2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: hydraulic
399 reports, newest first. Show all
Service brakes, Hydraulic, Mar 7, 2003
WHEN THE BRAKE WAS APPLIED, THERE WAS A LOUD NOISE, AND AFTER THE VEHICLE STOPPED SEVERAL TIMES, A HOT METAL SMELL APPEARED. *JB THE DEALER STATED THAT THE VEHICLE WASN'T DRIVABLE, DUE TO A POTENTIAL FIRE HAZARD, AND DIAGNOSED THE PROBLEM AS STUCK CALIPERS. THE BRAKE PADS AND THE CALIPERS WERE REPLACED, AND THE ROTORS WERE RESURFACED. (THE HUBCAP HAD BEEN SLIGHTLY MELTED AWAY FROM THE CALIPER) SCC
Service brakes, Hydraulic, Mar 6, 2003
I HAVE HAD NUMEROUS PROBLEMS W/ MY 2000 FORD FOCUS. THE MOST SEVERE IS THE BRAKES SQUEALING AND WEARING OUT PREMATURELY. THEY HAD TO BE REPLACED IN THE FIRST YEAR AND A HALF OF OWNERSHIP AND NEVER STOPPED MAKING NOISE. ON A SEPARATE OCCASION THE REAR WHEEL BEARINGS LEAKED FLUID ALL OVER THE BRAKE PADS WHICH COULD HAVE RESULTED IN A DEADLY ACCIDENT. I HAVE BEEN GIVEN A COPY OF A LETTER FROM FORD MOTOR CO. FROM A FORD DEALERSHIP SAYING THE BRAKE NOISE IS NORMAL AND CAN NOT BE FIXED AND IS NOT INDICATIVE OF A PROBLEM WITH THE BRAKES. PLEASE DO SOMETHING TO FIX THESE CARS, THEY ARE NOT SAFE! *JB
Suspension, Service brakes, Hydraulic, Mar 5, 2003
PROBLEMS WITH BRAKE EQUIPMENT. THE VEHICLE HAS BEEN TO THE DEALER AT LEAST 4 TIMES FOR A CRUNCHING SOUND WHEN DRIVING OVER BUMPS.. THE BRAKES SQUEALED WHEN THEY WERE APPLIED, THE CONSUMER WAS TOLD THEY WERE FIXED, HOWEVER THE PROBLEM RESURFACED. *JB
Service brakes, Hydraulic, Mar 5, 2003
THERE WAS A NOISE COMING FROM THE REAR BRAKES.*JB
Service brakes, Hydraulic, Power train, Electrical system, Seat belts, Latches/locks/linkages, Wheels, Mar 5, 2003
I SENT THIS LETTER TO FORD IN MAY OF 2000 I PURCHASED A FORD FOCUS, THINKING IT WOULD BE A SAFE, LOW MAINTENANCE CAR, CONSIDERING IT HAD BEEN IN EUROPE SINCE 1997. I WOULD THINK THIS WOULD BE PLENTY OF TIME TO WORK OUT ANY BUGS YOU MAY HAVE. OR, SHOULD I CALL THEM RECALLS. I THINK A CAR THAT HAS 16 RECALLS, MOST OF THEM WHICH I WOULD CONSIDER SAFETY ISSUES, SHOULD BE RECALLED ENTIRELY. I HAVE HAD OTHER ISSUES WITH THIS CAR AS WELL. MY KEY WOULD NOT TURN, SEAT BELTS LOCKING FOR NO REASON, DOOR HANDLES NOT OPENING THE DOOR (THIS IS ALL HAPPENING AGAIN). AND ONE THAT HAS NOT BEEN ADDRESSED, BRAKES. I AM NOW ON MY THIRD SET OF FRONT ROTORS SINCE I HAVE PURCHASED THE CAR. THE SAME THING HAS HAPPENED EVERY TIME. THE DRIVER SIDE ROTOR AND PAD WILL WEAR COMPLETELY DOWN YET THE PASSENGER SIDE WILL BE JUST FINE. I HAVE TALKED TO OTHER FOCUS OWNERS AND THE SAME THING IS HAPPENING. I STILL HAVE MY LAST SET OF ROTORS JUST TO PROVE IT. I GOT SMART THIS TIME AND BOUGHT REPLACEMENTS THAT WERE NOT MADE BY YOU. STOP TECH CROSS DRILLED ROTORS AND EBC GREENSTUFF KEVLAR PADS. I ALSO REPLACED THE DRIVER SIDE CALIPER WITH A NON-FORD REPLACEMENT. I WANT OUT OF THIS CAR BECAUSE I FEEL IT IS UNSAFE. I ALSO WOULD LIKE TO WARN OTHER FOCUS OWNERS THAT THIS CAR IS UNSAFE. YOU ALSO HAD BETTER NOT SEND ME TO THE DEALERSHIP AGAIN. WHAT DOES THE DEALERSHIP HAVE TO DO WITH THE PRODUCTION OF AN UNSAFE CAR? NOTHING, EXCEPT THAT THEY SELL IT. I AM NOT PUTTING UP WITH FORD PUSHING ME AROUND OR GIVING ME THE RUN AROUND EITHER. THIS CAR IS EXTREMELY UNSAFE AND SHOULD NOT BE ON THE ROAD. I DID NOT DO THIS BEFORE BUT THIS TIME YOU LEAVE ME NO CHOICE. THIS LETTER WILL BE SENT TO AS MANY BAD PRODUCT WEBSITES AS I CAN FIND. IT WILL ALSO BE SENT TO NHTSA, CONSUMER REPORTS AND THE BETTER BUSINESS BUREAU. YOU DID NOT DO ANYTHING WITH MY PREVIOUS COMPLAINT AND NOW THERE ARE MORE ISSUES WITH THIS PRODUCT THAT NOT ONLY CONCERN SAFETY, BUT THE LIFE OF THE CAR. SOMETHING WILL BE DONE.*JB
Service brakes, Hydraulic, Mar 3, 2003
THE FRONT ROTORS WERE WORN, WHICH CAUSED EXTENDED STOPPING DISTANCE.*JB
Service brakes, Hydraulic, Feb 28, 2003
THE FRONT BRAKE ROTORS WERE WORN, WHICH CAUSED EXTENDED STOPPING DISTANCE.*JB
Service brakes, Hydraulic, Feb 26, 2003
WHEN THE BRAKES WERE APPLIED, THEY LOCKED UP WHICH CAUSED EXTENDED STOPPING DISTANCE.*JB
Service brakes, Hydraulic, Feb 20, 2003
THE ROTORS WERE REPLACED ON 3 OCCASIONS.*JB
Service brakes, Hydraulic, Feb 19, 2003
FORD FOCUS BRAKE PADS AND ROTOR PROBLEMS SINCE 11,500 MILES ON VEHICLE, INSPECTED AND TOLD NOTHING WRONG, NORMAL SQUEEKING AND GRINDING. MY DAUGHTER FEELS THAT WHILE DRIVING THE CAR THE BRAKES ARE GRINDING AND GIVING UNDER HER. WE TAKE IT IN FOR THE 15K SERVICE AND THEY TELL US THE BRAKES ARE FINE AT 15,600 MILES INSPECTED AND TOLD NOTHING WRONG, NORMAL WITH CHANGE OF WEATHER. YESTERDAY MY DAUGHTER SAID THE BRAKES WERE NOT HOLDING AND WE TOOK THE CAR IN FOR A WHEEL BEARING RECALL FOR THE REAR BRAKE SYSTEM AND AT 18,000 MILES, DEALERSHIP SAYS BRAKE PADS AND ROTORS ARE COMPLETELY GONE! I HAVE TALKED TO THE DEALER AND FORD WHO SAY THEY WILL "COVER" THIS $400 REPAIR. MY COMPLAINT IS THAT THIS SHOULD HAVE NEVER OCCURRED AND COULD HAVE COST MY DAUGHTER, MY SON WHO RIDES IN THE CAR OR ME OUR LIVES. I FEEL THEY ARE VERY AWARE OF THIS PROBLEM AND CHOSE TO OVERLOOK THEIR RESPONSIBILITY THAT COULD HAVE COST MY FAMILY OUR LIVES. SOMEONE NEEDS TO MAKE THEM ACCOUNTABLE INCLUDING THE DEALERSHIP WHO "INSPECTED" THE BRAKES AND CHOSE TO LIE TO US ON 2 OTHER OCCASSIONS. IF FORD HAS A PROBLEM THEN THE DEALERSHIPS ARE ONLY COMPOUNDING THE PROBLEM WITH THE POSSIBLITY OF LOSS OF LIFE.
Service brakes, Hydraulic, Feb 15, 2003
FRONT BRAKES GRINDING. AFTER TAKING FOR A BRAKE INSPECTION WAS TOLD THE CAR NEEDS FRONT ROTORS AND PADS AND NEW CYLINDERS ON THE BACK AS IT IS LEAKING BRAKE FLUID. PH
Service brakes, Hydraulic, Feb 10, 2003
THE BRAKES SCREECHED VERY LOUD WHEN APPLIED, PADS WERE REPLACED AT 12000 MILES, HOWEVER PROBLEM STILL EXISTED. BRAKE EFFECTIVENESS WAS NOT REDUCED. DEALER ADVISED THE SCREECHING NOISE WAS NORMAL DUE TO BRAKE PADS BEING SEMI-METALLIC.*JB
Service brakes, Hydraulic, Equipment, Feb 4, 2003, crash
I HAVE A 2000 FORD FOCUS THAT I HAVE HAD ALLOT OF PROBLEMS WITH. I SPECIALLY ORDERED THIS CAR TO HAVE ALL THE SAFETY FEATURES INCLUDING SIDE IMPACT AIR BAGS, AND ANTI LOC BRAKES. WE ORIGINALLY HAD BOUGHT THE CAR IN CA. THE FIRST PROBLEM HAPPENED AT 3000 MILES THE REAR BRAKES STARTED SQUEALING, AND THE SEAT BELT BUZZER WONT GO OFF. WE TOOK IT TO FORD WERE THEY SAID NOTHING WAS WRONG. WE MOVED TO NC WERE WE NOW LIVE. TOOK IT BACK TO FORD WITH THE SAME COMPLAINT THIS NOW 30,000 MILES. THEY SAID THEY WERE DEFECTIVE, THEY HAD THE CAR OVER NIGHT FOR THE SEAT BELT BUZZER, STILL NO PROBLEM FOUND. SO THEY REPLACED THE BRAKES. WHEN WE PICKED UP THE CAR THE SEAT BELT BUZZER DID THE JOB OF STAYING ON FOR US. IT STOPPED THE SQUEAL PROBLEM WITH THE BRAKES. 1 1/2 WEEKS LATER WE HAD AN ACCIDENT. WHITCH I MIGHT ADD THE AIR BAGS DID NOT GO OFF. ALSO IN THE ACCIDENT THE REAR SEAT CAME UNHINGED AND THREW A PLASTIC PIECE THAT HOLDS THE SEATBELT AT THE BACK OF HER HEAD CAUSING A LUMP. MY WIFE SAID THE BRAKES JUST DIDN'T WORK AS THEY DID PREVIOUSLY WITH THE NOISE. I TOOK IT OUT FOR A TEST DRIVE FOUND THE BRAKES WERE NOT ACTING RIGHT, THE CAR WOULD NOT STOP PROPERLY. TOOK IT BACK TO FORD, THEY TOLD US THAT EVERYTHING WAS FINE. A FRIEND OF OURS WAS A FORD MECHANIC AT A DIFFERENT DEALERSHIP WAS GOING TO LOOK AT IT FOR US, HE WAS KILLED THAT WEEK IN A CAR ACCIDENT UN-RELATED. SO WE LOST OUR INSIDE MECHANIC TO TELL US WHAT WAS REALLY HAPPENING. NOW AT 50,000 MILES THE NOISE IS BACK, MY WIFE WHO DRIVES THE VEHICLE SAYS EVERY ONCE IN A WHILE THE BRAKES WILL ACT UP AGAIN. NOW WE JUST DON'T HAVE THE TIME NOR THE PATIENTS TO DEAL WITH THE DEALERSHIPS ONCE AGAIN FOR NOW THE FAN BLOWER ONLY WORKS ON 3 ON THE DIAL AND THE CABLE BROKE TO SELECT DEF, VENTS, ECT. ALONG WITH THE RECALL OF THE WIPER MOTOR, AND THE NEEEDING OF NEW ROTERS ON THE FRONT. THIS CAR TO ME IS A LEMON.
Service brakes, Hydraulic, Electrical system, Structure, Tires, Feb 3, 2003
THE KEY WOULD NOT TURN ONCE IN THE IGNITION AND WAS DIFFICULT TO REMOVE, THE DEALER REPLACED THE IGNITION TUMBLER. THE CONSUMER HAS ALSO REPLACED THE BRAKES, TIRES AND RADIATOR DEFLECTOR. *NLM
Service brakes, Hydraulic, Jan 28, 2003
FUMES IN PASSENGER COMPARTMENT WHENEVER HEAT OR AIR CONDITIONING ON. DEALER CLAIMS SMELLS NOTHING AND ALSO ROTORS ON BRAKE DRUMS ARE MINIMUM REQUIRED BY LAW WITHOUT HAVING TO BE REPLACED EVEN THOUGH THEY HAVE NEVER BEEN MACHINED OR SCARRED. DEALERSHIP SAYS THEY ARE AWARE OF PROBLEM BUT FORD HAS DONE NOTHING ABOUT IT AND ROTORS AREN'T UNDER WARRANTY EVEN THOUGH THEY ARE DEFECTIVE
Service brakes, Hydraulic, Jan 14, 2003
CONSUMER STATED VEHICLE HAS BEEN SERVICE FIVE TIMES IN THE PAST TWO YEARS FOR POOR BRAKE WARE UNDER TEN THOUSAND MILES DEALER REPLACE BRAKES PROBLEM RETURNS. PLEASE PROVIDE FURTHER INFORMATION. TS
Service brakes, Hydraulic, Engine and engine cooling, Power train, Electrical system, Vehicle speed control, Jan 8, 2003
CONSUMER HAS EXPERIENCED MANY PROBLEMS WITH THIS VEHICLE. THERE IS OCCASIONAL GRINDING NOISES WHEN BRAKING SUDDENLY, THE BRAKE PEDALS SQUEAK, THE TRANSMISSION JUMPS OUT OF GEAR, THERE ARE PROBLEMS WHEN ACCELERATING, THE VEHICLE STALLS WHEN DRIVING ABOVE 55 MPH, THE CRUISE CONTROL IS INOPERATIVE, AND VARIOUS ELECTRICAL PROBLEMS. *JG *JB
Steering, Suspension, Service brakes, Hydraulic, Fuel system, Gasoline, Electrical system, Latches/locks/linkages, Vehicle speed control, Tires, Jan 6, 2003, crash
CONSUMER WAS EXITING A PARKING GARAGE AND PLACED VEHICLE IN REVERSE. WITHOUT WARNING, CAR SUDDENLY ACCELERATED AND REAR TAIL SPUN AROUND 2 TIMES THEN HIT A PARKED VEHICLE. CONSUMER DID APPLY BRAKES WITH NO SUCCESS. PH INSURANCE COMPANY INFORMED DEALERSHIP THAT THERE WERE TWO RECALLS THAT DEALT WITH A DEFECTIVE THROTTLE AND SPEED CONTROL WHICH WAS NOT PERFORMED ON THE VEHICLE PRIOR TO THE ACCIDENT. OTHER PROBLEMS INCLUDED WEEZING NOISE WHILE TURNING. POWER STEERING RACKED FAILED AND REPLACED. LACK OF POWER STEERING IN STEERING WHEEL. REAR BRAKE PAD REPLACEMENT. REAR WHEEL BEARING NOISE. DEFECTIVE WHEEL BEARINGS REPLACED. TIRE PUNCTURED AND REPLACED. HESITATION ON ACCELERATION. FUEL PUMP AND GASKET REPLACED. TIRES ROTTED OUT. KEY STUCK IN IGNITION. REPLACED MALFUNCTIONED SHIFTER ASSEMBLY. TRUNK LID WOULDN'T LATCH. LATCH REPLACED. *TT
Service brakes, Hydraulic, Power train, Dec 26, 2002
BOTH FRONT ROTORS WERE CUPPED AND TAPERED, THE DEALER SUGGESTED THAT THE BRAKE PADS WERE TOO HARD FOR THE ROTORS WHICH CAUSED UNUSUAL WEAR. IN LESS THAN 3 YEARS, 27,736 MILES THE TRANSMISSION HAS SLIPPED 6-8 TIMES, THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM ON TWO DIFFERENT OCCASIONS. NLM
Service brakes, Hydraulic, Dec 23, 2002
CONSUMER STATES THAT REAR BRAKE CYLINDER IS LEAKING FLUID. THE BRAKE PADS HAVE LARGE METAL DEPOSITS IN THEM AND THE FRONT ROTORS ARE WORN EXCESSIVELY AND NOT ABLE TO BE TURNED BECAUSE THE ARE UNDER SPECIFICATIONS. TS
Service brakes, Hydraulic, Electrical system, Dec 20, 2002
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE ELECTRICAL SYSTEM ON THE VEHICLE. ALSO STATED THAT THE POWER WINDOWS DOES NOT WORK ALSO THE POWER LOCKS ON THE VEHICLE DO NOT WORK. DEALER WAS CONTACTED AND VEHICLE WAS TAKEN TO THE SHOP ON THREE DIFFERENT TIMES AND IT WAS FINELY FIXED BUT CONSUMER STILL THINKS THAT THE VEHICLE STILL HAS DIFFERENT ISSUES. TS THE BRAKES SQUEALED, AND THE VEHICLE WOULD SHUT OFF WHEN THE BRAKES WERE APPLIED HARD, AND THE VEHICLE WOULD HAVE TO BE PLACED IN PARK IN ORDER TO RESTART. A FUSE WAS REPLACED AND HAD BLOWN AGAIN, THERE WAS A SHORT GROUND IN THE WIRE ON THE REAR PASSENGER DOOR SHORTING TO THE GROUND, RECALL 00S50/DECK LID WIRE HARNESS, AND TWO DOOR LOCK ACTUATORS WERE REPLACED. SCC
Service brakes, Hydraulic, Nov 29, 2002
CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THEY CAN HEAR A LOUD NOISE AND THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER HAS REPAIR VEHICLE ON SEVERAL OCCASIONS. DEALER NOTIFIED. PH
Service brakes, Hydraulic, Nov 26, 2002
THE BRAKE LUG BOLTS ARE UNDER SIZED, CONSUMER STATES' THE WHEEL MAY FALL OFF. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
Service brakes, Hydraulic, Nov 25, 2002
WHEN APPLYING THE BRAKES, CONSUMER STATES' THERE A WIERD NOISE. TOOK TO FORD, AND FORD SAYS ITS NORMAL. CONSUMER NOTICED BLACK DUST COLLECTING ON PADS. TOOK TO DEALER AND THEY REPLACED ROTORS, PADS, AND BRAKES. NEXT CONSUMER STATES' WHILE APPLYING THE BRAKES PEDAL WENT TO THE FLOOR. CONSUMER WAS ABLE TO COME TO A SAFE STOP. CONSUMER STATES FORD IS NOT CORRECTING THE PROBLEM. PLEASE DESCRIBE FURTHER. TS
Service brakes, Hydraulic, Nov 21, 2002
WHEN APPLYING THE BRAKES, CONSUMER STATES' THE BRAKES MAKE A GRINGING NOISE AND A SQUEAKING NOISE, LIKE THE BRAKE PADS ARE RUBBING ON WHEELS. THE VEHICLES BRAKES HAVE BEEN CHANGED THREE TIMES AND THE NOISE KEEP RETURNING. CAUSE IS UNKNOWN. PLEASE DESCRIBE FURTHER. TS