2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: hydraulic
399 reports, newest first. Show all
Service brakes, Hydraulic, Apr 6, 2002
BRAKE PADS AND ROTORS HAVE WORN OUT PREMATURELY. ROTORS HAD TO BE REPLACE AT 27000 MILES.*AK
Service brakes, Hydraulic, Apr 5, 2002
FRONT ROTORS WERE REPLACED DUE TO VIBRATION AND SQUEALING WHEN APPLYING BRAKE. REPLACED A SECOND TIME IN FEBRUARY 2002 FOR THE SAME PROBLEM.*AK
Service brakes, Hydraulic, Apr 2, 2002
WHILE DRIVING WOULD STEP ON BRAKE PEDAL AND BRAKES WOULD MALFUNCTION AT TIME OF OPERATION, HAD TAKEN VEHICLE TO DEALER AND THEY REPLACED ROTORS FIVE TIMES *AK THE BRAKES SQUEAK OFTEN, BOTH THE ROTORS AND BRAKE PADS HAD TO BE REPLACED DUE TO WARPING, THE VEHICLE HAS 31,800 MILES. *YD
Service brakes, Hydraulic, Apr 2, 2002
BRAKES ARE SQUEAKING AND GRINDING. TOOK VEHICLE TO DEALER, AND HAD BRAKES REPAIRED, BUT PROBLEM STILL EXISTS. *AK
Service brakes, Hydraulic, Apr 2, 2002
BRAKES HAVE NOT BEEN RIGHT SINCE THE FIRST DAY OF DELIVERY. *AK
Service brakes, Hydraulic, Wheels, Apr 2, 2002, crash
WHILE DRIVING THE 2000 FORD FOCUS DOWN A 35 MPH ROAD I PROCEEDED TO BRAKE TO A STOP WHEN FRONT DRIVER'S SIDE WHEEL ASSEMBLY COLLAPSED, CAUSING CAR TO SKID OUT OF CONTROL. IT CAME TO A STOP AFTER HITTING A PARKED CAR.*AK
Service brakes, Hydraulic, Apr 2, 2002
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Steering, Service brakes, Hydraulic, Mar 24, 2002, crash
IN JAN 2002 FORD WANTED TO BUY CAR BACK BUT SAID THE CAR IS 2 YEARS OLD SO IT WAS ONLY WORTH HALF OF ITS VALUE DUE TO THE CAR WOULD HAVE TO GO TO AN AUCTION CAR WAS IN SHOP 77 DAYS THEN RELEASED AND 4 DAYS LATER PARTS WENT UP AGAIN AND CAR LOST STEERING AND BRAKES AND HAD ACCIDENT THIS IS A SERIOUS MATTER AND SOMEONE IS GOING TO BE KILLED BY THIS PROBLEM FORD KNOWS ABOUT THIS PROBLEM BUT SEEMS THEY DONT CARE. *AK
Service brakes, Hydraulic, Visibility, Air bags, Structure, Mar 22, 2002, crash
VEHICLE HAS BEEN GIVEN CONSUMER TROUBLE SINCE PURCHASING IT. 2ND DAY AFTER PURCHASE VEHICLE WAS IN DEALER'S SHOP FOR 2 WEEKS. WHEN PUTTING ON BRAKES VEHICLE SHAKES. ALSO, DRIVER CANNOT SEE TO MAKE TURNS BECAUSE TRUCK IS VERY HIGH.*AK WHILE DRIVING, THE CONSUMER AND HIS DAUGHTER WERE HURT DUE TO BRAKES AND WIPERS FAILED IN THE RAIN. THE REAR WINDOW IS VERY HIGH AND THE DRIVER WAS UNABLE TO SEE VEHICLES FROM BEHIND. BRAKES FAILED MORE THAN THREE TIMES, HOWEVER THE DEALER REFUSED TO FIX IT AFTER THE FIRST REPAIR THERE WERE 2 INJURIES, CONSUMER ALSO STATES THE AIRBAGS FAILED. *YH
Suspension, Service brakes, Hydraulic, Mar 19, 2002
AT ANY SPEED THERE'S A ROARING NOISE COMING FROM DRIVER SIDE. TOOK VEHICLE TO FORD, AND THEY STATED THAT BRAKES NEEDED TO BE CLEANED. CONSUMER FEELS IT IS THE WHEEL BEARING. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
Service brakes, Hydraulic, Mar 18, 2002
FRONT PADS AND ROTORS NEEDED REPLACEMENT AT 29000 MILES. *AK
Service brakes, Hydraulic, Air bags, Mar 15, 2002
BRAKES AND AIR BAGS FAILED
Service brakes, Hydraulic, Mar 13, 2002
2000 FORD FOCUS ONLY WITH 23500 MILES, MAINLY HIGHWAY. BRAKES STARTED MAKING GRINDING NOISE, SHOP REPLACED FRONT BRAKES, PADS AND ROTORS. CAR STILL MAKING GRINDING NOISE. ONE WEEK AFTER REPLACING FRONT BRAKES, SHOP REPLACE REAR DRUM BRAKES. BRAKES ARE STILL MAKING GRINDING NOISE. HAVE HAD BRAKES INSPECTED AND REINSPECTED BUT MECHANICS STATES NO PROBLEMS WITH BRAKES. GENERAL COMMENTS FROM MECHANICS ARE THAT THE FORD FOCUS BRAKES ARE BAD, WEAK AND WILL REQUIRE REPLACING MORE THAN THE AVERAGE AUTOMOBILES IN THE MARKET. *AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Visibility, Mar 12, 2002
BRAKES HAVE SQUEALED FRON ABOUT 1500 MILES. HAVE HAD PADS REPLACED, BUT SQUEALS DID NOT GO AWAY. FRONT BRAKES GRIND, AT SHOP NOW. IN NOVEMBER 2001 HAD TO HAVE STRUTS REPLACED WHILE HAVING RECALL WORK DONE. STRUTS LITTLE OVER A YEAR OLD. ENGINE MAKES A CHIRPING NOISE AT ABOUT 1000-2500 RPM, BUT DEALER UNABLE TO DUPLICATE. ALSO SQUEALS OR WHINES WHEN MAKING RIGHT TURNS. WINDSHIELD CRACKED WHEN A SMALL STONE HIT IT. WILL HAVE INSURANCE REPLACE. OVERALL, NOT HAPPY WITH CAR. BEEN IN THE SHOP THREE TIMES IN THE LAST YEAR!!
Steering, Service brakes, Hydraulic, Parking brake, Mar 12, 2002
FRONT DISC BRAKES - EXCESSIVE SQUEAL UPON BRAKING...TOOK CAR TO DEALER. DETERMINED FRONT BRAKE PADS & ROTORS NEEDED REPLACEMENT. ONLY 16000 MILES ON CAR! ALSO, REAR DRUM BRAKES MAKE SQUEALING NOISE AS WELL. DEALER REPLACED THEM AND TURNED DRUMS. STILL SQUEALS. ALSO, EMERGENCY BRAKE LEVER HAS EXCESSIVE TRAVEL AND POOR BRAKE HOLDING CAPACITY. TOOK BACK TO DEARLER TWICE, STILL POOR EMERGENCY BRAKE FUNCTION. POWER STEERING ASSIST SUDDENLY FAILED WHEN STARTED CAR COLD. STEERING WAS DIFFICULT AND SLOW UNTIL CAR WARMED UP. HAPPENED FOR SEVERAL DAY UNTIL TOOK TO DEARLER. SAID P.S. PUMP WAS BAD AND REPLACED IT.*AK
Service brakes, Hydraulic, Mar 8, 2002
BRAKES WAE MAKING A GRINDING NOISE. TOOK TO DEALER, AND HAD ROTORS REPAIRED, BUT PROBLEM STILL EXISTS. *AK
Service brakes, Hydraulic, Power train, Structure, Interior lighting, Mar 5, 2002
AFTER 6 MONTHS OF PURCHASE, THE BRAKE SYSTEM SPECIFICALLY ROTORS FAILED. WHILE APPLYING BRAKES THERE WAS A CONSTANT GRINDING NOISE, RESULTING IN EXTENDED STOPPING DISTANCE BEFORE VEHICLE CAME TO A COMPLETE STOP. MECHANIC STATED FORD FOCUS HAD THESE COMMON PROBLEMS, ALSO EXPERIENCING OTHER PROBLEMS SUCH AS ERRATIC SPEEDOMETER FAILURE, AN THE INTERIOR LIGHT FELL OUT FROM ROOF OF VEHICLE, AND 2 INCHES OF WATER ENTERING FROM SIDE OF DOOR. *AK *TT
Service brakes, Hydraulic, Mar 5, 2002
BRAKE PADS WILL STICK TO THE ROTORS WHEN CONSUMER IS TRYING TO ACCELERATE, MAKING IT HARDER TO ACCELERATE WHEN AT A COMPLETE STOP. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK
Suspension, Service brakes, Hydraulic, Power train, Tires, Mar 2, 2002
TIRES/ SHOCKS/ WHEEL BEARINGS/ TRANSMISSION STRUTS, AND ROTORS ALL BAD AND WORN OUT. DEALER UNRESPONSIVE AND SO IS FORD LONG FILE ON THIS CAR. DEALER REFUSES TO LEMON THE CAR OUT. TOTALLY FRUSTRATED BY LACK OF COMMUNICATION WITH DEALER AND FORD AM CONSIDERING LAW SUIT AGAINST BOTH (TIRESIZE: 195R7015)
Service brakes, Hydraulic, Feb 28, 2002
PREMATURE WEAR OF FRONT BRAKE PADS AND ROTORS. INSIDE OF BRAKE ROTORS HAVE WORN. HOWEVER, PADS ON THE OUTSIDE HAVE NOT. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Visibility, Structure, Seats, Equipment, Other or unspecified, Feb 28, 2002
THERE IS A VERY BAD SQUEAKING NOISE WHEN BRAKING, AND WHEN CONSUMER LETS OFF THE BRAKE THERE IS A GRINDING NOISE. DRIVER STATES MORE THAN TWICE BRAKE PEDAL WAS APPLIED, AND PEDAL WENT TO THE FLOOR. FORD HAS BEEN CONTACTED.*AK.ALSO CONSUMER WAS COMPLAINING OF THE TRANSMISSION SLIPPING, THE CIGARETTE LIGHTER WAS NOT WORKING, CUP HOLDER BUBBLING, SERPENTINE BELT WAS REPLACED DUE TO A SQUEAL COMING FROM UNDER THE HOOD, GAS LIGHT WAS COMING ON WHEN THE TANK WAS FULL OF GAS, DOOR AJAR LIGHT WAS COMING ON, STARTER AND BATTERY WERE REPLACED, DRIVER SIDER MIRROR KNOB FELL OFF, RPM RUNS HIGH, HEADLAMP MOLDING WAS REPLACED, SUNVISOR WAS BROKE, REAR CHILD SEAT LATCH COVER WAS BROKE, AIR CONDITIONER AND HEATER WERE REPLACED, PASSENGER DOOR TRIM, DRIVER SEAT METAL BAR, REWIND BUTTON FOR AM/FM CASSETTE WAS INOPERATIVE, CARPET LOOSE, PILLAR TRIM WAS COMING OFF, TICKING NOISE WAS COMING FROM THE FRONT OF VEHICLE, THE EGR VALVE WS REPLACED, REAR TAIL LIGHT WAS OUT, THE BULB WAS REPLACED, DECK LID WIRE HARNESS, A NEW FUEL TANK WAS INSTALLED DUE TO THE ENGINE LIGHT ILLUMINATING, THE FRONT AND REAR BRAKES HAVE BEEN REPLACED DUE TO WARPAGE, ALSO THE SPEEDOMETER STOPPED WORKING.*JB
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Visibility, Structure, Seats, Equipment, Child seat, Feb 26, 2002
WHEN APPLYING BRAKE PEDAL IT WOULD GO TO THE FLOOR, ALSO BRAKES WILL GRIND. ROTORS HAD TO BE TURNED, AND BRAKES WERE REPLACED 7 TIMES, BUT THE PROBLEM REOCCURRED. *AK TRANSMISSION SLIPS AND JERKS AND RPMS JUMP. NO PROBLEM FOUND. CONSUMER HEARS LOOSE GRAVEL SOUND FROM RIGHT FRONT WHEEL AREA. DEALER FOUND WHEEL WELL LOOSE. DEALER FOUND SERPENTINE BELT FAILED CAUSING WHISTLE SQUEAL UNDER HOOD. GAS LIGHT ON WITH FULL TANK AND DOOR AJAR LIGHT IS ON. DEALER REPLACED BATTERY. EVAPORATIVE HOSE LOOSE. DEALER REMOVED AND INSTALLED FUEL TANK. CIGARETTE LIGHTER NOT WORKING. R-CUP HOLD BUBBLING. DRIVER SIDE MIRROR KNOB FALLS OFF. REAR CHILD SEAT LATCH COVER IN BROKE. FRONT DRIVER SEAT METAL FELL OUT. BOTH HEADLAMPS MOULDING FALL OUT. SUNVISOR MIRROR/BRACKET MOULDING ON PASSENGER SIDE BETWEEN DOOR / DASH LOOSE. BROKEN. RIGHT OUTER AC VENT BROKEN. LOOSE CARPET ON RIGHT FRONT FLOOR. PILLAR TRIM COMING OFF. DECK LID WIRE HARNESS HAD TP BE REPLACED. CLICKING NOISE FROM L/H FRONT OF VEHICLE. EGR VALVE REPLACED. LEFT REAR TAIL LAMP IS OUT. ENGINE LIGHT IS ON. PROBLEMS WITH REWIND BUTTON FOR AM/FM CASSETTE. *TT
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Other, Feb 26, 2002
BRAKES SQUEAK WHEN APPLIED. AFTER 4TH TRIP INTO DEALERSHIP, SERVICE ADVISOR SAID THIS IS A COMMON PROBLEM FOR THE FORD FOCUS BUT THAT FORD IS NOT DOING ANYTHING ABOUT IT. ENGINE HAS FAILED ON ME 4 TIMES IN THE 18MONTHS THAT I HAVE HAD IT. THE DEALERSHIP JUST REPLACED THE FUEL SENDING UNIT AND SAID THAT IT "SHOULD TAKE CARE OF THE PROBLEM." I DOUBT IT! IF THIS HAPPENS AGAIN, I WILL BE CHECKING WITH CALIFORNIA LEMON LAW. THIS WAS MY FIRST FORD AND DEFINITELY MY LAST!
Service brakes, Hydraulic, Fuel system, Other, Electrical system, Visibility, Latches/locks/linkages, Feb 25, 2002
CONSUMER STATED THE GAS GAUGE FAILED, THE BRAKES WERE SQUEAKING, THE MIRROR WAS TORN OFF BY REPEATED CAR WASHES, GAS LEAKED ON THE BOTH DRIVER AND PASSENGER SIDE CARPET, AND THE TRUCK LATCH WAS BROKE, ALSO THE FUES BURST ON LOCKS. *YH
Service brakes, Hydraulic, Feb 25, 2002
WHILE DRIVING WOULD STEP ON BRAKES PEDAL AND BRAKES WILL MAKE A LOUD NOISE. HAD TAKEN VEHICLE TO DEALER FOR REPAIRS. PLEASE PROVIDE MORE INFORMATION.*AK