2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: gasoline
363 reports, newest first. Show all
Fuel system, Gasoline, Mar 20, 2003
WHILE DRIVING VEHICLE STALLED. DEALER REPLACED FUEL TANK. GTB *NLM....*AK
Fuel system, Gasoline, Mar 20, 2003
OUR 2000 FORD FOCUS STALLS. THE FIRST DEALER IT WAS TAKEN TO REPLACED THE FUEL FILTER - APPROXIMATELY AN HOUR EAST OF THAT DEALER THE CAR BEGAN TO STALL OUT AGAIN...THE NEXT DEALER TELLING US THE FUEL PUMP NEEDED TO BE REPLACED. THIS ALSO HAPPENED AS FAR BACK AS TWO YEARS AGO. *JB
Fuel system, Gasoline, Mar 18, 2003
MY 2000 FORD FOCUS WITH 45,000 MILES ON IT HAS BEEN EXPERIENCING VIOLENT STUMBLING AND HESITATION PROBLEMS AROUND HIGHWAY CORNERS. THIS HAS BEEN OCCURRING FOR THE PAST 15,000 MILES. FORD WAS UNABLE TO FIX THIS PROBLEM, BUT TALKING WITH OTHERS WHO TOOK SAFETY MATTERS INTO THEIR OWN HANDS FOUND THE FUEL PUMPS NOT KEEPING ADEQUATE FUEL FLOW TO THE ENGINE. MY CAR IS AT THE DEALERSHIP NOW WITH SPECIFIC DIRECTION TO REPLACE THIS AT MY COST. WHEN A CAR VIOLENTLY STALLS ON THE HIGHWAY AROUND A CORNER, IT'S NOT SAFE. PLEASE RECOMMEND TO FORD TO ADDRESS THIS PROBLEM BEFORE SOMEONE IS INJURED. *JB
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Exterior lighting, Equipment, Mar 18, 2003
THE FRONT AND REAR BRAKES, THE FUEL PUMP, FUEL INJECTOR, HEATER CHAMBER, HALF SHAFT BEARING, THIRD BRAKE LIGHT AND SPEEDOMETER CLUSTER WERE ALL REPLACED. *AK *JB
Fuel system, Gasoline, Mar 14, 2003
FUEL PUMP ON MY FORD FOCUS WENT OUT TWICE, ONCE AT 38000 MILES, THEN AT 91000 MILES. CAR DIED INTERMITTENTLY ON FREEWAYS, CLIMBING HILLS, AND WOULD SHAKE AT ACCELERATION. VERY FRIGHTENING.*JB
Fuel system, Gasoline, Mar 11, 2003
CAR WILL STALL WHEN ATTEMPTING MODERATE SPEED RIGHT TURN. HIGHWAY ENTRANCE IF GAS TANK IS LESS THAN HALF FULL.*JB
Fuel system, Gasoline, Feb 25, 2003
FUEL PUMP FAILURE. WITH LESS THAN 3/8 TANK OF GAS CAR WILL NOT START IF PARKED ON A GRADE. ALSO CAR HESITATED AT FULL THROTTLE ON THE HIGHWAY, BUT WAS OK AT PARTIAL THROTTLE, BUT SPEED COULD NOT BE MAINTAINED. DEALER DIAGNOSED BOTH PROBLEMS AS FUEL PUMP FAILURE. DEALER VOLUNTEERED THAT THEY HAVE A LOT OF PROBLEMS WITH THE FOCUS FUEL PUMP. OTHER COMPLAINTS ALSO MENTION SLAG OR CONTAMINATION FROM THE FUEL TANK, WHICH COULD CONTRIBUTE TO THE PUMP FAILURE.*JB
Fuel system, Gasoline, Feb 19, 2003
LOSS OF POWER. OCCURS AFTER THE FOLLOWING COMBINATION OF CONDITIONS: 1. FUEL LEVEL BELOW 1/4 TANK 2. ACCELERATING ONTO HIGHWAY WITH CIRCULAR APPROACH (RAMP) GOING CLOCKWISE. 3. VEHICLE SPEED ON CIRCULAR RAMP ABOVE 30 MPH. VEHICLE LOSES POWER UPON ENTERING HIGHWAY. PRESSING ACCELERATOR PEDAL GIVES ERRATIC RESULTS. VEHICLE WILL RESET AND OPERATE PROPERLY WHEN PULLED OFF ON SHOULDER AND VEHICLE IS TURNED OFF AND THEN ON AGAIN.
Suspension, Fuel system, Gasoline, Electrical system, Feb 12, 2003, crash
MY COMPLAINT DEALS WITH THE 2000 FORD FOCUS . I PURCHASED THIS VEHICLE IN JUNE OF 2001 WITH 100 MILES ON THE ODOMETER. SINCE THEN I HAVE HAD TO BRING MY CAR BACK FOR A FEW RECALS. ONE OF THE RECALS WAS THE REAR SUSPENSION WHERE MY CAR LOST CONTROL AND I VEERED OFF THE ROAD....LUCKILY NOONE WAS HURT. THE REASON WHY I AM WRITING THIS COMPLAINT IS BECAUSE I UNDERSTAND THAT THERE IS A INVESTIGATION ON THE FOCUS FOR VARIOUS PROBLEMS. I WANTED TO ADD TO THE INVESTIGATION BY SAYING THAT I JUST SPENT 340 BUCKS ON MY IGNITION SWITCH BECAUSE IT WOULDN'T TURN WHICH I UNDERSTAND IS A COMMON PROBLEM AND I ALSO HAD PROBLEMS WITH MY CAR STALLING IN THE MIDDLE OF THE THRUWAY. I ALMOST CRASHED INTO AN EIGHTEEN WHEELER! I HAVE HAD THE FUEL PUMP REPLACED AND MY CAR STILL IDOLS VERY ROUGH AND OCCASIONALY STALLS OUT WHEN I AM STOPPED. FORD SHOULD BE EMBARRASED BY THIS AND SHOULD TAKE ALL FOCUS'S OFF THE ROAD! I READ THAT THERE WERE HUNDREDS OF FORD FOCUS' WITH THE EXACT SAME PROBLEM BUT NO RECAL WAS ISSUED
Fuel system, Gasoline, Jan 27, 2003
ON WINDING TURNS AND HILLS CAR WOULD ACT AS IF IT WAS OUT OF GAS, ESPECIALLY IF TANK FELL BELOW HALF. CAR STALL ON ONE OCCASSIONS BUT ON OTHERS I TOOK FOOT OFF GAS AND MANAGED TO RECOVER POWER. THE DEALER REPLACED THE FUEL FILTER AND PUMP (WITH THE EXPLANATION THAT IT WAS FAILING UNDER HEAVY LOAD). WHILE THE PROBLEM HAS NOT REPEATED ITSELF, THE CAR FEELS MORE SLUGGISH THAN IT USED TO. I ALSO TRY TO KEEP THE TANK ABOVE HALF FULL, AS SEVERAL SITES HAVE RECOMMENDED.
Fuel system, Gasoline, Jan 25, 2003
MY WIFE WHO IS 7 MONTHS PREGNANT WHO ALSO HAD MY 5 YEAR OLD SON WITH HER, WAS PROCEEDING ON THE I-210 WHEN OUR 2000 FORD FOCUS SUDDENLY STALLED GOING APPROXIMATELY 55 MPH, THERE WERE MANY CARS BEHIND HER AND KEEPING HER WITS ABOUT HER PULLED THE CAR INTO THE EMERGENCY LANE, NARROWLY MISSING BEING REAR ENDED. AFTER SEVERAL ATTEMPTS, THE CAR RE-STARTED AND SHE WAS ABLE TO GET TO A PHONE AND CALL ME FOR ASSITANCE. ONCE I GOT THE CAR MOVING, I WAS NOTICING A STALLING AS WELL.
Fuel system, Gasoline, Jan 21, 2003
SEVERE HESITATION PROBLEMS ON SEVERAL OCCATIONS AS I WAS ACCELERATING. TOOK IT TO THE DEALER THREE TIMES. THEY WERE UNABLE TO CORRECT THE PROBLEM, BECAUSE THEY WERE NOT ABLE TO REPRODUCE THE SAME PROBLEM. JANUARY 2003 THE CAR WOULD NOT START. I HAD IT TOWED TO THE DEALERSHIP. I HAD TO REPLACE THE FUEL PUMP $440. MILEAGE ON THE VEHICLE WAS 48,000. I WAS HAVING THE HESTIATION DIFFICULTIES DURING THE WARRENTY PERIOD.
Steering, Suspension, Service brakes, Hydraulic, Fuel system, Gasoline, Electrical system, Latches/locks/linkages, Vehicle speed control, Tires, Jan 6, 2003, crash
CONSUMER WAS EXITING A PARKING GARAGE AND PLACED VEHICLE IN REVERSE. WITHOUT WARNING, CAR SUDDENLY ACCELERATED AND REAR TAIL SPUN AROUND 2 TIMES THEN HIT A PARKED VEHICLE. CONSUMER DID APPLY BRAKES WITH NO SUCCESS. PH INSURANCE COMPANY INFORMED DEALERSHIP THAT THERE WERE TWO RECALLS THAT DEALT WITH A DEFECTIVE THROTTLE AND SPEED CONTROL WHICH WAS NOT PERFORMED ON THE VEHICLE PRIOR TO THE ACCIDENT. OTHER PROBLEMS INCLUDED WEEZING NOISE WHILE TURNING. POWER STEERING RACKED FAILED AND REPLACED. LACK OF POWER STEERING IN STEERING WHEEL. REAR BRAKE PAD REPLACEMENT. REAR WHEEL BEARING NOISE. DEFECTIVE WHEEL BEARINGS REPLACED. TIRE PUNCTURED AND REPLACED. HESITATION ON ACCELERATION. FUEL PUMP AND GASKET REPLACED. TIRES ROTTED OUT. KEY STUCK IN IGNITION. REPLACED MALFUNCTIONED SHIFTER ASSEMBLY. TRUNK LID WOULDN'T LATCH. LATCH REPLACED. *TT
Steering, Suspension, Fuel system, Gasoline, Electrical system, Structure, Tires, Equipment, Jan 2, 2003
THE CONSUMER HAS EXPERIENCED THE FOLLOWING: THE REPLACEMENT OF THE LEFT DASH BOARD CLUSTER (TEMPERATURE GAUGE INOP FROM THE TIME OF PURCHASE), REATTACHMENT OF RUBBER SEAL AROUND DRIVER DOOR WINDOW, REATTACHMENT OF FUEL PUMP, REATTACHMENT OF HEADLINER IN REAR OF VEHICLE, UNCRIMPING OF FUEL LINE, LUBRICATION DRIVER DOOR HANDLE(STICKING), LUBRICATION OF CATCH ON REAR PASSENGER SIDE DOOR(HAD COME OPEN WHILE VEHICLE WAS IN MOTION), REPLACEMENT THE TURN SIGNAL SWITCH IN STEERING COLUMN-HAD TO BE TURNED OFF MANUALLY, PERSISTENT NOISES/VIBRATIONS IN THE FRONT END OF VEHICLE STARTING AT 36K MILES AND WAS TOLD THAT THE TIRES HAD TREAD THAT WAS TOO NARROW/WERE HIGH PERFORMANCE WHICH WASN'T NEEDED/WAS ALSO TOLD THAT THE VIBRATION WAS CAUSED BY IMPROPER TIRE CARE AND TIRE CUPPING, THE LEFT REAR SHOCK NEEDED REPLACEMENT, AND THE RADIO GOES OUT-SOMETIMES GOES OUT WHEN THE HEAT IS TURNED UP HIGH. SCC
Service brakes, Air, Fuel system, Gasoline, Dec 21, 2002
VEHICLE STALLED FOR 3-5 SECONDS IN A RIGHT HAND CURVE. NO CHECK ENGINE LIGHTS OR OTHER INDICATORS. CALLED DEALERSHIP AND THEY HAVE NOT HEARD OF ANY OTHER COMPLAINTS AND WANT TO CHARGE ME TO CHECK THE COMPUTER IN THE CAR. CAR HAS ALSO STALLED AND DIED WHEN APPROACHING STOP LIGHTS BUT RESTARTED FIRST TRY. BRAKES ALSO MAKE A LOUD HIGH PITCH SQUEAL AT ALL TIMES. I AM CONTACTING FORD FOR ASSISTANCE. WE WILL SEE HOW FAR I GET. TS
Fuel system, Gasoline, Dec 14, 2002
FUEL PUMP
Fuel system, Gasoline, Dec 3, 2002
CONSUMER STATED WHILE DRIVING AT ANY SPEED AND NO WARNING THE VEHICLE SHUT OFF. CAUSED CONSUMER TO PULL OFF THE ROAD. DEALER HAS BEEN NOTIFIED. TS ALSO NOTED VEHICLE SHUT OFF WHEN FUEL TANK AT 1/4 OR LOWER AND / OR WHEN A TURN WAS MADE. SENDER AND PUMP ASSEMBLY REPLACED. *TT
Fuel system, Gasoline, Dec 3, 2002
NO SUMMARY. DT
Fuel system, Gasoline, Electrical system, Nov 26, 2002
THE VEHICLE BEGAN STALLING AT EVERY STOP LIGHT OR INTERSECTION WHEN BRAKING. THE OWNER MANAGED TO TURN AROUND AND DRIVE BACK TO HER HOUSE. THE VEHICLE HAS BEEN TOWED TO THE NEAREST DEALERSHIP FOR DIAGNOSIS. PLEASE DESCRIBE DETAILS. TS
Fuel system, Gasoline, Nov 21, 2002
I HAVE HAD NUMEROUS PROBLEMS WITH MY 2000 FOCUS. FORD HAS NOT BEEN WILLING TO FIX ANY PROBLEM DUE TO THE FACT THAT I'M OUT OF MY WARRANTY. MY POWER STEERING SWITCH HAS WENT OUT 2 TIMES AND WHEN I TAKE IT BACK NOW THERE TELLING ME IT WASN'T THE SWITCH, ITS THE PUMP. SINCE THAT'S OUT OF WARRANTY THEY CAN'T REFUND MY MONEY OR ANYTHING. FORD HAS A RECALL ON LEFT WHEEL BEARINGS, BUT I HAD TO PAY FOR MINE TO BE DONE, BECAUSE THE RECALL WAS IN 2001 AND MY BEARINGS DID NOT GO BAD UNTIL 2002. THERE IS TOO MANY THINGS WRONG WITH THE FORD FOCUS. I HAVE NEVER SEEN A CAR IN WHICH I HAD TO FIX EVERY 5 MONTHS. THE CURRENT ISSUE IS THAT THE CAR IS STALLING. IN IDLE IT WILL GET A POINT WHERE IT WILL CUT OFF. WHEN SHIFTING TO DIFFERENT GEARS, IT HESITATES. THE CAR IS SHAKING LIKE IT WILL EVENTUALLY CUT OFF. IT HAS CUT OFF 3 TIMES AND THE EMISSION/ENGINE LIGHT CAME ON. DT
Fuel system, Gasoline, Nov 6, 2002
VEHICLE STALLED ON HIGHWAY AMIDST HEAVY TRAFFIC. DEALERSHIP SAID NOTHING WAS WRONG AND CHARGED $80 FOR CHECKING. DT
Fuel system, Gasoline, Oct 10, 2002
VEHICLE WILL SHUT DOWN DUE TO THE FUEL SYSTEM FAILING. THE FUEL SYSTEM WAS REPLACED BY THE DEALERSHIP BUT THE FAILURE STILL PERSIST. PLEASE DESCRIBE DETAILS. MR
Fuel system, Gasoline, Oct 9, 2002
THE VEHICLE STALLED WHILE DRIVING AND WOULD NOT RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHO NOTICED BLACK BUILD UP IN THE TANK. *MR *NLM
Service brakes, Hydraulic, Fuel system, Gasoline, Power train, Equipment, Sep 24, 2002
7/00- TAPE WAS STUCK IN STEREO, HAD TO REPLACE STEREO. 3/01- HAD TO REPLACE FRONT BRACK PADS AT 11000 MILES. 11/01- IGNITION LOCKED ON VEHICLE. HAD TO REPLACE IGNITION. 3/02- TRANSMISSION WAS NEUTRALIZING WHEN DRIVING. HAD TO REPLACE TRANSMISSION. 5/02- CAR WAS STALLING. FORD UNABLE TO DETECT PROBLEM. 9/02- CAR WAS NOT ACCELERATING AND STALLING SUDDENLY- HAD TO REPLACE FUEL PUMP. 9/02- HAD TO REPLACE FRONT BRAKE PADS AND BACK BRAKE SHOES AT 34000 MILES.
Fuel system, Gasoline, Sep 10, 2002
ON SEPTEMBER 3, 2002, AS CONSUMER WAS LEAVING WORK, HE SMELLED GASOLINE AND THE CAR HESITATED WHEN HE ACCELERATED. CONSUMER PULLED INTO A GAS STATION TO GET GAS SINCE THE GAS GAUGE READING WAS BETWEEN 3/8 AND 1/4 FULL. CONSUMER LOOKED UNDER THE CAR AND SAW SOME GAS LEAKING FROM THE CAR. CONSUMER THOUGHT MAYBE THE GAS AND THE SMELL WAS THE RESULT OF SOME SORT OF PRESSURE BUILDUP CAUSING AN OVERFLOW.) HOWEVER, AFTER HAVING THE CAR FILLED UP, HE THEN STARTED THE CAR AND WENT TO PULL AWAY. CONSUMER COULDNOT EVEN PULL AWAY FROM THE PUMP, WHEN HE STEPPED ON THE GAS PEDAL, GASOLINE WOULD POUR OUT UNDER THE CAR FROM THE GAS TANK. CONSUMER HAD THE CAR TOWED TO PACIFICO MARPLE FORD (BROOMALL, PA). THEY DETERMINED THAT THE LEAK PROBABLY WAS DUE TO THE TUBE ASSEMBLY BECOMING DISCONNECTED FROM THE FUEL PUMP. (THAT DIAGNONSIS WAS LATER CONFIRMED.) A NEW TUBE ASSEMBLY WAS INSTALLED AND THE CAR SEEMS TO BE RUNNING JUST FINE, CONSUMER IS SEEKING REIMBURSEMENT.*JB