VEHICLE, BUT IT DID NOT START. CONSUMER SMELLED FUEL ODORS INSIDE THE VEHICLE. CONSUMER LEFT THE VEHICLE TO DISCOVER A POOL OF GAS UNDER THE VEHICLE. DEALER EXAMINED THE VEHICLE, AND DETERMINED THAT THE FUEL LINE DETACHED FROM THE FUEL TANK. *AK CONNECTION OF FUEL LINE TO THE FUEL TANK AND FUEL LINE CLIP WAS REPAIRED BY SERVICE DEALERSHIP. VEHICLE WAS ALSO TESTED BY DEALER. *LA
Fuel system, Gasoline, Feb 9, 2004
UPON INSPECTION OF THE FUEL INJECTION BY THE DEALERSHIP CONSUMER WAS INFORMED THAT THE PART DIDN'T NEED REPLACEMENT, BUT IF ANY OF THE SYMPTOMS OCCURRED AGAIN, TO BRING THE VEHICLE IN IMMEDIATELY AND THE PART WILL BE REPLACED. CURRENTLY, THE SYMPTOMS REAPPEARED, BUT DEALERSHIP WAS NOT ABLE TO PERFORM RECALL REPAIRS BECAUSE THE PART WAS NOT AVAILABLE.*AK
Fuel system, Gasoline, Feb 5, 2004
THE DEALER CHARGED THE CONSUMER $80.00 FOR A DIAGNOSTIC TEST BEFORE THEY WOULD PERFORM THE RECALL. RECALL 03V482000 RELATED TO FUEL FILTER CONTAMINATION. *NM
Fuel system, Gasoline, Jan 30, 2004
THE CONSUMER REQUESTED A REFUND FOR A REPLACEMENT OF THE FUEL PUMP. *LA WHILE DRIVING, THE VEHICLE DIED AND THE BATTERY, ENGINE, AND OIL LIGHT WAS PRESENT. *SC *JB
Fuel system, Gasoline, Jan 29, 2004
AFTER RECEIVING A RECALL NOTICE ON MY 2000 FORD FOCUS, I TOOK THE CAR TO MY LOCAL DEALERSHIP (UNIVERSITY FORD) TO HAVE SERVICE DONE, AND ALSO TO INQUIRE ABOUT HAVING THE FUEL PUMP REPLACED. I TOLD THE DEALERSHIP THAT ON MORE THAN ONE OCCASION MY CAR HAS DEMONSTRATED THE SYMPTOMS INDICATED IN THE LETTER I RECEIVED FROM FORD, AND THAT I WOULD LIKE TO SCHEDULE A TIME TO HAVE THIS PART REPLACED. UPON SPEAKING WITH THE SERVICE ADVISOR I WAS TOLD THAT THEY WERE UNABLE TO DUPLICATE THE SYMPTOMS OF THE RECALL, AND THEREFORE THEY WOULD NOT REPLACE THE FUEL PUMP. AFTER PLAYING PHONE TAG WITH THE SERVICE MANAGER FOR ABOUT A WEEK, I FINALLY SPOKE WITH HIM TONIGHT, AND WAS TOLD THE SAME THING, THAT THEY WOULD NOT REPLACE THE FUEL PUMP WITHOUT BEING ABLE TO VALIDATE MY CLAIM, EVEN THOUGH I HAD ALREADY SPOKEN WITH FORD MOTOR COMPANY'S CUSTOMER RELATIONSHIP CENTER, WHERE I WAS TOLD THAT THIS SERVICE SHOULD BE DONE WITHOUT ANY FURTHER DIAGNOSTICS. *AK
Fuel system, Gasoline, Jan 27, 2004
I CAN NO LONGER DEFEND THE FORD MOTOR COMPANY FROM THE MONIKER "FIX OR REPAIR DAILY" CROWD. I AM THE UNHAPPY OWNER OF A 2000 FOCUS WHO WILL NO LONGER CHAMPION THE FORD BRAND. I COMMUTE APPROXIMATELY 130 MILES DAILY - MOSTLY HIGHWAY AND HAVE HAD MULTIPLE "NEAR MISSES" DUE TO THE FUEL PUMP FAILURE. I HAD THE FUEL PUMP REPLACED BEFORE THE "SILENT" RECALL AND AM NOW AGAIN EXPERIENCING THE SAME SYMPTOMS AT HIGHWAY SPEED THAT FORD WILLFULLY KNOWS ARE DANGEROUS TO THE MOTORING PUBLIC. MY LOCAL DEALER - DON SEELYE FORD OF KALAMAZOO, MI HAS NO SYMPATHY - IS ONLY WILLING TO REPLACE THE 2ND DEFECTIVE FUEL PUMP WHEN THE "NEW AND IMPROVED" PART IS AVAILABLE IN FEBRUARY OF 2004. IN THE MEANTIME - I AND THOSE AROUND ME ON THE HIGHWAY ARE AT SERIOUS RISK - ALL WITH FORD'S BLESSING. I CONTACTED THE FORD MOTOR COMPANY'S CUSTOMER RELATIONS CENTER AND MET WITH INDIFFERENCE TO THIS ISSUE. THEY RECORDED MY COMPLAINT, OFFERED NO SOLUTION THAN TO TAKE MY LIFE (AND OTHERS) AT RISK BY CONTINUING TO DRIVE THEIR FAULTY VEHICLE. THE SERVICE CENTER REPRESENTATIVE WOULD NOT (OR COULD NOT) TELL ME WHETHER THIS "SILENT" RECALL WAS AN NHSTA RECALL THAT FELL UNDER THE "SAFETY ACT" - WHICH WOULD MANDATE IMMEDIATE ATTENTION WITH THE FULL FORCE OF FEDERAL LAW. I READ WITH AMAZEMENT AND ASTONISHMENT THE ARTICLE IN THE BLUE OVAL NEWS DATED NOV. 19, 2003 BY ROBERT LANE RELATED TO THIS ISSUE. I WAS BORN AND RAISED IN DETROIT, MI AND HAVE SEVERAL FAMILY MEMBERS WHO HAVE AND CONTINUE TO WORK FOR THIS COMPANY WITH PRIDE. NO LONGER. I HAVE PURCHASED 3 NEW FORD VEHICLES IN THE LAST 10 YEARS, AM IN THE MARKET FOR A NEW VEHICLE AND WILL NOT BE LOOKING AT ANY FORD PRODUCTS. I AM THE HEAD OF A 3 CAR FAMILY - WITH 2 TEENAGERS - ONE OF DRIVING AGE. NO ONE IN MY IMMEDIATE FAMILY WILL BE PURCHASING, DRIVING OR RIDING IN A FORD VEHICLE IN MY LIFETIME. AND THAT LIFETIME MAY BE CUT SHORT DUE TO FORD'S DECISION IN RELATION TO THIS ISSUE. GOD HELP THEM. *JB
Fuel system, Gasoline, Jan 26, 2004
THE DEALERSHIP REFUSED TO PERFORM RECALL 03V482000 UNTIL THE CONSUMER REPAIRS THEIR ENGINE. THE RECALL SYMPTOMS HAVE ALREADY OCCURRED WHICH LEAD TO THE ENGINE FAILURE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM