2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: gasoline
363 reports, newest first. Show all
Engine and engine cooling, Fuel system, Gasoline, Power train, Jan 15, 2004
MY CAR STARTED BY LOSING POWER AND THE THE ENGINE WOULD RACE UP IN ANY GEAR. THE LIGHTS ON THE DASH WOULD DIM ALONG WITH THE RADIO AND THE HEADLIGHTS. THEN ON OCT 31 2002, THE GAGES WENT CRAZY. I PARKED THE CAR AND CALLED FORD AND ASKED IF THEY WOULD RUN A TEST TO SEE WHAT WAS WRONG. THEY SAID I WOULD HAVE TO PAY FOR THE TEST AND I TOLD THEM I COULD NOT AFFORD IT. SINCE THEN I ONLY DRIVE THE CAR TO THE STORE ABOUT 5 MILES FROM MY HOUSE AND BACK. NOW THE ENGINE IS STALLING AGAIN IN ANY GEAR. THE ENGINE LIGHT IS ON. I AGAIN ASKED THE DEALERSHIP AND FORD IF THEY COULD RUN THE TEST TO SEE WHAT IS WRONG WITH CAR AGAIN THEY REFUSED. I JUST NOW WROTE A E-MAIL TO FORD. I JUST WANT MY CAR THAT ONLY HAS ABOUT 49000 MILES TO RUN. FORD IS OFFERING A LONGER WARRANTY ON THE NEWER FOCUS WHY NOT OFFER IT TO US THAT OWNER THE PIECE OF JUNK OLDER FOCUS.
Fuel system, Gasoline, Power train, Wheels, Jan 15, 2004
WE PURCHASED THIS 2000 FORD FOCUS ON 11/13/00. WE BEGAN HAVING PROBLEMS WITH THE MANUAL TRANSMISSION FOR THE FIRST TIME IN JANUARY 2001 AND TOOK IT TO THE DEALERSHIP ON 1/25/01 FOR DIAGNOSIS AND REPAIR. THE VEHICLE HAS BEEN IN FOR REPAIRS 4 ADDITIONAL TIMES FOR MANUAL TRANSMISSION PROBLEMS ON 8/01/01, 1/11/02,7/09/02, AND 2/13/03. THE PROBLEMS HAVE BEEN DIFFICULTY SHIFTING INTO 1ST AND 2ND GEAR, GRINDING WHEN SHIFTING INTO 3RD GEAR. ONE OF THE TIMES IT WAS TAKEN IN WE HAD COMPLETELY LOST THE ABILITY TO SHIFT INTO 2ND OR 4TH GEAR. EACH TIME THEY HAVE FIXED THE PROBLEM ONLY TO HAVE MORE PROBLEMS OCCUR. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ON 1/30/03 FOR ROAD NOISE AND WOBBLING IN THE WHEEL. THE TIRE ALMOST FELL OFF ON THE WAY TO THE DEALERSHIP. AT THAT TIME WE WERE ADVISED THAT THERE WAS A RECALL ON THE WHEEL BEARINGS. WE HAD NEVER RECEIVED NOTIFICATION OF THIS AND IN FACT THE SERVICE MANAGER SAID THAT HE WAS UNAWARE OF THE RECALL UNTIL HE LOOKED UP OUR VEHICLE IN THE COMPUTER. THEY SUBSEQUENTLY PERFORMED THE FOLLOWING REPAIRS: FOUND RELATED DAMAGE BECAUSE OF RECALL AS FOLLOWS, LEFT DRUM, SPINDLE AND BEARINGS REFACED RIGHT DRUM R & R RIGHT SPINDLE. REAR SHOES REPLACED PARTS FOR RELATED DAMAGE. THIS IS THE INFORMATION STATED ON THE INVOICE. AT THIS TIME THE CHECK ENGINE LIGHT HAD ALSO BEEN ON SO WE ASKED THEM TO ALSO FIND OUT WHAT THAT PROBLEM WAS. THEY FOUND GROSS LEAK FOUND AT EVAP MANIFOLD LINE. REPLACED LINE. THIS VEHICLE HAS ALSO BEEN TO THE DEALERSHIP FOR SEVERAL RECALLS INCLUDING THE REPLACEMENT OF A BATTERY CABLE ON 1/30/03 AND ANOTHER UNSPECIFIED RECALL ON 10/02/01. THIS VEHICLE HAS BEEN IN THE SHOP 6 TIMES FOR A TOTAL OF 67 DAYS IN THE 27 MONTHS THAT WE HAVE OWNED IT. IT NOW HAS 35,800 MILES AND THE WARRANTY IS ABOUT TO EXPIRE. WE HAVE MADE SEVERAL CALLS TO THE DEALERSHIP AND TO FORD CUSTOMER SERVICE. THEY HAVE OFFERED TO EXTEND THE WARRANTY ON THE DRIVE TRAIN AND CHARGE US A $50 DEDUCTIBLE EACH TIME THAT THE VEHICLE REQUIRES SERVICE ON THIS SYSTEM.
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Visibility, Structure, Equipment, Jan 15, 2004
MY 2000 FORD FOCUS HAS HAD PROBLEMS STARTING 2 MONTHS AFTER I PURCHASED IT. IT'S BEEN IN 6 TIMES FOR EXCESSIVE BRAKE NOISE AND OR SQUEALING. THE DOOR HINGES WERE SQUEEKING AND HAD TO BE REPLACED DUE TO MISALIGNMENT..IT TOOK 5 TIMES TO DETERMINE THIS. WEATHER STRIP MOLDING HAS BEEN REPLACED DUE TO FALLING APART AROUND THE HEADLIGHTS. THE CD PLAYER/STEREO WAS REPLACED WITH A NEW FACTORY MODEL WHEN CD PLAYER WOULD NOT WORK PROPERLY. THE "NEW" MODEL WAS REPLACED YET AGAIN DUE TO CODING SEEN AND NO NUMBERS IN THE WINDOW DIGITAL AREA. THE FUEL PUMP WAS REPLACED AFTER STALLING MORE THAN 50 MILES FROM HOME...STILL DOES NOT RUN UP TO PERFORMANCE. FUEL AREA REWORKED AGAIN. WOULD NOT START DUE TO BATTERY CABLE. FORD NEEDS TO DISCONTINUE THIS MODEL UNTIL THEY CAN FIX THE PROBLEMS IT HAS WITH IT. THEY ALSO NEED TO GET ALL FOCUS MODELS OFF THE ROAD, THEY ARE SAFETY HAZZARDS.
Engine and engine cooling, Fuel system, Gasoline, Jan 15, 2004
AIR HAS NOT WORKED PROPERLY FROM PURCHASING THE CAR NEW. I PURCHASED THE CAR IN WA STATE AND HAVE MOVED TO OHIO. I AM NOW TOLD THAT EVEN THOUGH THE PROBLEMS STARTED PRIOR TO THE WARRANTY EXPIRING, SINCE I BOUGHT THE CAR FROM ANOTHER DEALER, I WILL HAVE TO PAY FOR ANY FUTURE PROLEMS MYSELF. FUEL, FORD KNOW THIS IS A PROBLEM, AND REFUSES TO TELL ME IF THE NEW FUEL PUMP I HAD THEM PUT IN IS AN OLD PUMP OR A NEW ONE WITHOUT THE PROBLEMS. OTHER, EXHAUST LEAK, I WAS TOLD I HAD AN EXHAUST LEAK, BUT THE ENGINE STILL SOUNDS VERY KNOCKY. I AM 4TH GENERATION FORD, MY SISTER WAS ALSO AND NOW BUYS ANYTHING BUT FORD, THIS WILL ALSO BE MY LAST FORD, BUT ANY CASH BACK WOULD BE GREAT AFTER BUYING THE MOST EXPENSIVE PIECE OF JUNK I HAVE EVER HAD.
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Seat belts, Other or unspecified, Jan 15, 2004
CAR HAS HAD THE BRAKES SERVICED A TOTAL OF FIVE TIMES AND THE CAR IS STALLING DURING ACCELERATION. THIS CAR HAS BEEN IN SHOPS FOR SEVERAL RECALLS AS WELL AS TWICE FOR IGNITION LOCK FAILURE. ONE OF OUR CHILDREN WAS TRAPPED IN REAR SEAT BY DEFECTIVE SEAT BELT & HAD TO BE CUT OUT WITH A KNIFE. CAR STALLS AFTER IT WARMS UP. DEALER SAYS IT'S FUEL PUMP BUT IF THAT WERE SO, WOULDN'T IT STALL WAARM OR COLD. I SPOKE TO AN EMPLOYEE AT ANOTHER DEALER WHO SAID FORD WAS FINDING PROBLEMS WITH SENSOR CONNECTED WITH COOLING SYSTEM. WHO DO I BELIEVE? THEY WANT TO CHARGE US $700 TO REPLACE FUEL PUMP THAT PROBABLY WORKS FINE.
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Visibility, Air bags, Seat belts, Structure, Equipment, Other or unspecified, Jan 15, 2004
I BOUGHT THE CAR IN JUNE OF 2000 SINCE THIS TIME THE CAR HAS HAD A NUMBER OF RECALLS ON THE CAR. I FEEL THAT THE PEOPLE THAT BOUGHT THE 2000 MODEL OF THIS CAR SHOULD NOT BE LIABLE TO PAY THE AMOUNT THE CONTACT WAS SIGNED. DUE TO THE FACT THAT AT THE TIME THE CAR WAS BOUGHT, THE PEOPLE THAT BOUGHT THE CAR DIDN'T KNOW THAT MOST OF THE CAR'S LIFE WOULD BE IN THE SHOP BEING FIXED. ALSO FORD KNEW THAT THE FOCUS WAS PRONE TO THIS HAPPENING.
Fuel system, Gasoline, Jan 15, 2004
CAR STALLS WHEN BELOW HALF A TANK OF GAS. MAKING SHARP RIGHT TURNS CAUSES ENGINE TO STALL. CAR ALSO LURCHES LIKE IT ISN'T GETTING FUEL PROPERLY WHEN GOING UPHILL. FUEL PUMP SYSTEM HAS BEEN REPLACED ONCE.
Fuel system, Gasoline, Jan 15, 2004
FUEL PUMP FAILURE AT 53,000 MILES.
Fuel system, Gasoline, Other or unspecified, Jan 15, 2004
FUEL SYSTEM: VEHICLE WAS FILLED WITH FUEL AT A GAS STATION. DRIVER WENT TO LEAVE, CAR DID NOT START. ATTENDANT INFORMED DRIVER THAT FUEL WAS LEAKING FROM VEHICLE. ALMOST A FULL TANK OF FUEL DUMPED ONTO PAVEMENT. FIRE DEPARTMENT SHOWED UP AND TOWED VEHICLE AWAY. APPARENT PROBLEM: FUEL HOSE LINKAGE HAD COME LOOSE AND HAD FALLEN OFF FROM INSIDE THE BODY OF THE VEHICLE. OTHER: THROTTLE CABLE BREAKAGE IN HEAVY TRAFIC AT HIGH RATE OF SPEED. DRIVER MEANWHILE MERGING WITH TRAFFIC. BREAKAGE RESULTING IN QUICK DECELERATION. SERIOUS ACCIDENT NARROWLY AVOIDED. CAR WAS UNFORTUNATELY OUT OF WARRANTY PERIOD, BUT FORD PAID FOR THE REPAIR. TOWING CHARGE WAS NOT REIMBURSED.
Suspension, Fuel system, Gasoline, Jan 15, 2004
CAR STALLS, HESITATES, GETTING WORSE VERY DANGEROUS!! FUEL SYSTEM SEEMS BAD
Fuel system, Gasoline, Jan 15, 2004
VEHICLE ENGINE STALLS AND HESITATES WHEN I GO AROUND A RIGHT HAND BEND. THIS HAPPENS VERY REGULARLY AS I GET ONTO LARGE OR INTERSTATE HIGHWAYS.
Fuel system, Gasoline, Jan 15, 2004
THE CONSUMER RECEIVED NHTSA RECALL #03V482000 CONCERNING A FUEL DELIVERY PROBLEM. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND THEY REFUSED TO HONOR THE RECALL. THE DEALER STATED A DIAGNOSTIC WAS NEEDED TO SEE IF THE VEHICLE QUALIFIED FOR THE RECALL. *JB
Fuel system, Gasoline, Wheels, Jan 15, 2004
REAR WHEEL BEARINGS WORE OUT WITHIN 22,000 MILES. THE BEARINGS HAD BEEN REPLACED UNDER RECALL 01I017000 , BUT FAILED AGAIN. *AK THE CONSUMER STATED THE FUEL GAUGE STARTED AT HALF A TANK AND THEN WENT TO THE FULL MARK. THE DEALER REPLACED THE FUEL PUMP. *JB
Fuel system, Gasoline, Jan 14, 2004
CONSUMER RECEIVED NHTSA RECALL 03V482000 CONCERNING FUEL DELIVERY PROBLEM. TOOK VEHICLE TO A DEALER, AND DEALER WON'T HONOR THE RECALL, CLAIMING NEED TO PERFORM FIRST A DIAGNOSTIC. CONSUMER PAID $75.00. *AK
Fuel system, Gasoline, Jan 13, 2004
WHILE DRIVING VEHICLE STALLED. DEALERSHIPS MECHANIC INFORMED THE CONSUMER THAT THE PROBLEM PERTAINED TO THE FUEL PUMP FAILURE. MECHANIC HAD NOT YET RESOLVE THE PROBLEM. *AK
Fuel system, Gasoline, Jan 12, 2004
I AM VERY ANGRY, I AM HAVING THE FORD FOCUS STALLING PROBLEM, DEALER ALREADY REPLACE FUEL PUMP AND STILL STALLS, THE CAR HAS BEEN 30 DAYS AT 3 DIFFERENT DEALERS BUT HAVEN'T FIX IT, THEY ARE AWARE OF THIS PROBLEM BUT THEY CAN'T FIX IT, I HAVE ALL THE SAME SYMPTOMS OF THE FUEL PUMP PROBLEM BUT THIS IS NOT WHAT IS CAUSING THE PROBLEM THEY ALREADY CHECK THE ALTERNATOR AND IT IS FINE. I HOPE SOME ONE CAN GIVE ME A HAND ON THIS I DON'T KNOW IF I CAN SUIT FORD, AND I DON'T WANT TO WAIT UNTIL I DIE BECAUSE THIS CAR IS HAZARD, LET ME KNOW WHAT CAN I DO. *LA
Engine and engine cooling, Fuel system, Gasoline, Jan 9, 2004
WHEN APPLYING GAS VEHICLE BEGINS TO HESITATE AND ENGINE STARTS TO PRODUCE A LOUD NOISE. *AK
Fuel system, Gasoline, Jan 8, 2004
WHILE DRIVING 55 MPH THE VEHICLE SPUTTERED AND STALLED WITHOUT WARNING. THE FUEL TANK WAS HALF FULL. THE DRIVER PULLED THE VEHICLE OVER TO THE SIDE OF THE HIGHWAY AND TRIED TO RESTART THE VEHICLE TWICE. THE VEHICLE WAS THEN TOWED TO THE DEALER WHO REPLACED THE FUEL DELIVERY MODULE. PLEASE PROVIDE ANY FURTHER DETAILS. *NLM CONSUMER NOTED THIS FAILURE WOULD HAVE BEEN VERY UNSAFE HAD IT HAPPENED AROUND OTHER VEHICLES. *PH *NM
Fuel system, Gasoline, Jan 7, 2004
FUEL PUMP MALFUNCTIONED, CAUSING INTERMITTENT STALLING. FUEL PUMP WAS REPLACED FIVE TIMES, HOWEVER THE PROBLEM STILL EXISTS. *AK
Fuel system, Gasoline, Power train, Jan 4, 2004
WE PURCHASED OUR 2000 FORD FOCUS IN AUGUST OF 2003 IT HAD LOW MILES AND WE FIGURED I WAS A GOOD CAR. IN OCTOBER IT BROKE DOWN ON US AND IT WAS A CLUTCH DISK THAT WENT OUT. WE SAID OK AND THEY FIXED IT UNDER WARRANTY. THE DAY AFTER WE GOT IT BACK FROM THE SHOP IT STARTED MAKING A WEIRD NOISE SO WE TOOK IT BACK AND THEY SAID THEY NEED TO MAKE A ADJUSTMENT. THEN LESS THAN 3 WEEKS LATER WE ENDED UP HAVING IT BREAK DOWN ON US ONCE AGAIN THEY HAD TO REPLACE THE TRANSMISSION. WELL HERE WE ARE ONCE AGAIN. ABOUT A MONTH AFTER THE TRANSMISSION. GOING THROUGH A STOP LIGHT ONE DAY THE CAR STARTED TO HAVE ENGINE HESITATION AND LOSS OF POWER AND THEN WOULD STALL OUT. NOW THEY ARE TELLING US THAT WATER GOT IN OUR FUEL TANK AND RUINED THE FUEL PUMP. I JUST FOUND OUT BY DOING SOME OF MY OWN RESEARCH THAT THE FUEL SYSTEM WAS RECALLED IN NOV OF 2003 FOR CARS EXHIBITING THE SIMILAR SYMPTOMS. THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE HAS NOT INFORMED US OF THIS RECALL AND STATES THAT THE WATER WAS THE CAUSE OF OUR PROBLEMS. *LA
Suspension, Fuel system, Gasoline, Electrical system, Dec 30, 2003
FORD FOCUS FUEL PUMP FAILS TO DELIVER FUEL AND CAR STALLS. DANGEROUS! I WAS ONLY LESS THAN HALF OF A TANK OF GAS FULL AND MY CAR STALLED OUT ON THE VERY BUSY DAVIS BLVD IN NRH TX. IT REPEATEDLY DIED WHEN TRYING TO RESTART THE CAR TO GET IT TO A SERVICE STATION. I FILLED THE CAR UP AND THE CAR WORKED FINE. NOW WE NEVER LET THE CAR GET BELOW A HAFF A TANK. PLEASE RESOLVE THIS ISSUE WE COULD HAVE BEEN KILLED! THIS WAS THE MOST RECENT TIME THIS HAS HAPPENED. THIS PROBLEM AND SIMILAR HESITATION UPON ACCELERATION IN TURNS AND GOING UPHILL HAVE HAPPENED NUMBEROUS TIMES AND HAVE LEFT ME FEELING LIKE I WAS GOING TO BE STRANDED OR WORSE- IN A WRECK. I HAVE ALSO HAD THE COMMON IGNITION CILINDER LOCK PROBLEM, A BROKEN DOOR ACTUATOR, A BROKEN LUMBAR SUPPORT, DRASTICALY LEAKING A/C ONTO THE FLOOR, A VERY NOISY FRONT STUT NOISE WHEN GOING OVER SPEED BUMPS, FRONT CAR CREAKING FROM RIGHT FRONT FENDER NOISE AT HIGHWAY SPEEDS, AND POOR SERVICE REPS THAT INSULT PERSON AND DESTROY CAR (BROKE THINGS ON CAR THAT WERE NOT BROKEN WHEN BROUGHT IN FOR SERVICE). ALL OF THESE THINGS NEED ADDRESSING, BUT MOST OF ALL THE FUEL/HESITATION/STALLING PROBLEM BEFORE SOMEONE IS KILLED!
Fuel system, Gasoline, Dec 21, 2003
2000 FORD FOCUS FUEL PUMP REPLACED IN WARRANTY AT 35000 MILES. FUEL PUMP OUT AGAIN AT 69000 MILES. *AK
Fuel system, Gasoline, Dec 11, 2003
I OWN A 200O FORD FOCUS AND RECENTLY SAW A MEDIA STORY REGARDING FUEL PUMP FAILURES. I HAVE HAD SEVERAL INCIDENTS WHERE MY CAR FAILED TO ACCELURATE OR STALLED OUT. THE LOCAL FORD DELERSHIP REPORTS I HAVE A DEFECTIVE FUEL PUMP. I BELEIVE THESE SHOULD BE A RECALL ITEM. *AK
Fuel system, Gasoline, Dec 10, 2003
WHILE DRIVING 60 MPH THE VEHICLE STALLED AND THE CONSUMER LOST POWER STEERING. THE CONSUMER MANAGED TO PULL OVER AND THE VEHICLE EXPERIENCED A HARD START. THE CONSUMER HAD THE VEHICLE TOWED THE TO DEALER. *AK THE CONSUMER WAS TOLD THAT THE MASS AIR FLOW SENSOR WAS DIRTY AND BY CLEANING IT WOULD REMEDY THE PROBLEM. *SCC THE VEHICLE STALLED AGAIN AND THE CONSUMER WAS THEN TOLD THE FUEL PUMP OR THE FUEL DELIVERY MODULE WAS THE CAUSE OF THE PROBLEM. *JB
Fuel system, Gasoline, Dec 4, 2003
ON THE 2 FORD FOCUS ZX3S I OWNED BOTH EXHIBITED A HESITATION PROBLEM WHEN THE FUEL GAUGE READ 1/4 TANK OF GAS OR LESS. ONE FOCUS WAS SOLD, WHILE THE OTHER FOCUS HAD THE FUEL PUMP REPLACED (BOTH VEHICLES' WARRANTIES HAD EXPIRED). THERE WERE NEVER ANY ACCIDENTS DUE TO THE PROBLEM, FORTUNATELY THE PROBLEMS AROSE IN THE NEIGHBORHOOD OR ON THE OPEN HIGHWAY. *NLM