2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: hydraulic
399 reports, newest first. Show all
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Visibility, Vehicle speed control, Equipment, Nov 17, 2003
HI, I OWN A 2000 FORD FOCUS AND IT HAS BEEN NOTHING BUT TROUBLE. I PURCHASED THE CAR BRAND NEW IN 2000 AND HAVE HAD IT IN THE SHOP SO MANY TIMES. I HAVE HAD MY REAR PASSENGER SIDE WINDOW MECHANISM REPLACED BY FORD, THEN PERSONALLY REPLACED THE DRIVER FRONT WINDOW MECHANISM AND THE DRIVER BACK MECHANISM DUE TO CABLE BREAKS. I HAVE HAD IT IN WITH THE RADIO 3 TIMES AND IT STILL DOES NOT WORK CORRECTLY. I HAVE HAD TO HAVE THE BRAKES REPLACED, THE IGNITION BLOCK REPLACED, THE STRUTS AND SHOCKS. THE TRUNK RELEASE HAS NEVER WORKED. NOW IT KEEPS BREAKING DOWN ON ME IF I DRIVE FOR MORE THAN 1 HOUR NON STOP. THIS WEEKEND I WENT TO SAN ANTONIO FROM CORPUS, IT DIED ON THE HIGHWAY 3 TIMES GOING TO SA AND COMING HOME 4 TIMES & HOW SAFE IS THAT! FORD SAID THEY CANNOT DO ANYTHING FOR ME UNLESS IT IS MESSING UP WHEN I BRING IT IN WHILE IT IS ACTING UP, HOWEVER IT ALWAYS HAPPENS WHEN I AM AWAY FROM TOWN. THEY TOLD ME THAT IF THEY HOOK IT UP TO THE MACHINE IT WILL NOT TELL THEM ANYTHING. ALSO, ON SEVERAL OCCASIONS MY ACCELERATOR HAS STUCK AND I CANNOT BRAKE, I HAVE TO PUT THE CAR IN NEUTRAL AND PRESS ON THE BRAKE HARD WHILE THE RPM'S ARE STILL REVVING AND PULL THE EMERGENCY BRAKE, THE FIRST TIME THIS HAPPENED I WAS PULLING INTO A PARKING SPOT AND WENT OVER THE YELLOW DIVIDER. IS THERE ANYTHING I CAN DO? *LA
Service brakes, Hydraulic, Nov 13, 2003
BRAKES/ROTORS/PAD HAVE WORN AND/OR MALFUNCTIONED MORE THAN THREE TIMES IN THE TWO YEARS I HAVE HAD THIS CAR. THE FIRST TIME WAS WITHIN TWO MONTHS OF OWNERSHIP, DEALER REPAIRED, BUT ONLY AFTER PRESSING THE POINT. HAD TO REPLACE THE ABOVE TWICE ALREADY. ONE TIME BRAKES FAILED AS MY WIFE DROVE MY CHILDREN AND NEARLY RESULTED IN A SERIOUS ACCIDENT. BRAKE PROBLEMS HAPPENING YET AGAIN. WHY IS THIS NOT A RECALLED ISSUE? I AM OUT HUNDREDS OF DOLLARS FOR THIS. *LA
Service brakes, Hydraulic, Electrical system, Tires, Nov 13, 2003
I HAVE REPLACED THE IGNITION SWITCH 3 TIMES IN LEAST THAT 2 YEARS AND TWICE IN THREE MONTHS. THE DEALERSHIP TELLS ME TO CALL FORD AND FORD TELLS ME IT A DEALERSHIP'S PROBLEM CALL THEM THE OLD RUN AROUND. I ALSO HAVE REPLACE ALL FOUR BRAKES AND TIRES WITH ONLY 25000 MILES ON THE CAR AND THEY STILL SQUEEZE AND GRIND WHEN APPLYING THE BRAKE. I BROUGHT THE CAR USED SO I DO NOT KNOW IF ANYTHING WAS REPLACE BEFORE I PURCHASED IT LOVELY VEHICLE. *LA
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Other, Electrical system, Structure, Tires, Nov 6, 2003
1ST RECALL,6/2000 SHOP FOR A/C PROBLEM,9/2000 SHOP FOR 7 DAYS FOR AC PROBLEM,1/2002 SHOP 7DAYS FOR ENGINE WORK,RECALLS X 4 OR 5 NOT SURE ABOUT DATES THERE HAS BEEN SO MANY ON THIS CAR,PROBLEMS WITH NOT STARTING ,GAS GAUGE, TIRE REPLACEMENT 3 SETS IN LESS THEN 3 YEARS, HESITATION,POOR GAS MILAGE,BRAKES SQUEALING, TRUNK DOES NOT CLOSE PROPERLY,10/2003 HAS BEEN IN SHOP FOR 3 WEEKS FOR POSSIBLE ENGINE WORK. DEALER CAN NOT SEEM TO FIND OR REPAIR THE PROBLEM, I AM NOT HAPPY WITH THIS CAR IT HAS HAD SERIOUS PROBLEMS FROM DAY ONE THERE ARE MORE TO MENTION CAN NOT LIST THEM ALL I NEED HELP. *AK
Service brakes, Hydraulic, Oct 29, 2003
HAVE HAD MY FRONT BRAKES REPLACED THREE TIMES. FIRST TIME AT 11,000 MILES, SECOND TIME (ROTORS REPLACED) AT 24,000 MILES AND THIRD TIME AT 36,000 MILES. BRAKES CONSISTENTLY SQUEAL, SO LOUDLY THAT I CAN HEAR THEM OVER MY RADIO! I'VE BEEN TOLD BY THE DEALERSHIP THAT FOCUS BRAKES TEND TO BE LOUD, BUT IT DOESN'T MEAN THEY DON'T WORK. DEALER ALSO SAID THEY RECEIVED NOTICE FROM FORD THAT FOCUS BRAKES JUST "SQUEAL". I DON'T BELIEVE THIS IS TRUE AND THAT THIS SHOULD NOT BE CONSIDERED "NORMAL WEAR AND TEAR".*AK
Suspension, Service brakes, Hydraulic, Oct 20, 2003
WE HAD TO PLACE THE 6TH SET OF TIRES ON OUR CAR. WE HAVEN'T HAD A SINGLE SET OF TIRES LAST LONGER THAN 20,000 MILES. WE HAVE OUR TIRES ROTATED AND BALANCED AND FRONT-END ALIGNED REGULARLY. WE HAVE REPLACED THE FRONT BRAKE PADS 5 TIMES. WE HAVE HAD ALL 5 RECALLS REPAIRED ON THE CAR. WHEN I HAD THE REAR BEARING REPLACED UNDER WARRANTY THE TECHNICIAN TOLD ME THAT THEY HAD TO ORDER EMERGENCY BEARINGS OVERNIGHT BECAUSE IT WAS NOT SAFE TO DRIVE. WHEN I INQUIRED ABOUT A RENTAL CAR, HE OFFERED TO REASSEMBLE MY CAR AND LET ME DRIVE IT HOME (EVEN THOUGH IT WAS UNSAFE)! THIS HAS ALWAYS BEEN A LOUD CAR, BUT A WEEK AGO THERE WAS A LOUD ROARING, GRINDING NOISE UP FRONT THAT GETS ESPECIALLY LOUD WHEN I TURN TO THE RIGHT. AFTER HAVING A TECHNICIAN LOOK AT IT, HE SAYS THE FRONT BEARINGS ARE GONE AND THE FRONT ROTORS AND BRAKE PADS ALSO NEED TO BE REPLACED AGAIN. I AM IN THE SAME SITUATION AS EVERYONE ELSE: BECAUSE THIS CAR HAS HAD SO MANY PROBLEMS AND COMPLAINTS IT IS ONLY VALUING AT $3000 AFTER 3 YEARS. FORD SHOULD BE FORCED TO DO SOMETHING TO SATISFY ALL OF THESE DISSATISFIED CUSTOMERS. *LA
Service brakes, Hydraulic, Engine and engine cooling, Oct 17, 2003
VEHICLE EXPERIENCED BRAKE PROBLEMS, IT MADE A LOUD NOISE WHILE DRIVING, AND OXYGEN SENSOR FAILED. ALSO, ENGINE PROBLEMS. OIL WAS LEAKING FROM THE OIL PAN UNDER THE MOTOR. OWNER WAS REFERRED TO THE STATE ATTORNEY GENERAL'S OFFICE TO SEEK PROTECTION UNDER THE LEMON LAW. *AK
Service brakes, Hydraulic, Power train, Sep 26, 2003
AUTOMATIC TRANSMISSION SLIPS GEARS WHILE DRIVING CAUSING THE VEHICLE TO JERK. ALSO, A SQUEAKING NOISE IS HEARD WHEN APPLYING PRESSURE TO THE BRAKE PEDAL. DEALER ATTEMPTED TO FIX THE TRANSMISSION AND THE BRAKES BUT HAS NOT REMEDIED THE PROBLEMS. *AK
Service brakes, Hydraulic, Sep 26, 2003
WHEN TRYING TO APPLY THE ANTI LOCK BRAKES. THE BRAKES WILL LOCK UP CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED. *AK
Service brakes, Hydraulic, Sep 9, 2003
CONSUMER WAS HAVING PROBLEMS WITH ROTORS RUSTING. DEALER WAS CONTACTED, AND STATED THAT ROTORS NEEDED TO BE REPLACED, BUT DID NOT EXPLAIN AS WHY THIS HAPPENED. *AK
Service brakes, Hydraulic, Sep 4, 2003
2000 FORD FOCUS BOUGHT NEW HAVE HAD BRAKE PROBLUMS SINCE DAY ONE, FRONT BRAKES WEAR OUT PREMATURLY ONCE AT 24000 MILES NOW AT 48000 MILES AND NOW EVEN THE FRONT ROTORS ARE WORN OUT, IT HAS BEEN THE INBOARD PADS THAT GO BAD. ALSO THE REAR BRAKES SQUEAL VERY BADLY AND HAVE SINCE NEW REAR BRAKES HAVE BEEN REPLACED THREE TIMES WITH NO CURE, MY FORD DEALER HAS TOLD ME ALL CARS DO THIS AND NOTHING CAN BE DONE TO SOLVE THE PROBLEM, I HAVE SINCE ASKED OTHER FOCUS DRIVES ABOUT THIS PROBLEM AND MOST SAY THET DON'T HAVE A BRAKE PROBLEM AND HAVE HEARD NO OTHE CAR OF ANY KIND SQUEELING AS MINE DOES IT'S EMBARESSING TO DRIVE AND EVERY ONE LOOKS AT US WHEN EVER WE APPLY THE BRAKES IT'S VERY BAD, THE CAR IS NOW OUT OF WARRENTY BUT FORD WILL NOT ADMIT TO HAVEING A PROBLEM AND HAS DONE NOTHING TO SOLVE THE PROBLEM, I FEEL THAT IT SHOULD BE TAKEN CARE OF REGUARDLESS BECAUSE THEY DO HAVE A PROBLEM, I FEEL IT IS BAD ROTORS-STICKING CALIPERS ON THE FRONT AND POSSIBLY A BAD PROPORSHING VALVE AS FOR THE REAR, THE VALVE COULD BE ALSO THE PROBLEM ALONG WITH THE SHOES ALSO, SOMETHING NEEDS DONE I AM AFRAID TO DRIVE IT AT TIMES NOT KNOWING WHAT WILL GO WRONG WITH THE BRAKES NEXT OR WHEN, BUT THIS SQUEEL HAS GOT TO STOP!!!*AK
Suspension, Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Sep 4, 2003, crash
HAS BEEN TO SHOP FOR 26 DAYS IN THE PAST 4 MONTHS. REPEATED FAILURE OF CLUTCH (MANUAL TRANSMISSION), FAILURE OF BRAKE PADS, RESULTING IN MINOR CRASH. HAVE HAD TO HAD BALL JOINTS REPLACED. CRUISE CONTROL WAS DISCONNECTED FROM ACCERATOR/BRAKE. KEY WOULD NOT GO INTO IGNITION AND RESULTED IN KEY IGNITION SWITCH HAVING TO BE REPLACED. NUMEROUS RECALLS AND TRIPS TO SHOP SINCE BOUGHT BRAND NEW IN AUGUST 2003*AK
Service brakes, Hydraulic, Aug 29, 2003
BRAKE PADS AND ROTORS REPLACED AT 27,000 MILES ON MY 2000 FOCUS. THE FORD DEALERSHIP I TAKE MY CAR TO FOR SERVICE SAID THAT REPLACING THE ROTORS ON THIS CAR IS 'NORMAL'. THEY SAID THAT THE ROTORS ARE SOFT AND TEND TO WEAR-OUT FAST AND THAT IS WAS NOT COVERED UNDER THE WARRANTY. THEY SAID THE FORD ESCAPE HAD THIS ISSUE ALSO. I TOOK MY CAR TO LES SCHWAB FOR THE REPAIR BECAUSE THEY PROVIDE A 2 YEAR 36,000 MILE WARRANTY ON THE BRAKES.*AK
Service brakes, Hydraulic, Aug 27, 2003
BRAKES SQUEAK, EXCESSIVE BREAK DUST ON THE FRONT WHEELS.*PH THE CONSUMER WAS INFORMED BY THE DEALER, THAT THE BRAKE DUST WAS NORMAL. THE REAR SHOES PAD ASSEMBLIES AND ROTORS WERE REPLACED AT LEAST FOUR TIMES. THE LAST TIME THE DEALER TOLD THE CONSUMER THE LEFT RIGHT EBRAKE CABLE SPRING RETAINER HAD POPPED OUT THE BACKING PLATE WHICH CAUSED THE SHOES TO NOT RETRACT ALL THE WAY. THE DEALER PUT THE RETAINER BACK AND RESET THE HEBRAIC. ALSO THE REAR WHEEL CYLINDERS WAS LEAKING AND HAD TO BE REPLACED. *JB
Service brakes, Hydraulic, Equipment, Aug 24, 2003
I OWN A 2000 FORD FOCUS. CURRENTLY I AM EXPERIENCING SEVERAL PROBLEMS. THE FIRST IS THE AIR CONDITIONING A/C. THE A/C WORKS ON THE #4 SETTING BUT DOESN'T WORK ON #1, #2, OR #3. NO AIR COMES FROM THE AIR VENTS WHEN THE FAN IS SET TO 1, 2, OR 3 WHETHER THE A/C IS ON OR NOT. THE SECOND PROBLEM IS THE BRAKES. I HAVE LESS THAN 46,000 MILES ON THE CAR, AND THE BRAKES FEEL LIKE THEY ARE GOING OUT. I'VE NEVER HAD TO REPLACE THE BRAKES ON A CAR BEFORE 70,000 MILES. THE THIRD PROBLEM IS COMPRISED OF THE GAUGES. WHEN I START MY CAR, ALL THE GAUGES GO IMMEDIATELY TO THE RIGHT. AFTER A FEW MOMENTS THEY RETURN TO THEIR PROPER POSITION, BUT I'M NOT SURE WHAT IS GOING ON. I FEEL THAT IF I PUT THE CAR IN GEAR DURING THIS PERIOD, THAT I WILL LOSE CONTROL OF THE VEHICLE AND IT MAY SURGE FORWARD. THE FOURTH PROBLEM IS THAT I HAVE ALREADY HAD TO REPLACE ALL OF THE TIRES ON THIS VEHICLE. THE FIFTH PROBLEM IS THE TRANSMISSION/ENGINE. MANY TIMES, ESPECIALLY IN THE IDLE POSITION (AT A STOP SIGN, ETC.), I FEEL THAT THE ENGINE IS GOING TO STALL. IT ALMOST FEELS LIKE THE ENGINE IS NOT RUNNING ON ALL CYLINDERS. THE SIXTH PROBLEM, AND PROBABLY NOT THE LAST, IS THAT I'VE ALREADY HAD TO DEAL WITH ALL OF THE RECALLS ON THIS VEHICLE, AND YET THIS CAR IS STILL UNSAFE AND FORD HAS DONE NOTHING TO CORRECT THIS EXCEPT OFFER A 5 YEAR/100,000 MILE WARRANTY TO NEW FORD FOCUS BUYERS.*AK
Service brakes, Hydraulic, Aug 6, 2003
WHILE APPLYING THE BRAKES VEHICLE HAD A GRINDING NOISE COMING FROM THE FRONT OF VEHICLE . *AK
Service brakes, Hydraulic, Fuel system, Gasoline, Power train, Aug 4, 2003
I HAVE A 2000 FORD FOCUS ZX3. EVER SINCE I BOUGHT THE CAR, I HAVE HAD PROBLEMS. THE DAY I BOUGHT IT, I NOTICED TRANSMISSION PROBLEMS, TWO MONTHS AFTER THAT, I HAD BRAKE PROBLEMS. SINCE I HAVE HAD THE CAR I HAVE GOTTEN MY BRAKES DONE TWICE. I HAVE HAD THE CAR ABOUT 15 MONTHS NOW. I ALSO HAD MY IGNITION CYLINDER REPLACED, A FUEL FILTER REPLACED, AND NOW MY CAR DIES WHEN I SLOW DOWN. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS CAR. *AK
Steering, Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Equipment, Jul 31, 2003
CONSTANT SQUEAKING NOISE WHEN THE BRAKES ARE APPLIED. I'VE ALREADY REPLACED THE ROTORS, BRAKES, BRAKE PADS, AND DRUMS ON SEVERAL OCCASIONS SINCE BUYING THIS FOCUS ABOUT 3 YEARS AGO. ALSO MY STEERING WHEEL LOCKED ON ME ONE DAY IN APRIL OF 2002 THE KEY WOULD NOT FIT INTO THE IGNITION TO START THE CAR I HAVE NO IDEA WHY THIS WOULD HAPPEN FROM ONE DAY TO ANOTHER. I HAD MY VEHICLE TOWED TO THE FORD DEALERSHIP AND THEY DIDN'T KNOW WHAT THE PROBLEM WAS CAUSED BY. THEY SAID THAT THEY NEEDED TO UPDATE THE LOCK CYLINDER. LUCKILY I PURCHASED THE API EXTENDED WARRANTY THAT COVER THE CAR FOR 100,000 MILES. SO THE COST OF THE WORK DONE FOR THIS WAS $427.20. ALL BUT $50.00 OF WHICH WAS MY DEDUCTIBLE WAS COVER BY THIS WARRANTY. THE PROBLEMS DIDN'T STOP HERE. I ALSO HAVE HAD TO GET THE CD SYSTEMS THAT CAME INSTALLED IN THE CAR REPLACED. THE WAS A CONSTANT CLICKING NOISE WITH THE CD PLAYER AND 90% OF THE TIME THE CD'S WOULDN'T EVEN PLAY. I CALLED THE DEALERSHIP AND THEY SAID THAT THEY COULD REPLACE IT FOR ME BUT THAT IT WOULDN'T BE COVERER BY THE WARRANTY SO I WOULD HAVE TO PAY FOR IT OUT OF MY POCKET. I ENDED UP HAVING A NEW SYSTEM INSTALLED BUT NOT FROM THE FORD DEALERSHIP, I TOOK IT TO CIRCUIT CITY. RECENTLY THIS MONTH JULY 2003, MY CAR HAS BEEN STALING AND SHUTTING OFF AT STOP SIGNALS AND STOP LIGHT ALSO JUST SHUT COMPLETELY OFF ON THE FREEWAY THANK GOD NO ACCIDENT OCCURRED. I CALLED THE DEALERSHIP TO REPORT THIS PROBLEM ALSO MY CHECK ENGINE LIGHT WOULD COME ON AND OFF SEVERAL TIMES AND THEY SAID TO BRING IT IN AND THEY WOULD CHECK THE ENGINE LIGHT BUT THAT I WOULD HAVE TO PAY $165. 00 JUST FOR THEM TO CHECK THE LIGHT AND IT WOULD BE MORE $$$ TO REPAIR WHAT EVER PROBLEM IT WAS. I WAS FED UP BY THEN. *PH
Service brakes, Hydraulic, Jul 30, 2003
VEHICLE BRAKING SYSTEM FAILURE IS WEARING EXCESSIVELY, APPROXIMATELY EVERY 13000 MILES.
Service brakes, Hydraulic, Jul 14, 2003
CONSUMER STATES THAT THERE IS A THUMPING NOISE WHILE DRIVING, CAUSE UNKNOWN. TOOK VEHICLE TO DEALER, AND THE DEALER STATED ROTORS NEED REPLACING. *AK
Suspension, Service brakes, Hydraulic, Electrical system, Jul 11, 2003
THE IGNITION HOUSING LOCKED UP AND AS A RESULT THE VEHICLE COULD NOT BE MOVED. THE FRONT AXLES ON THE RIGHT SIDE FELL OFF. THE DEALER REFUSED TO REPAIR THEM. THE FRONT BRAKE CALIPERS FELL OFF. THE REAR END SLID WHILE DRIVING ON A WET SURFACE. *MR CB *NLM
Service brakes, Hydraulic, Jul 11, 2003
THE ROTORS AND BRAKES HAVE HAD TO BE REPLACED BEFORE 35,000. THIS CAR IS NOT SAFE. WE TOOK THE CAR IN BECAUSE IT WAS MAKING NOISE FOR BRAKE PADS. THE CALLED AND TOLD USE THE ROTORS WERE DAMAGED. THIS IS TOOK SOON TO HAVE THIS PART REPLACED. *AK
Service brakes, Hydraulic, Jul 10, 2003
CONSUMER STATES BRAKES WEAR PREMATURLEY WEARING OUT WHICH PRODUCES A GRINDING NOIUSE. DEALER STATES THIS IS NORMAL FOR THE BRAKES.*AK
Service brakes, Hydraulic, Jul 9, 2003
CONSUMER STATES THAT REAR BRAKES HAVE NOT FUNCTIONED SINCE VEHICLE WAS PURCHASED. FRONT BRAKES HAVE BEEN STOPPING VEHICLE.*AK
Service brakes, Hydraulic, Jul 9, 2003
CONSUMER STATES HAS HAD TO REPLACE BRAKE PADS 13 TIMES SINCE VEHICLE PURCHASE. PADS WERE WEARING EXCESSIVELY EVERY 2000-3000 KILOMETERS.*AK