2000 Ford Focus
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 3,738 owner complaints filed for this model year. This is the 2nd highest complaint count among 19 Focus model years with reports.
Of the 2000 reports, 252 involved a crash and 127 involved a fire. 158 people were injured and 9 people died.
What owners report most often
Recalls and investigations
EquipmentFeb 24, 2012
RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.
IF THE ASSEMBLY SEPARATES DURING INSTALLATION, IT COULD RESULT IN INJURY TO THE INSTALLER. IF THE ASSEMBLY SEPARATES WHILE THE VEHICLE IS IN MOTION, IT COULD RESULT IN SECONDARY DAMAGE TO THE VEHICLE AND POSSIBLY RESULT IN A VEHICLE CRASH.
RIDE CONTROL WILL NOTIFY OWNERS AND WILL SET UP PROCEDURES TO INSPECT, REPAIR, AND/OR REPLACE THE AFFECTED PARTS WITHOUT CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON MARCH 30, 2012. OWNERS MAY CONTACT RIDE CONTROL AT 1-800-999-3903.
Campaign 12E007000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Latches/locks/linkages, doors, latchFeb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 05V030000 on NHTSA.gov
Fuel system, gasolineNov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V482000 on NHTSA.gov
Steering, linkagesNov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V289000 on NHTSA.gov
Electrical system, 12v/24v/48v battery, cablesNov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 02V288000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsNov 29, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.
THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE.
DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.
Campaign 01I017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seats, front assembly, reclinerDec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Campaign 00V418000 on NHTSA.gov
Electrical system, wiringDec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Campaign 00V411000 on NHTSA.gov
Wheels, lugs/nuts/bolts/studsOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V303000 on NHTSA.gov
Vehicle speed control, cablesOct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V302000 on NHTSA.gov
Structure, frame and membersAug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Campaign 00V218000 on NHTSA.gov
Vehicle speed controlDec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Campaign 99V346000 on NHTSA.gov
Representative owner complaints: service brakes
414 reports, newest first. Show all
Service brakes, Hydraulic, Power train, Electrical system, Latches/locks/linkages, Tires, Equipment, Jun 19, 2001
7 NEW STEREOS, 2 IGNITION CYLINDERS, A FEW TRUNK LATCHES, TRANSMISSION TROUBLE(DEALER CANNOT DUPLICATE), 20,000 MILES I HAVE TO REPLACE 4 TIRES AND 4 BRAKE PADS, HORRIBLE GRINDING NOISE WHEN STOPPING, SHAKES ON THE FREEWAY WHEN BRAKING, MISASSEMBLED INTERIOR RAILS, AND MANY OTHERS. I AM COMPLETELY DISSATISFIED WITH THIS VEHICLE, I WILL NEVER, EVER BUY ANOTHER FORD VEHICLE AND I WILL CERTAINLY NEVER RECCOMEND A FORD TO ANYONE.
Service brakes, Hydraulic, Jun 14, 2001
CONSUMER TRAVELED ON HIGHWAY ALOT AND VEHICLE STARTED MAKING GRINDING NOISE. BRAKE ROTORS AND DRUMS ON THE LEFT WERE CRUMBLING. MANUFACTURER'S RECALLS 00S20 AND 00S31 DID NOT AFFECT CONSUMER'S VEHICLE DUE TO VIN. *AK
Service brakes, Hydraulic, May 31, 2001
WHEN BRAKES WERE APPLIED UNDER NORMAL CONDITIONS, BRAKE PEDAL WAS NORMAL AND BRAKES DID NOT CATCH, RESULTING IN EXTENDED STOPPING DISTANCE. DEALER HAS INSPECTED AND REPAIRED VEHICLE; BUT, BRAKES GRIND WHEN APPLIED. *AK
Service brakes, Hydraulic, May 30, 2001
WHILE DRIVING WOULD STEP ON BRAKE PEDAL, AND THE BRAKES WILL MAKE NOISE. PADS HAD WORN OUT AND WERE REPLACED. *AK
Service brakes, Hydraulic, May 30, 2001
BRAKES SEEM SOFT AND THERE IS SQUEAKING. TOOK TO DEALER AND THEY REPLACED BRAKE SHOES. PROBLEM RETURNED 1 DAY LATER AND IS WORSE THEN WHEN I TOOK IN FOR SERVICE. I CALLED DEALER AGAIN AND THEY TOLD ME TO BRING IT BACK IN. SERVICE MANAGER SAID THAT HE HAD 3 CARS IN THERE FOR THE SAME PROBLEM. HE SAID THAT "FORD WAS AWARE OF THE PROBLEM, THEY WERE WORKING ON WHY THIS WAS HAPPENING AND IT WAS ONLY A SHORT TERM PROBLEM."*AK
Service brakes, Hydraulic, May 21, 2001
FRONT BRAKES ARE MAKING A SQUEAKING NOISE WHEN BRAKES ARE APPLIED. DEALERSHIP STATED THAT BRAKE PADS AND ROTORS WERE WORE OUT AND NEEDED TO BE REPLACED. DEALERSHIP INFORMED CONUSMER THAT ROTORS WERE NOT A COVERED PART, AND THEY WOULD HAVE TO HAVE THIS REPAIRED. *AK *SLC
Service brakes, Hydraulic, May 21, 2001, crash
I WAS APPROACHING A STOP LIGHT AND WAS MORE THAN 10 CAR LENGTHS BEHIND THE CAR IN FRONT OF ME WHEN I ATTEMPTED TO APPLY MY BRAKES. I DEPRESSED THE PEDAL BUT NOTHING HAPPENED. I APPLIED MORE AND MORE PRESSURE UNTIL THEY FINALLY ENGAGED NEAR THE FLOOR AND LOCKED. I TRIED TO AVOID THE CAR IN FRONT OF ME AND SLID ALONG SIDE SO I DID NOT IMPACT DIRECTLY IN THE BACK. I HAD DAMAGE TO THE LEFT FRONT OF MY CAR AND TO THE RIGHT REAR OF THE OTHER CAR. I WANT TO SEE IF SIMILAR REPORTS HAVE BEEN FILED WITH NHTSA. PLEASE CONTACT ME. *AK
Service brakes, Hydraulic, Power train, Exterior lighting, Structure, May 20, 2001
BRAKES NOISE RESULTING FROM LARGER THAN NORMAL CHUNK OF METAL IN PAD GROOVING THE LEFT FRONT ROTOR. TRANSMISSION- LEAK AT TRANSMISSION COOLER. SUSPENSION NOISE FRONT- THUMPING WHILE GOING OVER SPEED BUMPS, REAR SQUEEKING. WINDOW TRIM- COMING OFF OR SQUEEKING WHEN ROLLED UP. HEAD LAMP- DROPPING BLACK SILICON INTO SEALED UNIT (VISIBLE). ENGINE- STALLING, DYING WHILE COMING TO A STOP OR SITTING AT STOP. NO HELP FROM DEALER SERVICE DEPT. ONLY ARGUES WITH ME!. *AK (TIRESIZE: P205R70/15)( DOT NUMBER: TIRE SIZE: P205R70/15 )
Suspension, Service brakes, Hydraulic, May 16, 2001
BRAKES WERE SQUEAKING AT 10,000 MILES. TOOK VEHICLE TO DEALER, BUT WAS TOLD IT WAS A NORMAL CHARACTERISTIC. AT 22,000 MILES, CONSUMER TOOK VEHICLE TO DEALER FOR ANOTHER PROBLEM WITH ALIGNMENT. CONSUMER WAS TOLD BY DEALER THAT BRAKES WERE DOWN TO METAL. PLEASE PROVIDE FURTHER INFORMATION.*AK
Steering, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Visibility, Structure, Equipment, May 16, 2001
WINDSHIELD HAD CRACKED AND WAS REPLACED, APPROXIMATELY ONE MONTH LATER THE WINDSHIELD CRACKED AGAIN IN THE EXACT SAME SPOT, NOTHING HAD HIT THE WINDSHIELD ON EITHER TIMES THAT IT HAD CRACKED. AIR CONDITIONER DRAINS INSIDE THE CAR TO THE DRIVERS SIDE FLOOR. BRAKES SQUEAK, DEALER REPLACED REAR BRAKE SHOES, HOWEVER NOISE IS STILL THERE. STEERING WHEEL WAS PEELING, DEALER REPLACED IT. VEHICLE WILL NOT START AT TIMES, DEALER REPROGRAMMED THE PCM AND REPLACED THE FUEL PUMP. TRANSMISSION SLIPS INTO NEUTRAL WHILE DRIVING, IT WILL NOT SHIFT INTO REVERSE UNTIL AFTER ABOUT 10 SECONDS, DEALER HAS REPLACED THE MLP SENSOR AND TRANSMISSION RANGE SENSOR TO ATTEMPT TO CORRECT PROBLEM YET IT STILL CONTINUES, TRANSMISSION LINES LEAKING AND DEALER REPLACED LINES. NOISE COMING FROM UNDER THE HOOD. HOOD RATTLED, DEALER ADJUSTED AND LUBED THE HOOD STOPS. ENGINE RACES AT TIMES, VEHICLE HESITATES AND FEELS LIKE IT IS GOING TO STALL. *SLC
Service brakes, Hydraulic, May 14, 2001
WHILE TRAVELING AT APPROXIMATELY 30 MPH CONSUMER ATTEMPTED TO APPLY BRAKES FOR A RED LIGHT, AND CONSUMER HAD TO FORCE BRAKE PEDAL ALL THE WAY TO FLOOR WHICH SLOWED VEHICLE DOWN. BUT, DID NOT BRING IT TO A COMPLETE STOP. LIGHT CHANGED, AND CONSUMER CONTINUED ON, AND PARKED CAR. DEALERSHIP HAS YET TO EXAMINE VEHICLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
Service brakes, Hydraulic, May 11, 2001
CONSUMER STATES ON SEVERAL OCCASIONS WHEN VEHICLE WAS TAKEN IN FOR MAINTENANCE SHE WOULD TELL MECHANIC THAT SHE COULD HEAR BRAKES MAKING NOISE AND EACH TIME MECHANIC WOULD INSPECT VEHICLE, NOTHING WAS WRONG, MECHANIC MADE A STATEMENT TO CONSUMER THAT THE NOISE SHE WAS HEARING WAS FROM THE TIRES AND THEY NEEDED TO BE ROTATED AND THE NOISE WOULD CEASE, CONSUMER STATED THE NOISE BECAME WORSE AND WHEN SHE RETURNED, THE MECHANIC INFORMED HER THAT NEW ROTORS WERE NEEDED WHICH WERE REPLACED, AS OF 4/30/01 CONSUMER CONTINUES TO HEAR THE BRAKES. *JB
Service brakes, Hydraulic, May 10, 2001
BRAKES HAVE BEEN MAKING NOISE, DEALER SAID DUE TO WEAR AND TEAR ON THE VEHICLE.
Service brakes, Hydraulic, Power train, Tires, Wheels, May 4, 2001
BRAKE SYSTEM HAS HAD SHOES/BEARINGS/ DRUMS REPLACED DUE TO OVERHEATING OF WHEEL. REAR DRIVE'S SIDE TIRE IS BECOMING TOO HOT TO TOUCH AFTER NORMAL OPERATION OF VEHICLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
Service brakes, Hydraulic, Apr 30, 2001
CONSUMER STATES THAT WHEN VEHICLE WAS STARTED, AND PUT THE VEHICLE IN REVERSE THERE WAS A LOUD CLUNKING SOUND AND THE VEHICLE REFUSED TO MOVE, CONSUMER TURNED OFF THE VEHICLE AND GOT OUT TO SEE IF ANYTHING WAS LODGED BEHIND THE WHEELS THERE WAS NOTHING THERE SO CONSUMER RESTARTED THE VEHICLE PUT IT IN REVERSE AND THERE WAS A CRUNCHING SOUND THEN A SUDDEN SURGE AS THE VEHICLE MOVED AS CONSUMER BACKED OUT OF DRIVEWAY AND DROVE AWAY, VEHICLE SEEMED SLUGGISH, CONSUMER TOOK VEHICLE IN TO BE INSPECTED AND WAS ADVISED THAT SINCE THE BRAKE LININGS IN FORD PRODUCTS HAD BEEN CHANGED TO METAL PARTICLE FROM ASBESTOS THAT THE LININGS FLAKED OFF DUST AND THE DUST COLLECTS INSIDE THE DRUMS WHEN IT IS HUMID, THE DUST TENDS TO CLUMP AND FREEZE UP THE DRUMS. *JB
Service brakes, Hydraulic, Apr 28, 2001
BRAKE PROBLEMS: THERE IS ALOT OF NOISE WHEN APPLYING THE BRAKES. THIS HAS BEEN AN ON GOING THING SINCE ME AND MY HUSBAND PURCHASED THE FOCUS. WE HAVE CONTACTED THE DEALER SHIP ON SEVERAL OCCASSIONS TO REPORT THE PROBLEM AND TO THIS DAY NOTHING HAS BEEN DONE TO RESOLVE THE ISSUE. ALL THEY HAVE TO SAY IS THAT ITS SUPPOSE TO DO THAT. WE NOW HAVE TO TOTALLY REPLACE THE WHOLE BRAKE SYSTEM AND HAVEN'T EVEN HAD THE CAR FOR MORE THAN A YEAR AND A HALF. DEALERSHIP IS VERY UNPROFESSIONAL AND UNWILLING TO HELP AT ALL.*AK
Service brakes, Hydraulic, Apr 24, 2001
CONSTANT LOUD REAR BRAKE SQUEALS. VEHICLE HAS BEEN BROUGHT BACK TO DEALER 3 TIMES. SHOES HAVE BEEN REPLACED WITH SO-CALLED UPDATED VERSION, DRUMS HAVE BEEN GROUND ALL TO NO AVAIL. DEALER AND FORD CUSTOMER SERVICE SAYS THAT ENGINEERING IS WORKING ON THIS ISSUE. I'VE HEARD THIS STORY FOR WELL OVER A YEAR. *AK
Service brakes, Hydraulic, Air bags, Apr 23, 2001, crash
CONSUMER WAS DRIVING 5-7 MPH SLID ON WE PAYEMENT WHILE ABS WAS ACTIVATING, AND SLIGHTY HIT VEHICLE IN FRONT. DUAL AIR BAGS DEPLOYED, CAUSINGS 2ND TO 3RD DEGREE BURNS ON TOP OF HAND. PASSENGER HIT WINDSHIELD AND DASHBOARD. PLEASE PROVIDE FUERTHER INFORMATION. *AK
Service brakes, Hydraulic, Apr 19, 2001
REAR AND FRONT BRAKES ARE MAKING A SQUEAKING NOISE, TOOK TO DEALER AND CHANGED REAR BRAKES.*AK
Service brakes, Hydraulic, Apr 19, 2001
CONSUMER STATES BRAKES SQUEAK WHEN STOPPING, CONSUMER WAS ADVISED THAT FRONT BRAKES ARE NEEDED. *JB
Service brakes, Hydraulic, Apr 17, 2001
BRAKE PROBLEMS; THERE IS A LOT OF NOISE WHEN APPLYING BRAKES. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK
Service brakes, Hydraulic, Apr 17, 2001
VEHICLE WAS AT THE DEALERSHIP FOR ROUTINE CHECK UP, AND MECHANIC TOLD CONSUMER THAT SHE NEEDED BRAKES IN FRONT AND BACK. AT 15000 MILES SHE NEEDED ALL NEW BRAKES FRONT AND REAR. AT 18000 SHE NEEDED REAR BRAKES, BUT FRONT BRAKES WERE FINE.*AK
Steering, Suspension, Service brakes, Hydraulic, Vehicle speed control, Apr 17, 2001
WHILE DRIVING ON I275 NTH I HEARD WHAT SOUNDED LIKE THE NOISE A FLAT TIRE WOULD MAKE.GOT OFF MOTORWAY TO INVESTIGATE, COULD FIND NOTHING WRONG. GOT BACK ON ONLY TO FIND THE CAR STARTING TO PULL TOWARD THE PASSENGER SIDE. LUCKILY I WAS NEAR A REST AREA, PULLED OFF. ONLY TO FIND SMOKE POURING FROM THE REAR WHEEL. IT HAD SIEZED SOLID. IT WAS TAKEN TO A DEALER, WHO FIXED THE FOLLOWING, DRUM&BEARING CUP, SPINDLE, RETAINER ASY WHEEL, ROTOR BRAKE SK, CAP REAR WHEEL AND THE ABS SENSOR. REFUSED TO CHECK OTHER SIDE AS THAT HAD ALREADY(MUCH EARLY BEEN FIXED UNDER A RECALL) WHILE THEIR THEY DID FIND THE CAUSE FOR THE FUEL SMELL INSIDE THE VEHICLE, IN CIRCUIT 15RL3(GN.RD) @ C-87 TERMINAL WAS NOT SEATED IN CONNECTOR, FUEL CONSUMPTION HAS IMPROVED FROM 28MPG TO 31MPG. LOCAL DEALER AND FORD CUSTOMER SERVICE BOTH TOLD ME MY CONCERNS WITH THE OTHER REAR WHEEL AND THE ENGINE DUE TO IT'S CONSUMPTION OF UNBURNED FUEL(NOT TO MENTION MINE)WERE AREA'S THEY WILL NOT CHECK, EVEN IF I FEEL THEY ARE POTENTIALLY DANGEROUS TO MYSELF AND ANY PASSENGERS I MAY HAVE.*AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Apr 11, 2001
I AM NOT PLEASE WITH THIS CAR ,ME AND MY WIFE HAVE BROUGHT TWO OTHER CARS FROM THIS DEALER AND THIS IS THE FIRST ONE THAT HAS GIVEN A LOT OF GRIEF AND SORROR,PLEASE HELP ME BE A CONTINUE CUSTOMER BY ADDRESSING THIS PROBLEM IMMEDIATELY,AND ALSO FOR FUTURE REFERENCES. THANK YOU ,SIGN OFF---SADDEN. NO SAFETY DEFECT MENTIONED. *AK
Service brakes, Hydraulic, Apr 5, 2001
AFTER 400 MILES BRAKES START TO SQUEAK, CAN HEAR THEM A MILE AWAY. BRAKES HAVE BEEN REPLACED 3 TIMES, LAST TIME WAS 2 WEEKS AGO AND THERE WAS SQUEAKING AGAN. CURRENTLY, VEHICLE AT REPAIR SHOP FOR A FOURTH BRAKE REPAIR. CONSUMER FEARS THAT BRAKES MAY GO OUT AT ANYTIME. *AK